Professional Documents
Culture Documents
How To Achieve The "Sweet Spot" For Acrylic Coating Thickness
How To Achieve The "Sweet Spot" For Acrylic Coating Thickness
net
manufacturers aim between about .002 to .003, and meeting that guideline will ensure that you
stay within the two major thresholds of the two major specifications called out in the standard.
When calibrating the conformal coating machine, the finished substrate should meet these
thicknesses, and the standard should be in the companys product specification sheet, so that
everyone involved in the process knows what the standard is expected to be. If the standard
thickness is not met, then this could lead to failure of what the coating is trying to protect on the
final PCB--especially when trying to prevent moisture ingress on it.
Coating machines can meet this standard easily if the PCB requirements and the type of
machine are correctly matched. Then it is up to the machine programmer to get that pattern
and amount of passes correct that spray the PCB to ensure that the substrate has the correct
thickness on the finished product. Improper thickness is usually caused by too many passes
programmed into the coordinate software program, or on the other end of the spectrum-- there
may not be enough passes--resulting in conformal coat thickness falling under specification.
In these cases, the program would need to be tweaked a little by the developer to have it fall
back into the range of the standard without any deviation once it is complete. During these
processes there are measuring methods to gauge the thickness of the conformal coating using
a manual process or testing equipment.
Let the area dry and take measurements of the area again. The difference between the
beginning and end measurements will be your record for thickness. Write these measurements
down in a standardized record that shows proof that thickness was calibrated before beginning
a run of production. Periodically run other tests during the run to ensure the process is staying in
control.
Another dry method that is used frequently is testing equipment that utilizes eddy currents to
test conformal coat thickness. It is a little more expensive, but involves a non-contact technique.
The measurements involve lightly placing a test probe head on the surface of the coating to get
an almost instantaneous readout. This method is one you may want to invest in if the volume is
high for the amount of PCBs being produced on conformal coating printed circuit boards. The
measurement devices are extremely accurate, up to thin films of 25-50 um and 1 um for a
device such as the Positestor 6000, and are also recommended for high volume because they
are also very quick to display measurement readings.
Wet Film Conformal Coating Measurement
This method involves using a wet film gauge to measure the coating while its still wet, and it
allows operators to test and help accomplish quality assurance before the coating dries.
There are advantages to using this method. For one thing, applying to much conformal coating
costs your business a lot of money, and its also useful for conformal coating processes where
dry coating thickness can only be measured by using destructive methods.
How to do it: the wet film gauge is placed into the wet conformal coating after application until
the teeth of it contacts the substrate or surface of the components measured. There are
measurements on the gauge that indicate how thick the coating is. Count the measurement line
that the conformal coating has risen to. You will be able to tell the dry film coating thickness by
calculating it from measurement s derived from the solid resin content of the coating on the
PCB.