Professional Documents
Culture Documents
config
configure settings
login
maint
maintenance settings
perf
Performance statistics
reserved
show
display attributes
features
ip
configure IP settings
logout
port
security
snmp
configure snmp
switch
system
zoning
There are several commands that allow you to navigate through the switch "..", "ctrl-U" and
"root" .
M-Series (Mcdata) zoning commands are detailed in the below table
showactive
clearzone
deletezone
activezoneset
activation of changes
addzone
addwwnmem
showpending
renamezone
rename a zone
deletewwn
renamezoneset
Zoning limits
deafult should all ways be disabled (causes all port to see each other creating ghosts in a
FA's login table)
B-Series
B-Series (Brocade) switches uses both web and CLI, the table below displays some but not all
the CLI commands.
help
switchdisabled
switchenable
licensehelp
license commands
diaghelp
diagnostic commands
configure
diagshow
routehelp
routing commands
switchshow
supportshow
portshow #
nsshow
namesever contents
nsallshow
fabricshow
Fabric information
version
reboot
fastboot
create a zone
zoneshow
zoneadd
zoneremove
zonedelete
delete a zone
cfgcreate (zoneset)
cfgadd
cfgshow
cfgenable
cfgsave
cfgremove
cfgdelete
cfgclear
clears all zoning information (must disable the effective config first)
cfgdisable
saving the zone configuration cfgsave (this will save across reboots)
enable the zone configuration cfgenable "test_cfg"
saving the zone configuration cfgsave
view zoning information
zoneshow or cfgshow
MDS-Series
B-Series (Cisco) switches uses both web and CLI, the table below displays some but not all the
CLI commands, the ones highlighted will be the ones used most often.
EXEC mode commands:
attach
bios
callhome
callhome commands
clear
reset functions
clock
config
debug
debug functions
discover
discover information
exit
fcping
Ping a N_Port
fctrace
load
no
reload
setup
show
system
test
test command
write
zone
config aaa
boot
callhome
clock
fcalias
fcanalyzer
fcc
fcdomain
fcdroplatency
fcflow
configure fcflow
fcinterop
interop commands
fcns
fcroute
configure FC routes
fcs
fctimer
fspf
configure fspf
interface
ip
configure IP features
no
ntp
NTP configuration
power
poweroff
qos
radius-server
role
configure roles
snmp-server
configure snmp
span
ssh
switchname
system
trunk
username
vsan
zone
zoneset
There are several commands that allow you to navigate through the switch "cd", "copy", "dir",
"find", "mkdir", "move", "rmdir" and "tail".
MDS-series creating a zone
create a zone and place it in the vsan
add a member (FCID example - hard zoning) # member fcid 0x7f0000 (24 bit address)
add a member (FC alias example)
activatng a zoneset
delete a zoneset