Professional Documents
Culture Documents
Power Decoupling
Power Decoupling
www.softroniics.in
9037291113, 9037061113
Softroniics
which makes it out of common use. In addition, when applied to a power
system with a different topology, the controller needs to be redesigned. On
the other side, the CRIMs are using an additional device to afford the
alternating power so as to suppress the ripple. Even though there are
several additional devices in the CRIMs which increase cost, the CRIMs
are still praised for their mobility and reliability in various applications
since the ripple reduction is executed by the auxiliary equipment.
Existing system
H-bridge that enables a voltage to be applied across a load in either
direction. These circuits are often used in robotics and other applications to
allow DC motors to run forwards and backwards. Most DC-to-AC
converters (power inverters), most AC/AC converters, the DC-to-DC
pushpull converter, most motor controllers, and many other kinds of
power electronics use H bridges. In particular, a bipolar stepper motor is
almost invariably driven by a motor controller containing two H-bridges.
An H bridge is built with four switches (solid-state or mechanical). When
the switches S1 and S4 (according to the first figure) are closed (and S2
and S3 are open) a positive voltage will be applied across the motor. By
opening S1 and S4 switches and closing S2 and S3 switches, this voltage is
reversed, allowing reverse operation of the motor. The switches S1 and S2
should never be closed at the same time, as this would cause a short circuit
on the input voltage source. The same applies to the switches S3 and S4.
This condition is known as shoot-through.
Softroniics
Calicut||Coimbatore||Palakkad
www.softroniics.in
9037291113, 9037061113
Softroniics
Proposed system
The paper focuses on the inverter itself and proposes a power
decoupling method based on a novel four-switch single-phase inverter
instead of the traditional H-bridge inverter. The four-switch converter is a
three-port converter which is able to operate independently like a
conventional inverter or rectifier and is not limited by two-stage systems.
Furthermore, compared with the H-bridge inverter, no switches are added
in the presented topology. After analyzing the equivalent model of such
topology, ignoring the imperfection of the switches, the power of the dc
port and ac port can be controlled without interaction by choosing the
independent variables reasonably. The corresponding power control
strategy is illustrated with two inductors current as a control variable.
Then, the control parameters are designed easily, which is similar with the
control parameter design of the H-bridge inverter and half-bridge dc/dc
converter.
Softroniics
Calicut||Coimbatore||Palakkad
www.softroniics.in
9037291113, 9037061113