Professional Documents
Culture Documents
com
LCD TV
SERVICE MANUAL
CHASSIS : LP68A
MODEL : 20LS5R
20LS5R-ZA
CAUTION
BEFORE SERVICING THE CHASSIS,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
CONTENTS
CONTENTS .............................................................................................. 2
PRODUCT SAFETY ..................................................................................3
SPECIFICATION ........................................................................................6
ADJUSTMENT INSTRUCTION .................................................................9
TROUBLE SHOOTING ............................................................................13
BLOCK DIAGRAM...................................................................................17
EXPLODED VIEW .................................................................................. 20
REPLACEMENT PARTS LIST ............................................................... 22
SVC. SHEET ...............................................................................................
-2-
SAFETY PRECAUTIONS
IMPORTANT SAFETY NOTICE
Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by
in the
Schematic Diagram and Replacement Parts List.
It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent
Shock, Fire, or other Hazards.
Do not modify the original design without permission of manufacturer.
General Guidance
An isolation Transformer should always be used during the
servicing of a receiver whose chassis is not isolated from the AC
power line. Use a transformer of adequate power rating as this
protects the technician from accidents resulting in personal injury
from electrical shocks.
It will also protect the receiver and it's components from being
damaged by accidental shorts of the circuitry that may be
inadvertently introduced during the service operation.
If any fuse (or Fusible Resistor) in this TV receiver is blown,
replace it with the specified.
When replacing a high wattage resistor (Oxide Metal Film Resistor,
over 1W), keep the resistor 10mm away from PCB.
AC Volt-meter
-3-
To Instruments
exposed
METALLIC PARTS
0.15uF
1.5 Kohm/10W
SERVICING PRECAUTIONS
CAUTION: Before servicing receivers covered by this service
manual and its supplements and addenda, read and follow the
SAFETY PRECAUTIONS on page 3 of this publication.
NOTE: If unforeseen circumstances create conflict between the
following servicing precautions and any of the safety precautions on
page 3 of this publication, always follow the safety precautions.
Remember: Safety First.
General Servicing Precautions
1. Always unplug the receiver AC power cord from the AC power
source before;
a. Removing or reinstalling any component, circuit board
module or any other receiver assembly.
b. Disconnecting or reconnecting any receiver electrical plug or
other electrical connection.
c. Connecting a test substitute in parallel with an electrolytic
capacitor in the receiver.
CAUTION: A wrong part substitution or incorrect polarity
installation of electrolytic capacitors may result in an
explosion hazard.
2. Test high voltage only by measuring it with an appropriate high
voltage meter or other voltage measuring device (DVM,
FETVOM, etc) equipped with a suitable high voltage probe.
Do not test high voltage by "drawing an arc".
3. Do not spray chemicals on or near this receiver or any of its
assemblies.
4. Unless specified otherwise in this service manual, clean
electrical contacts only by applying the following mixture to the
contacts with a pipe cleaner, cotton-tipped stick or comparable
non-abrasive applicator; 10% (by volume) Acetone and 90% (by
volume) isopropyl alcohol (90%-99% strength)
CAUTION: This is a flammable mixture.
Unless specified otherwise in this service manual, lubrication of
contacts in not required.
5. Do not defeat any plug/socket B+ voltage interlocks with which
receivers covered by this service manual might be equipped.
6. Do not apply AC power to this instrument and/or any of its
electrical assemblies unless all solid-state device heat sinks are
correctly installed.
7. Always connect the test receiver ground lead to the receiver
chassis ground before connecting the test receiver positive
lead.
Always remove the test receiver ground lead last.
8. Use with this receiver only the test fixtures specified in this
service manual.
CAUTION: Do not connect the test fixture ground strap to any
heat sink in this receiver.
Electrostatically Sensitive (ES) Devices
Some semiconductor (solid-state) devices can be damaged easily
by static electricity. Such components commonly are called
Electrostatically Sensitive (ES) Devices. Examples of typical ES
devices are integrated circuits and some field-effect transistors and
semiconductor "chip" components. The following techniques
should be used to help reduce the incidence of component
damage caused by static by static electricity.
1. Immediately before handling any semiconductor component or
semiconductor-equipped assembly, drain off any electrostatic
charge on your body by touching a known earth ground.
Alternatively, obtain and wear a commercially available
discharging wrist strap device, which should be removed to
2.
3.
4.
5.
6.
7.
8.
-4-
IC Remove/Replacement
Some chassis circuit boards have slotted holes (oblong) through
which the IC leads are inserted and then bent flat against the
circuit foil. When holes are the slotted type, the following technique
should be used to remove and replace the IC. When working with
boards using the familiar round hole, use the standard technique
as outlined in paragraphs 5 and 6 above.
Removal
1. Desolder and straighten each IC lead in one operation by gently
prying up on the lead with the soldering iron tip as the solder
melts.
2. Draw away the melted solder with an anti-static suction-type
solder removal device (or with solder braid) before removing the
IC.
Replacement
1. Carefully insert the replacement IC in the circuit board.
2. Carefully bend each IC lead against the circuit foil pad and
solder it.
3. Clean the soldered areas with a small wire-bristle brush.
(It is not necessary to reapply acrylic coating to the areas).
