REDUCED NO-LOAD POWER LOSS. Sachin George Thomas Applied Electronics and Instrumentation College of Engineering Trivandrum Guided By :
Ms. Chandini G.S.
October 30, 2015
Overview
Introduction Motivation Problem Definition Methodology References
Introduction
Most of the portable products in our lives are powered by d.c
voltage and ac-dc adapters are used for conversion from the ac voltage to the required dc voltage.
The ac-dc adapter is composed of a rectifier, a dc bus
capacitor and a dc-dc converter.
The dc-dc converter can be of the isolated type which
includes flyback converters and forward converters or the non-isolated type .
Introduction
The flyback convertor which comes under the category of
isolated converter is of particular interest in this work.
Motivation
Compared to the flyback converters , the forward converters
requires a reset winding , an output inductor and a free wheeling diode which causes larger volume and more cost.
Even the conventional flyback converters suffers from low
conversion efficiency and high no-load power loss.
MOTIVATION
Furthermore , the parasitic capacitance of the transformer
between the primary and secondary windings needs to be reduced inorder to keep the common voltage under control.
Problem Definition
Requirement for a flyback converter with improved conversion
efficiency, reduced no-load power loss , and a power factor correction circuitry.
Methodology
Design of the lossless snubber circuit for suppressing the
voltage spikes
fig : Flyback convertor with RCD snubber
Methodology
Design of the energy recovery winding to recycle the energy
discharged from the gate -source capacitor of the main switch.
Check for the feasibility of a Power Factor Correction (PFC)
circuitry and if possible integrating the same.
Integration of all the circuits .The simulation can be carried
out in SIMULINK/SIMPLIS.
WORK PLAN
References
Ray-Lee Lin and Shih-Ho Hsu , Design and
Implementation of Self-Oscillating Flyback Converter With Efficiency Enhancement Mechanisms IEEE Transactons on Industrial Electronics,Volume 62,Issue 11,pages 6964-6955,November 2015
J.Y.Guo, Design and implementation of forward-flyback
converter with feed forward mechanism for mobile phoneM.S thesis,National Cheng Kung University,May 2013
Hao Ma , Yue Ji and Ye Xu, Design and Analysis of
Single-Stage Power Factor Correction Converter With a Feedback Winding IEEE Transactons on Power Electronics,Volume 25,Issue 6,pages 1460-1471,June 2010