You are on page 1of 28

SJ-43L-A2

SJ-47L-A2

SERVICE MANUAL
S2204SE47JPSY

REFRIGERATOR-FREEZER

MODELS

SJ-43L-A2G/A2S
SJ-47L-A2G/A2S
In the interests of user-safety (Required by safety regulations in some
countries) the set should be restored to its original condition and only
parts identical to those specified should be used.

SJ-43L

SJ-47L

DESTINATION .........................Y

Refrigerant; HFC-134a
Refer to "HFC-134a COOLING UNIT" Service Manual for handling this refrigerant.

TABLE OF CONTENTS
page
CAUTIONS AND INFORMATIONS .................................................................................................................. 2
SPECIFICATIONS ............................................................................................................................................ 3
DESIGNATION OF VARIOUS PARTS ............................................................................................................. 4
DIMENSIONS ................................................................................................................................................... 5
LIST OF ELECTRICAL PARTS ........................................................................................................................ 7
WIRING DIAGRAM ........................................................................................................................................... 8
FUNCTIONS ................................................................................................................................................... 10
ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS ............................................................. 13
COOLING UNIT .............................................................................................................................................. 19
REPLACEMENT PARTS LIST ....................................................................................................................... 21

SHARP CORPORATION
1

SJ-43L-A2
SJ-47L-A2

CAUTIONS AND INFORMATIONS


In case of following troubles, the cause is not related with the failure of refrigerator.
Please mention the correct way to the customer for the use of refrigerator when the repairing.

1. Some foods freezed in the refrigerator compartment.


Do not place food directly in front of
cold air outlet.
This may lead to the food freezing.

cold air flow


IN
OUT

2. Some plastic parts were cracked or splitted.

Some household cleaning chemicals may affect the internal


food liner and plastic parts resulting in splitting or cracks
occurring.
When cleaning all plastic parts inside this refrigerator, only
use diluted dishwashing liquid(soapy water). Make sure that
all plastic parts are thoroughly rinsed with water after cleaning.

3. IT IS NORMAL for the refrigerator to produce the following sounds.

Cracking or crunching sound;


Sound produced by expansion and contraction of inner walls and internal parts during cooling.
Squeaking sound;
Sound produced by expansion and contraction of internal parts.
Sound of flowing fluid (gurgling sound, fizzing sound);
Sound of refrigerant flowing in pipes (sound may become louder from time to time).

SJ-43L-A2
SJ-47L-A2

SPECIFICATIONS
Items
Type
Outer dimensions
(Including spacer)

Height
Width
Depth

Rated storage volume


(Rated volume)
Gross volume

Defrosting

System
Start
Finish

Temperature control
No-frost freezer
Interior lamp
Caster
Evaporating pan
Refrigerator
Refrigerator tray
Compartment
Vegetable tray
Vegetable case
V parting plate
R door pocket
Egg tray
R door pocket S
Bottle pocket
Bottle stopper
Door pocket
Fresh case
Freezer
Freezer tray
Compartment
Ice cube maker
Ice storage box
Door pocket
Deodorizing unit
RATING
Items
Rated voltage
(V~)
Rated frequency
(Hz)
Climate class
Rated current
(A)
Rated input
(W)
Rated input of heating elements (W)
Refrigerant (Charging quantity)
Net Weight
(kg)
PLUG TYPE
Plug cord
Plug type

Destination mark
COLOR
Items
Outside color
Inside color

SJ-43L-A2
2-Door
1700mm(66.9")
680mm(26.8")
660mm(26.0")
347 liter (12.3cu.ft)
F: 99liter (3.5 cu.ft)
R: 248 liter(8.8 cu.ft)
370 liter (13.1cu.ft)
F: 107liter (3.8 cu.ft)
R: 263 liter(9.3 cu.ft)
Heater system
Automatic
Automatic
Automatic (Adjustable)
Yes
1
2
1
2
1
1
1
1
1
2
1
1
1
1
1
Twin ice cube maker
1
2
2 ( Honeycomb type)

SJ-47L-A2
2-Door
1820mm(71.7")
680mm(26.8")
660mm(26.0")
384 liter (13.6 cu.ft)
F: 99 liter (3.5 cu.ft)
R: 285 liter(10.1 cu.ft)
407 liter (14.4 cu.ft)
F: 107 liter (3.8 cu.ft)
R: 300 liter(10.6 cu.ft)

SJ-43L-A2
220-240
50
ST
1.2-1.3
126-130
128-152
HFC-134a(105g)
66

SJ-47L-A2

68

2 pin
C-2

Y
-A2G
Gray
White

-A2S
Silver
3

SJ-43L-A2
SJ-47L-A2

DESIGNATION OF VARIOUS PARTS


The names are the denominations used in the
REPLACEMENT PARTS LIST.

18
1

19

2
3
20

4
5
6
7
5
8

21
22
23

24

10
11
12
13
14

25
26

20

15
16
17

21
Figure D-1. External Description

1. Freezer temp. control knob


2. Freezer shelf(Freezer tray)
3. Ice cube maker
4. Ice cube box(Ice storage box)
5. Deodorizing unit
6. Fresh case
7. Refrigerator temp. control knob
8. Light(Lamp)
9. Refrigerator shelf(Refrigerator tray)
10. Lever
11. Shelf(Vegetable tray)
12. Vegetable crisper(Vegetable case)
13. Separator plate(V parting plate)
14. Evaporating pan
15. Casters
16. Ventilating grille
17. Adjustable feet(Adjustable leg assy)
18. Fan switch
19. Fan & light switch
20. Utility pocket(Door pocket)
21. Magnetic door seal(Door packing)
22. Egg holder(Egg tray)
23. Egg pocket(R door pocket)
24. Small pocket(R door pocket S)
25. Bottle guard(Bottle stopper)
26. Bottle pocket