"Small-Signal" Discrete Transistor
Removal/Replacement
1. Remove the defective transistor by clipping its leads as close as
possible to the component body.
2. Bend into a "U" shape the end of each of three leads remaining
on the circuit board.
3. Bend into a "U" shape the replacement transistor leads.
4. Connect the replacement transistor leads to the corresponding
leads extending from the circuit board and crimp the "U" with
long nose pliers to insure metal to metal contact then solder
each connection.
Power Output, Transistor Device
Removal/Replacement
1. Heat and remove all solder from around the transistor leads.
2. Remove the heat sink mounting screw (if so equipped).
3. Carefully remove the transistor from the heat sink of the circuit
board.
4. Insert new transistor in the circuit board.
5. Solder each transistor lead, and clip off excess lead.
6. Replace heat sink.
Diode Removal/Replacement
1. Remove defective diode by clipping its leads as close as
possible to diode body.
2. Bend the two remaining leads perpendicular y to the circuit
board.
3. Observing diode polarity, wrap each lead of the new diode
around the corresponding lead on the circuit board.
4. Securely crimp each connection and solder it.
5. Inspect (on the circuit board copper side) the solder joints of
the two "original" leads. If they are not shiny, reheat them and if
necessary, apply additional solder.
Fuse and Conventional Resistor
Removal/Replacement
1. Clip each fuse or resistor lead at top of the circuit board hollow
stake.
2. Securely crimp the leads of replacement component around
notch at stake top.
-5-
SPECIFICATION
NOTE : Specifications and others are subject to change without notice for improvement.
1. General Specification
NO
Item
Content
Feature
20.1 LCD TV
Chassis Name
LP 68A
General Scope
Remark
External SW
8Keys
& Adj.
5
Power Cord
Length : 1.870.04 M
NATION
Shape : Wall-out,
Color : BLACK
6
Power Adapter
No
Type
640(H) x 480(V)
Electrical interface
TTL
LPL
Color Depth
P/N :
Size [mm]
Surface Treatment
EAJ30338001
Normally Black
6 CCFL (6 lamps)
R/T
Typ
2. Mechanical specification
No.
1
Item
Product Dimension
Width (W)
Length (D)
Height (H)
474.1
184.3
464.6
173
483
Before Packing
After Packing
2
Product Weight
Container
537
Only SET
6.5kg(LPL)
With BOX
Remark
Content
8.3kg(LPL)
Individual or Palletizing
20ft
40ft
Loading
Indi.
Wooden
Indi.
Wooden
Quantity
624
576
1248
1152
Stand Assy
Appearance
Type
Base detachable
Size (W x D x H)
Tilt Degree
Tilt force
Swivel Degree
- NON
Swivel Force
- NON
General
-6-
3. Engineering Specification
No.
1
ITEM
Specification
ENERGY
VIDEO
Remark
POWER CONSUMPTION
LED COLOR
Normal
Active
60W
Green
Stand by
Off
1W(110V)
Red
1W(220V)
2
D-SUB
1 : RED
2 : Green
Pin configuration
3 : Blue
4 : ID2 (GND)
5 : S.T (GND)
6 : RED GND
7 : Green GND
8 : Blue GND
9 : N.C
10 : D-GND
11: ID0(GND)
12 :SDA
13: H-Sync
14 : V-Sync
15: SCL
Shell : GND
Control Function
4. Optical Characteristic
No
Item
Specification
Min
1
2
Remark
Tpy
Max
Viewing Angle
R/L
89/89
<CR10>
U/D
89/89
Luminance
Luminance (cd/m2)
320
400
75%
80%
Contrast Ratio
CR
White
Wx
2400
3000
0.298
0.313
In AV input
(Warm)
Wy
0.314
0.329
0.344
PSM : Dynamic
White
Wx
0.270
0.285
0.300
(Normal)
Wy
0.278
0.293
0.308
White
Wx
0.261
0.276
0.291
(Cool)
Wy
0.268
0.283
0.298
-7-
5. Outgoing Condition
No
Item
Condition
Power
Volume Level
30
TV
Pr 01
Mute
STATION
Remark
Off
Off
Auto Programme
To set
System
Storage from
Search
Manual Programme
To set
Storage
System
Band
Channel
Fine
Search
Name
PICTURE
Programme Edit
To set
Favourite Programme
Off
PSM
Dynamic
Standard
Mild
Game
User
Contrast
Brightness
100
50
Colour
60
Sharpness
50
Tint 0
CSM
Cool
Normal
Warm
User
SOUND
Reset
To set
SSM
Flat
Red
Green
Blue
Music
Movie
Sports
User
AVL
TIME
Off
Balance
Clock
-- : --
Off time
-- : -- Off
On time
-- : -Pr.1
Vol. 30
Off
10
SPECIAL
Auto sleep
Off
Language
English
16 Language
Country
Others
30 Teletext Language
Child Lock
Off
-8-
ADJUSTMENT INSTRUCTION
5) After downloading, check OK message.
1. Application Range
These documents is applied to 20" LCD TV(chassis : LP68A)
(4)
f i l ex x x .bi n
2. Designation
( 6 ) ........ OK
(5)
2) Confirmation
(a) We confirm whether 0x8C address of EEPROM
0xB4 is 0xAA or not.
