Professional Documents
Culture Documents
1. Principle Analysis
1.1. DRD feature Fundamentals
DRD enables the UE to select a suitable cell to access . Different stages of
business processes using different types of DRD, so you can make to maximize
system capacity and can provide better service.
aperiodic retry DRD
Aperiodic retry DRD general application built on RAB, RAB modify or DCCC
channel reset phase.
cycle retry DRD
Periodically retry DRD general application in the RAB establishment or bearer
configuration changed .
[Aperiodic retry DRD] UE-based aperiodic blind handover retry DRD select a suitable cell to
perform access. Based on non-periodic retry DRD blind handover priority based on device type,
HSPA + technology satisfaction, business priorities and cell load cell to select the access. This may
enable the UE to obtain the best technical satisfaction and achieve business stratification and load
balancing. 1.1. Based on different technologies Satisfaction frequency DRD HSPA + technology
DRD satisfaction only when requested by the UE HSPA + services will be applied. HSPA +
technology satisfaction DRD has the following composition: 1. Based on UE support HSPA +
technology and attributes requested service, RNC judgment can be configured at the UE side of
HSPA + technology. 2. Based on the HSPA + technology priorities and can be configured at the UE
side, and community support for HSPA + technology, RNC judge each candidate cell HSPA +
technology satisfaction. 3. Based on HSPA + technology in priority order, RNC select the
appropriate cell so that UE access. In addition, RNC can judge the UE HSPA + technology (HSPA
+ technology which can be configured at the UE side and community support). 2. Non-exclusive
technology based on periodic retry Satisfaction frequency DRD According to customer demand, we
developed
line
open
test
site
characteristics
associated
technical
solutions:
HSPA + technology, including DC-HSDPA, L2 ( Layer 2 Enhanced ), MIMO, 64QAM, DTX + DRX, EDPCCH Boosting, upstream 16QAM and HS-SCCH Less Operation. Now HSPA + network technology
priorities
along
the
following
table:
Non- exclusive technology based on periodic retry Satisfaction frequency DRD feature is enabled
Verify the following figure : In June 23, 2013 , we opens up a sector UMU0825 DRD feature . Used
to support DC-HSDPA Huawei E392 LTE dongle in U900 cell download tasks 28251 .
From the signaling tracing see above , we find that based on the technical capabilities of DRD
satisfaction the successful implementation . UE from U900 to U2100 F1 DRD U2100 F1 is due to higher
technical satisfaction. From RB established signaling , we can see the DRD target frequency information
and
DC-HSDPA
frequency
information.
based on the signal measurements to select the target cell. Only on the basis of
the measurement cycle retry DRD is based on cell traffic priority.
Periodic blind handover retry DRD and measurement-based cycle retry DRD can
not open. When one of the characteristics of open, another feature will
automatically turn off.
DRD retry cycle support HSPA / HSPA + technology
Different types of cycle retry DRD support different HSPA / HSPA + technology.
For cycle-based DRD blind handover, only the business that can be configured to
better HSPA / HSPA + technology HSUPA, HSDPA, 64QAM, MIMO, DC-HSUPA, when
the DC-HSDPA, DC-HSDPA + MIMO or E-DPCCH Boosting, to trigger DRD cyclebased blind handover.
For cycle-based DRD measurement, only service that can be configured to better
HSPA / HSPA + technology, HSDPA, HSUPA, the upstream Layer 2 Enhanced uplink
16QAM, downlink layer 2 enhancement, CPC, 64QAM, DC-HSDPA, MIMO, DCHSDPA + MIMO and E-DPCCH Boosting, in order to trigger the cycle DRD-based
measurements.
According to customer demand, the development of a new experimental line site
open aspect related features:
July 3, 2013 , in the current network UMU0051 sites based on a different technology cycle retry
Satisfaction frequency DRD feature is enabled verification , validation features successfully opened .