Upper hinge cover

Mark: Cold air flow

Hot pipe
Fan motor
Freezer
compartment

Defrost thermostat
Evaporator

Freezer temp. control knob

Defrost heater

Hot pipe
Refrigerator
compartment

Damper thermostat
Refrigerator temp. control knob
Drain pipe
Vegetable case
Evaporating pan

Ventilating grille

Compressor
Starting relay, Overload relay(Protector)
Defrost timer

Adjustable leg assy

Caster

Figure D-2. Constructions


4

SJ-43L-A2
SJ-47L-A2

DIMENSIONS
OUTER DIMENSIONS AND CLEARANCE

more than

60
more than

680

more than

60

more than

60

680

73
16

1320

1022.5

1700

1260

9.5

595

90

660

472
1210
1: Include the badge
Not include the handle

(Unit : mm)

Fig. E-1(SJ-43L)

more than

60
more than

680

more than

60

more than

680

60

1320

1260

9.5

1820

472
73
16

1142.5

595

90

660

1210

1: Include the badge


Not include the handle

Fig. E-2(SJ-47L)
5

(Unit : mm)

SJ-43L-A2
SJ-47L-A2

INNER DIMENSIONS

502

229

The dimensions between shelves can be changed by setting the shelves on the other rails.

89

232

518

118

89

112

531
242

510

269

(125)

99

242

524

246

(168.5)

99

269

(165)

126

225

502

320

226

524
526

508.5

502

321

210

502

82

188

526

(Unit: mm)

502

229

Fig. E-3(SJ-43L)

89

232

518

99
242
99

242

510

269

(185)

126

524

502

82

526

320

226

526

225

246

269

(175)

524

(218.5)

112

531

628.5

89

118

502

321

210

502

188

(Unit: mm)

Fig. E-4(SJ-47L)
6

SJ-43L-A2
SJ-47L-A2

LIST OF ELECTRICAL PARTS

ITEMS
Thermostat

TYPE NAME
MM1-8149

Defrost thermostat
Thermo. fuse
Fan motor
Defrost heater
Door switch
Damper thermostat
Defrost timer

S101
SF70E
3R00121A
MM6-4264
DSD-5
MM1-6173
ND1004M2

Lamp socket
Lamp
Compressor

FL1568SD

RATING
125V 6A
250V 3A
250V 8A
250V 10A
220-240V 50/60Hz
220-240V 378
250V 0.25A

220-240V
50/60Hz
250V 1A
240V 15W
220-240V/50Hz

SPECIFICATIONS
(At normal notch)
ON/OFF : -20 / -25C
Open/Close : 8 / 1C
Working temp. : 70C
Working with 100 fan
140W at 230V
4 terminals push-button type
Open/Close : 5 / 0C
Integration type
Cycle time : 10h44m/8h57m(50/60Hz)
Delay time : 4m20s/3m37s(50/60Hz)
E-12(Hard plastic body type)
E-12
Cooling capacity : 188W (50Hz)
Main coil : 13.3
Common
Aux. coil : 25.6
(at 25C)

Aux. coil

Starting relay
PET0SAT
Overload relay(Protector) 1.8C36A1

22 300V
Open/ Close : 130/60C

Main coil

SJ-43L-A2
SJ-47L-A2

WIRING DIAGRAM
Be sure to replace the electrical parts with specified ones for maintaining the safety and performance of the set.

GY
BR
OR
Y
R
P
BL
BK
SB
G-Y
W

: GRAY
: BROWN (live)
: ORANGE
: YELLOW
: RED
: PINK
: BLUE (neutral)
: BLACK
: SKY-BLUE
: GREEN-YELLOW (earth)
: WHITE

CONNECTED IN TERMINAL BOX


CONNECTOR

Timer
(BR)

(GY)

(R)
F-Thermostat

TM

Lamp

FM

Source
Plug

Thermo.
fuse

(BK)

(Y)

Protector

Fan motor
(OR)

(SB)

(W)

Defrost
heater

Door switch
(BL)

Compressor

Defrost
thermo.

C
M
A
Starting relay

Figure W-1. Wiring Diagram

SJ-43L-A2
SJ-47L-A2

Cabinet assy

E.V. cover assy


Lead EV-cover assy
Fan motor

FM

F-thermostat
Def thermo. assy
Fuse assy

Def. heater assy

GY-1
OR-1
R-1
BR-1
Y-1
BL-1
BK-1
W-1

1
5
2
6
3
7
4
8

1
5
2
6
3
7
4
8

1
2

(W-1)
1
2 Y-2

Door switch
2 (PUSH OPEN)
1 (NEUTRAL)
3 (PUSH CLOSE)
4 (PUSH OPEN)

1
2
3
4

BL-2
(OR-1)
SB-1

R lamp box assy


Lamp

15W

L
Lamp socket

1
2

1
2

BR-2
(SB-1)

Terminal box

TM

1
2
3
4

1
2
3
4

(Y-1)
(Y-2)
(BK-1)
(R-1)
GY-2

BLUE

BROWN

GRAY
EARTH

Defrost timer

GY
BR
OR
Y
R
P
BL
BK
SB
G-Y
W

: GRAY
: BROWN (live)
: ORANGE
: YELLOW
: RED
: PINK
: BLUE (neutral)
: BLACK
: SKY-BLUE
: GREEN-YELLOW (earth)
: WHITE

Protector

1
L
E
N

Compressor
C
M
A

Source cord
Starting
relay

Figure W-2. Electric Accessories Layout

Terminal block

SJ-43L-A2
SJ-47L-A2

FUNCTIONS
1. ADJUSTABLE TEMPERATURE CONTROL
(1) Temperature control of freezer
Thermostat (senses freezer temperature) operates on ON/OFF switchover to control the compressor and
cool air circulating fan , and allows the freezer temperature to keep at a suitable temperature.
However adjust the freezer temp. control knob as follows depending upon the storing condition of foods.
PURPOSE

KNOB
SETTING
MAX(Coldest)

For making ice rapidly or fast freezing.


