You are on page 1of 27

Service

Manual

ORDER NO.

CRT2663

HIGH POWER CD PLAYER WITH FM/AM TUNER

DEH-P4350-2
DEH-P3350-2
DEH-P3350B-2

X1N/ES,X1M/ES

X1N/ES,X1M/ES
X1N/ES,X1M/ES

- This is the unit which has been replaced S8.1(CXK5201) CD mechanism module with S9(CXK5500).
- This service manual should be used together with the manual(s) listed below.
For the parts numbers, adjustments, etc. which are not shown in this manual,
refer to the following manual(s).
Model No.
CX-977
DEH-P4350/X1N/ES

Order No.
CRT2624
CRT2576

Mech. Module
S9

Remarks
CD Mech. Module:Circuit Description, Mech. Description, Disassembly

- CD Player Service Precautions


1. For pickup unit(CXX1480) handling, please refer
to"Disassembly"(see page 22).
During replacement, handling precautions shall be
taken to prevent an electrostatic discharge(protection
by a jumper-solder).

2. During disassembly, be sure to turn the power off


since an internal IC might be destroyed when a connector is plugged or unplugged.
3. Please checking the grating after changing the service pickup unit(see page 16).

PIONEER CORPORATION

4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan


PIONEER ELECTRONICS SERVICE INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A.
PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936

C PIONEER CORPORATION 2001

K-ZZU. MAR. 2001 Printed in Japan

DEH-P4350-2,P3350-2,P3350B-2

SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely; you should not risk trying to do so
and refer the repair to a qualified service technician.

EXPLODED VIEWS AND PARTS LIST


PACKING (Page 3)
- PACKING SECTION PARTS LIST
Mark No.
13
14

Description
Carton
Contain Box

DEH-P4350/X1N/ES
CHG4262
CHL4262

Part No.
DEH-P4350-2/X1N/ES
CHG4354
CHL4354

DEH-P4350-2/X1M/ES
CHG4367
CHL4367

DEH-P3350/X1N/ES
CHG4268
CHL4268

Part No.
DEH-P3350-2/X1N/ES
CHG4360
CHL4360

DEH-P3350-2/X1M/ES
CHG4373
CHL4373

DEH-P3350B/X1N/ES
CHG4269
CHL4269

Part No.
DEH-P3350B-2/X1N/ES DEH-P3350B-2/X1M/ES
CHG4361
CHG4374
CHL4361
CHL4374

- PACKING SECTION PARTS LIST


Mark No.
13
14

Description
Carton
Contain Box

- PACKING SECTION PARTS LIST


Mark No.
13
14

Description
Carton
Contain Box

EXTERIOR (Page 5)
- EXTERIOR SECTION PARTS LIST
Mark No.
7
15
25
84

Description
Cable
Tuner Amp Unit
Connector(CN501)
CD Mechanism Module

DEH-P4350/X1N/ES
CDE6444
CWM7376
CKS4398
CXK5201(S8.1)

Part No.
DEH-P4350-2/X1N/ES,X1M/ES
CDE6610
CWM7835
CKS3835
CXK5500(S9)

DEH-P3350/X1N/ES
CDE6444
CWM7383
CKS4398
CXK5201(S8.1)

Part No.
DEH-P3350-2/X1N/ES,X1M/ES
CDE6610
CWM7842
CKS3835
CXK5500(S9)

- EXTERIOR SECTION PARTS LIST


Mark No.
7
15
25
84

Description
Cable
Tuner Amp Unit
Connector(CN501)
CD Mechanism Module

- EXTERIOR SECTION PARTS LIST


Mark No.
7
15
25
84

Description
Cable
Tuner Amp Unit
Connector(CN501)
CD Mechanism Module

Part No.
DEH-P3350B/X1N/ES
DEH-P3350B-2/X1N/ES,X1M/ES
CDE6444
CDE6610
CWM7376
CWM7848
CKS4398
CKS3835
CXK5201(S8.1)
CXK5500(S9)

DEH-P4350-2,P3350-2,P3350B-2

ELECTRICAL PARTS LIST(Page 36)


Tuner Amp Unit

R520
R521
R522,R524,R534,R535
R523
R525,R526,R527

RS1/16S681J
RS1/16S102J
RS1/16S0R0J
RS1/16S102J
Not used

RS1/16S0R0J
RS1/16S222J
Not used
RS1/16S0R0J
RS1/16S222J

R529
R530
R536
R537

Not used
Not used
RS1/16S0R0J
Not used

RS1/4PU0R0J
RS1/16S0R0J
RS1/16S102J
RS1/16S104J

(1/4W)

104

D F CONTROL UNIT

CN701

Circuit Symbol and No.


