Professional Documents
Culture Documents
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
6/15/04 REMOTE START (RMST PARTS REQUIRED: FUSE PLACEMENT CHART Securilock (PATS) Interface:
2003-2005 - 1L2Z-19G365-AB
15
15
15
15
15
15
15
15
15
15
15
15
15
RELAY REQUIREMENTS:
1- Driver's Door Priority Unlock (Optional) 1- Headlight Illumination (Optional)
HVAC 1* HVAC 2*
MAIN B+ IGNITION*
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 4 6/15/04 (NOTE: ALSO INCLUDES RKE/RMST DRIVERS SIDE KICK PANEL HARNESS
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Factory Alarm Disarm (GREEN/VIOLET) Unlock Switch Sense (PINK/ORANGE) + Hatch Release Output (PINK/ORANGE) Memory Seat 1 (TAN/LT GREEN) Memory Seat 2 (BLACK/ORANGE) Cut and tape off if not used Vehicle Interior Underhood RED BLACK Siren (VSS only) HOOD TILT SWITCH DRIVERS SIDE REAR DOOR JAMB BOOT DRIVER'S REAR DOOR SILL PLATE HARNESS MEMORY SEAT SWITCH HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-3 A-2 A-14 A-11 A-9 C-4 A-12 A-13 C-12 C-13 A-24 C-9 B-10 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN WHITE/BLUE BROWN LT GREEN/BLACK LT GREEN TAN GREEN/WHITE YELLOW/GREEN BLUE/GREEN TAN/RED BLUE/BLACK
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Arm Input Disarm Input Factory Alarm Disarm Unlock Switch Sense Hatch Release Memory Seat 1 Output Memory Seat 2 Output Driver Door Unlock Output DO NOT USE Active Output
To Key Release Latch Relay *Must Be Connected* see page 4 of 4 Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/BLACK) FUEL INJECTOR
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
2 0f 4
6/15/04
Ignition (RED/GREEN) + Heater (GRAY/YELLOW) + Starter + (GREEN) CUT
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 C-10 C-11 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE RED/WHITE BLUE/WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output Rear Defroster Output
BRAKE SWITCH
Parking lights (BROWN) + Cut and tape off if not used Optional Installation Feature See Optional connections pages
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow
3 of 4
6/15/04
OPTIONAL CONNECTIONS
85
87
87a
86 30
Blue
Black
White
Headlights (RED/YELLOW) +
HEADLIGHT SWITCH
Headlight
'03 (BLUE/ORANGE) Rear Defroster '04/'05 (GRAY/LT.BLUE)
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output REAR DEFROST SWITCH
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
CUT
Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
Function
Siren Feed Driver Door Unlock Output Disarm Input 87
White
87a
Black
85 30
86 Red
Blue
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL RMST
Revision Date
4 of 4
6/15/04
REQUIRED CONNECTION
NOTE: This connection is required on all remote start installations in Aviator's
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
87
White
87a
Color
B-10 BLUE/BLACK
Function
Active Output 85
86 30
Black
Ignition (RED/GREEN)
+ IGNITION SWITCH
Blue
Red + CUT
IMPORTANT!
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
Ignition (RED/GREEN)
+ IGNITION SWITCH
1 of 2
6/15/04
Starter + (GREEN)
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 B-10 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE BLUE/BLACK
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Active Output
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/BLACK) FUEL INJECTOR
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL RMST
Revision Date
2 of 2
6/15/04
REQUIRED CONNECTION
NOTE: This connection is required on all remote start installations in Aviator's
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
87
White
87a
Color
B-10 BLUE/BLACK
Function
Active Output 85
86 30
Black
Ignition (RED/GREEN)
+ IGNITION SWITCH
Blue
Red + CUT
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
6/15/04
Color
A-5 A-20 A-3 A-2 A-14 A-11 A-9 C-4 A-12 A-13 C-12 C-13 A-24 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN WHITE/BLUE BROWN LT GREEN/BLACK LT GREEN TAN GREEN/WHITE YELLOW/GREEN BLUE/GREEN TAN/RED
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Arm Input Disarm Input Factory Alarm Disarm Unlock Switch Sense Hatch Release Output Memory Seat 1 Output Memory Seat 2 Output Driver Door Unlock DO NOT USE Cut and tape off if not used
Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Factory Alarm Disarm (GREEN/VIOLET) HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
DRIVERS SIDE REAR DOOR JAMB BOOT DRIVER'S REAR SILL PLATE HARNESS
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
6/15/04
Ignition (RED/GREEN) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (GREEN)
Horn (YELLOW/GREEN)
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
HEADLIGHT SWITCH
Yellow White IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87a
87
Black Blue
85 30
86
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
6/15/04
OPTIONAL CONNECTIONS
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
CUT
Function
Siren Feed Driver Door Unlock Output Disarm Input 87
White
87a
Black
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86 Red
Blue
UNDERHOOD HARNESS
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional) Chassis ground Do Not Ground to Hood!
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
VSS
Revision Date
1 of 2
6/15/04
Color
A-5 A-20 A-11 A-9 A-12 BLACK GREEN/VIOLET WHITE/BLUE BROWN LT GREEN
Function
Ground Door Ajar Switch Input Arm Input Disarm Input Unlock Switch Sense
+ IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
VSS
Revision Date
2 of 2
6/15/04
OPTIONAL CONNECTIONS
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'03-'05 Aviator
Equipment or Trim level System(s) applicable to:
ALL
Page
Preload
Revision Date
1 of 1
6/15/04
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-3 A-2 A-14 A-11 A-9 A-12 A-13 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN WHITE/BLUE BROWN LT GREEN TAN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Hatch Release Output
Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Unlock Switch Sense (PINK/ORANGE) +
DRIVERS SIDE REAR DOOR JAMB BOOT HARNESS UNDER DRIVERS SIDE REAR DOOR SILL PLATE
Color
C-4
Function
Factory Alarm Disarm (GREEN/VIOLET) -
*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
+ + IGNITION SWITCH KEY SIDE (after cut) IGNITION SWITCH + HEADLIGHT SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Starter + (GREEN)
CUT
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
9/29/04
REMOTE START (RMST) PARTS REQUIRED: Securilock (PATS) Interface: Econoline is not equipped with PATS Tach Inverter: 2004 - Part # 5C3Z-17C304-AA (6.0 Liter Diesel Vehicles)
DOME LIGHT**
15
15
15
15
15
15
15
15
15
15
RELAY REQUIREMENTS:
15
15
15
HVAC 1* HVAC 2*
MAIN B+ IGNITION*
2 - Door Lock/Unlock (W/O Factory RKE) 1 - Headlight Illumination (Optional) 1 - Driver's Door Priority Unlock (Optional) VEHICLE SPECIFIC PROGRAMMING:
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Vehicle (Year/Make/Model)
'02-'04 Econonline
Equipment or Trim level System(s) applicable to:
W/Factory RKE
Page
RKE/VSS/RMST
Revision Date
Door Lock (PINK/YELLOW) + Door Unlock (PINK/GREEN) + Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Optional Installation Feature See Optional connections page CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE DRIVER SIDE KICK PANEL
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE GRAY
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) Park Lights (BROWN) + + HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'02-'04 Econonline
Equipment or Trim level System(s) applicable to:
RKE/VSS/RMST
Revision Date
87
87a
Yellow
Black
85
White
86 30
Red Blue
Yellow
CUT
87
87a Black
85 30
86
Red Blue
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE GRAY
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) Park Lights (BROWN) + + HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
GASOLINE Tach Signal (WHITE/PINK) BLUNT CUT WIRE IN ENGINE COMPARTMENT BLUNT CUT WIRE IN ENGINE COMPARTMENT
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
4 of 5
8/25/04
MAKE THIS CONNECTION LAST! Battery (YELLOW) + Battery (YELLOW) + Ignition (RED/LT. GREEN) + Heater (GRAY/YELLOW) + IGNITION SWITCH
+ Starter (WHITE/PINK)
CUT
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 C-10 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN RED/WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Headlight Output
BRAKE SWITCH
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
Yellow
Battery (YELLOW) +
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
IGNITION SWITCH
5 of 5 8/25/04 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
Connect to the half of the wire going back into the vehicle's interior
Color
C-10 RED/WHITE
Function
Headlight Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86
Blue
Black
+ +
HEADLIGHT SWITCH
Headlight
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
1 of 2
8/25/04
Starter + (WHITE/PINK)
CUT
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
Color
A-5 BLACK
Function
Ground
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
2 of 2
9/30/04
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
GASOLINE Tach Signal (WHITE/PINK) BLUNT CUT WIRE IN ENGINE COMPARTMENT BLUNT CUT WIRE IN ENGINE COMPARTMENT
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
'02-'04 Econonline
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
8/25/04
Door Lock (PINK/YELLOW) + Door Unlock (PINK/GREEN) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Passenger Door Unlock Motor (PINK/ORANGE) + Cut and tape off if not used Optional Installation Feature See Optional connections page CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE DRIVER SIDE KICK PANEL
Color
A-5 A-2 A-14 A-11 A-9 A-12 A-24 C-8 BLACK BLUE GREEN WHITE/BLUE BROWN LT.GREEN BLUE/GREEN BLUE
Function
Ground Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Input Driver Door Unlock Output Trunk Ajar Input
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + HEADLIGHT SWITCH
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'02-'04 Econonline
Equipment or Trim level System(s) applicable to:
Deluxe RKE/VSS
Revision Date
2 of 4
8/25/04
IGNITION SWITCH HARNESS
87
87a
Yellow
Black
85
White
86 30
Red Blue
Yellow
CUT
87
87a Black
85 30
86
Red Blue
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
8/25/04
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (WHITE/PINK)
Horn (BLUE)
Yellow White
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
Yellow
Battery (YELLOW) +
ALL
Page
Deluxe RKE/VSS
Revision Date
87
White
87a
IGNITION SWITCH
4 of 4
8/25/04
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional, Not Included with Kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 1
9/29/04
Passenger Door Unlock (PINK/ORANGE) + DRIVER SIDE KICK PANEL
Color
A-5 A-12 A-11 A-9 BLACK LT.GREEN WHITE/BLUE BROWN
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input
Color
A-4 A-7 A-8 A-6 A-21 A-1 A-20 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE GREEN/VIOLET
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Door Ajar Switch Input
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (BLUE)
Vehicle (Year/Make/Model)
'02-'04 Econonline
Equipment or Trim level System(s) applicable to:
1 of 1
8/25/04
87
87a Yellow
Black
85
White
86 30
Red Blue
Yellow
CUT
Black
85 30
86
Red
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + HEADLIGHT SWITCH
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Horn (BLUE)
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
8/25/04
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
PRELOAD
Revision Date
1 of 1
8/25/04
Lock Switch (PINK/YELLOW) +
Color
A-5 A-2 A-14 A-12 A-11 A-9 BLACK BLUE GREEN LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + HEADLIGHT SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
Ignition (RED/LT. GREEN) + Starter + (WHITE/PINK) CUT KEY SIDE (after cut) Horn (BLUE)
Vehicle (Year/Make/Model)
'02-'04 Econoline
Equipment or Trim level System(s) applicable to:
PRELOAD
Revision Date
1 of 1
8/25/04
87
87a Yellow
Black
85
White
86 30
Red Blue
Yellow
CUT
Black
85 30
86
Red Blue
HEADLIGHT SWITCH
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + HEADLIGHT SWITCH
MAKE THIS CONNECTION LAST! Battery (YELLOW) + Ignition (RED/LT. GREEN) + Starter + (WHITE/PINK) CUT KEY SIDE (after cut) Horn (BLUE) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
3/4/05
REMOTE START (RMST) PARTS REQUIRED: Securilock (PATS) Interface: Econoline is not equipped with PATS Tach Inverter: 2005 - Part # 5C3Z-17C304-AA (6.0 Liter Diesel Vehicles)
DOME LIGHT**
15
15
15
15
15
15
15
15
15
15
RELAY REQUIREMENTS:
15
15
15
HVAC 1* HVAC 2*
MAIN B+ IGNITION*
2 - Door Lock/Unlock (W/O Factory RKE) 1 - Headlight Illumination (Optional) 1 - Driver's Door Priority Unlock (Optional) VEHICLE SPECIFIC PROGRAMMING:
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Vehicle (Year/Make/Model)
'05-'06 Econonline
Equipment or Trim level System(s) applicable to:
W/Factory RKE
Page
RKE/VSS/RMST
Revision Date
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Dome Light (BLACK/LT. BLUE) + Optional Installation Feature See Optional connections page DRIVER SIDE KICK PANEL
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'05-'06 Econonline
Equipment or Trim level System(s) applicable to:
RKE/VSS/RMST
Revision Date
87
87a
Yellow
Black
85
White
86 30
Red Blue
Yellow
CUT
87
87a Black
85 30
86
Red
Color
A-20 A-3 GREEN/VIOLET BLACK/WHITE
Function
Door Ajar Switch Input Dome Light Output Dome Light (BLACK/LT. BLUE) + DRIVER'S SIDE KICK PANEL
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
4 of 5
3/4/05
MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) + Battery (LT. GREEN/VIOLET) + Ignition (PINK/LT. GREEN) + Heater (GRAY/YELLOW) + IGNITION SWITCH
+ Starter (WHITE/PINK)
CUT
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 C-10 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN RED/WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Headlight Output
BRAKE SWITCH
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
Yellow
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
IGNITION SWITCH
5 of 5 3/4/05 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
Connect to the half of the wire going back into the vehicle's interior
Color
C-10 RED/WHITE
Function
Headlight Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86
Blue
Black
+ +
HEADLIGHT SWITCH
Headlight
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
Battery (LT. GREEN/VIOLET) + Battery (LT. GREEN/VIOLET) + Ignition (PINK/LT. GREEN) + Heater (GRAY/YELLOW) + IGNITION SWITCH
1 of 2
3/4/05
Starter + (WHITE/PINK)
CUT
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
Color
A-5 BLACK
Function
Ground
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
2 of 2
3/4/05
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
'05-'06 Econonline
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
3/4/05
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Dome Light (BLACK/LT. BLUE) + Optional Installation Feature See Optional connections page DRIVER SIDE KICK PANEL
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output
HEADLIGHT SWITCH
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'05-'06 Econonline
Equipment or Trim level
Deluxe RKE/VSS
Revision Date
2 of 4
3/4/05
85
White
87
87a
Yellow
Black
86 30
Red Blue
Yellow
CUT
87
Black
Optional Installation Feature See Optional connections page Cut and tape off if not used
85 30
86
Red Blue
Color
A-20 A-3 GREEN/VIOLET BLACK/WHITE
Function
Door Ajar Switch Input Dome Light Output Dome Light (BLACK/LT. BLUE) + DRIVER'S SIDE KICK PANEL
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
HEADLIGHT SWITCH
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
3/4/05
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (WHITE/PINK)
Yellow White
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
Yellow
ALL
Page
Deluxe RKE/VSS
Revision Date
87
White
87a
IGNITION SWITCH
4 of 4
3/4/05
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional, Not Included with Kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 1
3/4/05
Passenger Door Unlock (PINK/ORANGE) + DRIVER SIDE KICK PANEL
Color
A-5 A-12 A-11 A-9 A-20 A-3 BLACK LT.GREEN WHITE/BLUE BROWN GREEN/VIOLET BLACK/WHITE
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input Door Ajar Switch Input Dome Light Output
Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Dome Light (BLACK/LT. BLUE) +
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'05-'06 Econonline
Equipment or Trim level System(s) applicable to:
87
87a
Yellow
1 of 1
3/4/05
85
White
Black
86 30
Red Blue
Yellow
CUT
Black
85 30
86
Red Blue
Park Lights (BROWN) + MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) +
HEADLIGHT SWITCH
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
3/4/05
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
'05-06 Econoline
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
PRELOAD
Revision Date
1 of 1
3/4/05
Lock Switch (PINK/YELLOW)
Color
A-5 A-2 A-14 A-12 A-11 A-9 A-20 A-3 BLACK BLUE GREEN LT.GREEN WHITE/BLUE BROWN GREEN/VIOLET BLACK/WHITE
Function
Ground Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Door Ajar Switch Input Dome Light Output Unlock Switch (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) +
HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output
HEADLIGHT SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
Starter + (WHITE/PINK)
CUT KEY SIDE (after cut) Horn (DK. BLUE) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Vehicle (Year/Make/Model)
'05-'06 Econoline
Equipment or Trim level
CHASSIS GROUND POINT IN DRIVERS KICK PANEL Fused Battery (LT. GREEN/VIOLET) + IGNITION SWITCH HARNESS
PRELOAD
Revision Date
87
87a
Yellow
1 of 1
3/4/05
85
White
Black
86 30
Red Blue
Yellow
CUT
Black
85 30
86
Red Blue
HEADLIGHT SWITCH
MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) + Ignition (PINK/LT. GREEN) + Starter + (WHITE/PINK) CUT KEY SIDE (after cut) Horn (DK. BLUE) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
5/27/03
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
2002-04: 1S4Z-19G365-AB
RELAY REQUIREMENTS: 1 - REAR DEFROSTER (2002 MODEL YEAR) 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)
15
15 15
15
15
15
15
15
15
15
15
15
15
Door trigger polarity Negative Unlock switch sense polarity Negative Key in Sense polarity Positive
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
MODULE MOUNTING LOCATION: Behind fuse panel, High near bulkhead panel
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3
5/27/03
MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVER S KICK PANEL
Function
Ground Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output Driver Door Unlock Output DO NOT USE DO NOT USE Rear Defroster Output Trunk Ajar Input
Optional Installation Feature See DRIVERS DOOR UNLOCK (3 of 3) Cut & tape if not used
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Tach Signal
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 3
5/27/03
Function
Battery HVAC Feed Door Trigger Pull-Up Ignition Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Brake Input
IGNITION SWITCH
Brake (GREEN) +
Function
Parking Light Output Dome Light Output Door Ajar Switch Input Horn Relay Output Perimeter Alarm Disarm 2nd Heater Output 2nd Heater Polarity Headlight Output Parking Lights (BLACK/GREEN) Dome Lights (GREEN/ORANGE) Horn (YELLOW/GREEN) G.E.M.