When restocking with fresh food.
For normal freezing.

MED

For storing frozen food for a short period (up to one month).
When frozen food or ice cream is not stored.

MIN
Figure F-1.

(2) Temperature control of refrigerator


Damper-thermostat senses temperature of the refrigerator and changes the opening angle of the damper
automatically.
However, as the Damper-thermostat has no function to switch on or off the compressor and fan motor, the
freezer temperature control causes temperature in the refrigerator to vary to some extent.
However, adjust the refrigerator temp. control knob as follows depending upon the cooling condition.
PURPOSE

KNOB
SETTING

For keeping freshness of food longer.

Coldest

When the refrigerator does not provide sufficient cooling.


For normal operation.

MED

When the refrigerator provides excessive cooling.


MIN
Figure F-2.
NOTE:

The refrigerator temperature is affected also by the freezer temperature. If the freezer temp.
control knob is set at the position "MAX", the temperature tends to be lower than the following
values, and if set at near the position "MIN", temperature tends to be higher.
If the refrigerator is operated for a long time with the freezer temperature control sets the "MAX"
position, foods stored in the refrigerator compartment may also freeze.
When refrigerator temperature control sets to the "Coldest", some foods stored may freeze.
In this case adjust control set back to the "MED" position.
When refrigerator temperature control sets to the "Coldest", some foods stored in Fresh case may
also become frozen.

(3) Reference value of temperature


SETTING OF
FREEZER TEMP.
CONTROL KNOB

MAX
(Coldest)

MED

MIN

Freezer
temperature

Approx.
-21C

Approx.
-18C

Approx.
-15C

SETTING OF
REFRIGERATOR TEMP.
CONTROL KNOB

Coldest

MED

MIN

Refrigerator
temperature

Approx.
0c

Approx.
3c

Approx.
6c

Fresh case
temperature

Approx.
-3c

Approx.
1c

Approx.
4c

The values shown above refer to the case where the


freezer temp. control knob is set at "MED".
The values shown above refer to the measurement carried out center area and 1/3 of overall height from the bottom
at each of the refrigerator and the freezer after machine has been operated at an ambient temperature of 30C with no
food stored and the door closed until the temperature is stabilized.
The values vary depending upon frequency of opening and closing the door, ambient temperature, amount of stored
foods and manner of storing foods.

10

SJ-43L-A2
SJ-47L-A2

2. DEFROSTING
(1) No defrosting operation is necessary
No defrosting operation is necessary.
As this machine is so designed that a built-in
evaporator cools air and a fan circulates cooled
air, neither the freezer nor the refrigerator is
frosted, though the evaporator is frosted.
The frosted evaporator is defrosted automatically
due to the function of defrosting timer and heater,
requiring no defrosting operation.

(2) Where is melted frost brought


1. Melted frost is brought into the evaporating
pan at the back of the set and is evaporated
here by the heat of compressor.
2. Be sure to use Evaporating pan as inserted
so as to be level with the outer case.

(3) The following circuit diagrams in the table show automatic defrosting function of the refrigerator with
timer and defrost thermostat.
Operation
1. Cooling
(Normal)

Electric diagram
Defrost thermostat ON

Compressor running
Timer motor running

Thermo. fuse

Defrost heater

TM

Defrost
thermostat (ON)

COMP

Compressor

Timer contact
Timer motor

SOURCE

Thermostat

Description
The integration timer integrates running
time of the compressor. When it reaches
cycle time of defrost timer, the timer
contact is changed to start defrosting.

Figure F-3.
Defrost thermostat ON

(Time 20 to 30 min.)

Thermo. fuse

Defrost heater

TM

Defrost
thermostat (ON)

COMP

Compressor

Timer motor stops


Timer contact

Thermostat

SOURCE

Compressor stops

Timer motor

2. Defrosting

The timer contact is changed to start


defrosting, the timer motor stops, and
power is supplied to the defrost heater.
It takes about 20 to 30 min. to defrost.
When little frosted, the defrosting takes
little time. When much frosted, the defrosting takes much time.

Figure F-4 .
Defrost thermostat OFF

Thermo. fuse

Defrost heater

TM

Defrost
thermostat (OFF)

COMP

Compressor

Thermostat

SOURCE

Compressor stops
Timer motor running
Timer contact

(Time approx. 5 min.)

Timer motor

3. Drain

When the defrost thermostat becomes


OFF, the timer motor starts running.
During the operation time (delay time
of defrost time) defrosted water is
drained outside the refrigerator.

Figure F-5.
Defrost thermostat OFF

SOURCE

Thermostat

Compressor running
Timer motor stops
Timer contact

Thermo. fuse

Defrost heater

TM

Defrost
thermostat (OFF)

Figure F-6.

11

COMP

Compressor

(Time approx. 5 min.)

Timer motor

4. Restart

Timer contact is changed to cooling


operation and the compressor starts
running and the timer motor stops.
Defrost thermostat contact becomes ON
when its cooled. And the timer motor
starts running. (Figure F-3.)

