Professional Documents
Culture Documents
Drive Test Procedure For All
Drive Test Procedure For All
Table of contents
Procedure/Flow........................................................................................................................................... 2 Drive Test Preparation (General)............................................................................................................. 3 Drive Test New integrated Site................................................................................................................ 3 Drive Test Procedure........................................................................................................................... 4 Drive Test eport ................................................................................................................................ 4 Drive test o! e"#o$e/%utover Sites....................................................................................................... & Drive Test Procedure........................................................................................................................... & Drive Test eport................................................................................................................................. & Swap Site Drive Test .......................................................................................................................... '
Procedure/Flow
The purpose of this document is to define the process flow and the drive test procedures to be followed by Huawei DT and RF engineers to verify the functionality of the new sites in the rollout of Warids GS networ!" #loc! diagram of the steps to be followed on Drive Test $rocess is shown in Figure %"
2 Drive test
2. Drive Test *ewly +ntegrated Site ,utover-Re.Home Site Swap Sites /" Drive Test Report
Drive Test Report production for the site
The steps for the completion of each phase will be described in the sections below&
Drive Test Preparation (General) Some preparation activities must be initially performed in order to set up the testing equipment. This step will prepare the test equipment and set the software and hardware details for the measurements. See the attachment How to connect/setup equipment
Before leaving for the rive Test! see attachment rive Test chec" #ist
Cell $D Plot (Dedicated mode) Cell $D Plot (+dle mode) &PRS availabilit#'(es%)*+