CHASSIS GROUND
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
87
White
87a
3 of 3
5/27/03
85
86 30
Black
NOTE: RKE/VSS/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON RKE/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #1) option to ON
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Function
Headlight Output Rear Defroster Output
Headlights (RED/WHITE) -
G.E.M.
Yellow
87
Black White
87a
85 30
86
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Blue
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
MAKE THIS CONNECTION LAST! Battery (RED/Lt BLUE) + Ignition (Lt GREEN/VIOLET) + Heater (BLACK/GREEN) +
ALL
Page
RMST
Revision Date
1 of 1
5/27/03
IGNITION SWITCH
Function
Battery HVAC Feed Ignition Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Brake Input
Function
Ground
MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVER S KICK PANEL
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Tach Signal
Function
Parking Light Output Horn Relay Output 2nd Heater Output 2nd Heater Polarity
CHASSIS GROUND
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
DELUXE RKE/VSS
Revision Date
1 of 3
5/27/03
MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVER S KICK PANEL
Function
Ground Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output Driver Door Unlock Output DO NOT USE DO NOT USE Trunk Ajar Input
Cut & tape if not used CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE
Function
Siren Feed Siren Output
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
DELUXE RKE/VSS
Revision Date
2 of 3
5/27/03
MAKE THIS CONNECTION LAST! Battery (RED/Lt BLUE) + Ignition (Lt GREEN/VIOLET) +
CUT
IGNITION SWITCH
Function
Door Trigger Pull-Up Battery Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side)
Function
Parking Light Output Dome Light Output Door Ajar Switch Input Horn Relay Output Headlight Output Perimeter Alarm Disarm Parking Lights (BLACK/GREEN) Dome Lights (GREEN/ORANGE) Horn (YELLOW/GREEN) G.E.M.
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
DELUXE RKE/VSS
Revision Date
3 of 3
5/27/03
White
Yellow
87
87a
NOTE: Deluxe RKE/VSS Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
85 30
86
Black
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Function
Hood Open Switch Input
Vehicle Interior
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
1 of 1
5/27/03
Starter + (TAN/Lt BLUE) CUT
IGNITION SWITCH
Function
Door Trigger Pull-Up Battery Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side)
Function
Ground Door Unlock Output Door Lock Output
Door Unlock (PINK/WHITE) Door Lock (WHITE/VIOLET) DRIVERS KICK PANEL
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Color
A-1 A-3 A-20 A-21 WHITE BLACK/WHITE GREEN/VIOLET BROWN/BLACK
Function
Parking Light Output Dome Light Output Door Ajar Switch Input Horn Relay Output Parking Lights (BLACK/GREEN) Dome Lights (GREEN/ORANGE) Horn (BROWN/BLACK) G.E.M.
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
VSS
Revision Date
1 of 1
5/27/03
Starter + (TAN/Lt BLUE) CUT
IGNITION SWITCH
Function
Door Trigger Pull-Up Battery Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) MAKE THIS CONNECTION FIRST!
Function
Ground Disarm Input Arm Input Unlock Switch Sense
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Lock Motor (PINK/BLACK) + Door Unlock (PINK/WHITE) +
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Color
A-1 A-20 A-21 WHITE GREEN/VIOLET BROWN/BLACK
Function
Parking Light Output Door Ajar Switch Input Horn Relay Output
G.E.M.
Vehicle (Year/Make/Model)
02-04 Escape
Equipment or Trim level System(s) applicable to:
ALL
Page
PRELOAD
Revision Date
1 of 1
9/2/03
Starter + (TAN/Lt BLUE) CUT
IGNITION SWITCH
Function
Door Trigger Pull-Up Battery Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVER S KICK PANEL
Function
Ground Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output
Function
Parking Light Output Dome Light Output Door Ajar Switch Input Horn Relay Output Parking Lights (BLACK/GREEN) Dome Lights (GREEN/ORANGE) Horn (YELLOW/GREEN) G.E.M.
Color
C-4 LT.GREEN/BLACK
Function
Factory Alarm Disarm Output Perimeter Alarm Disarm (DK.BLUE/LT.GREEN) G.E.M.
*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
ALL
Page
ALL
Revision Date
1 of 1
3/31/05
REMOTE START (RMST) PARTS REQUIRED Securilock (PATS) Interface: 2005-2006 1L2Z-19G365-AB
DOME LIGHT**
REMOTE START (RMST) SPECIFIC PROGRAMMING Key in Sense polarity Rear Defroster Learn Tachometer Positive 0.5 sec. (Default Setting) Required On All Vehicles
15
15
15
15
15
15
RELAY REQUIREMENTS:
1- Driver's Door Priority Unlock (Optional)
15
15
15
15
15
15
15
5 MAIN B+
HVAC 1* HVAC 2*
IGNITION*
Door trigger polarity Unlock switch sense polarity Negative Negative
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3
3/31/05
MAKE THIS CONNECTION LAST! Battery (TAN/BLACK)
Function
Ground HVAC 2 Polarity Battery HVAC 1 Battery Door Trigger Pull-up Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output Perimeter Alarm Disarm HVAC 2 Output Dome Light Output Door Ajar Switch Input Driver Door Unlock Output Trunk Ajar Input
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Lock Motor (PINK/BLACK) + Door Unlock (PINK/WHITE) Door Lock (WHITE/VIOLET) Perimeter Alarm Disarm (DK BLUE/LT. GREEN) Dome Light (PINK) DRIVER'S SIDE KICK PANEL HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 3
3/31/05
Ignition (LT. GREEN/VIOLET) + Heater (BLACK/LT. GREEN) + Starter + (TAN/LT. BLUE) CUT KEY SIDE (after cut) IGNITION SWITCH
Color
A-7 B-4 A-8 A-6 B-8 A-21 A-1 B-7 C-10 C-11 PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK WHITE BROWN RED/WHITE BLUE/WHITE
Function
Ignition Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Parking Light Output Brake Input Headlight Output Rear Defroster Output
STEERING COLUMN
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
3 of 3
3/31/05
Battery (TAN/BLACK) +
87
White
87a
85 30
86
Black
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Connect to the half of the wire going to the back of the vehic
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Headlights (RED/YELLOW)
STEERING COLUMN
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
1 of 1
3/31/05
CUT KEY SIDE (after cut) IGNITION SWITCH
Color
A-7 B-4 A-8 A-6 B-8 A-21 A-1 B-7 PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK WHITE BROWN
Function
Ignition Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Parking Light Output Brake Input
Color
A-5 B-1 A-4 B-2 B-5 BLACK BLUE RED RED ORANGE/WHITE
Function
Ground HVAC 2 Polarity Battery HVAC Feed HVAC 2 Output MAKE THIS CONNECTION LAST! Battery (TAN/BLACK) +
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
DELUXE RKE/VSS
Revision Date
1 of 3
3/31/05
Color
A-5 A-4 A-10 A-9 A-11 A-12 A-14 A-2 C-4 A-3 A-20 A-24 C-8 BLACK RED YELLOW/WHITE BROWN WHITE/BLUE Lt GREEN GREEN BLUE LT.GREEN/BLACK BLACK/WHITE GREEN/VIOLET BLUE/GREEN BLUE
Function
Ground Battery Door Trigger Pull-Up Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output Perimeter Alarm Disarm Dome Light Output Door Ajar Switch Input Driver Door Unlock Output Trunk Ajar Input
Battery (TAN/BLACK) +
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Lock Motor (PINK/BLACK) + Door Unlock (PINK/WHITE) Door Lock (WHITE/VIOLET) Perimeter Alarm Disarm (DK BLUE/LT. GREEN) Dome Light (PINK) DRIVER'S SIDE KICK PANEL HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
DELUXE RKE/VSS
Revision Date
2 of 3
3/31/05
Ignition (Lt GREEN/VIOLET) + IGNITION SWITCH Starter + (TAN/LT. BLUE) CUT KEY SIDE (after cut)
Color
A-7 A-8 A-6 A-21 A-1 C-10 PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Horn (YELLOW/LT. GREEN) Parking Lights (WHITE/BLACK) Headlights (RED/YELLOW)
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
3/31/05
Yellow
Battery (TAN/BLACK) +
87
White
87a
85 30
86
Black
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Connect to the half of the wire going to the back of the vehic
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Vehicle (Year/Make/Model)
Ignition (LT GREEN/VIOLET) + IGNITION SWITCH Starter + (TAN/LT. BLUE) CUT KEY SIDE (after cut)
1 of 1
3/31/05
Color
A-7 A-8 A-6 A-21 A-1 PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Horn (YELLOW/LT. GREEN) Parking Lights (WHITE/BLACK)
Color
A-5 A-4 A-10 A-14 A-2 A-3 A-20 BLACK RED YELLOW/WHITE GREEN BLUE BLACK/WHITE GREEN/VIOLET
Function
Ground Battery Door Trigger Pull-Up Door Unlock Output Door Lock Output Dome Light Output Door Ajar Switch Input
Battery (TAN/BLACK) +
Vehicle (Year/Make/Model)
W/ Factory RKE
Page
VSS
Revision Date
1 of 1
3/31/05
Starter + (TAN/LT. BLUE)
Ignition (LT GREEN/VIOLET) + IGNITION SWITCH CUT KEY SIDE (after cut)
Color
A-7 A-8 A-6 A-21 A-1 PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Horn (YELLOW/LT. GREEN) Parking Lights (WHITE/BLACK)
Color
A-5 A-4 A-10 A-9 A-11 A-12 A-3 A-20 BLACK RED YELLOW/WHITE BROWN WHITE/BLUE Lt GREEN BLACK/WHITE GREEN/VIOLET
Function
Ground Battery Door Trigger Pull-Up Disarm Input Arm Input Unlock Switch Sense Dome Light Output Door Ajar Switch Input
Battery (TAN/BLACK) +
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Lock Motor (PINK/BLACK) + Door Unlock (PINK/WHITE)
Vehicle (Year/Make/Model)
Ignition (LT GREEN/VIOLET) + IGNITION SWITCH Starter + (TAN/LT. BLUE) CUT KEY SIDE (after cut)
ALL
Page
PRELOAD
Revision Date
1 of 1
3/31/05
Color
A-7 A-8 A-6 A-21 A-1 PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Ignition Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Horn (YELLOW/LT. GREEN) Parking Lights (WHITE/BLACK) MAKE THIS CONNECTION FIRST!
Color
A-5 A-4 A-10 A-9 A-11 A-12 A-14 A-2 A-3 A-20 BLACK RED YELLOW/WHITE BROWN WHITE/BLUE Lt GREEN GREEN BLUE BLACK/WHITE GREEN/VIOLET
Function
Ground Battery Door Trigger Pull-Up Disarm Input Arm Input Unlock Switch Sense Door Unlock Output Door Lock Output Dome Light Output Door Ajar Switch Input
Battery (TAN/BLACK) +
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Lock Motor (PINK/BLACK) + Door Unlock (PINK/WHITE) Door Lock (WHITE/VIOLET) DRIVER'S SIDE KICK PANEL HARNESS
Color
C-4
Function
Perimeter Alarm Disarm (DK.BLUE/LT.GREEN) -
*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
SK5W7J-19A361-AB
Vehicle (Year/Make/Model)
ALL
Page
ALL
Revision Date
1 of 1
9/29/04
REMOTE START (RMST) PARTS REQUIRED: Securilock (PATS) Interface: 2002-2003 - 1L3Z-19G365-AB (Excursion Only) Tach Inverter: 2003 - Part # 5C3Z-17C304-AA (6.0 Liter Diesel Vehicles)
DOME LIGHT**
15
15 15 15 5
15
15
15
15
15
15
15
15
15
HVAC 1* HVAC 2*
MAIN B+ IGNITION*
2 - Door Lock/Unlock (W/O Factory RKE) 1 - Headlight Illumination (Optional) 1 - Driver's Door Priority Unlock (Optional) VEHICLE SPECIFIC PROGRAMMING:
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system.
MODULE MOUNTING LOCATION: Upper Left side of the driver's underdash behind fuse panel near parking brake assembly.
Vehicle (Year/Make/Model)
W/Factory RKE
Page
RKE/VSS/RMST
Revision Date
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + DRIVER'S DOOR JAMB BOOT HARNESS DRIVER'S SIDE KICK PANEL HARNESS
+ +
NOTE: If vehicle is equipped with trim switch disable, refer to page 5 for the wiring diagram
Vehicle (Year/Make/Model)
RKE/VSS/RMST
Revision Date
Yellow
87
87a Black
85
White
86 30
Red Blue
IGNITION SWITCH
Yellow
87
White 87a Black
CUT
85 30
86
Red Blue
+ +
Optional Installation Feature See Optional connections page Cut and tape off if not used
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
Chassis ground Do Not Ground to Hood! BLUNT CUT WIRE BEHIND FUSE PANEL
(taped to harness)
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
MAKE THIS CONNECTION LAST! Battery (YELLOW) Battery (YELLOW) Battery (YELLOW) Ignition (RED/GREEN) + + + + + + IGNITION SWITCH
4 of 5
8/25/04
Color
A-4 B-2 B-1 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 C-10 C-11 C-8 RED RED BLUE PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN RED/WHITE BLUE/WHITE BLUE
Function
Battery HVAC1 Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Headlight Output Rear Defrost Output Trunk Ajar Input
Cut and tape off if not used Optional Installation Feature See Optional connections page Brake light (GREEN) + BRAKE SWITCH
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
87
87a
85 30
86
Black
IGNITION SWITCH
Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
87
Black
87a
85 30
86
CUT
Blue
Color
C-11 C-10 BLUE/WHITE RED/WHITE
Function
Rear Defroster Output Headlight
Excursion only
DEFROSTER SWITCH
Headlight
Yellow White
87
87a
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Black Blue
IMPORTANT!