SJ-43L-A2
SJ-47L-A2

(4) As a reference to determine the causes of trouble, malfunction and phenomena are described below.
Refer to the following when repairing.
1. Disconnection of defrost heater
As off-cycle defrosting is performed, the defrosting time is extremely prolonged. Each time defrosting is
started, the freezer temperature rises and a portion of ice and stored foods are melted.
2. Melted thermo. fuse or opened-circuit due to the defect of defrost thermostat.
When the above mentioned trouble occurs in cooling operation, the timer motor does not run, defrosting
will not take place, and consequently freezing is caused. In the above mentioned condition, when the timer
shaft is turned by hand to defrost, the timer motor runs during the operation time. However, the motor stops
from the time when the contact is changed, and freezing causes.
NOTE:
As the thermo. fuse assembly is intended to prevent dangers, do not use it under shorted condition even
for a short period.
3. DEW PREVENTION
The hot pipe, namely D.P.-condenser, is arranged around the flange part of
cabinet and the C-partition plate, preventing dew from being generated on
the cabinet.
NOTE:
D.P.-condenser pipe may be felt hot if touched by hand while the
compressor is in operation.
If you are asked about this, please explain that the hot pipe serve to
prevent the dew generation.

Hot pipe

Figure F-7
4. INSPECTION OF INITIAL STARTING
(1) Inspection of cooling unit
1. Set the temperature control knob to "MAX" and check that the compressor starts to operate.
2. Depress the door switch to run the fan and check that cool air is blown out of the cold air outlet of the
freezer and the refrigerator.
3. When the compressor does not work, check that the timer is not set to "defrost" position.
4 It takes about an hour and a half or two hours to put food in the refrigerator after starting operation.
NOTE:
After return the temperature control knob to "MED" position.
When the refrigerator is operated initially after installed, the compressor may vibrate excessively for 1 to 2
min. However, vibration becomes normal if it is continuously operated.
(2) Inspection of defrost device
Operate the refrigerator for 20 to 30 min. and then check the defrost device in the following procedures :
Allow 5 min. to restart the compressor since immediate starting after stopping will cause unsmooth operation.
1. Turn the timer shaft clockwise with a screw driver.
At this time, make certains the timer clinks and the compressor stops.
2. After more than 5 min., turn the shaft further to operate.
Make certain cooling operation is started again.

12

SJ-43L-A2
SJ-47L-A2

ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS


CAUTION: DISCONNECT THE UNIT FROM THE POWER SUPPLY BEFORE ANY REPAIRING.
1. R-AIR GUIDER ASSEMBLY

Damper thermo.
A-sealer ag1

R air guider S
Thermo. cap. sealer
A-sealer ag3
A-sealer ag2
Dial sealer
R air guider
Figure A-1

Less than 160 mm

(1) Forming sensor of Damper thermo.

8 +1 mm

5 +1 mm

Damper
thermostat

Less than 12 mm

After forming, fix it to the refrigerator.

Stick thermo.
cap. sealer

10 + 2 mm

NOTE
Minimum bending radius is R5mm.
There should be no gas leak by reforming of sensor tube.

Figure A-2
(2) Setting R air guider S and sticking sealers to R air guider.

R air guider S

A-sealer ag1

R air guider

A-sealer ag1

Masking tape
OVERLAP 15mm

R air guider

A-sealer ag2

A-sealer ag1

A-sealer ag2
Dial sealer

A-sealer ag1

Figure A-3
13

A-sealer ag3

OVERLAP AREA

DATUM

DATUM

OVERLAP 8mm

OVERLAP 15mm
DATUM

SJ-43L-A2
SJ-47L-A2

2. FAN LOUVER AND E.V COVER ASSEMBLY


2-1. How to remove the Fan louver
(1) Take out the 2 screws.
(2) Insert the screwdriver into the air hole of the Fan
louver.
(3) Press the Fan louver to the left side with the
screwdriver,and pull it toward yourself to take off 2
claws on the right side.
(4) Then take off the other 4 claws.

(4)

Fan louver

Claw
(4)

Claw

(1)

Screw
(4)

Claw
(3)

(3)

Claw
(1)

Screw

(2)

Figure A-4
2-2. E.v cover assembly
Motor cushion
Fan motor holder B

Fan motor
holder A
E.v cover sealer C

Defrost thermo.
assy
L-band C

E.v cover

Propeller fan
100

Fan motor

Fan clamp
U-sealer
handle
E.v cover
sealer G

Lead EV-cover
assy

E.v cover
sealer C

E.v cover
sealer A

Fuse assy

L-band C

E.v cover
sealer B

F-thermostat

E.v cover sealer E

E.v cover sealer D

Figure A-5

(1) Sticking of Sealers to E.V cover

(2) Fixing of Fan motor and Fan


(2)-1 Stick U-sealer handle to Fan motor holder A.
Fan motor holder A

E.v cover sealer A

7 + 2mm

E.v cover sealer C

STICK START

STICK START

E.v cover

0 + 1mm

E.v cover sealer G

U-sealer handle

STICK START

E.v cover sealer B

SEC. C-C

[back side]

Figure A-7

Figure A-6
14

C
U-sealer handle

SJ-43L-A2
SJ-47L-A2

(2)-2 Insert the terminals of Lead EV-cover ass'y to


Fan motor.
(2)-3 Fix two Motor cushions to Fan motor, and set it
at Fan motor holder A and B.
Then fix with Tapping screw.

(2)-4 Set Fan clamp to Propeller fan 100 and insert


it to the shaft of Fan motor.

Fan clamp

Fan motor
holder B

Motor cushion

Fan clamp

Fan motor
holder A

Tapping
screw

Slit

Propeller
fan 100

Slit of each Fan clamp


and Propeller fan
should not be at same position.

Fan motor
4 + 0.5mm

Note
Propeller fan should not be
taken out from shaft when
pulled by 3 kgf.