IC601
R514,R515
R516
R518
R519

Part No.
DEH-P4350/X1N/ES DEH-P4350-2/X1N/ES,X1M/ES
DEH-P3350/X1N/ES DEH-P3350-2/X1N/ES,X1M/ES
DEH-P3350B/X1N/ES DEH-P3350B-2/X1N/ES,X1M/ES
PE5203A
PE5246A
RS1/16S473J
Not used
RS1/16S473J
RS1/16S104J
RS1/16S222J
Not used
RS1/16S222J
RS1/16S102J

104

DEH-P4350-2,P3350-2,P3350B-2

CD MECHANISM MODULE

DF

DEH-P4350-2,P3350-2,P3350B-2

- CD MECHANISM MODULE SECTION PARTS LIST


Mark No. Description

Part No.

Mark No. Description

Part No.

Control Unit
Connector(CN701)
Connector(CN101)
Screw
Screw

CWX2481
CKS1959
CKS3486
BMZ20P025FMC
BSZ20P040FMC

46
47
48
49
50

Gear
Arm
Arm
Arm
Arm

CNV6320
CNV6322
CNV6323
CNV6324
CNV6325

6
7
8
9
10

Screw(M2x4)
Screw(M2x3)
Screw
Washer
Washer

CBA1362
CBA1527
CBA1545
CBF1037
CBF1038

51
52
53
54
55

Arm
Guide
Arm
Guide
Rack

CNV6326
CNV6327
CNV6328
CNV6329
CNV6330

11
12
13
14
15

Washer
Washer
Spring
Spring
Spring

CBF1039
CBF1060
CBH2378
CBH2379
CBH2380

56
57
58
59
60

Clamper
Arm
Guide
Cover
Arm

CNV6331
CNV6332
CNV6333
CNV6334
CNV6335

16
17
18
19
20

Spring
Spring
Spring
Spring
Spring

CBH2381
CBH2382
CBH2383
CBH2384
CBH2385

61
62
63
64
65

Guide
Roller
Damper
Damper
Guide

CNV6336
CNV6338
CNV6339
CNV6340
CNV6484

21
22
23
24
25

Spring
Spring
Spring
Spring
Spring

CBH2386
CBH2387
CBH2390
CBH2391
CBH2392

66
67
68
69
70

Chassis Unit
Arm Unit
Arm Unit
Arm Unit
Motor Unit(M2)

CXB5898
CXB5899
CXB5900
CXB5901
CXB5903

26
27
28
29
30

Spring
Spring
Spring
Spring
Shaft

CBH2426
CBH2444
CBL1494
CBL1495
CLA3845

71
72
73
74
75

Screw Unit
Gear Unit
Bracket Unit
Motor Unit(M1)
Arm Unit

CXB5904
CXB5905
CXB6006
CXB6007
CXB6237

31
32
33
34
35

Roller
Frame
Lever
Lever
Arm

CLA3910
CNC8946
CNC8948
CNC8949
CNC8951

76
77
78
79
80

Screw(M2x5)
Screw
Screw
Washer
Washer

EBA1028
JFZ20P020FMC
JGZ17P020FZK
YE15FUC
YE20FUC

36
37
38
39
40

Arm
Arm
Bracket
Frame
Belt

CNC9016
CNC9017
CNC9123
CNC9263
CNT1086

81 Pickup Unit(Service)(P9) CXX1480


82 Screw
IMS26P030FMC
83 Guide
CNV6832

41
42
43
44
45

Gear
Gear
Gear
Gear
Gear

CNV6315
CNV6316
CNV6317
CNV6318
CNV6319

1
2
3
4
5

DEH-P4350-2,P3350-2,P3350B-2

CD MECHANISM MODULE

DF

CONTROL UNIT

PICKUP UNIT(SERVICE)(P9)

RF AMP

CN101

ACT/MOTOR DRIVER
C

SPINDLE
M1 CXB6007
LOADING/CARRIAGE
M2 CXB5903

5V REGULATOR
6

DF
1

DEH-P4350-2,P3350-2,P3350B-2

SERVO CONTROL/DSP/DAC/LPF

16.934MHz

ER
C
SWITCHES:
CONTROL UNIT
S901 : HOME SWITCH.....ON-OFF
S902 : CLAMP SWITCH....ON-OFF
S903 : DSCSNS SWITCH....ON-OFF
S904 : 12EJ SWITCH....ON-OFF
S905 : 8EJ SWITCH....ON-OFF
The underlined indicates the switch position.