(b) If 0x8C address of EEPROM 0xB4 isnt 0xAA,
we adjust once more.
(c) We can confirm the ADC values from 0x00~0x05
addresses in a page 0xB4.
4) Click Auto tab and set as below, and then click Run.
-9-
- Tool Option
20LS5R-ZA
REMARK
896
Resolution
Module
TV
SCART
AV2
COMPONENT
PC-RGB
DVI
HDMI
- Area Option [ A B ]
(A) 0 : FACTORY MODE OFF
1 : FACTORY MODE ON
Item
Condition
Remark
OPTION 1 [6]
1
200PR
ACMS
0 : 200 PR Off
1 : 200 PR On
0 : ACMS Off
1 : ACMS On
TEXT
0 : TOP
1 : FLOF
CH+AU
BOOSTER
OPTION 2 [2]
1
SYS
A2 ST
I II SAVE
0 : BG/I/DK/L
1 : BG/I/DK/M
HDEV
V-Curve
MONO
1 : China
1 : Turbo Volume On
OPTION 3 [2]
KEY-TYPE
2 : 8Key
OPTION 4 [3]
1
Default Lang
Lang
T- Lang
OPTION 5 [9]
1
2HR-OFF
TV-LINK-TUNER
FACTORY-MODE
CHANNEL-MUTE
- 10 -
5. Adjustment Command
CMD(hex) ADR
E4
00
VAL
00
EEPROM Read
E7
00
00
EEPROM Write
E8
00
data
COLOR SAVE
EB
00
00
ST ART
Description
ST ART
D1
84
6F
H POSITION
20
00
V POSITION
30
00
CLOCK
90
00
PHASE
92
00
00 100
R DRIVE
16
00
00 FF
10 G DRIVE
18
00
00 FF
11 B DRIVE
1A
00
00 FF
12 R CUTOFF
80
00
00 7F
13 G CUTOFF
82
00
00 7F
14 B CUTOFF
84
00
00 7F
15 BRIGHT
10
00
00 3F
Bright adjustment
16 CONTRAST
12
00
00 - 64
Luminance adjustment
17 AUTO_COLOR_
F1
00
02
F2
00
F4
00
00
A DL
CS
ST OP
Dn
ST OP
Details
0-Page 0~7F Read
80
80
80
80
Offset adjustment
Auto COLOR
ST ART
6E
Data_1
LEN
CMD
ADH
3: USER
ADL
Data
0 : TV
1 : AV1
50
A 84+ n
...
03
Data_n
CMD A
CS
A DH
A DL A
ST OP
: 84h+Bytes
: 8Eh
: E2PROM Slave Address(A0,A2,A4,A6,A8),
Not 00h(Reserved by BufferToEEPROM)
: E2PROM Sub Address(00~FF)
: Write data
DEFAULT
A0
Drive adjustment
2: WARM
00
E7
A6
1: NORMAL
00
A DH
A4
Adjustment
F3
A CMD A
A2
0, 1, 2, 3 0: COOL
TEMP
03
ADJUST
Color Save
Contrast, Bright)
INPUTCHANGE
EEPROM Write by
20 AUTO_
50
EEPROM Read
19 FACTORY_
128 Bytes
some values
18 CHANGE_COLOR_
6E
Delay 100ms
2 : AV2
No.
Adjustment contents
CMD(hex)
LEN
Details
4 : RGB
EEPROM WRITE
E8
94
16-Byte Write
5 : DVI
84+n
n-byte Write
3 : Component
<Purpose>
1) EDID write : 16-byte by 16-byte, 8 order (128-byte) write
(TO 00 7F of EEPROM Page A4)
2)FOS Default write : 16-mode data (HFh, HFl, VF, STD,
HP, VP, Clk, ClkPh, PhFine) write
3) Random Data write : write the appointment Address of
E2PROM
6E
50
84
03
70
00
00
CS
ST OP
- 11 -
6F
Data1
...