Shaft

Lead EV-cover assy

RED

Detail of D

BROWN

Figure A-8

Figure A-9

(3) Setting of Fan motor ass'y , Defrost thermo. ass'y and Fuse ass'y.
E.v cover

Lead e.v cover


assy

Tapping screw

L-band C
more than 3.5mm

more than 3.5mm

Aluminum tape
L-band C
F

E.v cover sealer C


Take out lead wire
from square hole to
front and fix with
L-band C, then seal
with E.v cover sealer C

Tapping screw
Set metal side below

[front side]

Defrost thermo.
assy
H

Aluminum tape
Fuse assy

Aluminum tape

Turn up lead wire

CUT

Fuse assy

ATTENTION

Defrost thermo.
assy

E.v cover
sealer E

10 + 5mm

[back side]

Aluminum tape
L-band C

Detail of G

Not come out of claw.

SEC. F F

SEC. H H

E.v cover sealer E

[Front side]
Figure A-10
15

SJ-43L-A2
SJ-47L-A2

(4) Inserting of pins


After inserting, fix with vinyl tape.

F-thermostat 2
(RED, inserted)
Defrost thermo. 3 (PINK)
Fuse 8 (WHITE)

Fan motor 1 , 5
WIRE COLOR FOR FAN MOTOR
100-110V : WHITE
127V : YELLOW
220-240V : BLUE

F-thermostat 6
(BROWN, inserted)

Vinyl tape

Fuse 8 (BLACK)
Defrost thermo. 7 (BLUE)

Note

Pins should be inserted surely,


and check by pulling it.

Figure A-11

Figure A-12

(5) Setting of F-thermostat


(5)-3 Set to E.V cover.
Stick E.v cover sealer D.

(5)-1 Form capillary tube of F-thermostat.

E.v cover sealer D

21mm

R10mm

R10mm

Note

F-thermostat

Bending radius of
capillary tube should be
from R5mm to R10mm.
8.5mm

50mm

Figure A-13
(5)-2 Insert terminal of Lead EV-cover ass'y.
B

SEC. B B

RED
(front side)

Figure A-15

BROWN
(back side)

Figure A-14

16

SJ-43L-A2
SJ-47L-A2

(2) Replacement of Def. heater ass'y.


(2)-1 Remove the center screw of Drain support al
to take it off from the food liner.

3. DEFROST HEATER
(1) Taking-out Evaporator
(1)-1. Take out E.v cover ass'y (Fig. A-16).

Drain support al

Evaporator

Screw
Food liner convex part

Fig. A-19
Fig. A-16

(2)-2 Raise the protrusion part of Drain support al.


Then remove Heater cover.

(1)-2. As shown in Fig. A-17, pull the upper part of


Evaporator toward you, pull it diagonally so that
the pipe of Evaporator does not contact the convex
part of food liner.

Protrusion parts

Food liner convex part

Drain support al
Evaporator
Pipe

Heater cover

Protrusion part of Drain support al(2 pcs.)

Fig. A-17
(1)-3. As shown in Fig. A-18, bend the removed
Evaporator horizontally so that Defrost heater can
be replaced easily.
NOTE: When pulling Evaporator and bending the
pipes, pay attention so as not to break and
deform the pipes. Still, take care not to hurt
yourself by fin of Evaporator.

Def. heater assy

Heater cover

Fig. A-20
(2)-3 Open Def.heater fixed part of Drain support al to
the right and left, then remove Def.heater ass'y.
Evaporator

Fixed parts

Fig. A-18

Drain support al
Def.heater assy

Fig. A-21
17

SJ-43L-A2
SJ-47L-A2

(2)-4. Replace Def. heater ass'y with new one.

(2)-7. Stick the longer wire to the Drain support by


aluminum tape (2 pieces), and wind vinyl tape
(2 pieces) to lead wires of Def. heater ass'y by
aluminum tape as shown in Fig. A-25.
Note: Glass cloth tape part shall be both side of Drain
support to protect the lead wire from damaged.

Heater cover

Glass cloth tape


Glass cloth tape

Def.heater assy

Sec. AA

[back side]

aluminum tape
(W25 X L40)

Drain support al

Fig. A-22

Glass cloth tape


Glass cloth tape

(2)-5. Wind the Glass cloth tape (3M: No. 27) to lead wire
of Def. heater ass'y. (2 places)

(more than 2 turns)

[bottom side]

Fig. A-25
Def. heater assy
360 + 5

(2)-8. Set Heater cover on Drain support, and bend top


edge c and d to outside as shown in Fig. A-26.

(40)

(40) 50 + 5

Heater cover
top edge

Glass cloth tape


(W40 x L25)

Def.heater assy

Drain support al

Lead wire

Heater cover

Glass cloth tape


Wind the Glass cloth tape
more than 2 turns.

c
Sec. BB

Fig. A-23

(2)-6. Bend a and b of Drain support al to right angle


(90) to set Def. heater ass'y. (Fig. A-24)

Def.heater assy
B

Fig. A-26

This side is longer wire

(2)-9. Wind up Leading wire sealer as shown in Fig. A-27

This side is shorter wire

Drain support al
Heater cover
Leading wire sealer

Drain support al
0
19

Def.heater assy

0
+2

b
Def.heater assy

Fig. A-24
Fig. A-27
(2)-10. Set the assembly above on the food liner by fixing
a screw.
18

SJ-43L-A2
SJ-47L-A2

(3) Installing of Evaporator


(3)-1. Install Evaporator as shown in Fig. A-16 in the
reverse order of Fig. A-17.
(3)-2. Correct the deformed fin.
NOTE
1. When installing Evaporator, take care not to
deform significantly and break the pipes.
2. Take care not to damage the lead wires and hurt
yourself by the fin of Evaporator.

