Professional Documents
Culture Documents
Thesis format
COURSE NO: EEE-800
1.
The top page: It is a HARD BOUND page or NORMAL page for Spiral binding
copy.
(See example on page I )
2.
3.
4.
It have:
a. The heading NOTATION on the top. (Font 16, Bold, Centered, Capital letter)
b. Text describing the significant of symbol used. (Font 12, left aligned, Normal)
Spacing between these contents:
Spacing between a and b is 3 blank spaces of 12 fonts.
7. The CONTENTS: (See example on page VII )
It have:
a. The heading CONTENTS on the top. (Font 16, Bold, Centered, Capital letter)
b. Text describing the contents.
(Font 12, left aligned, Normal)
Title of the chapter should be written as:
CHAPTER I
INTRODUCTION
PAGE NO.
1.1 General concept of traffic signal
1
1.2
3
CHAPTER II HARDWARE DESIGN
2.1 Types of parallel port
10
8. BODY OF THE THESIS:
a. The word CHAPTER.
(Font 16, Bold, Centered, Capital letter)
b. The chapter number.
(Font 16, Bold, Centered, ROMAN)
c. The name of the chapter.
(Font 16, Bold, Centered, Capital letter)
d. Paragraphs.
(Font 12, left aligned, Justified)
e. Sub-hading and Sub-sub-heading
(Font 12, Bold, left aligned, Capital letter)
( sub-hading: 1.1.2 and Sub-sub-hading 1.1.1.2 etc)
f. The general text will be written in Times New Roman font and with 1.5 line
spacing.
9. REFERENCES: (Examples, See page 9)
i) Journal:
ii) Books:
iii) M.Sc./ P.hd. thesis.(etc)
10. Page set-up and paper size:
a. Final copy must be hard bounded copy.
b. Paper size A4.
c. Page set-up: left-1.5 inch, right- 1 inch, top-1 inch and bottom-1 inch.
d. Page number at right top corner from Chapter-1 onwards.
e. All figures, Tables and equations must be numbered and should be at the centre
of the page.
(A MINOR ADJUSTMENT FOR INCONVENIENCE IS ALLOWED)
i
(Cover page)
THESIS TITLE
(font 16-24)
Name of Student 2
Student # XXX
( Monogram of MEC )
ii
THESIS TITLE
Student Name 1
Student # 00206
Student Name 2
Student # 00201
January, 2016
iii
THESIS TITLE
(font 14-24)
A THESIS (font-14)
Submitted in partial fulfillment of the requirements for the award of
the degree
of (font 12)
BACHELOR OF SCIENCE
IN
ELECTRICAL & ELECTRONIC ENGINEERING
BY
(font 14)
Student Name (font 14 bold)
Student # XXX
Registration # XXXX
Session 2010-2011 (font 12)
In co-operation with
Student Name
Student Name
Student # XXX
Registration # XXXX
Session 2010-2011 (font 12)
Student # XXX
Registration # XXXX
Session 2010-2011 (font 12)
iv
ACKNOWLEDGEMENT
(font 14 bold)
{ Text here font 12 }
ABSTRACT
(font 14 bold)
{ Text here font 12}
vi
Contents
Pages
iv
v
viii
x
xi
xiii
Introduction
The multiuser Communications
The Cellular Concept
Modes of Channel Operation
Aims and Objectives of this Work
Organization of the Thesis
1
2
5
7
9
10
Introduction
Cellular CDMA Systems
The Uplink in a CDMA System
The Downlink in a CDMA System
Theoretical Capacity in a CDMA System
TDD Properties
TDD Bandwidth Efficiency
Channel Reciprocity.
RF Hardware Implication
TDD-CDMA
TDD and Power Control.
The TDD Air Interface of UMTS.
Radio Resource Allocation Techniques
12
13
16
17
18
19
19
21
22
23
24
24
25
REFERENCES
(font 14 bold)
[1]
[2]
[3]
[4]
[5]
Mohammad Shahed Akond, Fast and Efficient Computational Technique for the
Solution of Electromagnetic Scatering Problem, M.Sc. Engg. thesis Dept. EEE,
DUET, Gazipur, Bangladesh, Aug. 2004.
[6]
M. Shell. (2002, May 10). The test flow diagnostic suite. [Online]. Available:
http://www.ctan.org/tesarchive/macros/laex/contribut/suppoted/IEEtran/testflow.
[7]
The general text will be written in Times New Roman font and with 1.5 line spacing.
Final copy must be hard bounded copy (3 copies).
Paper size A4.
Page set-up: left-1.5 inch, right- 0.5 inch, top-1 inch and bottom-0.8 inch.
Page number at right top corner from Chapter-1 onwards.
All figures, Tables and equations must be numbered and should be at the centre
of the page.
(A MINOR ADJUSTMENT FOR INCONVENIENCE IS ALLOWED)