Data12
CS
NA
ST OP
6. Preset CH information
PIF[MHz]
SYSTEM
SOUND
VIDEO
System
LGE Gumi
LGEMA
LGEWA
LGENT
TXT
NAME
Mode
PR 0
575.25
SECAM-DK
DIGITAL
DUAL
PR 1
45.25
PAL-BG
PHILIPS
MONO
C 34
PR 2
175.25
PAL-BG
PHILIPS
STEREO
PR 3
231.25
PAL-I
FUBK
MONO
S 11
PR 4
62.25
SECAM-BG
PHILIPS
DUAL
C 04
PR 5
189.25
PAL-BG
Crosshatch
PR 6
703.25
PAL-BG
RGB, WHITE
PR 7
719.25
PAL-BG
MATRIX C/B
PR 8
631.25
PAL-I
PHILIPS
PR 9
807.25
PAL-I
Crosshatch
PR 10
55.75
PAL-L
Crosshatch
PR 11
152.75
PAL-L
PHILIPS
NICAM
DUAL
S 07
PR 12
591.25
PAL-L
Colorbar
NICAM
STEREO
C 36
PR 13
175.25
PAL-B
DUAL
FLOF
C 05
PR 14
711.25
PAL-G
DIGITAL
NICAM
STEREO
FLOF
C 51
PR 15
631.25
PAL-I
Crosshatch
NICAM
STEREO
FLOF
PR 16
93.25
SECAM-D
DIGITAL
C 01
FLOF
C 07
DUAL
NICAM
MONO
C 05
FLOF
C 50
STEREO
C 52
NICAM
STEREO
C 41
NICAM
STEREO
C 63
MONO
C 02
Crosshatch+Circle NICAM
C41
C 05
MONO
PR 17
62.25
PAL-B
Crosshatch
A2
STEREO
PR 18
551.25
PAL-G
Colorbar
A2
DUAL
TOP
C 31
PR 19
471.25
PAL-I
DIGITAL
STEREO
FLOF
C 21
PR 20
855.25
PAL-I
DIGITAL
MONO
FLOF
C 69
PR 21
687.25
NTSC-M
DIGITAL
MONO
PR 22
200.25
SECAM-L
DIGITAL
PR 23
663.25
SECAM-L
Crosshatch(16:9)
PR 24
189.25
PAL-B
PR 25
327.25
NTSC-M
PR 26
615.25
PAL-B
PR 27
535.25
PAL-BG
PR 28
45.25
PAL-BG
Monoscope
PR 29
575.25
PAL-DK
Monoscope
PR 30
175.25
PAL-BG
SMPTE
PR 31
231.25
PAL-I
Colorbar
PR 32
62.25
PAL-BG
PR 33
703.25
PR 34
719.25
PR 35
C 04
C 08
C 45
DUAL
NICAM
MONO
FLOF
C 25
C 07
STEREO
A2
STEREO
FLOF
S 24
NICAM
STEREO
FLOF
C 39
NICAM
STEREO
NICAM
C 29
MONO
FLOF
C 01
STEREO
FLOF
C 34
C 04
MONO
DUAL
S 11
White Raster
MONO
C 04
SECAM-DK
White Raster
MONO
C 50
PAL-BG
Crosshatch+Circle
MONO
C 52
591.25
SECAM-L
Colorbar
STEREO
C 36
PR36
175.25
PAL-B/G
Philips
1Khz
PR 37
503.25
PAL-B/G
PR 38
623.25
PAL-B/G
Monoscope
Sweep
C 40
PR 39
49.75
SECAM D/K
Color Bar(2)
400Hz
C 01
PR 40
200.25
PAL-D/K
Color Bar
Sweep
PR 41
695.25
PAL-D/K
Philips
NICAM
NICAM
- 12 -
C 05
FLOF
C 25
C 10
FLOF
C 36
TROUBLESHOOTING
No power
(LED indicator off)
Check 15V or 5V
of Lips.
:[A]Process
Fail
Pass
Check Output of
Q904.
Pass
Check Output of
IC903.
Fail
Change IC903.
Pass
Pass
- 13 -
Change Q904.
Fail
No Raster
:[B]Process
Fail
Pass
Check
IC900, IC901, IC906, IC908,
IC909, IC910.
Fail
Pass
Fail
Change IC100.
Pass
Check inverter
connector or inverter.
Fail
Fail
Pass
Pass
- 14 -
No Raster on AV Signal
(Component, CVBS, S-VHS)
Repeat
[A] Process .
Fail
Fail
Check 5V of TU500.
Re-solder or change the
defect part.
Pass
Fail
Fail
Pass
Check the
input/ output of IC100.
Pass
- 15 -
No Sound
Check the
input source.
Fail
Pass
Fail
Fail
Pass
Pass
- 16 -
DIM_CTL
MX232A
(RS-232C)
MX25L4005A
(Serial Flash)
EEPROM
(24C64)
5V
12V
IR detector
LED
CS4352
(DAC)
CVBS
Jack
Rx/Tx
SCL/SDA
Regulator
Regulator
Regulator
CLK,DQM,
W EZ,CASZ,RASZ
Data
Address
12V_Panel
3.3V
M12L16161A -5TG
(SDRAM)
Rx/Tx
Regulator
FET Switch
(SI4925BDY)
SCART
Jack
CVBS out
5V
15V
15V
Audio out
Audio in
Regulator
RGB in
5V
CVBS in
15V
5V
ON/OFF
PWM_DIM
Video in
- 17 Audio in
RS-232C
(Option)
5V
12V
MST96585
1.8V
LED/IR Board
D-Sub
(Option)
S-Video
Jack
Y in
TTL MODULE
IF_Video
H/P
Output
5V
CVBS Tuner
Stereo -In
(Option)
SCL/SDA
EEPROM
(24C02)
SCL/SDA
SIF_OUT
Control in/out
CVBS OUT
YDA138
(Audio amp)
LVDS MODULE
Audio
Data
Video
Speaker Left
Speaker Right
Control
LED / IR / Control
LIPS
C in
Power
BLOCK DIAGRAM
- 18 -
MEMO
- 19 -
591
300
590
120
200
210
550
220
580
431
520
451
432
450
430
581
400
530
531
EXPLODED VIEW
- 20 -
No.
PART NO.