COOLING UNIT

Mark: Refrigerant flow


Mark: Brazing portion
Hot pipe L
(Side condenser)

Hot pipe
(DP-condenser)

Hot pipe R
(Side condenser)

Evaporator

Back condenser

Suction pipe

Eva-pan pipe

Compressor
Capillary tube
Dryer

Figure C-1. Cooling unit

19

SJ-43L-A2
SJ-47L-A2

Dryer

Capillary tube

Charge pipe
Hot pipe

Evaporator

Charge pipe

Compressor
Suction pipe

S.P. connector

Eva-pan pipe
Back condenser

Figure C-2. Location

From Eva-pan pipe assy


to Back condenser In
From Back condenser out
to Hot pipe

From Compressor
to Discharge p connector

From Suction pipe


to SP connector

From Hot pipe


to Dryer

From Dryer
to Capillary tube

From SP connector
to Compressor

From Compressor
to Charge pipe

Figure C-3. Location

20

From Discharge p connector


to Eva-pan pipe assy

SJ-43L-A2
SJ-47L-A2

REPLACEMENT PARTS LIST(SJ-43L/47L-A2G/A2S)


REF. NO.

PART NO.

DESCRIPTION

Q'TY
SJ-43L
SJ-43L
-A2G
-A2S

CODE

SJ-47L
-A2G

SJ-47L
-A2S

ELECTRIC PARTS
1-1
1-2
1-3
1-4
1-5
1-6
1-7
1-8
1-9
1-10
1-11
1-17
1-20
1-21
1-22
1-33

RTHM-A103CBZZ
RSTT-A134CBE0
QSWTDA047CBZZ
PDMP-A050CBEZ
FTHM-A039CBKZ
RMOTRA046CBE0
QSOCAA084CBEZ
RLMP-A029CBEZ
QACC-A110CBE0
QSW-PA090CBZA
RHOG-A161CBZZ
FFS-TA061CBKZ
FW-VZA146CBEZ
FHETBA161CBEZ
FCNW-A680CBKZ
QCNW-A886CBE0

F-themostat
Starting relay
Defrost timer
Damper thermo
Defrost thermo.ass'y
Fan motor
Lamp socket
Lamp15w
Source cord
Door switch
Protector
Fuse ass'y
Lead ev-cover ass'y
Def.heater ass'y
Relay cord s ass'y
Olr cord

2-2
2-4
2-7
2-7-1
2-7-2
2-8
2-8-2
2-13
2-14
2-15
2-16
2-17
2-19
2-20
2-21
2-22
2-23
2-24
2-26
2-27
2-28
2-29
2-29
2-31
2-32
2-36
2-36
2-38
2-39
2-41
2-44
2-45
2-46
2-49
2-50
2-55
2-55
2-56
2-56
2-57
2-57
2-63
2-64
2-65
2-66
2-67
2-68
2-69
2-70
2-71
2-72
2-73
2-77
2-78
2-79
2-80

JKNB-A036CBFC
LHLD-A489CBFA
FLEGPA083CBKZ
FAJS-A015CBKZ
LHLD-A533CBPZ
FLEGPA084CBKZ
LHLD-A534CBPZ
DHNG-A417CBMZ
DHNG-A419CBMZ
DHNG-A418CBMZ
GCOV-A210CBFZ
LCRA-A010CBE0
LHLD-A389CBF0
NFANPA011CBF0
PSEL-C067CBEZ
PSEL-C068CBEZ
PSEL-C066CBEZ
PCOVPA308CBFA
PCOV-A277CBFA
GCOVPA142CBRA
HGRL-A206CBRA
GCOV-A209CBFA
GCOV-A209CBFB
JKNB-A033CBFC
JKNB-A063CBFA
PCAP-A006CBFX
PCAP-A077CBFA
PGID-A161CBFZ
PGID-A162CBFZ
PSEL-B848CBEZ
HGRL-A203CBRA
HGRL-A204CBFA
PFIL-A047CBEZ
LSTPPA108CBFA
LSTPPA118CBFA
HGRL-A205CBFA
HGRL-A209CBFA
PFPFPB334CBFZ
PFPFPB345CBFZ
PSEL-C085CBEZ
PSEL-C095CBEZ
LHLD-A484CBFA
LHLD-A485CBFA
PSEL-B209CBE0
PSHEMA225CBPZ
LPLTMA633CBPZ
PSEL-A415CBE0
PSEL-C069CBEZ
PSEL-C135CBEZ
PSEL-A552CBE0
PSEL-C078CBEZ
PSEL-C079CBEZ
LHLD-A359CBFA
LPLTMA399CBP0
LBND-A019CBE0
PBOX-A132CBFA

F-temp. control knob


E.v. holder
Leg holder l ass'y
Adjustable leg ass'y
Leg holder l
Leg holder r ass'y
Leg holder r
Upper hinge ass'y
Bottom hinge r ass'y
Center hinge r ass'y
E.v cover
Fan clamp
Motor cushion
Propeller fan 100
E.v cover sealer a
E.v cover sealer b
E.v cover sealer c
Terminal cover
R lamp cover
R-c box cover
Fan louver
Upper hinge cover
Upper hinge cover
R-temp.control knob
V-tray control knob
Screw cover
Screw cover
R-air guider
R-air guider s
A-sealer thermo.cap
F deodo.louver
R deodo.louver
Deodorizer
Chilled stopper
Case stopper v
Multi louver l
Multi louver s
R-louver insu.l
R-louver insu.s
A-sealer r-louver
A-sealer r-louver
Fan motor holder b
Fan motor holder a
U-sealer handle
Heater cover
Drain support al
E.v cover sealer c
E.v cover sealer d
E.v cover sealer e
Dial sealer
A-sealer ag1
A-sealer ag2
T-box holder
Dryer support
Nylon band
Terminal box

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

AV
AS
AZ
AW
AM
AZ
AL
AH
AZ
AS
AX
AM
AL
AY
AK
AE

1
2
1
2
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
2
2
2
1
1
2
1
1
2
1
1
1
1
1
1
2
1
1
1
1
1