CN701

A
CN501

DF
8

DEH-P4350-2,P3350-2,P3350B-2
Note:1. The encircled numbers denote measuring pointes in the circuit diagram.
2. Reference voltage
VREF:2.1V

- Waveforms
1
2
3
4

CH1:DSCSNS 5V/div.
CH2:CLCONT 5V/div.
500ms/div.
CH3:LOEJ
5V/div.
CH4:VD
10V/div.
When loading (12 cm CD)

1
2
3
4

5 CH1:FD
500mV/div.
CH1:DSCSNS 5V/div.
6 CH2:FOK
5V/div.
500ms/div.
CH2:CLCONT 5V/div.
500ms/div.
7 CH3:MD
5V/div.
CH3:LOEJ
5V/div.
CH4:VD
10V/div.
When setting up "Source On"
When loading (8 cm CD)

Ref. :
GND

Ref. :
GND

Ref. :
VREF

Mode :
Normal

Mode :
Normal

Mode :
Normal

5 CH1:FD
6 CH2:FOK
7 CH3:MD

500mV/div.
5V/div.
100ms/div.
5V/div.

8 CH1:FE
500mV/div.
500ms/div.
9 CH2:FOON 5V/div.
When setting up "Source On"

0 CH1:TE
8 CH2:FE

500mV/div.
200ms/div.
500mV/div.

When setting up "Source On"

Magnified drawing for "time"

Ref. :
VREF

Ref. :
VREF

Ref. :
VREF

Mode :
Normal

Mode :
Normal

Mode :
Normal

8
5
0
!

CH1:FE
500mV/div.
CH2:FD
500mV/div.
CH3:TE
500mV/div.
CH4:TD
500mV/div.
During "Play"

@ CH1:BCK
1ms/div.

2V/div.

1s/div. # CH1:LRCK 2V/div.


$ CH2:DOUT 2V/div.

During "Play"
During "Play"

Ref. :
VREF

Ref. :
VREF

Ref. :
VREF

Mode :
Normal

Mode :
Normal

Mode :
Normal

7 CH1:MD

500mV/div.

During "Play"

500mV/div.
500mV/div. 0.5s/div. % CH1:RFO
0 CH2:TE
500mV/div.
During "Play"
During "Tracking Open"

10s/div. % CH1:RFO

Ref. :
VREF

Ref. :
VREF

Ref. :
VREF

Mode :
Normal

Mode :
Normal

Mode :
Test

10s/div.

2ms/div.

DEH-P4350-2,P3350-2,P3350B-2

5 CH1:FD
^ CH2:FOP

1V/div.
2V/div.

200ms/div.

% CH1:RFO
0 CH2:TE
! CH3:TD

With no disk inserted


During "Focus Close"

% CH1:RFO
1V/div.
500mV/div. 500s/div. 0 CH2:TE
! CH3:TD
1V/div.

Ref. :
VREF

Ref. :
VREF

Mode :
Test

Mode :
Test

Mode :
Test

1V/div.
1V/div.
1V/div.

%
5ms/div. &
5
!

100 Track Jump

CH1:RFO
CH2:DFCT
CH3:FD
CH4:TD

2V/div.
5V/div.
1V/div.
2V/div.

% CH1:RFO
500s/div. 0 CH2:TE
& CH3:DFCT

When reproducing black dots (800m)

Ref. :
VREF

Ref. :
VREF

Mode :
Test

Mode :
Normal

Mode :
Normal

500mV/div. 200ms/div.
2V/div.

1 CH1:DSCSNS
2 CH2:CLCONT
3 CH3:LOEJ

1V/div.
500mV/div. 200ms/div.
5V/div.

During inside/outside search

Ref. :
VREF

* CH1:TEY
( CH2:SD

5ms/div.

32 Track Jump

1 Track Jump

Ref. :
VREF

% CH1:RFO
0 CH2:TE
! CH3:TD

1V/div.
1V/div.
1V/div.

1 CH1:DSCSNS
5V/div.
5V/div. 200ms/div. 2 CH2:CLCONT
3 CH3:LOEJ
5V/div.

5V/div.
5V/div. 200ms/div.
5V/div.

During inside/outside search


When "Eject" (12 cm CD)

When "Eject" (8cm CD)

Ref. :
VREF

Ref. :
GND

Ref. :
GND

Mode :
Normal

Mode :
Normal

Mode :
Normal

) CH1:LOUT 2V/div.
CH2:ROUT 2V/div.

200s/div.