DESCRIPTION
120
EAB35995501
200
EAJ30338001
LCD,Module-TFT LC201V02-SDA1 VGA 20.1INCH 640X480 450CD COLOR 72% 4/3 800
210
MCK36815003
Cover MOLD HIPS 51SF 20LS5R HIPS 51SF MODULE FIX BRACKET (LPL) RIGHT_CKD
220
MCK36815004
Cover MOLD HIPS 51SF 20LS5R HIPS 51SF MODULE FIX BRACKET (LPL) LEFT_CKD
300
ABJ32624702
400
ACQ32625202
430
ACQ32300802
431
MCK36017202
432
ACQ32300504
450
ADV30635219
451
MGJ32259302
520
EBU36061601
EBU36061602
EBR31760602
EBR31760603
531
MEY30552601
Knob MOLD HIPS 405AF SUB CONTROL KNOB LS1R LS1R CONTROL KNOB
550
EBR35712602
PCB Assembly,Interface INTERFACE T.T LP68A 20LS1R-ZK CKD 20LS1R-ZK CKD (LPL)
EBR35712603
PCB Assembly,Interface INTERFACE T.T LP68A 20LS1R-ZK SKD 20LS1R-ZK SKD (LPL)
580
EAY32636401
Power Supply Assembly AIV-P0032 FREE 20LS1R LCD 20 INCH 4:3 6 LAMP LIPS
581
EBT36118901
590
EBR32541801
EBR32541807
PCB Assembly SUB T.T CL81 / LP68A 17LS5R-ZA / Mx21A LED IR NT PCBA
MES36625301
530
591
- 21 -
PART NO.
DESCRIPTION / SPECIFICATION
CAPACITORs
C100
0CK104CK56A
C102
0CK104CK56A
C103
0CK104CK56A
C104
0CK104CK56A
C105
0CK104CK56A
C106
0CK473CK56A
C107
0CK473CK56A
C108
0CK473CK56A
C1089
0CK104CK56A
C109
0CK473CK56A
C1090
0CK104CK56A
C1091
0CK104CK56A
C1091
0CK105CD56A
C1092
0CK104CK56A
C1093
0CK104CK56A
C110
0CK473CK56A
C111
0CK473CK56A
C112
0CK473CK56A
C113
0CK473CK56A
C114
0CK473CK56A
C115
0CK473CK56A
C116
0CK473CK56A
C117
0CK104CK56A
C118
0CE106WFKDC
C121
0CK104CK56A
C122
0CK104CK56A
C123
0CK225DH94A
C124
0CK104CK56A
C127
0CK473CK56A
C128
0CK473CK56A
C129
0CK473CK56A
C131
0CK473CK56A
C132
0CK473CK56A
C133
0CK473CK56A
C134
0CK473CK56A
C135
0CK473CK56A
C137
0CE106WFKDC
C138
0CE106WFKDC
C139
0CE106WFKDC
C140
0CE106WFKDC
C142
0CK104CK56A
C143
0CK104CK56A
C144
0CK104CK56A
C145
0CK104CK56A
C146
0CE106WFKDC
C148
0CE106WFKDC
C149
0CK104CK56A
C150
0CK475CC94A
C151
0CC102CK41A
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
C152
0CK104CK56A
C154
0CK105CD56A
C155
0CK224DK56A
C156
0CK104CK56A
C157
0CK473CK56A
C158
0CK473CK56A
C159
0CK104CK56A
C161
0CH5200K416
C162
0CH5200K416
C164
0CE106WFKDC
C168
0CK225DH94A
C169
0CK225DH94A
C170
0CK225DH94A
C171
0CK225DH94A
C172
0CK104CK56A
C173
0CK225DH94A
C174
0CK225DH94A
C176
0CK104CK56A
C179
0CK104CK56A
C180
0CK153CK56A
C181
0CK153CK56A
C183
0CK104CK56A
C184
0CK104CK56A
C185
0CK104CK56A
C186
0CK104CK56A
C187
0CK104CK56A
C188
0CK104CK56A
C190
0CK104CK56A
C191
0CK104CK56A
C192
0CK104CK56A
C194
0CK104CK56A
C195
0CK104CK56A
C196
0CK104CK56A
C197
0CK104CK56A
C199
0CE106WFKDC
C250
0CK104CK56A
C251
0CE107WF6DC
C252
0CC220CK41A
C253
0CC102CK41A
C253
0CK104CK56A
C255
0CC101CK41A
C261
0CC101CK41A
C262
0CC101CK41A
C270
0CC101CK41A
C271
0CC101CK41A
C272
0CC101CK41A
C273
0CE107WF6DC
C274
0CC102CK41A
C274
0CK104CK56A
C275
0CE475WJ6DC
- 22 -
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
C300
0CK104CK56A
C710
0CC331CK41A
C301
0CK104CK56A
C711
0CC331CK41A
C303
0CK104CK56A
C712
0CC102CK41A
C304
0CK104CK56A
C713
0CC102CK41A
C306
0CK104CK56A
C718
0CE107WF6DC
C308
0CK104CK56A
C720
0CC220CK41A
C400
0CK225DH94A
C721
0CC220CK41A
C4000
0CN1040K949
C722
0CC220CK41A
C4001
0CN1040K949
C723
0CC220CK41A
C401
0CE107WF6DC
C724
0CK104CK56A
C402
0CK224DH56A
C725
0CK104CK56A
C403
0CK474DK56A
C726
0CK104CK56A
C404
0CK224DH56A
C727
0CE106WFKDC
C405
0CK105CF94A
C728
0CC331CK41A
C406