1
2
1
2
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
2
2
2
1
1
2
1
1
2
1
1
1
1
1
1
2
1
1
1
1
1

1
2
1
2
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
2
2
2
1
1
2
1
1
2
1
1
1
1
1
1
2
1
1
1
1
1

1
2
1
2
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
2
2
2
1
1
2
1
1
2
1
1
1
1
1
1
2
1
1
1
1
1

AC
AD
AF
AE
AL
AF
AP
AE
AD
AE
AR
AD
AF
AD
AA
AA
AC
AE
AE
AQ
AS
AC
AC
AC
AC
AB
AA
AG
AC
AC
AF
AE
AC
AC
AC
AM
AM
AE
AE
AC
AB
AH
AH
AB
AC
AF
AC
AA
AC
AC
AC
AB
AE
AD
AB
AF

MECHANICAL PARTS

21

SJ-43L-A2
SJ-47L-A2

REF. NO.

PART NO.

DESCRIPTION

Q'TY
SJ-43L
SJ-43L
-A2G
-A2S

2-83
2-84
2-87
2-91
2-93
2-98
2-99
2-100
2-101

PSEL-C080CBEZ
PSEL-C081CBEZ
LBND-A018CBE0
HGRL-A202CBFA
PCAP-A068CBFA
LHLD-A504CBE0
PSEL-A562CBE0
PSEL-C138CBEZ
PSEL-C139CBEZ

A-sealer ag3
A-sealer ag4
Fastening band a
F return cover
C sliding cap a
Sl-3n clip
Leading wire sealer
E.v cover sealer g
Ev-insulation 47

3-5
3-5
3-5-1
3-5-2
3-5-3
3-5-4
3-5-5
3-5-5
3-6
3-7
3-7
3-8
3-8
3-10
3-10
3-15
3-15
3-15
3-15
3-15-1
3-15-2
3-15-3
3-17
3-17
3-18
3-18
3-19
3-19
3-21
3-21

FDORFB512CBKZ
FDORFB513CBKZ
LSTPPA082CBFA
NBRGPA013CBFB
LSTPMA008CBM0
GDAI-A059CBMZ
HBDGDA922CBEA
HBDGDA928CBEA
FPACGA346CBKZ
HDECQA409CBFA
HDECQA412CBFA
JHNDPA154CBFA
JHNDPA154CBFB
LPLTPA286CBFA
LPLTPA286CBFB
FDORRB300CBKZ
FDORRB302CBKZ
FDORRB303CBKZ
FDORRB304CBKZ
LSTPPA084CBFA
NBRGPA022CBFA
LSTP-A058CBM0
FPACGA347CBKZ
FPACGA348CBKZ
HDECQA410CBFA
HDECQA413CBFA
JHNDPA155CBFA
JHNDPA155CBFB
LPLTPA287CBFA
LPLTPA287CBFB

F-door s ass'y
F-door s ass'y
Fd-stopper spring r
Nylon bearing 2
F-door stopper r
Badge base
Badge
Badge
F-door packing
Handle trim fl
Handle trim fl
Door handle fl
Door handle fl
Handle base fl
Handle base fl
R-door ass'y
R-door ass'y
R-door ass'y
R-door ass'y
Rd-stopper spring r
Nylon bearing 3s
R-door stopper r
R-door packing
R-door packing
Handle trim rl
Handle trim rl
Door handle rl
Door handle rl
Handle base rl
Handle base rl

CODE

SJ-47L
-A2G

SJ-47L
-A2S

1
2
1
1
4
1
1
1
2

1
2
1
1
4
1
1
1
2

1
2
1
1
4
1
1
1
2

1
2
1
1
4
1
1
1
2

AA
AA
AP
AF
AC
AD
AC
AA
AC

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
-

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
-

1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1

BM
BL
AD
AH
AD
AK
AP
AM
AT
AK
AM
AK
AK
AK
AK
BS
BR
BR
BR
AD
AC
AF
AV
AV
AK
AN
AK
AK
AK
AK

2
2
3
1
4

2
2
3
1
4

2
2
3
1
4

2
2
3
1
4

AC
AB
AH
AA
AA

1
2
3
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1

1
2
3
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1

1
2
3
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1

1
2
3
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1

AR
AH
AM
AL
AH
AS
AT
AM
AM
AM
AG
AX
AL
AV
AN
AU
AW
AG
AG
AC

1
4
1
1

1
4
1
1

1
4
1
1

1
4
1
1

BW
AE
AH
AX

DOOR PARTS

OTHER PARTS
4-1
4-3
4-11
4-15
4-17

LBND-A023CBE0
LX-VZA003CBE0
QTAN-A012CBE0
LX-BZ0202JBE0
LX-WZA003CBE0

L-band c
Special screw
Solderless term. b
Special screw
Washer

ATTACHMENT PARTS
5-1
5-2
5-3
5-4
5-5
5-6
5-9
5-13
5-13
5-14
5-15
5-16
5-17
5-18
5-19
5-24
5-25
5-31
5-32
5-35

UPOK-A180CBRA
UPOKPA268CBFA
UPOK-A179CBRA
UPOK-A181CBRA
UTNA-A282CBFA
FSRA-A193CBYZ
USRA-A270CBFA
HGRL-A201CBFA
HGRL-A201CBFB
USRA-A268CBFA
GGAD-A032CBFA
UYOK-A401CBFA
UYOK-A399CBFA
UYOK-A400CBFA
GDORPA072CBRA
USRA-A272CBFA
USRA-A271CBFA
LRALPA136CBFA
LRALPA137CBFA
UPOKPA269CBFA

Bottle pocket
R door pocket s
Door pocket
R door pocket
Egg tray
Ice cube maker
Freezer tray
Ventilating grille
Ventilating grille
Evaporating pan
V parting plate
Vegetable case
Ice storage box
Fresh case
Fresh door hs
Refrigerator tray
Vegetable tray
Ice tray holder l
Ice tray holder r
Bottle stopper

6-1
6-2
6-4
6-5

PCMPLA215CBEZ
PSPAGA042CBE0
FFRM-A119CBKZ
FDRY-A006CBK0

Compressor
Rubber grommet
Base frame ass'y
Dryer ass'y

CYCLE PARTS

22

SJ-43L-A2
SJ-47L-A2

REF. NO.

