Professional Documents
Culture Documents
INSTRUCTION
HOLY ANGEL UNIVERSITY
AERONAUTICAL ENGINEERING DEPARTMENT
DATE :
28 July 2015
I.
SUBJECT:
Engine Main
Disassembly
II.
REFERENCE:
III.
EFFECTIVITY:
Dornier DO328-100
IV.
BACKGROUND:
V.
DESCRIPTION:
VI.
COMPLIANCE:
VII.
None.
VIII.
MATERIAL INFORMATION:
PART NO. /
REFERENCE NO.
PWC37388
PWC37389
PWC37390
PWC37392
PWC05-054
Accessory
Drive
NOMENCLATURE
QTY
Holding fixture
Socket
Puller
Puller
Bag, polyethylene
n/a
n/a
n/a
n/a
As required
Gearshaft
SIGN OFF
Page 1 of 5
INSTRUCTIONS
IX.
X.
XI.
MAINTENANCE PLANNER
A) Schedule accomplishment of E.I. No. HAU EI-72-01.
_____________
_____________
MAINTENANCE CONTROLLER
A) Monitor accomplishment of E.I. No. HAU EI-72-01.
_____________
_____________
MATERIAL PLANNER
A) Ensure availability of materials prior to accomplishment of E.I.
No. HAU EI-72-01.
INSTRUCTIONS
_____________
SIGN OFF
Performe Inspector
Page 2 of 5
d by:
XII.
ACCOMPLISHMENT PROCEDURES
Disassembly
1. Put the holding fixture (PWC37388) in the bench vise.
______
______
______
______
3. Use the socket (PWC37389) and a torque wrench to remove the nut
(10) from the spur gearshaft (4).
______
______
4. Remove the keywasher (9) and the oil seal runner (8) from the spur
gearshaft (4).
______
______
5. Use the puller (PWC37390) to remove the No. 25 rear bearing (7)
from the spur gearshaft (4).
______
______
6. Remove the bolts (5) and the keywashers (6) from the spur
gearshaft (4). Discard the keywashers.
______
______
7. Remove the
(PWC37388).
______
______
______
______
______
______
10. Remove the packings (2, 3) from the spur gearshaft (4). Discard the
packings.
______
______
______
______
spur
gearshaft
(4)
from
the
holding
fixture
Page 3 of 5
FIGURES
Page 4 of 5
XIII.
ACCOMPLISHMENT RECORD
a) Aircraft Registration: ___________________
b) Aircraft TSN / CSN: ___________________
c) Date Accomplished: ___________________
d) Mechanic and License No.: ___________________
e) Inspector and License No.: ___________________
Prepared By:
Approved by:
Engineering Student
Engineering Instructor
Date: _________________
Page 5 of 5