You are on page 1of 4

Versawall

www.australianpaving.com
AUSTRALIAN PAVING CENTRE
The Versawall

system is a unique interlocking retaining wall system which is perfect


for reclaiming sloping land and constructing garden beds and planter boxes. These blocks
feature a patent pending design with self locating lugs which makes it quick and easy
to build garden walls. The Versawall

system creates pure vertical retaining walls which


means less yard space is required and a modern look is achieved.
Universal Capping Unit
Versawall

Standard Unit
Versawall

Corner Unit*
*Versawall

corner units are sold as pairs

C *
AVAILABLE SIZES
Charcoal Oatmeal Sunstone
300mm
400mm
390mm
250mm
200mm
200mm
60mm
215mm
215mm
unique self interlocking lugs
COLOUR OPTIONS
FEATURES INCLUDE
Ve|] (uic| orJ eos] tu |uilJ o woll wit| t|ese sel irte|luc|ir |luc|s
BuilJ uu tu cJJaa |i| ,+ cuu|ses ulus t|e couuir urit
BUILDING STEPS
Versawall

units can be used to create


steps in your backyard. The simplest
step design uses standard units with
corner units. The Universal cap is then
used as the step treads. Alternatively,
bullnose pavers can also be used for
step treads. Cross Section Landscape View
Existing soil
20mm drainage
aggregate column
and to fill block voids
No structural
load within
this zone
1.5
1
NOTE: Allow minimum 50mm ebeddment to cover leveling pad
Max 867mm high
4 courses + cap
450 x 130mm
compacted roadbase
or concrete pad
100mm socked
subsoil drain 2%
fall to discharge
at 20m max centres
Adbri Masonry Versawall


units and Universal caps
300mm
Adbri Masonry Versawall


units and Universal caps
Garden soil
300mm
Max 867mm high
4 courses + cap
450 x 130mm
compacted roadbase
or concrete pad
20mm drainage
aggregate column
and to fill block voids
100mm socked subsoil drain 2%
fall to discharge at 20m max centres
NOTE: Allow minimum 50mm
ebeddment to cover leveling pad
TYPICAL CROSS SECTION OF VERSAWALL

Versawall

cross section - Raised planter Versawall

cross section - Retaining wall


Maximum unreinforced height is 800mm plus the capping unit. This is four courses plus the cap. This wall can be constructed to heights in excess of 800mm when
designed by an engineer and reinforced. Check with your local council for any further requirements regarding building retaining walls in your area.
LAYING INSTRUCTIONS - How to build your own wall!
Step 1
Step 3
Step 2
Step 4
Notes - Slope the soil above and below the wall to ensure that water will
ow away from and not accumulate near the wall.
- It is advisable to place a dob of adhesive between corner units.
Step 1 - Dig a shallow trench, level and
place 100mm of crushed rock in
the bottom. Level and compact.
Allow for 50mm embedment of
the bottom course and 300mm
behind the wall for drainage.
Step 2 - Spread and level approximately
25mm of coarse sand as a
bedding layer then place the rst
course of Versawall

units. Use a
stringline for creating a straight
line, and level from side to side
and front to back. Install a 90mm
Agricultural Pipe (on grade) at
the rear of the wall for drainage.
Step 3 - Fill Versawall

cores and 300mm


behind each course with granular
rock for drainage and carefully
compact. Check each course
is level before proceeding and
stacking each additional row
offsetting from the block below
to maintain half bond.
Step 4 - On the last course of stacking
units, remove locating lugs on
top of the Versawall

blocks,
place a line of adhesive front
and back and place the capping
unit. Apply pressure to secure
and use a stringline and level
for the best result.
(See Pic 3A and 3B)
Pic 3A
Pic 1A
Pic 2A
Pic 1B
Pic 2B
Pic 3B
How to build your own internal corner!
Use standard Versawall

units, remove locating lugs set corner at half bond.


Fill cores and 300mm behind each course with granular rock for drainage
and carefully compact.
How to build your own external corner!
Use Versawall

left and right corner units to construct an external corner.


1. Remove the two lugs from the corner unit prior to installing the following courses.
2. To nish the wall, mitre cut the caps and remove all locating lugs from the top
of the block prior to securing capping units.
Even the corner units feature the unique self locating lugs which
makes it very easy to create perfect 90 degree external corners.
Flinders Park Kadina Hallet Cove
284 Grange Road, Flinders Park, SA 5025 86 Port Road, Kadina, SA 5554 9-11 Commercial Road, Sheidow Park, SA 5158
phone: (08) 8234 7144 I fax: (08) 8234 9644 phone: (08) 8821 2077 | fax: (08) 8821 2977 phone: (08) 8381 9142 I fax: (08) 8381 7666
Lonsdale Streaky Bay Gawler
13 Sherriffs Road, Lonsdale, SA 5160 18 Bay Road, Streaky Bay, SA 5680 Cnr Main North & Tiver Rd, Evanston, SA 5116
phone: (08) 8381 2400 I fax: (08) 8381 2366 phone: (08) 8626 7011 I mob: 0427 263 050 phone: (08) 8522 2522 I fax: (08) 8522 2488

Mount Barker Westbourne Park Gepps Cross
4 Oborn Road, Mount Barker, SA 5251 455 Goodwood Rd, Westbourne Park, SA 5041 700 Main North Road, Gepps Cross, SA 5094
phone: (08) 8391 3467 fax: (08) 8398 2518 phone: (08) 8299 9633 I fax: 08) 8299 9688 phone: (08) 8349 5311 I fax: (08) 8349 5833

Mount Gambier Whyalla
Holden Hill
6 Graham Road, Mount Gambier West, SA 5291 132 Norrie Ave, Whyalla Norrie, SA 5608
578 North East Road, Holden Hill, SA 5088
phone: (08) 8725 6019 I fax: (08) 8725 3724 phone: (08) 8644 0918 I mob: 0412 810 056
phone: (08) 8369 0200 I fax: (08) 8266 6855

You might also like