0CE107WF6DC
C731
0CK222CK51A
C407
0CK475EF67A
C732
0CK222CK51A
C408
0CK475EF67A
C738
0CE106WFKDC
C409
0CE227WF6DC
C740
0CK104CK56A
C410
0CK105CF94A
C741
0CE335WK6D8
C411
0CK105CF94A
C742
0CE335WK6D8
C412
0CE227WF6DC
C743
0CK104CK56A
C413
0CK475EF67A
C744
0CE106WFKDC
C414
0CK104CK56A
C745
0CE106WFKDC
C415
0CK475EF67A
C746
0CC561CK41A
C416
0CE106WFKDC
C747
0CC561CK41A
C417
0CK474DK56A
C748
0CE335WK6D8
C418
0CK224DH56A
C749
0CE335WK6D8
C419
0CK105CF94A
C804
0CC561CK41A
C420
0CK224DH56A
C805
0CC561CK41A
C421
0CC102CK41A
C810
0CK473CK56A
C422
0CC102CK41A
C821
0CC331CK41A
C423
0CC102CK41A
C822
0CC331CK41A
C424
0CC102CK41A
C823
0CC331CK41A
C425
0CC102CK41A
C880
0CK473CK56A
C426
0CC102CK41A
C881
0CK473CK56A
C427
0CC102CK41A
C900
0CE477WF6DC
C428
0CC102CK41A
C901
0CE477EH618
C5000
0CH5101K416
C902
0CE477EH618
C5001
0CH5101K416
C903
0CE107WF6DC
C5002
0CH5470K416
C904
0CE107WF6DC
C5003
0CH3104K566
C906
0CK104CK56A
C501
0CK103CK56A
C906
0CK105CD56A
C503
0CE107WF6DC
C907
0CE107WF6DC
C504
0CK103CK56A
C908
0CK104CK56A
C505
0CE107WF6DC
C909
0CK104CK56A
C506
0CC390CK41A
C911
0CK105DH56A
C507
0CC390CK41A
C912
0CE226WF6DC
C508
0CK103CK56A
C913
0CK105DH56A
C510
0CK104CK56A
C914
0CK104CK56A
C658
0CC330CK41A
C915
0CK104CK56A
C659
0CC330CK41A
C916
0CE107WF6DC
C660
0CC330CK41A
C918
0CE107WF6DC
C701
0CK104CK56A
C919
0CK104CK56A
C702
0CK104CK56A
C919
0CK105CD56A
C706
0CK104CK56A
C920
0CE107WF6DC
- 23 -
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
ICs
C921
0CK104CK56A
C921
0CK105CD56A
C926
0CE107WF6DC
IC100
EAN33715801
IC101
0IMMRAL026C
0IMCRKE004A
C927
0CC101CK41A
LGE9655-LF(MST96585) 300MVTO3.6V,300MVTO1.9
C928
0CK104CK56A
IC103
C934
0CK104CK56A
IC300
EAN32236001
IC400
EAN33643401
IC700
EAN33594801
IC900
0IMCRAU004A
IC901
0IPMGSG016A
IC906
0ISS780500H
C935
R273
0CE477WF6DC
0CC101CK41A
DIODEs
D400
0DS181009AA
IC907
0IMCRKE010A
D401
0DS181009AA
IC908
0IMCRKE014A
D402
0DS181009AA
IC909
0IPMGRH001G
D600
0DS226009AA
IC910
0IPMGRH001G
D601
0DS226009AA
D602
0DS226009AA
ZD4000
0DZ560009CF
ZD4001
0DZ560009CF
IC903
EBK32753101
ZD5000
0DZRM00178A
Q250
0TR387500AA
ZD651
0DZ560009DA
Q251
0TFIR80017B
ZD653
0DZ560009DA
Q252
0TR387500AA
ZD655
0DZ560009DA
Q253
0TR390609FA
ZD656
0DZ560009DA
Q254
0TR390609FA
ZD657
0DZ560009DA
Q400
0TR150400BA
ZD700
0DZ560009DA
Q402
0TR387500AA
ZD701
0DZ560009DA
Q500
0TR387500AA
ZD702
0DZ560009DA
Q5001
0TR387500AA
ZD703
0DZ560009DA
Q5002
0TR387500AA
ZD704
0DZ560009DA
Q501
0TR150400BA
ZD705
0DZ560009DA
Q504
0TR150400BA
ZD706
0DZ560009DA
Q507
0TR150400BA
ZD707
0DZ560009DA
Q508
0TR387500AA
ZD708
0DZ560009DA
Q900
0TR387500AA
ZD709
0DZ560009DA
Q904
0TR390409AE
ZD710
0DZ560009DA
RESISTORs
ZD711
0DZ560009DA
ZD712
0DZ560009DA
ZD713
0DZ560009DA
R1008
0RJ4701D677
ZD714
0DZ560009DA
R1010
0RJ1002D677
ZD800
0DZ560009DA
R1011
0RJ1002D677
ZD801
0DZ560009DA
R1012
0RJ1002D677
ZD802
0DZ560009DA
R104
0RJ0472D677
ZD803
0DZ560009DA
R1041
0RJ0000D677
ZD804
0DZ560009DA
R1042
0RJ0000D677
ZD805
0DZ560009DA
R1048
0RJ2202D677
ZD806
0DZ560009DA
R1049
0RJ2202D677
ZD811
0DZ560009DA
R105
0RJ0472D677
ZD820
0DZ560009DA
R1050
0RJ4701D677
ZD821
0DZ560009DA
R1051
0RJ4701D677
ZD822
0DZ560009DA
R1052
0RJ0222D677
ZD823
0DZ560009DA
R1053
0RJ0222D677
ZD824
0DZ560009DA
R1054
0RJ0222D677
ZD844
0DZ560009DA
R1055
0RJ0222D677
ZD845
0DZ560009DA
R1057
0RJ0472D677
- 24 -
LOC. NO.
