rmal release ratio of the radio channel exceeds the alarm threshold.
The traffic volume is zero in the configured detection period.
The BTS detects that the UL level and the DL level differ greatly. The channel type or channel status on the BSC side is inconsistent with that on the BTS side. Procedure 1. Locate the cause of the alarm on the M2000. a. Locate the cause of the alarm 8008 Radio Link Failure Description This alarm is reported when the BTS detects that the radio link is faulty. Parameters Impact on the System System Actions The alarm is automatically cleared when the system detects that the fault in the radio link is rectified. Possible Causes The abnormal release ratio of the radio channel exceeds the alarm threshold. The traffic volume is zero in the configured detection period. The BTS detects that the UL level and the DL level differ greatly. The channel type or channel status on the BSC side is inconsistent with that on the BTS side. Procedure 1. Locate the cause of the alarm on the M2000. a. Locate the cause of the alarm based on the alarm location information. If "Specific Problem" is "Release Abnormal", go to step 2. If "Specific Problem" is "No Traffic on TRX", go to step 3. If "Specific Problem" is "Uplink and Downlink Imbalance", go to step 4. If "Specific Problem" is "Activation Abnormal", go to step 5. 2. Check for the interference and improper data configuration. a. Check the TRX-level counters for interference. The TRX-level counters are the receive quality counter and interference band counter in the measurement report. Y => The interference exists. Go to sub-step b. Y => The interference does not exist. Go to step 5. Parameter Name Parameter Description Cabinet No. Cabinet number of the faulty board Subrack No. Subrack number of the faulty board Slot No. Slot number of the faulty board Carrier No. Faulty carrier number Specific Problem Specific Problem of the alarm(Activation A