"Play" in 1kHz, 0dB

Ref. :
GND
Mode :
Normal

10

VREF

HOME

PICKUP UNIT(SERVICE)(P9)

CN501

12EJ

DSCSNS

M2 LOADING/CARRIAGE MOTOR

M1 SPINDLE MOTOR

D F CONTROL UNIT

DEH-P4350-2,P3350-2,P3350B-2

1
2

CD MECHANISM MODULE
SIDE A

DF

DEH-P4350-2,P3350-2,P3350B-2

SIDE B
8EJ

D F CONTROL UNIT

CLAMP

DF

11

DEH-P4350-2,P3350-2,P3350B-2

ELECTRICAL PARTS LIST


NOTES:
- Parts whose parts numbers are omitted are subject to being not supplied.
- The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
=====Circuit Symbol and No.===Part Name
--- -----------------------------------------------

Part No.
-------------------------

Number : CWX2481
D F Unit
Unit Name
: Control Unit

R
R

407
408

RS1/16S622J
RS1/16S622J

MISCELLANEOUS

R
R
R
R
R

409
410
701
702
703

RS1/16S113J
RS1/16S752J
RS1/16S102J
RS1/16S221J
RS1/16S221J

R
R
R
R
R

704
705
706
707
708

RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S102J

R
R
R
R
R

709
710
901
902
903

RS1/16S102J
RS1/16S102J
RS1/16S104J
RS1/16S473J
RS1/16S273J

=====Circuit Symbol and No.===Part Name


--- -----------------------------------------------

Part No.
-------------------------

IC
IC
IC
IC
Q

101
201
401
701
101

IC
IC
IC
IC
Transistor

TA2153FN
TC9495F2
BA5996FM
BA05SFP
2SD1664

Q
L
L
X
S

102
201
202
301
901

Transistor
Inductor
Inductor
Ceramic Resonator 16.934MHz
Spring Switch(HOME)

UMD2N
CTF1546
CTF1546
CSS1525
CSN1051

S
S
S
S

902
903
904
905

Spring Switch(CLAMP)
Spring Switch(DSCSNS)
Spring Switch(12EJ)
Spring Switch(8EJ)

CSN1052
CSN1051
CSN1052
CSN1051

RESISTORS
R
R
R
R
R

101
102
103
201
202

RS1/16S222J
RS1/8S120J
RS1/8S100J
RS1/16S513J
RS1/16S513J

R
R
R
R
R

203
204
206
208
209

RS1/16S823J
RS1/16S823J
RS1/16S823J
RS1/16S124J
RS1/16S183J

R
R
R
R
R

210
211
212
213
215

RS1/16S153J
RS1/16S103J
RS1/16S103J
RS1/16S124J
RS1/16S0R0J

R
R
R
R
R

216
301
302
303
304

RS1/16S471J
RS1/16S333J
RS1/16S332J
RS1/16S332J
RS1/16S514J

R
R
R
R
R

306
307
312
313
315

RS1/16S102J
RS1/16S102J
RS1/16S103J
RS1/16S473J
RD1/4PU334J

R
R
R
R
R

321
322
323
401
402

RS1/16S331J
RS1/16S0R0J
RS1/16S332J
RS1/16S684J
RS1/16S103J

R
R
R

403
404
405

RS1/16S103J
RS1/16S183J
RS1/16S123J

12

CAPACITORS
C
C
C
C
C

101
102
103
104
105

CEV470M6R3
CKSRYB102K50
CKSRYB104K16
CKSRYB224K16
CEV470M6R3

C
C
C
C
C

106
107
201
202
204

CKSRYB104K16
CKSRYB105K6R3
CKSRYB104K16
CCSRCH560J50
CKSRYB224K16

C
C
C
C
C

205
206
207
208
209

CKSRYB224K16
CKSRYB273K25
CKSRYB273K25
CKSRYB104K16
CKSRYB104K16

C
C
C
C
C

210
211
301
302
303

CCSRCK2R0C50
CCSRCH220J50
CKSRYB153K25
CKSRYB104K16
CKSRYB103K50

C
C
C
C
C

304
305
306
307
308

CKSRYB103K50
CKSRYB104K16
CKSRYB104K16
CKSRYB333K16
CKSRYB104K16

C
C
C
C
C

309
310
311
312
315

CKSRYB473K16
CKSRYB473K16
CKSRYB104K16
CKSRYB104K16
CEV220M6R3

C
C
C
C
C

317
318
319
320
325

CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
CCSRCH470J50
CKSRYB471K50

DEH-P4350-2,P3350-2,P3350B-2

=====Circuit Symbol and No.===Part Name


--- -----------------------------------------------

Part No.
-------------------------

C
C
C
C
C

328
329
330
331
401

CKSRYB472K50
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
CKSRYB221K50

C
C
C
C
C

402
403
404
405
702

CKSRYB221K50
CKSRYB153K25
CKSRYB103K50
CEV101M10
CKSRYB104K16

C
C
C
C

703
801
802
803

10F/10V

CKSRYB104K16
CCH1349
CEV101M10
CKSRYB224K16

Miscellaneous Parts List


M
M

1
2

Pickup Unit(Service)(P9)
Motor Unit(SPINDLE)
Motor Unit(LOADING/CARRIAGE)

