For Cars With a Standard Transmission 1. Find a stretch of downhill road (ensuring there is no other traffic) Jump Starting Your 2. Fully push on the clutch and Car 101 put the car in first gear ENG 320 3. Turn the ignition on 4. Take your foot off the brake and start rolling down the hill How to jump-start a car engine. (n.d.) Car tech home. (leaving the clutch fully Retrieved November 10, pushed down) 2010, from 5. Coast down the hill until you http://www.cartechhome.com/ 2008/04/jump-starting-your- reach between 5-7 miles per car-engine.html hour 6. Release the clutch quickly Jump starting your vehicle. (11, Dec., 2008). DIY my ride. (you should feel the engine Retrieved November 10, turn and start. If it doesn’t 2010, from start the first time, depress http://www.diymyride.com/jum the clutch and release it p-starting-your-vehicle-447/ again 7. If no hill is available, you can have some friends push your car and follow the steps listed above Your Name Here 9. Attach the other negative cable to a Precautions To piece of metal under the hood of the Jump Starting Your Car car that is running (bolt, frame etc.) , not to the battery post because that will draw an arc. 1. Use eye protection 10. Let the battery charge for 20-30 2. Do not let cars touch each other seconds. 11. Try and start the dead car. 3. Do not smoke 12. If the car doesn’t start then let the 4. Do not jump start car while battery charge a little longer. Jump Starting Your Vehicle refueling 13. If the car does start then you may remove the cables 5. Keep away all metal tools 14. Remove negative cable from the car Jump Starting Your Car With that was used to jump your own 6. If the battery appears to be Jumper Cables 15. Remove positive cable from the post damaged (cracked or frozen) do 1. If at any point you don’t feel of the car that jumped yours not jump start the car comfortable jumping your battery you 16. Remove negative cable from your car 7. Ensure there are no open flames may call a tow truck for help. 2. Identify what was drawing a charge 17. Remove positive cable from your car 8. Make sure the terminals are from your battery and shut the 18. Let your car run for 30-40 minutes to allow the alternator to recharge your clean component off 3. Call someone to come jump your battery. 9. Ensure the jumper cables are not battery 19. Drive to a garage shop to have you touching 4. Make sure the vehicles are lined up battery checked. properly so you aren’t over stretching 10. Drive the car for 30-40 minutes the jumper cables after jump starting the car to 5. Make sure the vehicle that is dead has recharge the battery the keys turned off so that the battery won’t be drawing a charge. 6. Attach the positive clamp (red) cable to the positive post of your battery 7. Attach the negative clamp (black) cable to the positive post of your battery 8. Attach the positive (red) cable to the Proper order to connect cables (1-4) positive (red) post of the car that is Car A is the live battery running. Car B is the dead battery