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
85 30
86
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
+ + + + IGNITION SWITCH
1 of 2
8/25/04
Color
A-4 B-2 B-1 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 RED RED BLUE PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN
Function
Battery HVAC1 Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
KEY SIDE (after cut) Key-in-Sense (BLACK/PINK) Horn (BLUE) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
BRAKE SWITCH
Color
A-1 A-5 WHITE BLACK
Function
Parking Light Output Ground
CHASSIS GROUND POINT IN DRIVERS KICK PANEL MAKE THIS CONNECTION FIRST!
Vehicle (Year/Make/Model)
All
Page
RMST
Revision Date
2 of 2
9/30/04
UNDERHOOD HARNESS
Vehicle Interior
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input OR Chassis ground Do Not Ground to Hood! BLUNT CUT WIRE BEHIND FUSE PANEL
(taped to harness)
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
W/Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
8/19/04
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Connect only on vehicles with factory RKE Optional Installation Feature See Optional connections page DRIVER DOOR JAMB BOOT HARNESS DRIVER'S SIDE KICK PANEL HARNESS
NOTE: If vehicle is equipped with trim switch disable, refer to page 4 for the wiring diagram
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
Deluxe RKE/VSS
Revision Date
Yellow
87
87a Black
2 of 4
8/20/04
85
White
86 30
Red Blue
CUT
Yellow
87
White 87a Black
CUT
85 30
86
Red Blue
Optional Installation Feature See Optional connections page Cut and tape off if not used
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + DRIVER SIDE KICK PANEL
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
8/19/04
Ignition (RED/GREEN) +
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 C-10 C-8 RED PINK VIOLET VIOLET/RED BROWN/BLACK RED/WHITE BLUE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Headlight Output Trunk Ajar Input
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Horn (BLUE)
Yellow White
87
87a
85 30
86
Blue
Black
+ + HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
4 of 4
8/20/04
White
Yellow
87
87a
OPTIONAL CONNECTIONS
85
86 30
Black
IGNITION SWITCH
Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
87
Black
87a
85 30
86
CUT
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
8/19/04
Passenger Door Unlock (PINK/ORANGE) + DRIVER'S SIDE KICK PANEL HARNESS
Color
A-5 A-12 A-11 A-9 A-20 BLACK LT.GREEN WHITE/BLUE BROWN GREEN/VIOLET
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input Door Ajar Switch Input
DRIVER DOOR JAMB BOOT HARNESS REAR OF DRIVER SIDE SILL PLATE HARNESS
+ + IGNITION SWITCH
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN DRIVER SIDE KICK PANEL OR HEADLIGHT SWITCH
Horn (BLUE)
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
Vehicle (Year/Make/Model)
Yellow
1 of 1
8/20/04
85
White
87
87a Black
86 30
Red Blue
CUT
Yellow
87
Black
CUT
85 30
86
Red
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + MAKE THIS CONNECTION LAST! Battery (YELLOW) + + IGNITION SWITCH REAR OF DRIVER'S DOOR SILL PLATE HARNESS
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Horn (BLUE)
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
8/19/04
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
w/Factory RKE
Page
Preload
Revision Date
1 of 3
8/19/04
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + DRIVER'S SIDE KICK PANEL HARNESS
Color
A-5 A-2 A-14 A-12 A-11 A-9 C-4 BLACK BLUE GREEN LT. GREEN WHITE/BLUE BROWN LT.GREEN/BLACK
Function
Ground Lock Output Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Perimeter Disarm Output
NOTE: If vehicle is equipped with trim switch disable, refer to page 2 for the wiring diagram
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + MAKE THIS CONNECTION LAST! REAR OF DRIVER'S DOOR SILL PLATE HARNESS
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Starter + (DARK GREEN) CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Horn (BLUE)
Vehicle (Year/Make/Model)
w/ Factory RKE
Page
Preload
Revision Date
2 of 3
8/20/04
87
Black
87a
85 30
86
CUT
Vehicle (Year/Make/Model)
Preload
Revision Date
3 of 3
8/20/04
Yellow
87
87a Black
85
White
86 30
Red Blue
IGNITION SWITCH
Yellow
87
Black
CUT
85 30
86
Red Blue
Color
A-20 A-3 A-1 GREEN/VIOLET BLACK/WHITE WHITE
Function
Door Ajar Switch Input Dome Light Output Parking Light Output Dome Light (BLACK/BLUE) + Park Lights (BROWN) + REAR OF DRIVER'S DOOR SILL PLATE HARNESS
Battery (YELLOW)
+ + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Horn (BLUE)
SK5W7J-19A361-AB
Vehicle (Year/Make/Model)
ALL
Page
ALL
Revision Date
1 of 1
3/29/05
REMOTE START (RMST) PARTS REQUIRED: Securilock (PATS) Interface: 2004-2005 - 1L3Z-19G365-AB (Excursion Only) Tach Inverter: 2004-2006 - Part # 5C3Z-17C304-AA (6.0 Liter Diesel Vehicles)
DOME LIGHT**
15 15 15 15
15 15 15 5 15
15
15
15
15
15
HVAC 1* HVAC 2*
MAIN B+ IGNITION*
2 - Door Lock/Unlock (W/O Factory RKE) 1 - Headlight Illumination (Optional) 1 - Driver's Door Priority Unlock (Optional) VEHICLE SPECIFIC PROGRAMMING:
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system.
MODULE MOUNTING LOCATION: Upper Left side of the driver's underdash behind fuse panel near parking brake assembly.
Vehicle (Year/Make/Model)
W/Factory RKE
Page
RKE/VSS/RMST
Revision Date
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + DRIVER'S DOOR JAMB BOOT HARNESS DRIVER'S SIDE KICK PANEL HARNESS
NOTE: If vehicle is equipped with trim switch disable, refer to page 4 for the wiring diagram
Vehicle (Year/Make/Model)
RKE/VSS/RMST
Revision Date
Yellow
87
87a Black
85
White
86 30
Red Blue
IGNITION SWITCH
Yellow
87
White 87a Black
CUT
85 30
86
Red Blue
Optional Installation Feature See Optional connections page Cut and tape off if not used
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
Battery (YELLOW) +
4 of 5
3/31/05
Battery (LT. GREEN/VIOLET) + Battery (DK. BLUE/ORANGE) + Ignition (RED/GREEN) + + + IGNITION SWITCH
Color
A-4 B-2 B-1 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 A-3 C-10 C-11 C-8 RED RED BLUE PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN BLACK/WHITE RED/WHITE BLUE/WHITE BLUE
Function
Battery HVAC1 Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Dome Light Output Headlight Output Rear Defrost Output Trunk Ajar Input
Cut and tape off if not used Optional Installation Feature See Optional connections page
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
87
87a
85 30
86
Black
IGNITION SWITCH
Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
Color
C-11 C-10 BLUE/WHITE RED/WHITE
Function
Rear Defroster Output Headlight
Excursion only
DEFROSTER SWITCH
Headlight
Yellow White
87
87a
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Black Blue
IMPORTANT!
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
85 30
86
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
Battery (YELLOW)
Battery (LT. GREEN/VIOLET) + Battery (DK. BLUE/ORANGE) + Ignition (RED/GREEN) + IGNITION SWITCH
1 of 2
3/31/05
Color
A-4 B-2 B-1 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 RED RED BLUE PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN
Function
Battery HVAC1 Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
KEY SIDE (after cut) Key-in-Sense (BLACK/PINK) Horn (DK. BLUE) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
BRAKE SWITCH
Color
A-1 A-5 WHITE BLACK
Function
Parking Light Output Ground
CHASSIS GROUND POINT IN DRIVERS KICK PANEL MAKE THIS CONNECTION FIRST!
Vehicle (Year/Make/Model)
All
Page
RMST
Revision Date
2 of 2
3/14/05
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
OR
IGNITION SWITCH
Tach Inverter Part # 5C3Z-17C304-AA Required For All 6.0 Liter Diesel Applications
Vehicle (Year/Make/Model)
W/Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
3/30/05
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Connect only on vehicles with factory RKE Optional Installation Feature See Optional connections page Cut and tape off if not used Parking Lights (BROWN) + DRIVER DOOR JAMB BOOT HARNESS DRIVER'S SIDE KICK PANEL HARNESS
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
Deluxe RKE/VSS
Revision Date
Yellow
87
87a Black
2 of 4
3/30/05
85
White
86 30
Red Blue
CUT
Yellow
87
White 87a Black
CUT
85 30
86
Red Blue
Optional Installation Feature See Optional connections page Cut and tape off if not used
Color
A-20 A-1 GREEN/VIOLET WHITE
Function
Door Ajar Switch Input Parking Light Output Dome Light (BLACK/LT. BLUE) + Park Lights (BROWN) + DRIVER SIDE KICK PANEL
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
3/30/05
Ignition (RED/GREEN) +
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-3 C-10 C-8 RED PINK VIOLET VIOLET/RED BROWN/BLACK BLACK/WHITE RED/WHITE BLUE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Dome Light Output Headlight Output Trunk Ajar Input
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
HEADLIGHT SWITCH
85 30
86
Blue
Black
+ + HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
4 of 4
3/14/05
White
Yellow
87
87a
OPTIONAL CONNECTIONS
85
86 30
Black
IGNITION SWITCH
Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
3/14/05
Passenger Door Unlock (PINK/ORANGE) + DRIVER'S SIDE KICK PANEL HARNESS
Color
A-5 A-12 A-11 A-9 A-20 BLACK LT.GREEN WHITE/BLUE BROWN GREEN/VIOLET
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input Door Ajar Switch Input
DRIVER DOOR JAMB BOOT HARNESS REAR OF DRIVER SIDE SILL PLATE HARNESS
+ + IGNITION SWITCH
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN DRIVER SIDE KICK PANEL OR HEADLIGHT SWITCH
Color
A-1 WHITE
Function
Parking Light Output Park Lights (BROWN) +
Vehicle (Year/Make/Model)
Yellow
1 of 1
3/30/05
85
White
87
87a Black
86 30
Red Blue
CUT
Yellow
87
Black
CUT
85 30
86
Red Blue
Color
A-20 A-1 GREEN/VIOLET WHITE
Function
Door Ajar Switch Input Parking Light Output Dome Light (BLACK/LT. BLUE) + Park Lights (BROWN) + MAKE THIS CONNECTION LAST! Battery (YELLOW) + + IGNITION SWITCH REAR OF DRIVER'S DOOR SILL PLATE HARNESS
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 A-3 RED PINK VIOLET VIOLET/RED BROWN/BLACK BLACK/WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Dome Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
3/14/05
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
w/Factory RKE
Page
Preload
Revision Date
1 of 1
3/30/05
Door Lock (WHITE/RED) Door Unlock (BLACK/WHITE) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + DRIVER'S SIDE KICK PANEL HARNESS
Color
A-5 A-2 A-14 A-12 A-11 A-9 C-4 BLACK BLUE GREEN LT. GREEN WHITE/BLUE BROWN LT.GREEN/BLACK
Function
Ground Lock Output Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Perimeter Disarm Output
Driver Door Unlock Motor (RED/ORANGE) + Driver Door Ajar (YELLOW/BLACK) Dome Light (BLACK/LT. BLUE) + Park Lights (BROWN) + MAKE THIS CONNECTION LAST!
Color
A-20 A-1 GREEN/VIOLET WHITE
Function
Door Ajar Switch Input Parking Light Output REAR OF DRIVER'S DOOR SILL PLATE HARNESS
Ignition (RED/GREEN)
Color
A-4 A-7 A-8 A-6 A-21 A-3 RED PINK VIOLET VIOLET/RED BROWN/BLACK BLACK/WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Dome Light Output Starter + (DARK GREEN) CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
Preload
Revision Date
1 of 1
3/30/05
Yellow
87
87a Black
85
White
86 30
Red Blue
IGNITION SWITCH
Yellow
87
Black
CUT
85
86 30
Red Blue
Color
A-20 A-1 GREEN/VIOLET WHITE
Function
Door Ajar Switch Input Parking Light Output
Dome Light (BLACK/LT. BLUE) + Park Lights (BROWN) + MAKE THIS CONNECTION LAST! Battery (YELLOW) + +
Ignition (RED/GREEN)
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-3 RED PINK VIOLET VIOLET/RED BROWN/BLACK BLACK/WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Dome Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
System(s) applicable to:
02 Expedition/Navigator
Equipment or Trim level
ALL
Page
ALL
Revision Date
1 of 1
1/5/04
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start) 2002: 1L3Z-19G365-AB
DOME LIGHT**
RELAY REQUIREMENTS: 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 2 - MEMORY SEATS (OPTIONAL) 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)
15
15 15 15
15
15
15
15
15
15
15
15
15
VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Unlock switch sense polarity Key in Sense polarity Aux 2 (Rear Defrost) Positive (Default setting) Positive (Default setting) Negative (Default setting) 0.5 sec. (Default setting)
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
MODULE MOUNTING LOCATION: Driver side kick panel high, near bulkhead panel.
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 4 1/5/04 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-2 A-14 A-12 A-11 A-9 A-24 A-20 A-3 C-4 BLACK BLUE GREEN LT.GREEN WHITE/BLUE BROWN BLUE/GREEN GREEN/VIOLET BLACK/WHITE LT.GREEN/BALCK Ground Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Driver Door Unlock Output Door Ajar Switch Input Dome Light Output Perimeter Alarm Disarm
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + KEYLESS ENTRY MODULE LEFT OF BRAKE PEDAL
Optional Installation Feature See Optional connections page Cut and tape off if not used Dome Light (BLACK/BLUE) +
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground Do Not Ground to Hood! Tach Signal (TAN) FUEL INJECTOR
Vehicle (Year/Make/Model)
02/03 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
MAKE THIS CONNECTION LAST! Battery (YELLOW) Battery (YELLOW) Battery (YELLOW) Ignition (BLUE/GREEN) + + + + + + IGNITION SWITCH
2 of 4
1/5/04
Function
Battery HVAC1 Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Headlight Output Rear Defrost Output Cut and tape off if not used
CUT
BRAKE SWITCH
Function
Parking Light Output
Park Lights (BROWN) Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column.
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON Yellow
87
White
87a
3 of 4 1/5/04 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVERS DOOR PRIORITY UNLOCK Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Function
Rear Defrost Output Headlight Output Rear Defroster (BLUE/ORANGE)
Yellow White IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87a
87
Black Blue
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
85 30
86
+ +
HEADLIGHT SWITCH
Headlight
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
4 of 4
1/5/04
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
1/5/04
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor + (RED/ORANGE) Passenger Door Unlock (PINK/ORANGE) + Connect only on vehicles with factory RKE Optional Installation Feature See Optional connections page Cut and tape off if not used Driver Door Latch Switch (BLACK/YELLOW) DRIVER KICK PANEL HEADLIGHT SWITCH KEYLESS ENTRY MODULE LEFT OF BRAKE PEDAL
Function
Ground Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Input Driver Door Unlock Output DO NOT USE DO NOT USE Perimeter Disarm Output
Function
Park Light Output Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column. Dome Light (BLACK/BLUE) + Park Lights (BROWN) +
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
1/5/04
Ignition (BLUE/GREEN)
IGNITION SWITCH
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Headlight Output Rear Defrost Output
Starter + (RED/BLUE)
Horn (BLUE)
Yellow White
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
1/5/04
87
87a
Yellow
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
OPTIONAL CONNECTIONS
White
85 30
86
Black
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
UNDERHOOD Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional) Chassis ground Do Not Ground to Hood!