CXX1480
CXB6007
CXB5903

13

DEH-P4350-2,P3350-2,P3350B-2

CD ADJUSTMENT
1) Precautions
This unit uses a single power supply (+5V) for the regulator. The signal reference potential, therefore, is
connected to VREF(approx. 2.1V) instead of GND.
If VREF and GND are connected to each other by mistake during adjustments, not only will it be impossible to measure the potential correctly, but the servo
will malfunction and a severe shock will be applied to
the pick-up. To avoid this, take special note of the following.
Do not connect the negative probe of the measuring
equipment to VREF and GND together. It is especially
important not to connect the channel 1 negative
probe of the oscilloscope to VREF with the channel 2
negative probe connected to GND.
Since the frame of the measuring instrument is usually at the same potential as the negative probe, change
the frame of the measuring instrument to floating status.
If by accident VREF comes in contact with GND,
immediately switch the regulator or power OFF.
Always make sure the regulator is OFF when connecting and disconnecting the various filters and wiring
required for measurements.
Before proceeding to further adjustments and measurements after switching regulator ON, let the player
run for about one minute to allow the circuits to stabilize.
Since the protective systems in the unit's software are
rendered inoperative in test mode, be very careful to
avoid mechanical and /or electrical shocks to the system when making adjustment.
The RFI and RFO signals are easy to oscillate because
of a wide band. When observing them, insert a resistor of about 1 k to the series.
This equipment will not guarantee the load ejection
operation when the mechanical unit is turned upside
down. In particular, if the ejection operation is incorrectly performed and recovery is disabled, the recovery is enabled by resetting a product or turning ACC
off to on.

14

2) Test Mode
This mode is used for adjusting the CD mechanism
module of the device.
Test mode starting procedure
Reset while pressing the 4 and 6 keys together.
Test mode cancellation
Switch ACC, back-up OFF.
After pressing the EJECT key, do not press any other
key until the disk is completely ejected.
If the ] or [ key is pressed while focus search is in
progress, immediately turn the power off (otherwise
the actuator may be damaged due to adhesion of the
lenses).
Jump operation of TRs other than 100TR continues
after releasing the key. CRG move and 100TR jump
operations are brought into the Tracking close status when the key is released.
Powering Off/On resets the jump mode to Single
TR(91), the RF AMP gain setting to 0 dB, and the
automatic adjustment value to the initial value.

DEH-P4350-2,P3350-2,P3350B-2

- Flow Chart
[4]+[6]+Reset

[KEY]

Test Mode In

Contents
Display

[CD] or [SOURCE]
Source On
TRK

MIN

[BAND]

[3]

Power On
(T. offset is adjusted)
TRK00 MIN00 SEC00

[BAND]

MIN

(T. offset is not adjusted)


TRK 99 MIN99 SEC 99

[3]
Focus Close /
S. curve check

Power Off
TRK

Power On

SEC

TRK

91 MIN91 SEC91

[2]

[6]

RF AMP
Gain switching*1

New Test Mode

TRKGGMINGGSECGG

[1]

[]]

Tracking Servo
Close

CRG+

[6]
Focus Mode switching*2
TRK

0x MIN0x SEC 0x

TRK

or

[BAND]

[1]
T.CLS and F,T AGC
and RF AGC and

Power Off
TRK

MIN

Applicable servomechanism
TRKxx MINxx SECxx

SEC

00 MIN00 SEC00
99 MIN99 SEC99

[6]

or

TRK ?? MIN ?? SEC ??

[BAND]

[1]
F,T,RF AGC /

TRK

MIN

*7
F.Bias display switching

SEC

TRK

?? MIN?? SEC??

[3]

TRK

CRG/TR jump value


switching

xx MINxx SEC xx

TRK

00 MIN00 SEC00
99 MIN 99 SEC 99

[[]

TRK8x MIN8x SEC8x

TRK8x MIN8x SEC8x

TRK 9x MIN9x SEC 9x

or

[2]
T.Balance adjustment /
T.Balance coefficient display

TRK

TRK ?? MIN?? SEC ??