PART NO.
R1059
0RJ0222D677
R106
0RJ0472D677
R1060
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
R163
0RJ0000D677
R164
0RJ1000D677
0RJ0222D677
R166
0RJ0332D677
R1063
0RJ1000D677
R167
0RJ0332D677
R1064
0RJ1000D677
R169
0RJ1000D677
R1065
0RJ3301D677
R171
0RJ1000D677
R1067
0RJ0000D677
R172
0RJ1000D677
R1068
0RJ0000D677
R173
0RJ1000D677
R1069
0RJ1000D677
R174
0RJ1000D677
R107
0RJ0472D677
R175
0RJ1000D677
R1070
0RJ1000D677
R176
0RJ1000D677
R1071
0RJ1002D677
R180
0RJ1000D677
R1072
0RJ4701D677
R181
0RJ0000D677
R1075
0RJ1001D677
R183
0RJ1002D677
R1076
0RJ4701D677
R184
0RJ0332D677
R1078
0RJ4701D677
R185
0RJ0332D677
R108
0RJ0472D677
R186
0RJ0332D677
R1081
0RJ1001D677
R187
0RJ0332D677
R1086
0RJ0000D677
R188
0RJ1000D677
R109
0RJ0472D677
R190
0RJ1000D477
R110
0RJ0472D677
R191
0RJ1000D677
R111
0RJ0472D677
R192
0RJ1000D677
R112
0RJ0472D677
R193
0RJ0000D677
R113
0RJ0472D677
R194
0RJ0000D677
R114
0RJ0472D677
R195
0RJ0000D677
R115
0RJ0472D677
R196
0RJ1000D677
R116
0RJ0472D677
R197
0RJ1000D477
R118
0RJ4701D677
R199
0RJ1000D477
R120
0RJ3301D477
R250
0RJ1002D677
R121
0RJ3301D477
R251
0RJ4701D677
R127
0RJ0472D677
R256
0RJ3000D677
R128
0RJ0472D677
R258
0RJ0222D677
R129
0RJ0472D677
R259
0RJ0222D677
R131
0RJ0472D677
R260
0RJ0222D677
R132
0RJ0472D677
R261
0RJ0222D677
R133
0RJ0472D677
R262
0RJ0000D677
R134
0RJ0472D677
R264
0RJ1002D677
R135
0RJ0472D677
R265
0RJ0000D677
R139
0RJ0000D677
R267
0RJ1002D677
R140
0RJ0000D677
R268
0RJ4701D677
R141
0RJ0000D677
R269
0RJ1002D677
R143
0RJ0000D677
R270
0RJ4701D677
R144
0RJ0000D677
R271
0RJ1002D677
R146
0RJ3900D677
R274
0RJ0000D677
R147
0RJ4701D677
R275
0RJ0000D677
R149
0RJ1002D677
R276
0RJ0000D677
R150
0RJ1002D677
R3204
0RJ4701D677
R151
0RJ1000D677
R4000
0RN6801F409
R152
0RJ1004D477
R4001
0RN2201F409
R155
0RJ1000D677
R4002
0RN1001F409
R156
0RJ1000D677
R4003
0RN6801F409
R157
0RJ1000D677
R4004
0RN2201F409
R158
0RJ1000D677
R4005
0RN1001F409
R160
0RJ0332D677
R401
0RJ0000D677
R162
0RJ0332D677
R402
0RJ1001D677
- 25 -
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
LOC. NO.