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 2
1/5/04
Passenger Door Unlock (PINK/ORANGE) + KEYLESS ENTRY MODULE LEFT OF BRAKE PEDAL
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input Door Ajar
+ IGNITION SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (BLUE)
Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column.
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
VSS
Revision Date
2 of 2
5/30/03
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
02 Expedition/Navigator
Equipment or Trim level System(s) applicable to:
ALL
Page
PRELOAD
Revision Date
1 of 1
1/5/04
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS ABOVE DRIVERS KICK PANEL KEYLESS ENTRY MODULE LEFT OF BRAKE PEDAL
Color
C-4 LT.GREEN/BLACK
Function
Factory Alarm Disarm Output Driver Door Ajar Switch (BLACK/YELLOW) -
*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Function
Park Light Output MAKE THIS CONNECTION LAST! Park Lights (BROWN) +
HEADLIGHT SWITCH
Battery (YELLOW)
+ IGNITION SWITCH KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Starter + (RED/BLUE)
Horn (BLUE)
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
ALL
Page
ALL
Revision Date
1 of 1
3/28/05
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
2003-2006: 1L2Z-19G365-AB
15
RELAY REQUIREMENTS: 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL) 1 - POWER RUNNING BOARD DEPLOYMENT VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Positive (Default setting) Unlock switch sense polarity Positive (Default setting) Key in Sense polarity Positive Rear Defroster 0.5 Sec pulse (default)
15
15
15
15
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
15
15
15
15
MODULE MOUNTING LOCATION: Above hood release cable near bulkhead panel, in front of parking brake.
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 4 3/28/05 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-20 A-2 A-14 A-11 A-9 A-12 A-24 C-9 C-12 C-13 C-2 C-8 BLACK GREEN/VIOLET BLUE GREEN WHITE/BLUE BROWN LT GREEN BLUE/GREEN TAN/RED GREEN/WHITE YELLOW/GREEN BLACK/GREEN BLUE Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Driver Door Unlock Output DO NOT USE Memory Seat 1 Output Memory Seat 2 Output Motorized Rear Gate Output Trunk Ajar Input
Dome Light (BLACK/LT. BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Unlock Switch Sense (PINK/ORANGE) + HARNESS UNDER DRIVERS SIDE REAR DOOR SILL PLATE
CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE Flip Up Glass (WHITE/VIOLET) Siren (w/VSS only) KEYLESS ENTRY MODULE
Color
A-13 TAN
Function
Hatch Release Output
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Chassis ground
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 4
3/29/05
MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) + Battery (LT. GREEN/VIOLET) + IGNITION SWITCH
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 A-3 C-10 C-11 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE BLACK/WHITE RED/WHITE BLUE/WHITE
Function
Battery HVAC 1 12 volt Battery Feed Ignition 1 Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Dome Light Output Headlight Output Rear Defroster Output
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
3 of 4 3/28/05 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK Color Function
A-24 A-9 BLUE/GREEN BROWN Driver Door Unlock Output Disarm Input
White
87a
IGNITION SWITCH
CUT
87
Black
85 30
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
86 Red
Blue
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Headlight
Rear Defroster (DK. BLUE/ORANGE)
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
4 of 4 3/28/05 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS (con't) MEMORY SEATS (IF EQUIPPED)
Color
C-12 C-13 GREEN/WHITE YELLOW/GREEN
Function
Memory Seat 1 Memory Seat 2
Color
A-15 C-4
Function
Key-in-Sense (BLACK/PINK) +
Yellow
IGNITION SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
85 30
86
Black Blue
Color
C-2 BLACK/GREEN
Function
Motorized Rear Gate Power Lift Gate (GRAY/RED)
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) + Battery (LT. GREEN/VIOLET) + IGNITION SWITCH
1 of 1
3/29/05
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE
Function
Battery HVAC 1 12 volt Battery Feed Ignition 1 Input/Output HVAC Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) FUEL INJECTOR
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
3/28/05
Dome Light (BLACK/LT. BLUE) +
Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Unlock Switch Sense (PINK/ORANGE) + Optional Installation Feature See Optional connections page Optional Installation Feature See Optional connections page HARNESS UNDER DRIVERS SIDE REAR DOOR SILL PLATE HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE Flip Up Glass (WHITE/VIOLET) KEYLESS ENTRY MODULE
Color
A-13 TAN
Function
Hatch Release Output
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
3/28/05
Ignition (DK. BLUE/LT. GREN) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 A-3 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE BLACK/WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Dome Light Output Headlight Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different! White
HEADLIGHT SWITCH
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Color
A-15 C-4
Function
Yellow
Key-in-Sense (BLACK/PINK) +
IGNITION SWITCH
87
White
87a
85 30
86
Black Blue
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
3/28/05
IGNITION SWITCH
CUT
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input 87
White
87a
Black
85 30
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
86 Red
Blue
IMPORTANT!
UNDERHOOD HARNESS
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
Color
C-2 BLACK/GREEN
Function
Motorized Rear Gate Power Lift Gate (GRAY/RED)
Vehicle (Year/Make/Model)
ALL
Page
VSS
Revision Date
1 of 2
3/28/05
Dome Light (BLACK/LT. BLUE) + Driver Door Unlock Motor + (RED/ORANGE)) Lock Motor (PINK/BLACK) +
Color
A-5 A-20 A-9 A-11 A-12 BLACK GREEN/VIOLET BROWN WHITE/BLUE LT. GREEN
Function
Ground Door Ajar Switch Input Disarm Input Arm Input Unlock Switch Sense Input
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) STEERING COLUMN HARNESS HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
VSS
Revision Date
2 of 2
3/28/05
OPTIONAL CONNECTIONS
UNDERHOOD
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
ALL
Page
Preload
Revision Date
1 of 1
3/29/05
Dome Light (BLACK/LT. BLUE) +
Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS UNDER DRIVERS SIDE REAR DOOR SILL PLATE KEYLESS ENTRY MODULE HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-13 TAN
Function
Hatch Release Output MAKE THIS CONNECTION LAST! Battery (LT. GREEN/VIOLET) + Flip Up Glass (WHITE/VIOLET)
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 A-3 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE BLACK/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Dome Light Output
HEADLIGHT SWITCH
SK5W7J-19A361-AB
Vehicle (Year/Make/Model)
ALL
Page
ALL
Revision Date
1 of 1
6/21/04
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
2002-05: 1L2Z-19G365-AB
RELAY REQUIREMENTS:
15
15
15
15
15
15
15
15
15
15
15
15
15
HVAC 1* HVAC 2*
Door trigger polarity Unlock switch sense polarity Key in Sense polarity Rear Defroster
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
MODULE MOUNTING LOCATION: Left side of under dash between fuse/junction box and bulkhead panel.
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 4 6/16/04 (NOTE: ALSO INCLUDES RKE/RMST DRIVERS SIDE KICK PANEL HARNESS
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Factory Alarm Disarm (GREEN/VIOLET) HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-13 A-24 C-12 C-13 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK TAN BLUE/GREEN GREEN/WHITE YELLOW/GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Hatch Release Driver Door Unlock Output Memory Seat 1 Output Memory Seat 2 Output
Optional Installation Feature See Optional connections page Siren (VSS only)
UNDERHOOD HARNESS
Cut and tape off if not used Vehicle Interior Underhood RED BLACK HOOD TILT SWITCH
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Chassis ground Do Not Ground to Hood! Tach Signal (PINK/WHITE) IGNITION COIL
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 4
6/21/04
Ignition (RED/GREEN) + Heater (GREEN/LT. GREEN) +
Starter (RED)
Color
A-4 RED B-2 RED A-7 PINK B-4 ORANGE A-8 VIOLET A-6 VIOLET/RED B-8 BLACK/WHITE A-21 BROWN/BLACK B-7 BROWN A-1 WHITE C-10 RED/WHITE C-11 BLUE WHITE C-8 BLUE
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output Rear Defroster Output Trunk Ajar Input
Brake light (TAN/BLACK) + CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR Parking lights (BROWN) + Cut and tape off if not used
BRAKE SWITCH
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
87
87a
3 of 4
6/21/04
85
White
86 30
Blue
Black
+ HEADLIGHT SWITCH
Headlight
'03-'05 Headlights (RED/BLACK) '02 Rear Defroster (BLUE/ORANGE) '03-'05 Rear Defroster (GRAY/BLUE) REAR DEFROST SWITCH
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
FUSE 15-AMP
Battery (YELLOW) +
IGNITION SWITCH
CUT
Function
Driver Door Unlock Output Disarm Input
White
87
Black
87a
85
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86 30 Red
Blue
NOTE: Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON
Vehicle (Year/Make/Model)
w/Factory RKE
Page
RKE/VSS/RMST
Revision Date
4 of 4
6/21/04
Memory Seat1 (BROWN/LT GREEN) UNDER DRIVERS DOOR SILL PLATE Memory Seat 2 (BLACK/ORANGE)
Color
C-12 GREEN/WHITE C-13 YELLOW/GREEN
Function
Memory Seat 1 Output Memory Seat 2 Output
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
1 of 1
6/21/04
Starter (RED) +
+ + IGNITION SWITCH
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (PINK/WHITE) IGNITION COIL
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
6/21/04
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-13 A-24 C-12 C-13 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK TAN BLUE/GREEN GREEN/WHITE YELLOW/GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Hatch Release Output Driver Door Unlock Output Memory Seat 1 Output Memory Seat 2 OutpuT
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Factory Alarm Disarm (GREEN/VIOLET) HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
6/21/04
Ignition (RED/GREEN) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 C-8 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE BLUE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output Trunk Ajar Input
Starter (RED)
Horn (YELLOW/GREEN) CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
HEADLIGHT SWITCH
Yellow White IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87a
85
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
3 of 3
6/21/04
FUSE 15-AMP
OPTIONAL CONNECTIONS
Battery (YELLOW) +
IGNITION SWITCH
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
White
Yellow
CUT
87
87a
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
85 30
86 Red
Blue
IMPORTANT!
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
UNDERHOOD HARNESS
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Chassis ground Hood Tilt Switch (Optional) Do Not Ground to Hood!
Memory Seat1 (BROWN/LT GREEN) UNDER DRIVERS DOOR SILL PLATE Memory Seat 2 (BLACK/ORANGE)
Color
C-12 GREEN/WHITE C-13 YELLOW/GREEN
Function
Memory Seat 1 Output Memory Seat 2 Output
Vehicle (Year/Make/Model)
ALL
Page
VSS
Revision Date
1 of 2
6/21/04
Color
A-5 A-20 A-12 A-11 A-9 BLACK GREEN/VIOLET LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input
Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
+ IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
ALL
Page
VSS
Revision Date
2 of 2
6/21/04
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Preload
Revision Date
1 of 1
6/21/04
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-2 A-14 A-12 A-11 A-9 A-13 BLACK GREEN/VIOLET BLUE GREEN LT.GREEN WHITE/BLUE BROWN TAN
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Hatch Release Output
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Rear Hatch Release (PINK/ORANGE) HARNESS UNDER DRIVERS SIDE REAR DOOR SILL PLATE HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
C-4
Function
Factory Alarm Disarm (GREEN/VIOLET) -
*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Starter (RED)
KEY SIDE (after cut) Horn (YELLOW/GREEN) Parking lights (BROWN) + IGNITION SWITCH HEADLIGHT SWITCH
SK5W7J-19A361-AB
A LL
1 of 1
Revision Date
6/16/05
REMOTE START (RMST) PARTS REQUIRED: Securilock (PATS) Interface: 2006 - 1L2Z-19G365-AB (Kit 3)
P K L IG H T S D O O R L O C K S **
D O ME L I G H T ** F L IP U P G L A S S
REMOTE START (RMST) SPECIFIC PRORAMMING: Key in Sense polarity Positive Required on all vehicles
Learn Tachometer
15
15
15
15
15
15
15
15
15
15
RELAY REQUIREMENTS:
1 - Driver's Door Priority Unlock (Optional)
MA I N B + IG N IT IO N *
15
15
15
H V AC 1* H V AC 2*
*O nly us e d on ( P C -3 2 ) s ys te ms with C a r S ta rt ( R MS T ) ** N ot us e d on V S S s ys te m
Positive (Default setting) Door trigger polarity Unlock switch sense polarity Negative MODULE MOUNTING LOCATION:
Note: If vehicle is equipped with power deployable running boards that are set to "automatic", technician may have to enable this feature through the message center when the battery is disconnected. See owner's manual for instructions.
RKE/VSS/RMST
Revision Date
1 of 3
7/8/05
Co l o r
Fu n ct i o n
Ground MAKE THIS CONNECTION LAST! Battery (VIOLET/RED) + IGNITION SWITCH HARNESS
Battery HVAC1 Battery Feed Ignition 1 Input/Output HVAC1 Output Key-in-sense Input Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output Brake Input
CUT Key Side After Cut Horn (BLUE/WHITE) Brake Switch (VIOLET/WHITE) + STEERING COLUMN HARNESS
UNDERHOOD HARNESS
A-19 B-9 GRAY VIOLET/WHITE
Co l o r
Fu n ct i o n
Vehicle Interior
Underhood
Chassis ground
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
NOTE: There are 2 different VIOLET/GRAY connections in the driver's kick panel test carefully
2 of 3
6/16/05
Lock Motor (GRAY/BROWN) + Driver's Door Unlock Motor + (BLUE/GREEN) Door Lock Switch (GRAY/YELLOW) Door Unlock Switch (VIOLET/GRAY) Flip Out Glass (BROWN) DRIVER'S KICK PANEL
Color
A-20 A-11 A-9 A-2 A-14 A-12 A-13 A-1 A-3 A-24 C-10 GREEN/VIOLET WHITE/BLUE BROWN BLUE GREEN LT. GREEN TAN WHITE BLACK/WHITE BLUE/GREEN RED/WHITE
Function
Door Ajar Switch Input Arm Input Disarm Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Trunk Release Output Parking Light Output Dome Light Output Driver Door Unlock Output Headlight Output
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
RKE/VSS/RMST
Revision Date
87
White
Yellow
Battery (VIOLET/RED) +
85
87a
30
86
Black
Co l o r
A-24 A-9 BLUE/GREEN BROWN
Fu n ct i o n
Driver Door Unlock Output Disarm Input
CUT
Rel ay s s h o w n are n o t s u p p l i ed i n kit . Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
HEADLIGHTS
C-10
Co l o r
RED/WHITE
Headlight Output
Fu n ct i o n
Headlamps (BLUE/WHITE)
HEADLAMP SWITCH
MEMORY SEATS
Co l o r
C-12 C-13
Fu n ct i o n
Vehicle (Year/Make/Model)
ALL
Page
RMST
Revision Date
1 of 1
6/16/05
Color
A-5 BLACK
Function
Ground
Battery (VIOLET/RED) +
Function
Battery HVAC1 Battery Feed Ignition 1 Input/Output HVAC1 Output Key-in-sense Input Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output Brake Input Parking Light Output
X
CUT
Horn (BLUE/WHITE) STEERING COLUMN HARNESS Brake Switch (VIOLET/WHITE) + HEADLAMP SWITCH
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wirewill result in vehicle damage!
