You are on page 1of 13

1. check E1 in use by particular link (in this case MMU2D pos 1/2 is 17 E1) 2.

All of these configuration to be done on both end.

2. Dedicate the packet to 22 Mbps (the balance will be in E1) but make sure do not disturb the running E1 in the link (in this case 35 is E1, 22.6 Mbps is packet)

4. After this action. WAN will be created

5. After the configuration is done until last page, counter of Received and Transmitted will be NOT zero. The counter will show increasing in values.

6. The value of VLAN ID as per design.

You might also like