Professional Documents
Culture Documents
الدائرة الخدميه في كرسي الاسنان..نبهان اعبية
الدائرة الخدميه في كرسي الاسنان..نبهان اعبية
Projector Unit - 1
Cup & Cuspidor Unit - 2
Saliva Ejector Unit - 3
Chair Unit - 4
Projector Unit - 1
The process of lighting in your teeth differ from those in normal
lighting: So are not directly from the lamp to the patient's eye, but
is through the light-reflecting curved incised to work on a reverse
.lighting and focus on the position of the mouth only
:The lamps used are two types
Tungsten Lamp by alternating voltage and the capacity of 100 - 1
.watts used in older devices
Halogen Lamp by a small voltage (12-24) volts and high - 2
.capacity of 50-150 watts
"Return to the form 4"
Service for the maintenance of the lamp, you must run only when
required for use; because of the lamp base hours of operation,
.which carries the heat generated, for certain
The Service consists of part Alvntore valve and open the water
"can be electrically or mechanically" and pipes connected to the
.patient's mouth
Electrical chair .2
using this type of dental chairs in modern devices and operating all
the movements in the chair through the switches manually or by
.foot
It consists of the chair base or support seating, and back of the
chair, the headrest and armrest, either internal parts consist of the
oil tank and oil pump, pistons and uploaded, valves, and relays, or
.Faith operating, switches height determination
.To understand the rise and the coming of the Holy See Figure 5
:rising the seat .1
When you close the key onto the relay CR2 will work, whereupon
SV1 running while you stimulate RelayCR1 engine oil pump and
make it spin and working to pay the oil inside the compressors
worked to raise the chair, and continues to climb to reach the high
rise depends limited by limit switch (LS1) which determines the
.height of the rise of the chair
:Lowering the seat .2
When you shut down the key will open the valve SV2 and works
.on the return of oil to the oil tank and drop the chair
:Rising the backrest .3
When you close the key to forward the relay CR4 will work
whereupon the operation of the valve SV3 and Relay CR1.
Stimulates 1Relay CR engine oil pump and make it going, is
working to raise the back of the chair, and continues to rise back to
reach a specific height is dependent by ascending limit switch LS3
.which determines the height of the rise of the chair
:the backrest Lowering .4
When you close the back key, the SV4 valve will open, is working
.to restore the oil to the Treasury and the back of the chair down
To ensure the continuation of the movements required in the
.previous four chairs must continue pressing the keys required
:Preset .5
When you close the key to preset the relay CR6 and 7relay CR will
work, relay CR6 stimulate 2relay CR. 2relay CR stimulate valve
SV1 and CR1. Relay stimulate engine oil pump is working to raise
the chair up, either 7relay CR, it stimulates 4SV who works on the
descent back of the chair, 7 CR-relay CR6 to continue the work to
.be kept off-key delivery LS5-LS6
:Auto return .6
When Auto return key to close the relay CR5 will be gearing up
and open the valve SV2 and down the chair and stimulate the
relay CR4, which stimulates the valve SV3, and relay CR1 which
stimulate the engine pump the fat and lift back of the chair CR4 .5
relay CR to continue to work uninterrupted delivery of the keys
.LS2-LS3
Continue as the previous two movements Preset and auto and
return
To stop these movements enough to touch any of the first four
keys depends then instruct the issued and can be run movements
Down and up through the foot switch at the bottom of a chair as
.well as hand the keys at the top of the chair
It should be noted that the chair can rotate the entire 360-degree
angle to the direction of what is needed by the doctor through the
pedal feet placed under the base of the Holy headrest can be
.moved mechanically to the desired position
For the maintenance of this type of chairs should be back into the
chair to zero upon completion of the return of keys and observe
the descent of the Holy and the descent of the chair to zero, to
.preserve the valves down
:Air compressor
The air pressure in the teeth of the parts that cannot be dispensed
:with and consists of two types
.A. Electric air compressor
.B. Mechanical air compressor
:Air Tank
When you start running your teeth begin to pay the air pressure of
air into the air tank, and continued until it reaches the air inside the
tank to the required pressure, then start pressure switch to cut off
electricity supply depends on the engine to pump air into the
reservoir. When you start using the first to use compressed air and
pressure drop inside the tank the pressure switch to bring
electricity to the engine to start the process of pumping the air
.again and deliver it to the total pressure