[2]

[[]
*4

CRG+/TR Jump+

xxMIN xxSEC xx

*4

Tracking Open

CRG-/TR Jump-

xxMIN xxSEC xx

TRK

xxMIN xxSEC xx

TRK

or

MIN

Tracking Open

SEC

TRK8x MIN8x SEC8x

or

*1)

TYP
TRK

MIN SEC

+12dB
12 MIN12 SEC12

TRK

TRK 9x MIN9x SEC 9x

Operation

[Key]
Test Mode

*2)

*3)

Focus Close setting


TRK
00 MIN00 SEC00
or TRK99 MIN99 SEC99

F.Offset
Display

T.Offset
Display

S. curve check setting


TRK

01 MIN01 SEC01

F. EQ measurement setting

[BAND] Power On/Off

02 MIN02 SEC02
[]]

CRG +/TR Jump+


TRK+/FF
(Direction of the external surface)

[[]

CRG -/TR JumpTRK-/REV


(Direction of the internal surface)

Switch to the order of the original display

*4) 1TR/32TR/100TR
Single TR
TRK
91 MIN91 SEC91
TRK
or 81 MIN81 SEC81

[2]
32TR
TRK
92 MIN92 SEC92
TRK
or 82 MIN82 SEC82

100TR
TRK
93 MIN93 SEC93
TRK
or 83 MIN83 SEC83

CRG Move
TRK
94 MIN94 SEC94
TRK
or 84 MIN84 SEC84

[3]

F.AGC
Gain

T.AGC
Gain

F.Bias

RF AGC
Gain

T.CLS and AGC and Applicable servomechanism/


AGC,AGC display switching
RF Gain switching/Offset adjustment display/
T.Balance adjustment/T.OPN

F.CLS,S.Curve/Rough Servo and RF AGC/


F,T,RF AGC

SCAN
MODE
(ITP)

SPDL 1X/2X switching


(Double-speed compatibility only)

Error rate measurement

F.Mode switching/T.CLS/CRG,TR
Jump switching

Auto/Manual switching

*6) Only at the time of CRG move or 100TR jump


*7) TRK/MIN/SEC

New Test Mode


Error occurrence time/
cause display switching

TRK

[1]

*5

8x MIN8x SEC8x
9xMIN 9xSEC 9x

TRK

[2]

[BAND]
Power Off
TRK

?? MIN?? SEC??

TRK 9x MIN 9x SEC 9x

[]]
*5

TRK

TRK

CRG-

[6]

F,T AGC,F.Bias
and RF AGC

TRK

or

[]]

RF AGC coefficient display

TRK xx MINxx SEC xx

[2]
Automatic adjustment value
*3
display switching

*8

CRG+

[3]

or

Power Off

00 MIN00 SEC00
99 MIN99 SEC 99

TRK

RF AGC /

Applicable servomechanism

CRG-

TRK

TRK

T.Close and

[[]
*8

[6]
*8) CRG motor voltage = 2 [V]

15

DEH-P4350-2,P3350-2,P3350B-2

CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT


Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted
PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if
the PU unit must be changed, the grating should be checked using the procedure below.

Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
Symptoms of Mal-adjustment :
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment
Measuring Points
Disc
Mode

Oscilloscope, Two L.P.F.


E, F, VREF
ABEX TCD-784
TEST MODE

CONTROL UNIT

L.P.F.
E

Xch
100k
390pF

VREF

Oscilloscope

100k
390pF

VREF
L.P.F.

E
F

VREF

Ych

Checking Procedure
1. In test mode, load the disc and switch the 5V regulator on.
2. Using the ] and [ buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth
press.
4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".

16

DEH-P4350-2,P3350-2,P3350B-2

Grating waveform

Ech Xch 20mV/div, AC


Fch Ych 20mV/div, AC

30

45

60

75

90

17

DEH-P4350-2,P3350-2,P3350B-2

GENERAL INFORMATION
TEST MODE
- Error Messages
If a CD is not operative or stopped during operation due to an error, the error mode is turned on and cause(s) of the
error is indicated with a corresponding number. This arrangement is intended at reducing nonsense calls from the
users and also for facilitating trouble analysis and repair work in servicing.
(1) Basic Indication Method
1) When SERRORM is selected for the CSMOD (CD mode area for the system), error codes are written to DMIN (minutes display area) and DSEC (seconds display area). The same data is written to DMIN and DSEC. DTNO remains
in blank as before.
2) Head unit display examples
Depending on display capability of LCD used, display will vary as shown below. xx contains the error number.
8-digit display
ERRORxx

6-digit display
ERRxx

4-digit display
Exx

(2) Error Code List


Code Class
Displayed error code Description of the code and potential cause(s)
10
Electricity Carriage Home NG
CRG can't be moved to inner diameter.
SERVO LSI ComCRG can't be moved from inner diameter.
munication Error
Failure on home switch or CRG move mechanism.
11

Electricity

Focus Servo NG

Communication error between microcomputer and SERVO LSI.


