Professional Documents
Culture Documents
05 09 Ford Mustang Z Grille Installation Manual
05 09 Ford Mustang Z Grille Installation Manual
For Return Authorization, write or telephone: E&G Classics, Inc., 8910 McGaw Court, Columbia, MD 21045 (410) 381-4900 Attn: Return Department.
Part #1049-0185-05Q
You are responsible for inspecting all packages containing E&G Classics' parts and product immediately upon their receipt and must file a claim with the car-
Quantity Description Part No. rier for any damage disclosure by such inspection and notify E&G classics in writing at the above address of any such damage. This warranty does not extend
Stainless Steel “Q” Grille - Upper to any of our products which have been subject to misuse, neglect, accident or have been altered or repaired in any way. This warranty does not cover any
1 1049-0184-05Q accidental or consequential damages for any breach of this warranty agreement. E&G Classics shall have no responsibility for any loss of time, inconvenience,
1 Stainless Steel “Q” Grille - Lower 1049-0183-05Q commercial loss or consequential damage, nor shall E&G be liable for any injury or damage to persons or property by reason of any defect in material, work-
1 Hardware Kit (components listed below) 1049-0182-05 manship or finish of its parts or products. This warranty gives you specific legal rights and you may also have other rights which may vary from state to state.
10 8-32 ESNA Half Nuts 1999-0065-00
8
2
3/16” x 1/2” x .062” Black Nylon Washers1999-0256-00
1.006” x .189” x .064 Black Washers 1999-0264-00
-------- WARNING! ---------
PLEASE HANDLE WITH CARE! THE EDGES OF THE STAINLESS STEEL “Z”
10 .156” x 1” Vinyl Caps 1999-0241-00 GRILLE MAY BE SHARP!
3
1
2 2
4
5
4. Carefully align the upper grille so that it is perfectly 5. Carefully remove the stainless grille. Use a 5/16” 6. Carefully align the grille back into place and pass
centered around the running horse emblem. Press drill bit to drill through the marks made by the the center mounting studs through the holes
the grille firmly at all four (4) center stud locations center mounting studs. drilled in step 5. Apply enough pressure to the
to indent the factory plastic grille. outer mouting stud locations to indent the factory
plastic grille.
10
7. Carefully remove the stainless grille. Use a 5/16” 8. Remove the 10mm bolt retaining the bumper 10. Install a black plastic washer and a 8-32 ESNA half
drill bit to drill through the marks made by the cover to the support to allow access to the lower nut onto each stud and tighten. Tighten the top
outer mounting studs. mounting studs. nuts first.
9. Lift up on the bumper cover to clear the alignment
tab and pull the bumper cover forward.
14
15
11
11. Pull the grille and bumper cover out far enough to 13. Carefully align the lower grill into place, and press 15. Align the studs into the mounting holes and press
access the lower mounting studs and use a ratch- the studs firmly to indent the plastic on the factory the lower grille firmly into place. Install a 1” nylon
eting box wrench (works best) to tighten. grille (not shown). washer and an 8-32 ESNA half nut onto each stud
12. Once the hardware is tightened, reposition the 14. Use a 5/16” drill bit to drill through the marks and tighten.
bumper cover back into place and install the made in step 12.
10mm bolts.
16