Chassis ground
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
6/16/05
MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVERS KICK PANEL
Color
A-5 BLACK
Function
Ground
Function
Battery Ignition 1 Input/Output Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output
X
CUT
Horn (BLUE/WHITE)
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: There are 2 different VIOLET/GRAY connections in the driver's kick panel test carefully
2 of 3
6/16/05
Lock Motor (GRAY/BROWN) + Driver's Door Unlock Motor + (BLUE/GREEN) Door Lock Switch (GRAY/YELLOW) Door Unlock Switch (VIOLET/GRAY) Flip Out Glass (BROWN) DRIVER'S KICK PANEL
Color
A-20 A-11 A-9 A-2 A-14 A-12 A-13 A-1 C-10 A-3 A-24 GREEN/VIOLET WHITE/BLUE BROWN BLUE GREEN LT. GREEN TAN WHITE RED/WHITE BLACK/WHITE BLUE/GREEN
Function
Door Ajar Switch Input Arm Input Disarm Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Trunk Release Output Parking Light Output Headlight Output Dome Light Output Driver Door Unlock Output
Parking Lights (GRAY) Optional Installation Feature See Optional connections Headlamps (BLUE/WHITE)
HEADLAMP SWITCH
DIMMER SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
3 of 3
6/16/05
87
Yellow
Battery (VIOLET/RED) +
OPTIONAL CONNECTIONS
White
87a
85 30
86
Black
Co l o r
A-24 A-9 BLUE/GREEN BROWN
Fu n c t i o n
Driver Door Unlock Output Disarm Input
CUT
Rel ay s s h o w n are n o t s u p p l i ed i n kit . Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
MEMORY SEATS
Co l o r
C-12 C-13
Fu n c t i o n
UNDERHOOD
Co l o r
A-19 GRAY
Fu n c t i o n
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - Not supplied in kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS
Revision Date
1 of 1
6/16/05
Color
A-5 BLACK
Function
Ground
Function
Battery Ignition 1 Input/Output Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output
X
CUT
Horn (BLUE/WHITE)
Function
Door Ajar Switch Input Door Lock Output Door Unlock Output Trunk Release Output Parking Light Output Dome Light Output
Door Lock Switch (GRAY/YELLOW) Door Unlock Switch (VIOLET/GRAY) Flip Out Glass (BROWN)
NOTE: There are 2 different VIOLET/GRAY wires in the driver's kick panel test carefully
Vehicle (Year/Make/Model)
ALL
Page
VSS
Revision Date
1 of 1
6/16/05
Color
A-5 BLACK
Function
Ground
Function
Battery Ignition 1 Input/Output Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output
X
CUT
Horn (BLUE/WHITE)
Lock Motor (GRAY/BROWN) + Driver's Door Unlock Motor + (BLUE/GREEN) Door Unlock Switch (VIOLET/GRAY) HEADLAMP SWITCH DIMMER SWITCH
Color
A-20 A-11 A-9 A-12 A-1 A-3 GREEN/VIOLET WHITE/BLUE BROWN LT. GREEN WHITE BLACK/WHITE
Function
Door Ajar Switch Input Arm Input Disarm Input Unlock Switch Sense Input Parking Light Output Dome Light Output
NOTE: There are 2 different VIOLET/GRAY wires in the driver's kick panel test carefully
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
6/16/05
OPTIONAL CONNECTIONS
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
ALL
Page
PRELOAD
Revision Date
1 of 1
6/16/05
Color
A-5 BLACK
Function
Ground MAKE THIS CONNECTION LAST! Battery (VIOLET/RED) + Ignition (WHITE/ORANGE) + Starter (BLUE/WHITE) + IGNITION SWITCH HARNESS
Function
Battery Ignition 1 Input/Output Starter Interrupt Motor Side Starter Interrupt Key Side Horn Relay Output
X
CUT
Horn (BLUE/WHITE)
Lock Motor (GRAY/BROWN) + Driver's Door Unlock Motor + (BLUE/GREEN) Door Lock Switch (GRAY/YELLOW) Door Unlock Switch (VIOLET/GRAY) Flip Out Glass (BROWN) DRIVER'S KICK PANEL
Color
A-20 A-11 A-9 A-2 A-14 A-12 A-13 A-1 GREEN/VIOLET WHITE/BLUE BROWN BLUE GREEN LT. GREEN TAN WHITE
Function
Door Ajar Switch Input Arm Input Disarm Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Trunk Release Output Parking Light Output
NOTE: There are 2 different VIOLET/GREY connections in the driver's kick panel test carefully
HEADLAMP SWITCH
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
1/5/04
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
15
15
RELAY REQUIREMENTS: 1 - REAR DEFROST (OPTIONAL) 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR UNLOCK PRIORITY (OPTIONAL) VEHICLE SPECIFIC PROGRAMMING:
15
15
15
15
15
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
15
15
15
15
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Door trigger polarity Unlock switch sense polarity Key in Sense polarity Aux 2 (Rear Defrost)
MODULE MOUNTING LOCATION: Above hood release cable near bulkhead panel, in front of emergency brake.
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3 5/30/03 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 A-13 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN TAN TAN/RED Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) IGNITION COIL
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
MAKE THIS CONNECTION LAST! Battery (YELLOW) Battery (YELLOW) Battery (YELLOW) Ignition (GREEN/VIOLET) + + + + + + IGNITION SWITCH
2 of 3
5/30/03
Function
Battery HVAC2 Feed HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output Rear Defroster Output
Starter + (RED/BLUE)
BRAKE SWITCH
Parking lights (WHITE/BLACK) Optional Installation Feature See Optional connections page
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneath the drivers side door sill plate. Wire changes to BROWN (+).
Vehicle (Year/Make/Model)
Yellow
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
3 of 3 1/5/04 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVERS DOOR PRIORITY UNLOCK Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85
Yellow White
86 30
Blue
Black
+ +
HEADLIGHT SWITCH
87
87a
Headlight
86
Black
85 30
Rear Defroster
Blue IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
+ + + + + + IGNITION SWITCH
ALL
Page
RMST
Revision Date
1 of 1
5/30/03
Function
Battery HVAC2 Feed HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Note: Parking light circuit can also be found in the wiring harness that runs underneth the drivers side door sill plate. Wire color changes to BROWN (+).
Function
Ground MAKE THIS CONNECTION FIRST!
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) IGNITION COIL
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
5/30/03
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
1/5/04
Ignition (GREEN/VIOLET)
IGNITION SWITCH
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (RED/BLUE)
Horn (YELLOW/GREEN)
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneth the drivers side door sill plate. Wire changes to BROWN (+).
Yellow White
87
87a
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
1/5/04
Yellow
OPTIONAL CONNECTIONS
White
87
87a
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
85 30
86
Black
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Connect to the half of the wire going back into the vehicles interior
UNDERHOOD Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
CHASSIS GROUND POINT IN DRIVERS KICK PANEL HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
1 of 1
5/30/03
Dome Light (BLACK/BLUE) +
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) DRIVER DOOR JAMB BOOT HARNESS
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (YELLOW/GREEN) Note: Parking light circuit can also be found in the wiring harness that runs underneth the drivers side door sill plate. Wire color changes to BROWN (+).
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
5/30/03
Dome Light (BLACK/BLUE) +
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input
+ IGNITION SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Note: Parking light circuit can also be found in the wiring harness that runs underneth the drivers side door sill plate. Wire color changes to BROWN (+).
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
5/30/03
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
ALL
Page
Preload
Revision Date
1 of 1
1/5/04
Dome Light (BLACK/BLUE) +
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Connect only on vehicles with factory RKE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Color
C-4 LT.GREEN/BLACK
Function
Factory Alarm Disarm Output Driver Door Ajar Switch (YELLOW/BLACK) -
*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Battery (YELLOW) + Ignition (GREEN/VIOLET) Starter + (RED/BLUE) CUT KEY SIDE (after cut) Horn (YELLOW/GREEN) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH + IGNITION SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
ALL
Page
ALL
Revision Date
1 of 1
7/6/04
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
2004-2005: 1L2Z-19G365-AB
15
15
RELAY REQUIREMENTS: 1 - REAR DEFROST (OPTIONAL) 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR UNLOCK PRIORITY (OPTIONAL) VEHICLE SPECIFIC PROGRAMMING:
15
15
15
15
15
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
15
15
15
15
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Door trigger polarity Unlock switch sense polarity Key in Sense polarity Aux 2 (Rear Defrost)
MODULE MOUNTING LOCATION: Above hood release cable near bulkhead panel, in front of emergency brake.
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3 7/6/04 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 A-13 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN TAN TAN/RED Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground Do Not Ground to Hood! Tach Signal (WHITE/YELLOW) IGNITION COIL
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 3
7/6/04
+ + + IGNITION SWITCH
Heater (BROWN)
Heater (GRAY/YELOW) +
Color
A-4 B-1 B-2 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 A-1 C-10 C-11 RED BLUE RED PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE RED/WHITE BLUE/WHITE
Function
Battery HVAC2 Feed HVAC1 12 volt Battery Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output Rear Defroster Output
Starter + (RED/BLUE)
BRAKE SWITCH
Parking lights (BROWN) Optional Installation Feature See Optional connections page
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneath the driver's side door sill plate. Wire changes to BROWN (+).
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON Yellow
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
Battery (RED) +
IGNITION SWITCH
3 of 3 7/6/04 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85
Yellow White
86 30
Blue
Black
+ +
HEADLIGHT SWITCH
87
87a
Headlight
86
Black
85 30
Rear Defroster
Blue IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
+ + + + + IGNITION SWITCH
ALL
Page
RMST
Revision Date
1 of 1
7/6/04
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (WHITE/YELLOW) IGNITION COIL
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
7/6/04
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 A-13 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN TAN TAN/RED
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
1/5/04
Ignition (GREEN/VIOLET) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (RED/BLUE)
Horn (YELLOW/GREEN)
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).
Yellow White
87
87a
85 30 Note: Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
1/5/04
87
87a
Yellow
Battery (RED) +
IGNITION SWITCH
OPTIONAL CONNECTIONS
White
85 30
86
Black
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
CUT
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
CHASSIS GROUND POINT IN DRIVERS KICK PANEL HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
1 of 1
7/6/04
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-3 A-2 A-14 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) DRIVER DOOR JAMB BOOT HARNESS
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
7/6/04
Dome Light (BLACK/BLUE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-12 A-11 A-9 BLACK GREEN/VIOLET LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
7/6/04
OPTIONAL CONNECTIONS
UNDERHOOD
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
ALL
Page
Preload
Revision Date
1 of 1
7/6/04
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-2 A-14 A-12 A-11 A-9 BLACK GREEN/VIOLET BLUE GREEN LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Connect only on vehicles with factory RKE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Color
C-4
Function
Driver Door Ajar Switch (YELLOW/BLACK) -
*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Battery (RED) + Ignition (GREEN/VIOLET) Starter + (RED/BLUE) CUT KEY SIDE (after cut) Horn (YELLOW/GREEN) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
ALL
Page
ALL
Revision Date
1 of 1
1/5/04
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start) 2002: 1L3Z-19G365-AB 2003: 1L3Z-19G365-AB 2004: 1L3Z-19G365-AB RELAY REQUIREMENTS: 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL) 2 - DOOR LOCK/UNLOCK VEHICLES w/o RKE VEHICLE SPECIFIC PROGRAMMING:
MAIN B+ IGNITION*
DOME LIGHT**
15
15 15 15 5
15
15
15
15
15
15
15
15
15
HVAC 1* HVAC 2*
Door trigger polarity Positive (Default setting) Unlock switch sense polarity Positive (Default setting) Key in Sense polarity Negative (Default setting)
* Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system.
MODULE MOUNTING LOCATION: Driver side kick panel high, near bulkhead panel.
Vehicle (Year/Make/Model)
W/Factory RKE
Page
RKE/VSS/RMST
Revision Date
1 of 4 1/5/04 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-2 A-14 A-12 A-11 A-9 A-20 A-3 C-4 A-24 BLACK BLUE GREEN LT.GREEN WHITE/BLUE BROWN GREEN/VIOLET BLACK/WHITE LT.GREEN/BALCK BLUE/GREEN Ground Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Door Ajar Switch Input Dome Light Output Perimeter Alarm Disarm Driver Door Unlock Output
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS ABOVE DRIVERS KICK PANEL KEYLESS ENTRY MODULE LEFT OF BRAKE PEDAL
Optional Installation Feature See Optional connections page Cut and tape off if not used
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground Do Not Ground to Hood! Tach Signal (TAN) FUEL INJECTOR
Vehicle (Year/Make/Model)
87
87a Black
Fuse 15 AMP
86 30
Red Blue
CUT
Function
Ground Door Lock Output Door Unlock Output Door Ajar Switch Input Dome Light Output Driver Door Unlock Output
Yellow
CUT
87
White 87a
85 Optional Installation Feature See Optional connections page Cut and tape off if not used
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
86 30
Red Blue
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Chassis ground Do Not Ground to Hood! Tach Signal (TAN) FUEL INJECTOR
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
3 of 4
1/5/04
Function
Battery HVAC1 12 volt Battery Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Headlight Output
CUT
BRAKE SWITCH
Function
Parking Light Output Park Lights (BROWN) Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column.
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
4 of 4 1/5/04 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVERS DOOR PRIORITY UNLOCK Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Function
Siren Feed Driver Door Unlock Output Disarm Input
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
Connect to the half of the wire going back into the vehicles interior
DEFROSTER SWITCH
Function
Headlight Output Rear Defroster Output
Yellow White IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Headlight
Vehicle (Year/Make/Model)
Battery (YELLOW) Battery (YELLOW) Battery (YELLOW) Ignition (BLUE/GREEN) Heater (RED/BLACK)
+ + + + + + IGNITION SWITCH
ALL
Page
RMST
Revision Date
1 of 1
1/5/04
Heater (GRAY/YELLOW)
Function
Battery HVAC1 12 volt Battery Feed HVAC 2 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
Starter + (RED/BLUE)
CUT
Function
Parking Light Output
Function
Ground
HEADLIGHT Park Lights (BROWN) + SWITCH Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column. CHASSIS GROUND POINT IN DRIVERS KICK PANEL MAKE THIS CONNECTION FIRST! Vehicle Interior Underhood HOOD TILT SWITCH
Function
Hood Open Switch Input Tach Sense Input
Chassis ground Do Not Ground to Hood! Tach Signal (TAN) FUEL INJECTOR
Vehicle (Year/Make/Model)
W/Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
1/5/04
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Optional Installation Feature See Optional connections page Cut and tape off if not used DRIVER DOOR JAMB BOOT HARNESS
Function
Park Light Output Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column. Park Lights (BROWN) +
Function
Door Ajar Switch Input Dome Light Output
Function
Siren Feed Siren Output
Vehicle Interior
Siren
Vehicle (Year/Make/Model)
2 of 4
IMPORTANT!
1/5/04
87
87a
Yellow
Fuse 15 AMP
The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
White
Black
85 30
CUT
Function
Ground Door Lock Output Door Unlock Output Driver Door Unlock Output
White
Yellow
CUT
87
87a
Optional Installation Feature See Optional connections page Cut and tape off if not used
85 30
86
Red Blue
Function
Park Light Output Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column. Park Lights (BROWN) + HEADLIGHT SWITCH
Function
Door Ajar Switch Input Dome Light Output
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
5/30/03
Ignition (BLUE/GREEN)
IGNITION SWITCH
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Headlight Output
Starter + (RED/BLUE)
Horn (BLUE)
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Yellow White IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
87
White
87a
4 of 4
1/5/04
85 30 Red Blue 86
Black
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Function
Siren Feed Driver Door Unlock Output Disarm Input
CUT
NOTE: Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON
Connect to the half of the wire going back into the vehicles interior
UNDERHOOD Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional) Chassis ground Do Not Ground to Hood!