Focusing not available.
Stains on rear side of disc or excessive vibrations on REWRITABLE.

12

Electricity

Spindle Lock NG
Subcode NG

Spindle not locked. Sub-code is strange (not readable).


Failure on spindle, stains or damages on disc, or excessive vibrations.
A disc not containing CD-R data is found.
Turned over disc are found, though rarely.
CD signal error.
AGC protection doesn't work. Focus can be easily lost.
Damages or stains on disc, or excessive vibrations on REWRITABLE.

17

Electricity

Setup NG

30

Electricity

Search Time Out

Failed to reach target address.


CRG tracking error or damages on disc.

44

Electricity

ALL Skip

Skip setting for all track.


(CD-R/RW)

50

Mechanism CD On Mech Error

Mechanical error during CD ON.


Defective loading motor, mechanical lock and mechanical sensor.

A0

System

Power (VD) is ground faulted.


Failure on SW transistor or power supply (failure on connector).

Power Supply NG

Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors).
Unreadable TOC does not constitute an error. An intended operation continues in this case.
Upper digits of an error code are subdivided as shown below:
1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors.

18

DEH-P4350-2,P3350-2,P3350B-2

- New Test Mode


S-CD plays the same way as before.
If an error such as off focus, spindle unlocking, unreadable sub-code, or sound skipping occurs after setup, its
cause and time occurred (in absolute time) are displayed.
During setup, operational status of the control software is displayed.
These displays and functions are prepared for enhancing aging in the servicing and efficiency of trouble analysis.
(1) Shifting to the New Test Mode
1 Turn on the current test mode by starting the reset from the key.
2 Select S-CD for the source through the specified procedure including use of the [SOURCE] key, and inserting the
disc. Then, press the [Jump Mode Selector] key while maintaining the regulator turned off.
3 After the above operations, the new test mode remains on irrespective of whether the S-CD is turned on or off.
You can reset the new test mode by turning on the reset start.
(2) Key Correspondence
Key
Regulator Off
BAND To regulator on

Test mode
Regulator On
To regulator off

In-play

New test mode


Error Production
Time/Err.No. switching

FWD-Kick

FF/TR+

REV-Kick

REV/TR-

Tracking Close
Scan
2

Tracking Open
Mode
3

Focus Close

Focus Open

Jump Off

6
To new test mode
Jump mode switching
Auto/Manu
Note: Eject and CD on/off is performed in the same procedure as that for the normal mode.
(3) Cause of Error and Error Code
Code Class
Contents
40
Electricity Off focus detected.

Description and cause


FOK goes low.
Damages/stains on disc, vibrations or failure on servo.

41

Electricity

Spindle unlocked.

LOCK = Low continued for 150 msec.


Damages/stains on disc, vibrations or failure on servo.

42

Electricity

Sub-code unreadable.

Sub-code was unreadable for 500 msec.


Damages/stains on disc, vibrations or failure on servo.

43

Electricity

Sound skipping detected.

Last address memory function was activated.


Damages/stains on disc, vibrations or failure on servo.

Note: Mechanical errors during aging are not displayed.

19

DEH-P4350-2,P3350-2,P3350B-2

(4) Display of Operational Status during Setup


Status No. Contents
21
Focus search start
22
Focus search 2
23
Focus search 3
24
Focus search 4
25
Focus search(Setup protection)
26
Focus search(Fast recovery)
27
RF detection
28
Spindle rough servocontrol
29
Tracking balance adjustment start
30
Tracking balance adjustment 2
31
Tracking balance adjustment 3
32
Tracking close start(Spindle stationary servocontrol setting)
33
Tracking close 2
34
Tracking close 3
35
Focus/Tracking AGC start
36
Focus/Tracking AGC 2
37
Focus/Tracking AGC 3
38
Focus/Tracking AGC 4
39
Focus/Tracking AGC 5
40
Focus/Tracking AGC 6
41
Focus/Tracking AGC 7
42
Focus/Tracking AGC 8
43
FE bias start
44
FE bias 2
45
RF AGC start
46
RF AGC 2
47
Lock check start
48
Lock is being checked
49
Subcode check start
50
Subcode is being checked

20

Protective action
Focus search timeout.
Focus search timeout.
Focus search timeout.
Focus search timeout.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off.
Focus slips off, spindle lock is not performed.
Focus slips off, no subcode can be read.

