Professional Documents
Culture Documents
tpoo/'W ""
S'06: 1 FN:AN201lAD301(1401)
(i v) What is parting line? J.
FUNDAMENTALS OF DESIGN AND MANUFACfURING
(v) What is the significanceof recrystallisation
temperaturein metalforming'1 Time: Three hours
Group A
5
1. (a) What are the major stages of engineering design?
Discuss with a suitable example. 8
Ii) Bicycle
(iii I Discrete Manufacturing and Continuous Manufac' 8. (a) Define cutting velocity, feed and depth of cut as
turing applied to turning in lathes. What major factors are
considered while selecting the values of those three
(iv) Physical Reliability an4 Economic Feasibility. machining parameters? 8
c
Group B ( b I Distinguish between: 4
'" lal What isthe source of heat in resistance welding '1Why (i) Boring and Internal Turning
is the control of pressure important in resistance
(ii) Shaping and Planning.
welding? 8
(b) Explain bricOy the purposes of using Ouxes in (c) What is computer aided process planning (CAPP)?
weld;ng? 6 What type of data are required for developing a CAPP
system? Distinguish between variant and generative
,,~( I \1. 10) (I.H II I 2 ) (ContinuedJ systems of process planning. 8
IFN AN201/AD30l(l40lJ ( J (TuroO",r)
lid In which process the malerial is pulled through
adie?
Group C
Ix6 /1al Extrusion process
9. Write Ihe most correct answer:
I b) Rolling process
IA) (i) In which of the following process, the electrode
-~
is non -consumable 7 (e) Wire drawing process
(c) less than the fraclure strength of the mate- (ii) Derme the term deep drawability.
rial. (iii) What is 'Bath Tub Curve' 7
(d) less than Ihe limit of proportionality. 11'N:AN201/AD301 (14011 I 5 ) ( Turn O"cr)
( 4 ) (Continued )
I FN:AN201/AD301 (1401)