Professional Documents
Culture Documents
Engine S/N
Engine Hours
Driven S/N
Driven Hours
Date Inspection
WORK DESCRIPTION
RESULT
REMARKS
PT Indoturbine Rep.
Customer Rep.
Standard Inspection Page 3
TASK
CONDITION
REMARKS
Inspect
Replace
S 2. Inspect
Oil lubricator (if applicable) Starter seals for gas leaking LUBE OIL SYSTEM Check List: Pre/post lube oil pump Oil lubricator (if applicable) Back up lube oil pump Lube oil filter element Servo oil filter element (if applicable) Back up seal oil pump Lube oil cooler fan shaft bearings (if applicable) SEAL OIL SYSTEM Check List: Seal oil trap inlet strainer Seal oil separator filter GAS FUEL SYSTEM Check List: Fuel control poppet valve, replace if necessary (if applicable) Operation of fuel control valve. Observe T5 temperature and fuel control actuator signals during a start: compare with original readings or stripchart recordings Fuel gas filter element Pilot filter element Disassemble, clean, and rebuild gas valves (as applicable) ELECTRICAL SYSTEM Check List:
Inspect Inspect Inspect Inspect Inspect Inspect Inspect Inspect Inspect Inspect Inspect
Replace Replace Replace Replace Replace Replace Replace Replace Replace Replace Replace
Inspect
Replace
Inspect
Replace
S S S 5. Inspect
Inspect control console electrical connections for cleanliness Check battery charger for proper operation. For NiCad batteries, place charger to high rate for a few hours AIR SYSTEM Check List: Check air inlet system for obstructions and contamination. Record differential pressure. ENGINE Check List: Inlet guide vane - Looseness Hydraulic Filter (if applicable) MISCELLANEOUS: Check List: Air inlet filter element
Inspect
Replace
Inspect
Replace
Parameter Data
Parameter Before PM After PM No Load After PM With Load
Engine
GP (%) PT (%) T5 (F) T7 (F) PCD (psig) Lube Oil Pressure (Psig) Lube Oil Temperature (F) Fuel Pressure (Psig) T1 (F) Air inlet DP (inH2O) Enclosure Temp (F) Compressor P1 (psig) P2 (psig) T1 (F) T2 (F) Q (mmscfd) Surge Margin (%) Generator Load (kW) Frequency (Hz) Winding Temp A (F) Winding Temp B (F) Winding Temp C (F) Gen Drive End Bearing Temp (F) Gen Exctr End Bearing Temp (F) Gen Voltage Gen Voltage Gen Voltage Gen Amps Gen Amps Gen Amps Vibration GP BRG#1 X/Y (ips/mms/mils/microns) GP BRG#2 X/Y (ips/mms/mils/microns) GP BRG#3 X/Y (ips/mm/mils/microns) PT X/Y (ips/mms/mils/microns) Compr Fwd X/Y (mils/microns) Compr Aft X/Y (mils/microns) Gearbox (ips/mms/Gs) Generator Drive End X/Y (ips/mm/mils/microns) Generator Exciter End X/Y (ips/mm/mils/microns)