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
1/4/05
Passenger Door Unlock (PINK/ORANGE) + DRIVER DOOR JAMB BOOT HARNESS
Function
Ground Unlock Switch Sense Input Arm Input Disarm Input
Function
Door Ajar Switch Input Dome Light Output
+ IGNITION SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Note: Parking lights and brake switch connections can also be found at the trailer connector right of the steering column. CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (BLUE)
Vehicle (Year/Make/Model)
Yellow
87
87a Black
Fuse 15 AMP
Battery (YELLOW)
1 of 1
1/5/04
85
White
86 30
Red Blue
CUT
Function
Ground Door Lock Output Door Unlock Output DO NOT USE DO NOT USE
Yellow
CUT
87
White 87a
85 30
86
Red Blue
Function
Door Ajar Switch Input Dome Light Output
Function
Park Light Output MAKE THIS CONNECTION LAST! Park Lights (BROWN) Battery (YELLOW) + IGNITION SWITCH KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Starter + (RED/BLUE)
Horn (BLUE)
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
5/30/03
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
02/03 F-150
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
1 of 1
1/5/04 8/29/02
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Passenger Door Unlock (PINK/ORANGE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Driver Door Latch Switch (BLACK/YELLOW) DRIVER KICK PANEL DRIVER DOOR JAMB BOOT HARNESS
Function
Door Ajar Switch Input Dome Light Output
Function
Park Light Output MAKE THIS CONNECTION LAST! Park Lights (BROWN) + Battery (YELLOW) +
HEADLIGHT SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Starter + (RED/BLUE)
IGNITION SWITCH
Horn (BLUE)
Vehicle (Year/Make/Model)
Preload
Revision Date
Yellow
87
87a Black
Fuse 15 AMP
Battery (YELLOW)
1 of 1
1/5/04
85
White
86 30
Red Blue
CUT
Function
Ground Door Lock Output Door Unlock Output DO NOT USE DO NOT USE
Yellow
CUT
87
White 87a
85 30
86
Red Blue
Function
Door Ajar Switch Input Dome Light Output
Function
Park Light Output MAKE THIS CONNECTION LAST! Park Lights (BROWN) Battery (YELLOW) + IGNITION SWITCH KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Starter + (RED/BLUE)
Horn (BLUE)
SK5W7J-19A361-AB
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
7/8/05 SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start) 2004-2006: 1L2Z-19G365-AB
DOME LIGHT** PK LIGHTS DOOR LOCKS
RELAY REQUIREMENTS:
15
15
15
15
15
15
15
15
15
15
15
15
VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Unlock switch sense polarity Key in Sense polarity Rear Defroster Positive (Default setting) Positive (Default setting) Positive 0.5 sec. (Default setting)
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
Important Note! In order to access transmitter and option programming it will be necessary to manually turn the interior light to the ON position using the dimmer switch.
MODULE MOUNTING LOCATION: Upper left kick panel, near parking brake assembly.
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 4
7/8/05
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Unlock Switch Sense (PINK/ORANGE) + Optional Installation Feature See Optional connections page Optional Installation Feature See Optional connections page **CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE** DRIVER SIDE KICK PANEL
(NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-20 A-2 A-14 A-11 A-9 A-12 A-24 A-13 C-9 C-12 C-13 C-8 BLACK GREEN/VIOLET BLUE GREEN WHITE/BLUE BROWN LT. GREEN BLUE/GREEN TAN TAN/RED GREEN/WHITE YELLOW/GREEN BLUE Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Driver Door Unlock Output DO NOT USE DO NOT USE Memory Seat 1 Output Memory Seat 2 Output Trunk Ajar Input
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 4
7/8/05
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 A-3 C-10 C-11 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE BLACK/WHITE RED/WHITE BLUE/WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Lights Dome Light Output Headlight Output Rear Defrost Output Cut and tape off if not used Starter + (RED/LT. BLUE) CUT
BRAKE SWITCH
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
NOTE: Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON
3 of 4 7/8/05 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
Battery (LT.GREEN/VIOLET)
CUT
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input 87
White
87a
Black
85 30
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
86 Red
Blue
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85 30
86
Blue
Black
HEADLIGHT SWITCH
Headlight
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
Color
C-12 C-13 GREEN/WHITE YELLOW/GREEN
Function
Memory Seat 1 Memory Seat 2
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
1 of 1
7/8/05
Color
A-4 B-2 A-7 A-8 A-6 B-8 A-21 B-7 A-1 RED RED PINK VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE
Function
Battery Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
7/8/05
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-2 A-14 A-11 A-9 A-12 A-24 A-13 C-9 C-12 C-13 C-8 BLACK GREEN/VIOLET BLUE GREEN WHITE/BLUE BROWN LT GREEN BLUE/GREEN TAN TAN/RED GREEN/WHITE YELLOW/GREEN BLUE
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense Driver Door Unlock Output DO NOT USE DO NOT USE Memory Seat 1 Output Memory Seat 2 Output Trunk Ajar Input
Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Unlock Switch Sense (PINK/ORANGE) + DRIVER'S SIDE REAR SILL PLATE HARNESS HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
MAKE THIS CONNECTION LAST! Battery (LT GREEN/VIOLET) + Ignition (DK. BLUE/LT. GREEN) + IGNITION SWITCH
2 of 3
7/8/05
Color
A-4 A-7 A-8 A-6 A-21 A-1 A-3 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE BLACK/WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Dome Light Output Headlight Output
HEADLIGHT SWITCH
DIMMER SWITCH
Yellow White
87
87a
85 30
86
Blue
Black
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
NOTE: Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON
3 of 3
7/8/05
Battery (LT.GREEN/VIOLET) + IGNITION SWITCH
CUT
DRIVER SIDE KICK PANEL Connect to the half of the wire going back to RKE module.
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input 87
White
87a
Black
85 30
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
86 Red
Blue
UNDERHOOD HARNESS
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
Color
C-12 C-13 GREEN/WHITE YELLOW/GREEN
Function
Memory Seat 1 Memory Seat 2
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
VSS
Revision Date
1 of 2
7/8/05
Dome Light (BLACK/BLUE) + Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-11 A-9 A-12 BLACK GREEN/VIOLET WHITE/BLUE BROWN LT. GREEN
Function
Ground Door Ajar Switch Input Arm Input Disarm Input Unlock Switch Sense Input
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) STEERING COLUMN HARNESS HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
VSS
Revision Date
2 of 2
7/8/05
OPTIONAL CONNECTIONS
UNDERHOOD
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
'04-'06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
7/8/05
HEADLIGHT SWITCH
Color
A-1 A-3 WHITE BLACK/WHITE
Function
Parking Light Output Dome Light Output Park Lights (BROWN) +
HEADLIGHT SWITCH
DIMMER SWITCH
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 RED PINK VIOLET VIOLET/RED BROWN/BLACK
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output
Vehicle (Year/Make/Model)
'04-06 F-150/Mark LT
Equipment or Trim level System(s) applicable to:
ALL
Page
Preload
Revision Date
1 of 1
7/8/05
Dome Light (BLACK/LT. BLUE) +
Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Lock Motor (PINK/BLACK) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-2 A-14 A-11 A-9 A-12 BLACK GREEN/VIOLET BLUE GREEN WHITE/BLUE BROWN LT. GREEN
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Arm Input Disarm Input Unlock Switch Sense
Driver Door Unlock Motor (RED/ORANGE) + DRIVER'S SIDE REAR SILL PLATE HARNESS
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) STEERING COLUMN HARNESS HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
'04-'06 Freestar/Monterey
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
4/28/05
REMOTE START (RMST) PARTS REQUIRED Securilock (PATS) Interface: 2004-2006 1L2Z-19G365-AB
REMOTE START (RMST) SPECIFIC PROGRAMMING Key in Sense polarity Learn Tachometer Negative (Default Setting) Required On All Vehicles
15
15
15
15
15
15
15
15
RELAY REQUIREMENTS:
1-Parking Lights (Required) 1- Driver's Door Priority Unlock (Optional)
15
15
15
15
15
15
5 MAIN B+
HVAC 1* HVAC 2*
IGNITION*
Door trigger polarity Unlock switch sense polarity Positive (Default Setting) Positive (Default Setting)
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL
Page
RKE/VSS/RMST
Revision Date
White
Black Red
1 of 4
4/28/05
Headlight Off (TAN/WHITE) -
Blue CUT
Color
A-5 A-1 A-3 A-13 C-2 C-10 C-12 C-13 BLACK WHITE BLACK/WHITE TAN BLACK/GREEN RED/WHITE GREEN/WHITE YELLOW/GREEN
Function
Ground Parking Light Output Dome Light Output Trunk Release Output LEFT- Power Sliding Door RIGHT- Power Sliding Door Memory Seat 1 Memory Seat 2
HEADLIGHT SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Optional Installation Feature See POWER OPTIONS (4 of 4) 4Optional Installation Feature See POWER OPTIONS (4 of 4)
Door Lock (WHITE/VIOLET)
Color
A-2 A-14 C-4 A-9 A-11 A-12 A-24
Function
Door Unlock (DK. BLUE/LT. GREEN) Factory Alarm Disarm(LT. BLUE/BLACK) Driver Door Unlock Motor (YELLOW) + Driver Door Lock Motor (RED/ORANGE) +
BLUE Door Lock Output GREEN Door Unlock Output LT. GREEN/BLACK Factory Alarm Disarm BROWN Disarm Input WHITE/BLUE Arm Input LT. GREEN Unlock Sense Input BLUE/GREEN Driver Door Unlock Output
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 4
4/28/05
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
FUEL INJECTOR
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
IMPORTANT! The vehicle is equipped with (2) Lt. GREEN/VIOLET wires, use both
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
RKE/VSS/RMST
Revision Date
3 of 4
4/28/05
Battery (RED)
+ + + IGNITION SWITCH
Heater (VIOLET/ORANGE) + Starter + (DK. GREEN) CUT KEY SIDE (after cut)
Function
Battery HVAC2 Feed HVAC1 12 volt Battery Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Door Ajar Switch Input Brake Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level System(s) applicable to:
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON Yellow
ALL
Page
RKE/VSS/RMST
Revision Date
Battery (GREEN/VIOLET) +
87
White
87a
IGNITION SWITCH
4 of 4
4/28/05
NOTE: ALSO INCLUDES RKE/RMST OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
85 30
86
Black
Red Blue Driver Door Unlock Motor (YELLOW) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
POWER OPTIONS
NOTE: Power Sliding Doors Program the "Aux 4 Remapped to Aux 1" (Option #5, Option bank #4) option to ON
Color
C-2 C-10 C-12 C-13 BLACK/GREEN RED/WHITE GREEN/WHITE YELLOW/GREEN
Function
LEFT Power Sliding Door RIGHT Power Sliding Door Memory Seat 1 Memory Seat 2
Left Power Sliding Door (WHITE/LT.GREEN) Right Power Sliding Door (LT.GREEN/RED)
IMPORTANT! ALL CUT AND SPLICED WIRES MUST BE CAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
IMPORTANT! The vehicle is equipped with (2) Lt. GREEN/VIOLET wires, use both
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
RMST
Revision Date
1 of 2
5/9/05
Battery (RED)
+ + + IGNITION SWITCH
Heater (VIOLET/ORANGE) + Starter + (DK. GREEN) CUT KEY SIDE (after cut)
Function
Battery HVAC2 Feed HVAC1 12 volt Battery Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
RMST
Revision Date
2 of 2
5/9/05
MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVER'S KICK PANEL
87a 85 86 30
White
Black Red
Blue CUT
Color
A-5 A-1 BLACK WHITE
Function
Ground Parking Light Output
HEADLIGHT SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Vehicle Interior
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
FUEL INJECTOR
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL
Page
Deluxe RKE/VSS
Revision Date
White
Black Red
1 of 3
5/9/05
Headlight Off (TAN/WHITE) -
Blue CUT
Color
A-5 A-1 A-3 A-13 C-2 C-10 C-12 C-13 BLACK WHITE BLACK/WHITE TAN BLACK/GREEN RED/WHITE GREEN/WHITE YELLOW/GREEN
Function
Ground Parking Light Output Dome Light Output Trunk Release Output LEFT- Power Sliding Door RIGHT- Power Sliding Door Memory Seat 1 Memory Seat 2
HEADLIGHT SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Optional Installation Feature See POWER OPTIONS (3 of 3) Optional Installation Feature See POWER OPTIONS (3 of 3)
Door Lock (WHITE/VIOLET)
Color
A-2 A-14 C-4 A-9 A-11 A-12 A-24
Function
Door Unlock (DK. BLUE/LT. GREEN) Factory Alarm Disarm(LT. BLUE/BLACK) Driver Door Unlock Motor (YELLOW) + Driver Door Lock Motor (RED/ORANGE) + DRIVER SIDE KICK PANEL
BLUE Door Lock Output GREEN Door Unlock Output LT. GREEN/BLACK Factory Alarm Disarm BROWN Disarm Input WHITE/BLUE Arm Input LT. GREEN Unlock Sense Input BLUE/GREEN Driver Door Unlock Output
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
5/9/05
Battery (RED)
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Door Ajar Switch Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Chassis Ground
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level System(s) applicable to:
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON Yellow
ALL
Page
Deluxe RKE/VSS
Revision Date
Battery (GREEN/VIOLET) +
87
White
87a
IGNITION SWITCH
3 of 3
5/9/05
85 30
86
Black
Red Blue Driver Door Unlock Motor (YELLOW) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
POWER OPTIONS
NOTE: Power Sliding Doors Program the "Aux 4 Remapped to Aux 1" (Option #5, Option bank #4) option to ON
Color
C-2 C-10 C-12 C-13 BLACK/GREEN RED/WHITE GREEN/WHITE YELLOW/GREEN
Function
LEFT Power Sliding Door RIGHT Power Sliding Door Memory Seat 1 Memory Seat 2
Left Power Sliding Door (WHITE/LT.GREEN) Right Power Sliding Door (LT.GREEN/RED)
IMPORTANT! ALL CUT AND SPLICED WIRES MUST BE CAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL
Page
VSS
Revision Date
White
Black Red
1 of 2
5/9/05
Headlight Off (TAN/WHITE) -
Blue CUT
Color
A-5 A-1 BLACK WHITE
Function
Ground Parking Light Output
HEADLIGHT SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Driver Door Unlock Motor (YELLOW) + Driver Door Lock Motor (RED/ORANGE) +
Color
A-9 A-11 A-12 BROWN WHITE/BLUE LT. GREEN
Function
Disarm Input Arm Input Unlock Sense Input
IMPORTANT! ALL CUT AND SPLICED WIRES MUST BE CAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
VSS
Revision Date
2 of 2
5/9/05
Battery (RED)
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Door Ajar Switch Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
OPTIONAL CONNECTIONS
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren (OptionalNot Included in Kit) Hood Tilt Switch (Optional-Not Included in Kit) Do Not Ground to Hood!
Chassis Ground
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL
Page
RKE/VSS
Revision Date
White
Black Red
1 of 2
5/9/05
Headlight Off (TAN/WHITE) -
Blue CUT
Color
A-5 A-1 A-3 BLACK WHITE BLACK/WHITE
Function
Ground Parking Light Output Dome Light Output
HEADLIGHT SWITCH
DIMMER SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Color
A-2 A-14 C-4
Function
BLUE Door Lock Output GREEN Door Unlock Output LT. GREEN/BLACK Factory Alarm Disarm
IMPORTANT! ALL CUT AND SPLICED WIRES MUST BE CAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
RKE/VSS
Revision Date
2 of 2
5/9/05
Battery (RED)
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Door Ajar Switch Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
OPTIONAL CONNECTIONS
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren (OptionalNot Included in Kit) Hood Tilt Switch (Optional-Not Included in Kit) Do Not Ground to Hood!
