Professional Documents
Culture Documents
201203
RBID DIP Switch new backplane (BPSN: 070200 and later versions; BCTC: 060201 and later versions; BGSN: 060801 and later versions) installed in the new box 9U machine, either use the RBID can also use the backplane jumper settings frame box NO. If you want to use RBID, we must remove the jumper on the backplane jumper cap (where the backplane jumper configuration on the failure does not work). The use of specific 1. RBID inserted in the functional insert box behind the top 17 slots. For the backplane backplane to provide the TRIB, RACK, SHELF and other ID information. Set RBID need to pull out RBID to operate.
2.
If you want to use to set RBID backplane TRIB, RACK, SHELF and other ID information, it would take should the jumper cap back on all the pull. Interchange project please set the rack in standardizing RBID frame slot number, RBID the jumper layout and instructions are as follows
X2 X3
X4
X3
1.1
1.2
Has exchange box interconnect Note: GUIM connected with the GLI, the two GUIM of 8-ray port to be
Description: The control box and switching boxes do not need to connect the clock line, resource box for each gigabit connection is as follows
RNC clock uniform extraction from the MGW, each RNC has two APBE boards, they are post-flashboard RGIM1 of 8KOUT/DEBUG-232 a clock extracted from each line, connected to the RCKG1 the 8KIN1 and RCKG2 the 8KIN2 mouth.