R403
0RJ1003D677
R724
0RJ4701D677
R407
0RJ1500D677
R728
0RH0222D622
R408
0RJ4701D677
R729
0RH0222D622
R410
0RJ4701D677
R730
0RH0222D622
R412
0RJ1000D677
R731
0RH0222D622
R413
0RJ0000D677
R737
0RJ5600D677
R414
0RJ1003D477
R738
0RJ5600D677
R415
0RJ1000D677
R739
0RJ1002D677
R418
0RJ0000D677
R740
0RJ1002D677
R419
0RJ1001D677
R741
0RJ1002D677
R420
0RJ1003D477
R742
0RJ9101D677
R421
0RJ1001D677
R743
0RJ9101D677
R500
0RJ1002D677
R744
0RJ0222D677
R5001
0RH1501D622
R745
0RJ0000D677
R5002
0RH1001D622
R748
0RJ1002D677
R5003
0RH1001D622
R749
0RJ0000D677
R5004
0RH1001D622
R750
0RJ1001D677
R5005
0RH1001D622
R751
0RJ1001D677
R5005
0RH2001D622
R800
0RJ0752D677
R501
0RJ0332D677
R801
0RJ0752D677
R502
0RJ0332D677
R802
0RJ0000D677
R506
0RJ2700D677
R803
0RJ0000D677
R507
0RJ1000D677
R823
0RJ4703D677
R508
0RJ2700D677
R824
0RJ4703D677
R509
0RJ1000D677
R825
0RJ1002D677
R512
0RJ1500D677
R826
0RJ0752D677
R513
0RJ1002D677
R827
0RJ1002D677
R514
0RJ1002D677
R834
0RJ9101D677
R515
0RJ4700D677
R835
0RJ9101D677
R517
0RJ1500D677
R837
0RJ0152D677
R518
0RJ3300D677
R838
0RJ0152D677
R519
0RJ4701D677
R866
0RJ0000D677
R520
0RJ4701D677
R880
0RJ0152D677
R652
0RJ2201D677
R881
0RJ0152D677
R653
0RJ2201D677
R887
0RJ4701D677
R654
0RJ0752D677
R888
0RJ4701D677
R655
0RJ0752D677
R902
0RJ1000D677
R656
0RJ0000D677
R904
0RJ4701D677
R657
0RJ0000D677
R906
0RJ3301D677
R658
0RJ1000D677
R907
0RJ1002D677
R659
0RJ1000D677
R909
0RJ3301D677
R660
0RJ1001D677
R915
0RJ1002D677
R661
0RJ0752D677
R916
0RJ4702D677
R702
0RJ1500D677
R929
0RX0912K665
R703
0RJ0752D477
R931
0RX0912K665
R704
0RJ0752D477
R932
0RX0912K665
R705
0RJ0752D677
RA100
0RJ1000C687
R706
0RJ0752D477
RA101
0RJ1000C687
R707
0RJ1500D677
RA102
0RJ1000C687
R709
0RJ5602D477
RA300
0RJ1000C687
R710
0RJ2402D677
RA301
0RJ1000C687
R712
0RJ0000D677
RA310
0RJ1000C687
R715
0RJ4703D677
RA311
0RJ1000C687
R716
0RJ4703D677
R723
0RJ0682D677
- 26 -
PART NO.
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
LOC. NO.
PART NO.
DESCRIPTION / SPECIFICATION
P260
6602T20009B
P270
6602T20009D
L101
6210TCE001G
P280
6602V12001C
L102
6210TCE001G
P400
6602T20009C
L103
6210TCE001G
P4000
6602T20009B
L106
6210TCE001G
P5000
6602T20009D
L107
6210TCE001G
P901
6602T20008K
L109
6210TCE001G
6631900024D
L110
6210TCE001G
6631900026A
L111
6200J00005E
6631900042B
L252
6210TCE001G
L261
6210TCE001A
L262
6210TCE001A
L270
6210TCE001G
JA700
6612M00010A
L271
6210TCE001A
JA800
6612F00024C
L400
6210TCE001G
JA820
6612J10003K
L401
61409B0002A
JA880
6612F00099A
L402
61409B0002A
L403
61409B0002A
L404
61409B0002A
L405
6210TCE001G
SW4000
140-058B
SW4001
140-058B
SW4002
140-058B
SW4003
140-058B
SW4004
140-058B
SW4005
140-058B
SW4006
140-058B
SW4007
140-058B
L406
L407
L408
L409
L410
L411
6210TCE001G
6210TCE001G
6210TCE001G
6210TCE001G
6210TCE001G
6210TCE001G
L412
6210TCE001G
L501
6210TCE001G
L700
6210TCE001A
L701
6210TCE001A
L702
6210TCE001A
L703
6210TCE001A
L704
6210TCE001A
L706
6200J00005E
L707
6200J00005E
JACKs
SWITCHes
OTHERs
L708
6200J00005E
L800
0LC0233002A
L801
0LC0233002A
L820
6210TCE001A
L821
6210TCE001A
L822
0LC0233002A
L880
6210TCE001A
L881
6210TCE001A
L882
6210TCE001A
L900
6210TCE001A
L901
6210TCE001G
IC102
SAA30688501
LED500
0DLBE0138AA
PA5000
6712SCA232A
TU500
EBL35311201
TU500
EBL35311207
X100
6202VDT002B
6631900037A
CONNECTOR
J805
6602T10002E
J806
6602T10002F
JA650
6630TGA004H
LB2
6631T20038G
P253
6602T10002F
- 27 -
ACCESSORY
A1
MFL33997808
A1
MFL33997809
A2
SAC30033604
A3
6410TEW010A
A3
6410TPW003A
A4
MKJ32816601
A5
MCK36017402
P/NO : MFL37159901
Feb., 2007
Printed in Korea