Chassis Ground
Vehicle (Year/Make/Model)
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL
Page
PRELOAD
Revision Date
White
Black Red
1 of 2
5/9/05
Headlight Off (TAN/WHITE) -
Blue CUT
Color
A-5 A-1 A-3 BLACK WHITE BLACK/WHITE
Function
Ground Parking Light Output Dome Light Output
HEADLIGHT SWITCH
DIMMER SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Color
A-2 A-14 C-4 A-9 A-11 A-12
Function
Door Unlock (DK. BLUE/LT. GREEN) Factory Alarm Disarm(LT. BLUE/BLACK) Driver Door Unlock Motor (YELLOW) + Driver Door Lock Motor (RED/ORANGE) + DRIVER SIDE KICK PANEL
BLUE Door Lock Output GREEN Door Unlock Output LT. GREEN/BLACK Factory Alarm Disarm BROWN Disarm Input WHITE/BLUE Arm Input LT. GREEN Unlock Sense Input
IMPORTANT! ALL CUT AND SPLICED WIRES MUST BE CAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
Vehicle (Year/Make/Model)
IMPORTANT!
System(s) applicable to:
'04-'06 Freestar/Monterey
Equipment or Trim level
ALL CUT AND SPLICED WIRES MUST BECAREFULLY TAPED AND PROPERLY SECURED PER GOOD WIRING PRACTICES. NO EXCEPTIONS!
ALL
Page
PRELOAD
Revision Date
2 of 2
5/9/05
Battery (RED)
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Door Ajar Switch Input
4-WAY PLUG (RIGHT OF COLUMN) 8-PIN CONN. (Connects instrumentpanel harness to steering column clockspring). Access instrument panel harness side
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
6/2/03
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
15
15
15
15
15
15
1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL) VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Positive (Default setting) Unlock switch sense polarity Negative Key in Sense polarity Negative (Default setting)
15
15
5 MAIN B+ IGNITION*
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system *** HVAC2 circuit not used on Ranger
15
15
15
15
MODULE MOUNTING LOCATION: High on driver side kick panel near bulkhead panel
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
CHASSIS GROUND POINT IN DRIVERS KICK PANEL HARNESS TO THE RIGHT OF GAS PEDAL
1 of 3
6/2/03
Dome Light (BLACK/BLUE) +
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory alarm disarm output Driver Door Unlock Output DO NOT USE DO NOT USE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + UPPER DRIVERS KICK PANEL
Driver Door Unlock Motor (RED/ORANGE) + Connect only on vehicles with factory RKE Driver Door Ajar Switch 02 (BLACK/YELLOW) 03 (YELLOW/BLACK) Optional Installation Feature See Optional connections page DRIVER DOOR JAMB BOOT HARNESS
UNDERHOOD Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) COIL PACK
Note: Tach Signal wire can also be located at the Bulkhead harness inside the vehicle - TAN/YELLOW
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 3
6/2/03
+ + + + IGNITION SWITCH
Starter + (RED/BLUE)
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output
Brake light (GREEN) Cut and tape off if not used Parking lights (BROWN)
BRAKE SWITCH
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
3 of 3
6/2/03
White
87
87a
OPTIONAL CONNECTIONS
85 30
86
Black
NOTE: RKE/VSS/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON RKE/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #1) option to ON
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
HEADLIGHT Color
C-10 RED/WHITE
Function
Headlight Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Headlight
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
MAKE THIS CONNECTION LAST! Battery (YELLOW) Battery (YELLOW) Ignition (GREEN/VIOLET) Heater (GREY/YELLOW) + + + + IGNITION SWITCH
1 of 1
8/28/02
Starter + (RED/BLUE)
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output
Function
Ground MAKE THIS CONNECTION FIRST!
UNDERHOOD Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) COIL PACK
Note: Tach Signal wire can also be located at the Bulkhead harness inside the vehicle - TAN/YELLOW
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
6/2/03
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Factory alarm disarm output Disarm Input Driver Door Unlock Output DO NOT USE DO NOT USE Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Connect only on vehicles with factory RKE Driver Door Ajar Switch 02 (BLACK/YELLOW) 03 (YELLOW/BLACK) Optional Installation Feature See Optional connections page Cut and tape off if not used DRIVER DOOR JAMB BOOT HARNESS UPPER DRIVERS KICK PANEL
UNDERHOOD Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
6/2/03
Battery (YELLOW) +
Ignition (GREEN/VIOLET)
IGNITION SWITCH
Function
Battery Ignition 1 Input/Ouput Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (RED/BLUE)
Horn (YELLOW/GREEN) Cut and tape off if not used Parking lights (BROWN) +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
Yellow
87
White
87a
3 of 3
6/2/03
OPTIONAL CONNECTIONS
85 30
86
Black
NOTE: RKE/VSS/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON RKE/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #1) option to ON
Red
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
UNDERHOOD Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Chassis ground Hood Tilt Switch (Optional) Do Not Ground to Hood!
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87
87a
85 30
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 1
6/2/03
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input Factory alarm disarm output
Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + Driver Door Ajar Switch 02 (BLACK/YELLOW) 03 (YELLOW/BLACK) DRIVER DOOR JAMB BOOT HARNESS UPPER DRIVERS KICK PANEL
Battery (YELLOW)
+ IGNITION SWITCH
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
6/2/03
OPTIONAL CONNECTIONS
UNDERHOOD Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
02/03 Ranger
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
Preload
Revision Date
1 of 1
6/2/03
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + DRIVER DOOR JAMB BOOT HARNESS
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN + HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
8/9/05
REMOTE START (RMST) PARTS REQUIRED Securilock (PATS) Interface: 2004- 1L2Z-19G365-AB 2005- Not Equipped With PATS 2006- 1L2Z-19G365-AB (All engines except 2.3L )
DOME LIGHT**
REMOTE START (RMST) SPECIFIC PROGRAMMING Key in Sense polarity Learn Tachometer Negative (Default setting) Required On All Vehicles
15
15
15
15
RELAY REQUIREMENTS: 2 - Door Locks (Required for vehicles w/o factory RKE) 1 - Headlight Illumination (Optional) 1 - Driver's Door Priority Unlock (Optional) VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Unlock switch sense polarity Key in Sense polarity Positive (Default setting) Negative Negative (Default setting)
15
15 15
15
15
15 5
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
MODULE MOUNTING LOCATION: High on driver side kick panel near bulkhead panel
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
RKE/VSS/RMST
Revision Date
1 of 4
8/9/05
Dome Light (BLACK/LT. BLUE) + HARNESS TO THE RIGHT OF GAS PEDAL
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory alarm disarm output Driver Door Unlock Output
Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Driver's Door Lock Motor (RED) + DRIVER DOOR JAMB BOOT HARNESS
Driver Door Unlock Motor (LT. BLUE) + Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) COIL PACK
Note: 2005 (All Engines) and 2006 (2.3L) are not equipped with PATS
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level
RKE/VSS/RMST
Revision Date
2 of 4
8/9/05
Battery(LT GREEN/VIOLET) +
87
IGNITION SWITCH
87a
Black
Color
A-5 A-20 A-3 A-2 A-14 A-24 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN BLUE/GREEN
Function
Ground Door Ajar Switch Input Dome Light Outpuyt Door Lock Output Door Unlock Output Driver Door Unlock
85
White
86 30
Red Blue
CUT
Yellow
CUT
White
87
87a Black
DRIVER DOOR JAMB BOOT HARNESS Half of harness that goes back into the vehicles door.
85 30
86
Red Blue
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Engine Compartment
RED BLACK
Chassis Ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) COIL PACK
Note: 2005 (All Engines) and 2006 (2.3L) are not equipped with PATS
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
3 of 4
8/9/05
+ +
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 C-10 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE RED/WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output
Brake light (LT. GREEN) + Cut and tape off if not used Parking lights (WHITE/BLACK)
BRAKE SWITCH
HEADLIGHT SWITCH
Note: 2005 (All Engines) and 2006 (2.3L) are not equipped with PATS
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
RKE/VSS/RMST
Revision Date
4 of 4
8/9/05
Yellow
87
87a
Battery (YELLOW) 86
Black
IGNITION SWITCH
85 30
Red Blue Driver Door Unlock Motor (LT. BLUE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
HEADLIGHT
Connect to the half of the wire going back into the vehicle's interior
Color
C-10 RED/WHITE
Function
Headlight Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
Note: 2005 (All Engines) and 2006 (2.3L) are not equipped with PATS
85 30
86
Blue
Black
Battery (RED/YELLOW)
HEADLIGHT SWITCH
Headlight
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
1 of 1
8/9/05
Color
A-4 B-2 A-7 B-4 A-8 A-6 B-8 A-21 B-7 A-1 RED RED PINK ORANGE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE
Function
Battery HVAC1 Feed Ignition 1 Input/Ouput HVAC 1 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output
Note: 2005 (All Engines) and 2006 (2.3L) are not equipped with PATS DRIVER SIDE KICK PANEL HARNESS
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (TAN/WHITE) COIL PACK
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
Deluxe RKE/VSS
Revision Date
1 of 4
8/9/05
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory alarm disarm output Driver Door Unlock Output Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Driver's Door Lock Motor (RED) + Driver's Door Unlock Motor (LT. BLUE) + Connect only on vehicles with factory RKE DRIVER DOOR JAMB BOOT HARNESS
Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level
Deluxe RKE/VSS
Revision Date
2 of 4
8/9/05
Yellow
Battery(LT GREEN/VIOLET) +
87
IGNITION SWITCH
87a
Black
Color
A-5 A-20 A-3 A-2 A-14 A-24 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN BLUE/GREEN
Function
Ground Door Ajar Switch Input Dome Light Outpuyt Door Lock Output Door Unlock Output Driver Door Unlock
85
White
86 30
Red Blue
CUT
Yellow
CUT
White
87
87a Black
DRIVER DOOR JAMB BOOT HARNESS Half of harness that goes back into the vehicles door.
85
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
86 30
Red Blue
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 4
8/9/05
Battery (YELLOW) +
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Ouput Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Horn (YELLOW/LT. GREEN) Cut and tape off if not used Parking lights (WHITE/BLACK)
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
Yellow
87
White
87a
4 of 4
8/9/05
85 30 Red Blue 86
Black
Battery (YELLOW)
OPTIONAL CONNECTIONS
IGNITION SWITCH
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
CUT
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Chassis ground Hood Tilt Switch (Optional) Do Not Ground to Hood!
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
87
87a
85 30
86
Blue
Black
Battery (RED/YELLOW)
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
1 of 1
8/9/05
Yellow
Battery(LT GREEN/VIOLET) +
87
IGNITION SWITCH
87a
Black
Color
A-5 A-20 A-3 A-2 A-14 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN
Function
Ground Door Ajar Switch Input Dome Light Outpuyt Door Lock Output Door Unlock Output
85
White
86 30
Red Blue
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
Yellow White
87
87a Black
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86
Red Blue
Battery (YELLOW)
+ IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 1
7/12/05
Color
A-5 A-20 A-12 A-11 A-9 C-4 BLACK GREEN/VIOLET LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input Factory alarm disarm output
Door Unlock (PINK/LT. GREEN) Driver's Door Lock Motor (RED) + Driver's Door Unlock Motor (LT. BLUE) + DRIVER DOOR JAMB BOOT HARNESS
Battery (YELLOW)
+ IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
ALL
Page
1 of 1
7/12/05
OPTIONAL CONNECTIONS
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level System(s) applicable to:
w/ Factory RKE
Page
PRELOAD
Revision Date
1 of 1
8/9/05
Door Lock (PINK/YELLOW) Door Unlock (PINK/LT. GREEN) Driver's Door Lock Motor (RED) + DRIVER DOOR JAMB BOOT HARNESS
Driver Door Unlock Motor (LT. BLUE) + MAKE THIS CONNECTION LAST! Battery (YELLOW) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Color
C-4
Function
This connection only needed if vehicle is equipped with "Trim Switch Disable"
Vehicle (Year/Make/Model)
'04-'06 Ranger
Equipment or Trim level
PRELOAD
Revision Date
1 of 1
8/9/05
Yellow
Battery(LT GREEN/VIOLET) +
87
IGNITION SWITCH
87a
Black
Color
A-5 A-20 A-3 A-2 A-14 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN
Function
Ground Door Ajar Switch Input Dome Light Outpuyt Door Lock Output Door Unlock Output
85 30
White
CUT
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
Yellow White
CUT
87
87a Black
DRIVER DOOR JAMB BOOT HARNESS Half of harness that goes back into the vehicles door.
85 30
IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
86
Red Blue
Battery (YELLOW)
+ IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
02/03 Windstar
Equipment or Trim level System(s) applicable to:
ALL
Page
ALL
Revision Date
1 of 1
6/2/03
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
2002: 1L2Z-19G365-AB 2003: 1L2Z-19G365-AB RELAY REQUIREMENTS: 1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL) 1 - PARKING LIGHT ACTIVATION (Only required if vehicle is equipped with autolamps) Relays are available by ordering Ford part number YL3Z-19G390-AA(single) or YL3Z-19G390-BA (10 pack). Note: Headlight Illumination option is not available on Windstar.