PART NO.

DESCRIPTION

Q'TY
SJ-43L
SJ-43L
-A2G
-A2S

6-6
6-9
6-11
6-18
6-19
6-21
6-24
6-25
6-26
6-28
6-29

PCLI-A050CBE0
PSPAFA034CBE0
PPIPCA386CBEZ
PPIPCA252CBE0
FPIPCA172CBKZ
PCOVPA246CBE0
PGUM-A004CBF0
QTAN-A045CBE0
FPIPCA162CBKZ
LANG-A058CBPZ
PGUM-A003CBF0

Clip
Sleeve
S.p connector
Charge pipe
Discharge p. ass'y
Terminal cover
Absorbent rubber a
Terminal block
Eva pan pipe s ass'y
Absorbent rubber clm
Absorbent rubber b

CODE

SJ-47L
-A2G

SJ-47L
-A2S

1
4
1
2
1
1
2
1
1
2
2

1
4
1
2
1
1
2
1
1
2
2

1
4
1
2
1
1
2
1
1
2
2

1
4
1
2
1
1
2
1
1
2
2

AD
AD
AF
AD
AM
AL
AH
AQ
AS
AC
AH

1
1
1
4
1
1
1
1
1
1
1
1

1
1
1
4
1
1
1
1
1
1
1
1

1
1
1
4
1
1
1
1
1
1
1
1
1

1
1
1
4
1
1
1
1
1
1
1
1
1

AF
AC
BA
AZ
AC
AC
AV
AQ
AK
AK
AG
AG
AC
AD
AK

MISCELLANEOUS
90-1
90-2
90-3
90-3
90-5
90-5
90-6
90-7
90-8
90-9
90-10
90-11
90-15
90-21
90-25

TINS-A534CBRZ
TLAB-A876CBRZ
SPAKCJ135YDEZ
SPAKCJ140YDEZ
TLAB-A897CBEZ
TLAB-A973CBEZ
CPADBA799YDKZ
CPADBA798YDKZ
SPADBC439YDEZ
SPADBC440YDEZ
SPADBC435YDEZ
SPADBC436YDEZ
TLAB-B055CBEZ
TLAB-A939CBRZ
TGAN-A196CBRZ

Operation manual
Warning label
Packing case 47l
Packing case 43l
Case label a2g
Case label a2s
Bottom pad ass'y
Top pad ass'y
Corner post fl
Corner post fr
Corner post bl
Corner post br
R-door pocket label
Caution label rof
Warranty card

HOW TO ORDER REPLACEMENT PARTS


To have your order filled promptly and correctly, please furnish the following information.
1. MODEL NUMBER
3. PART NO.

2. REF. NO.
4. DESCRIPTION

23

SJ-43L-A2
SJ-47L-A2

DOOR PARTS
A

3-6

3-5

3-5-2

3-10

B
3-8

C
3-7
3-5-4
3-5-5

5-3

3-5-3

3-15

3-5-1

5-5

3-15-2
5-4

90-15
5-2

5-2

3-18

3-21

5-35

3-19

F
5-1

5-3
3-17

G
3-15-3

3-15-1

SJ-43L-A2
SJ-47L-A2

24

SJ-43L-A2
SJ-47L-A2

CABINET PARTS
A

5-9

B
5-31

5-6

2-29
2-13

5-17
5-32

C
2-93

5-18

2-36
2-91

2-93

5-19

1-10
2-49
2-36
4-3 2-15

2-49

5-24

5-25
2-32

5-15
2-14

2-7

2-93

5-13

2-7-2
2-7-1

2-8

2-8-2
2-7-1

5-16
2-93

SJ-43L-A2
SJ-47L-A2

25

SJ-43L-A2
SJ-47L-A2

CABINET PARTS
A

A
2-19
1-6

2-63

2-64 2-19

2-23
2-17
2-16

1-5

2-65

4-1

1-20

2-20

2-100

4-1

B
2-21

2-68
2-28

2-22

1-17

2-101

1-1

2-4
1-9

2-70

2-44

2-46

2-69
2-2
2-66

2-84

1-21
4-11
1-4
2-72
2-67

2-39

2-99
2-41

2-24
2-79

2-78
6-18

1-3

6-5

2-83
2-73
2-71
2-46

2-77

2-38

2-98

2-80

2-27

2-45

1-22
2-87

2-84

2-50
2-31

6-28
6-24

1-7
1-8
6-26

6-29

90-2

5-14

F
2-57

6-11
6-1

2-56

2-26

4-17
6-18

6-19

2-55
1-33
1-11

6-9
6-2

6-25
4-15
6-21

6-6

1-2
6-4

SJ-43L-A2
SJ-47L-A2

26

SJ-43L-A2
SJ-47L-A2

27

SJ-43L-A2
SJ-47L-A2

COPYRIGHT 2002 BY SHARP CORPORATION


ALL RIGHTS RESERVED.

No part of this publication may be reproduced, stored in retrieval systems, or


transmitted in any form or by any means,
electronic, mechanical, photocopying, recording, or otherwise, without prior written
permission of the publisher.

43JPSY/ 43JPUY/ 47JPSY/ 47JPUY

28

2002 SHARP CORP. (02K0.12E) Printed in Japan

You might also like