15
15 15
15
15
15
15
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
15
15
15
15
VEHICLE SPECIFIC PROGRAMMING: Door trigger polarity Unlock sensitivity polarity Key in Sense polarity Negative (Default setting) Positive (Default setting) Negative (Default setting)
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
MODULE MOUNTING LOCATION: Drivers side kick panel, below headlight switch and behind knee blocker panel
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3
6/2/03
12V+ Constant
IGNITION SWITCH
D.BLUE/WHITE
Function
Ground Parking Light Output Dome Light Output Power Sliding Door Power Sliding Door Memory Seat 1 Memory Seat 2
HEADLIGHT SWITCH
DIMMER SWITCH
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
Optional Installation Feature See POWER OPTIONS (3 of 3) Optional Installation Feature See POWER OPTIONS (3 of 3)
Door Lock (BLUE/ORANGE) Connector C201d Cavity #6 Door Unlock (GREEN/YELLOW) Connector C201d Cavity #4 Perimeter Alarm (BLUE/BLACK) Connector C201e Cavity #14 Horn (ORANGE/RED) Connector C201a Cavity #8 -
Function
Door Lock Output Door Unlock Output Perimeter Alarm Disarm Horn Relay Output Rear Defroster Output Disarm Input Arm Input Unlock Sense Input Driver Door Unlock Output DO NOT USE DO NOT USE
FEM
Rear Defroster (WHITE) Connector C201e Cavity #21 Driver Door Unlock Motor (YELLOW) + Connector C201e Cavity #26 Driver Door Lock Motor (RED/ORANGE) + Connector C201e Cavity #12 Passenger Door Unlock Motor + (Lt BLUE) HARNESS UNDER PASS. DOOR SILL PLATE
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMTST
Revision Date
2 of 3
6/2/03
Battery (RED)
Battery (GREEN/VIOLET) + Battery (GREEN/VIOLET) + Ignition (WHITE/YELLOW) + Heater (BLACK/Lt GREEN) + IGNITION SWITCH
Heater (YELLOW) + Starter + (GREEN) CUT KEY SIDE (after cut) 4-WAY PLUG (RIGHT OF COLUMN)
Function
Door Trigger Pull-Up Battery HVAC2 Feed HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Door Ajar Switch Input Brake Input
Key-In Sense (BLACK/PINK) Dome Light (YELLOW/BLUE) Brake (RED/GREEN) BRAKE PEDAL SWITCH
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
AT COIL PACK
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
ALL
Page
RKE/VSS/RMST
Revision Date
Yellow
87
White
87a
3 of 3
6/2/03
NOTE: ALSO INCLUDES RKE/RMST OPTIONAL CONNECTIONS DRIVERS DOOR PRIORITY UNLOCK Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
85 30
86
Black
NOTE: RKE/VSS/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON RKE/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #1) option to ON
Red Blue Driver Door Unlock Motor (YELLOW) + CUT DRIVER SIDE JAMB BOOT HARNESS
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Power Sliding Door (Lt GREEN/RED) Power Sliding Door (WHITE/Lt GREEN) SLIDING DOOR SWITCH (OVERHEAD CONSOLE)
Function
Power Sliding Door Power Sliding Door Power Feed Memory Seat 1 Memory Seat 2
Black Yellow
87
White
87a
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
85 30
86
Blue Black Yellow
87
White
87a
85 30
86
Blue
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
ALL
Page
RMST
Revision Date
1 of 1
6/2/03
Ignition (WHITE/YELLOW) + Heater (BLACK/Lt GREEN) + Heater (YELLOW) + Starter + (GREEN) CUT
IGNITION SWITCH
Function
Battery HVAC2 Feed HVAC1 Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Brake Input Key-in-sense Input
Brake (RED/GREEN) -
Function
Horn Relay Output
FEM
IGNITION SWITCH
12v constant
86
Function
Ground Parking Light Output
CUT
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level
ALL
Page
DELUXE RKE/VSS
Revision Date
1 of 3
6/2/03
Function
Door Trigger Pull-Up Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Door Ajar Switch Input CUT
KEY SIDE (after cut) UNDERDASH LIGHT (BAR BEHIND CRASH PANEL)
Function
Door Lock Output Door Unlock Output Perimeter Alarm Disarm Horn Relay Output Disarm Input Arm Input Unlock Sense Input Driver Door Unlock Output DO NOT USE DO NOT USE
Door Lock (BLUE/ORANGE) Connector C201d Cavity #6 Door Unlock (GREEN/YELLOW) Connector C201d Cavity #4 Perimeter Alarm (BLUE/BLACK) Connector C201e Cavity #14 Horn (ORANGE/RED) Connector C201a Cavity #8 -
FEM
Driver Door Unlock Motor (YELLOW) + Connector C201e Cavity #26 Driver Door Lock Motor (RED/ORANGE) + Connector C201e Cavity #12 Passenger Door Unlock Motor + (Lt BLUE) HARNESS UNDER PASS. DOOR SILL PLATE
Connect only on vehicles with factory RKE Cut & tape if not used Optional Installation Feature See DRIVERS DOOR UNLOCK (3 of 3)
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level
ALL
Page
DELUXE RKE/VSS
Revision Date
2 of 3
6/2/03
*For vehicles w/autolamp only*
85
30 CUT
D.BLUE/WHITE
HEADLIGHT SWITCH DIMMER SWITCH
Function
Ground Parking Light Output Dome Light Output Power Sliding Door Power Sliding Door Memory Seat 1 Memory Seat 2
Optional Installation Feature See POWER OPTIONS (3 of 3) Optional Installation Feature See POWER OPTIONS (3 of 3)
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Siren
Chassis Ground
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
Yellow
ALL
Page
Deluxe RKE/VSS
Revision Date
87
White
87a
3 of 3
6/2/03
85 30
86
Black
NOTE: RKE/VSS/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #2) option to ON RKE/RMST Program the "Drivers door priorty unlock" (Option #1, Option bank #1) option to ON
NOTE: ALSO INCLUDES RKE/RMST OPTIONAL CONNECTIONS DRIVERS DOOR PRIORITY UNLOCK Color
A-15 A-24 A-9 RED BLUE/GREEN BROWN
Red Blue Driver Door Unlock Motor (YELLOW) + CUT FEM DRIVER SIDE JAMB BOOT HARNESS
Function
Siren Feed Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicles interior
Power Sliding Door (Lt GREEN/RED) Power Sliding Door (WHITE/Lt GREEN) SLIDING DOOR SWITCH (OVERHEAD CONSOLE)
Function
Power Sliding Door Power Sliding Door Power Feed Memory Seat 1 Memory Seat 2
Black Yellow
87
White
87a
85 30
Black Yellow
86
Blue
87
White
87a
85 30
86
Blue
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
1 of 1 Color
A-10 A-4 A-7 A-8 A-6 A-20 YELLOW/WHITE RED PINK VIOLET VIOLET/RED GREEN/VIOLET
6/2/03 Function
Door Trigger Pull-Up Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Door Ajar Switch Input Starter + (GREEN)
Ignition (WHITE/YELLOW) +
KEY SIDE (after cut) Dome Light (YELLOW/BLUE) Door Lock (BLUE/ORANGE) Connector C201d Cavity #6 FEM UNDERDASH LIGHT
Function
Door Lock Output Door Unlock Output Horn Relay Output
Door Unlock (GREEN/YELLOW) Connector C201d Cavity #4 Horn (ORANGE/RED) Connector C201a Cavity #8 MAKE THIS CONNECTION FIRST!
IGNITION SWITCH
85 30 CUT
Function
Ground Parking Light Output Dome Light Output
D.BLUE/WHITE
HEADLIGHT SWITCH DIMMER SWITCH
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Chassis Ground
Hood Tilt Switch (Optional - Not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
02/03 Windstar
Equipment or Trim level System(s) applicable to:
w/Factory RKE
Page
VSS
Revision Date
1 of 1
6/2/03
Function
Door Trigger Pull-Up Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Door Ajar Switch Input CUT
Dome Light (YELLOW/BLUE) Driver Door Unlock Motor (YELLOW) Connector C201e Cavity #26
+ +
KEY SIDE (after cut) UNDERDASH LIGHT (BAR BEHIND CRASH PANEL)
Function
Disarm Input Arm Input Horn Relay Output Unlock Sense Input
Driver Door Lock Motor (RED/ORANGE) Connector C201e Cavity #12 Horn (ORANGE/RED) Connector C201a Cavity #8 Passenger Door Unlock Motor + (Lt BLUE) MAKE THIS CONNECTION FIRST!
FEM
Function
Ground Parking Light Output Parking Lights (BLACK/GREEN) HEADLIGHT SWITCH
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Engine Compartment
RED BLACK
Chassis Ground
Hood Tilt Switch (Optional - Not Included in Kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
02/03 Windstar
Equipment or Trim level System(s) applicable to:
ALL
Page
PRELOAD
Revision Date
1 of 1 Color
A-10 A-4 A-7 A-8 A-6 YELLOW/WHITE RED PINK VIOLET VIOLET/RED
9/3/03 Function
Door Trigger Pull-Up Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Starter + (GREEN)
Ignition (WHITE/YELLOW) +
CUT KEY SIDE (after cut) Door Lock (BLUE/ORANGE) Connector C201d Cavity #6 -
Function
Door Lock Output Door Unlock Output Horn Relay Output Factory Alarm Disarm Output Disarm Input Arm Input Unlock Sense Input
Door Unlock (GREEN/YELLOW) Connector C201d Cavity #4 Horn (ORANGE/RED) Connector C201a Cavity #8 Perimeter Alarm (BLUE/BLACK) Connector C201e Cavity #14 Driver Door Unlock Motor (YELLOW) + Connector C201e Cavity #26 Driver Door Lock Motor (RED/ORANGE) + Connector C201e Cavity #12 Passenger Door Unlock Motor + (Lt BLUE) MAKE THIS CONNECTION FIRST! CHASSIS GROUND POINT IN DRIVERS KICK PANEL
87a
FEM
Function
Ground Parking Light Output Door Ajar Switch Input Dome Light Output
85 30 CUT
D.BLUE/WHITE
-
Vehicle (Year/Make/Model)
SK5W7J-19A361-AB
ALL
Page
ALL
Revision Date
1 of 1
3/17/06
SECURILOCK (PATS) INTERFACE APPLICATION CHART (Required for systems with remote start)
PK LIGHTS DOOR LOCKS**
DOME LIGHT**
1L2Z-19G365-AB
15
15
RELAY REQUIREMENTS: 1 - REAR DEFROST (OPTIONAL) 1 - HEADLIGHT ILLUMINATION (OPTIONAL) 1 - DRIVER DOOR UNLOCK PRIORITY (OPTIONAL) VEHICLE SPECIFIC PROGRAMMING:
15
15
15
15
15
15
15
5 MAIN B+ IGNITION*
HVAC 1* HVAC 2*
15
15
15
15
*Only used on (PC-32) systems with Car Start (RMST) ** Not used on VSS system
Door trigger polarity Unlock switch sense polarity Key in Sense polarity Aux 2 (Rear Defrost)
MODULE MOUNTING LOCATION: Above hood release cable near bulkhead panel, in front of emergency brake.
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
1 of 3 3/17/06 (NOTE: ALSO INCLUDES RKE/RMST) DRIVERS SIDE KICK PANEL HARNESS Color Function
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 A-13 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN TAN TAN/RED Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Dome Light (BLACK/BLUE) + Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 A-19 B-9 RED BLACK GRAY VIOLET/WHITE
Function
Siren Feed Siren Output Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
RED BLACK
Chassis ground Do Not Ground to Hood! Tach Signal (WHITE/YELLOW) IGNITION COIL
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
RKE/VSS/RMST
Revision Date
2 of 3
3/17/06
+ + + IGNITION SWITCH
Heater (BROWN)
Heater (GRAY/YELOW) +
Color
A-4 B-1 B-2 A-7 B-4 B-5 A-8 A-6 B-8 A-21 B-7 A-1 C-10 C-11 RED BLUE RED PINK ORANGE ORANGE/WHITE VIOLET VIOLET/RED BLACK/WHITE BROWN/BLACK BROWN WHITE RED/WHITE BLUE/WHITE
Function
Battery HVAC2 Feed HVAC1 12 volt Battery Feed Ignition 1 Input/Output HVAC 1 Output HVAC 2 Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Key-in-sense Input Horn Relay Output Brake Input Parking Light Output Headlight Output Rear Defroster Output
Starter + (RED/BLUE)
BRAKE SWITCH
Parking lights (BROWN) Optional Installation Feature See Optional connections page
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneath the driver's side door sill plate. Wire changes to BROWN (+).
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON Yellow
ALL
Page
RKE/VSS/RMST
Revision Date
87
White
87a
Battery (RED) +
IGNITION SWITCH
3 of 3 3/17/06 (NOTE: ALSO INCLUDES RKE/RMST) OPTIONAL CONNECTIONS DRIVER'S DOOR PRIORITY UNLOCK
85 30
86
Black
Red Blue Driver Door Unlock Motor (RED/ORANGE) + CUT DRIVER SIDE JAMB BOOT HARNESS
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
Connect to the half of the wire going back into the vehicle's interior
Color
C-10 C-11 RED/WHITE BLUE/WHITE
Function
Headlight Output Rear Defroster Output
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack). Yellow White
87
87a
85
Yellow White
86 30
Blue
Black
+ +
HEADLIGHT SWITCH
87
87a
Headlight
86
Black
85 30
Rear Defroster
Blue IMPORTANT! The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!
Vehicle (Year/Make/Model)
+ + + + + IGNITION SWITCH
ALL
Page
RMST
Revision Date
1 of 1
3/17/06
Color
A-5 BLACK
Function
Ground
UNDERHOOD HARNESS
Color
A-19 B-9 GRAY VIOLET/WHITE
Function
Hood Open Switch Input Tach Sense Input
Vehicle Interior
Underhood
Chassis ground Do Not Ground to Hood! Tach Signal (WHITE/YELLOW) IGNITION COIL
IMPORTANT! The tach sense input wire must be properly insulated and secured. Avoid routing the wiring at or near hot or moving parts. Failure to properly connect this wire will result in vehicle damage!
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
1 of 3
3/17/06
Color
A-5 A-20 A-3 A-2 A-14 A-12 A-11 A-9 C-4 A-24 A-13 C-9 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN LT.GREEN WHITE/BLUE BROWN LT GREEN/BLACK BLUE/GREEN TAN TAN/RED
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Factory Alarm Disarm Output Driver Door Unlock Output DO NOT USE DO NOT USE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Connect only on vehicles with factory RKE Driver Door Ajar Switch (YELLOW/BLACK) Optional Installation Feature See Optional connections page
UNDERHOOD HARNESS
Color
A-15 A-16 RED BLACK
Function
Siren Feed Siren Output
Vehicle Interior
Underhood
RED BLACK
Siren
Vehicle (Year/Make/Model)
ALL
Page
Deluxe RKE/VSS
Revision Date
2 of 3
3/17/06
Ignition (GREEN/VIOLET) + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 C-10 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE RED/WHITE
Function
Battery Ignition 1 Input/Output Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output Headlight Output
Starter + (RED/BLUE)
Horn (YELLOW/GREEN)
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).
HEADLIGHT SWITCH
Note: Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).
Yellow White
87
87a
85 30 Note: Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).
86
Blue
Black
+ +
HEADLIGHT SWITCH
Vehicle (Year/Make/Model)
NOTE: Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON
ALL
Page
Deluxe RKE/VSS
Revision Date
3 of 3
3/17/06
87
87a
Yellow
Battery (RED) +
IGNITION SWITCH
OPTIONAL CONNECTIONS
White
85 30
86
Black
Color
A-24 A-9 BLUE/GREEN BROWN
Function
Driver Door Unlock Output Disarm Input
CUT
Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z19G390-BA (10 pack).
Connect to the half of the wire going back into the vehicle's interior
UNDERHOOD
Color
A-19 GRAY
Function
Hood Open Switch Input
Vehicle Interior
Underhood Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Chassis ground
Vehicle (Year/Make/Model)
w/Factory RKE
Page
VSS
Revision Date
1 of 1
3/17/06
Dome Light (BLACK/BLUE) + HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
Color
A-5 A-20 A-12 A-11 A-9 BLACK GREEN/VIOLET LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Ajar Switch Input Unlock Switch Sense Input Arm Input Disarm Input
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
CHASSIS GROUND POINT IN DRIVERS KICK PANEL HARNESS UNDER DRIVERS SIDE DOOR SILL PLATE
1 of 1
3/17/06
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-3 A-2 A-14 BLACK GREEN/VIOLET BLACK/WHITE BLUE GREEN
Function
Ground Door Ajar Switch Input Dome Light Output Door Lock Output Door Unlock Output Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) DRIVER DOOR JAMB BOOT HARNESS
IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output
CUT KEY SIDE (after cut) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH
Horn (YELLOW/GREEN)
Vehicle (Year/Make/Model)
ALL
Page
1 of 1
3/17/06
OPTIONAL CONNECTIONS
UNDERHOOD
Color
A-15 A-16 A-19 RED BLACK GRAY
Function
Siren Feed Siren Output Hood Open Switch Input
Vehicle Interior
Underhood
RED BLACK
Siren
Chassis ground
Hood Tilt Switch (Optional - not included in kit) Do Not Ground to Hood!
Vehicle (Year/Make/Model)
ALL
Page
Preload
Revision Date
1 of 1
3/17/06
Dome Light (BLACK/BLUE) +
Color
A-5 A-20 A-2 A-14 A-12 A-11 A-9 BLACK GREEN/VIOLET BLUE GREEN LT.GREEN WHITE/BLUE BROWN
Function
Ground Door Ajar Switch Input Door Lock Output Door Unlock Output Unlock Switch Sense Input Arm Input Disarm Input Connect only on vehicles with factory RKE
Door Lock (PINK/YELLOW) Door Unlock (PINK/GREEN) Lock Motor (PINK/BLACK) + Driver Door Unlock Motor (RED/ORANGE) +
Color
C-4
Function
Driver Door Ajar Switch (YELLOW/BLACK) -
*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.
Battery (RED) + Ignition (GREEN/VIOLET) Starter + (RED/BLUE) CUT KEY SIDE (after cut) Horn (YELLOW/GREEN) 6-WAY CONNECTOR TO RIGHT OF STEERING COLUMN HEADLIGHT SWITCH + IGNITION SWITCH
Color
A-4 A-7 A-8 A-6 A-21 A-1 RED PINK VIOLET VIOLET/RED BROWN/BLACK WHITE
Function
Battery Ignition Input Starter Interrupt (Motor side) Starter Interrupt (Key side) Horn Relay Output Parking Light Output