DEH-P4350-2,P3350-2,P3350B-2

(5) Display Examples


1) During Setup
8-digit display, 6-digit display
TNO. Min Sec
11 11' 11"

4-digit display(Auto setting)


TNO.
11

4-digit display(Manual setting)


Min Sec
11' 11"

2) During Operation (TOC read, TRK search, Play, FF and REV)


The same as in the normal mode.
3) When a Protection Error Occurred
(A) Error display ((A)(B), (C) : BAND key)
8-digit display
ERROR-xx

6-digit display
ERR-xx

4-digit display
E-xx

(B) Error occurrence timing display in track no. ((B)(C) : Auto/Manual key)
8-digit display, 6-digit display
TNO. Min Sec
10 40' 05"

4-digit display(Auto setting)


TNO.
10

(C) Error occurrence timing display in absolute time. ((B)(C) : Auto/Manual key)
8-digit display, 6-digit display
TNO. Min Sec
10 40' 05"

4-digit display(Manual setting)


Min Sec
40' 05"

21

DEH-P4350-2,P3350-2,P3350B-2

DISASSEMBLY
- How to hold the Mechanical Unit
1. Hold the top and bottom frame.
2. Do not squeeze top frame's front portion too tight,
because it is fragile.

Do not squeeze.

- How to remove the Top and Bottom Frame


1. When the disk is "clamp" state, unlock Spring A (6
pieces) and Spring B (2 pieces), and unscrew screws
(4 pieces).
2. Unlock each 1 of pawl at the both side of the frame,
then remove the top frame.
3. Remove the Carriage Mechanical part in such way Carriage
Mechanical
that; you remove the mechanical part from 3 pieces Part
of Damper while slowly pulling up the part.
4. Now, the top frame has been removed, and under
this state, fix the genuine Connector again, and eject
the disk.
(Caution)
Bottom Frame
When you reassemble the Carriage Mechanical part,
apply a bit of alcohol to Dampers.

Top Frame

Damper

- How to remove the Guide Arm Assy


1. Unlock the spring (1 piece) at the right side of the
assembly.
2. Unscrew screws (2 pieces), then remove the Screw
Gear Bracket.
3. Shift the Guide Arm Assy to the left and slowly rotate
it to the upper direction.
4. When the Guide Arm Assy rotates approximately 45
degree, shift the Assy to the right side direction and
remove it.

Screw Gear Bracket


Guide Arm
Assy

Spring

22

DEH-P4350-2,P3350-2,P3350B-2

- How to remove the Control Unit


1. Give jumper-solder treatment to the Flexible Wire of
the Pickup unit, then remove the wire from the
Connector.
2. Remove all 4 points of solder-treatment on the Lead
Wire. Also, unscrew the screw(1 piece).
3. Then, Remove the Control unit.
(Caution)
Be careful not to damage SW when you reassemble
the Control Unit into the device.

Jumper-Solder
Control Unit

Solder

- How to remove the Loading Arm Assy


1. Unlock the spring (1 piece) and remove the E ring (1
piece) of the Fulcrum Shaft.
2. Shift the arm to the left side direction and unlock pins
(2 pieces).

Loading Arm Assy

- How to remove the Pickup Unit


1. Unscrew 2 pieces of screws, then remove the Pulley
Cover.
2. Remove the Feed Screw unit from the pawl of the
Feed Screw Guide (The pawl is located inside the
guide).
3. Remove the belt from the Pulley, then remove the
Pickup unit.
Pulley Cover
(Caution)
Make sure not to stain the belt with grease when you
fix the belt.

Grease Application

Pickup Unit

Grease Application
Belt

Feed Screw Guide

23

DEH-P4350-2,P3350-2,P3350B-2

IC
- Pin Functions(TA2153FN)
Pin No.
1
2
3
4
5
6
7
8
9
10

Pin Name
VCC
RFGC
GMAD
FNI
FPI
TPI
TNI
MDI
LDO
SEL

I/O
I
I
I
I
I
I
O
I
I

11
12
13
14
15
16
17
18
19
20
21

TEB
2VRO
TEN
TEO
SBAD
FEO
FEN
SEB
VRO
RFRP
BTC

I
O
I
O
O
O
I
I
O
O
I

22
23
24
25
26
27
28
29
30

RFCT
PKC
RFRPIN
RFGO
GVSW
AGCIN
RFO
GND
RFN2

O
I
I
O
I
I
O
I
I

TA2153FN

24

15

16

30

Function and Operation


Power supply voltage terminal
RF amplitude adjustment control signal terminal
AGC amplifier frequency characteristic adjustment terminal
Main beam amplifier input terminal
Main beam amplifier input terminal
Sub beam amplifier input terminal
Sub beam amplifier input terminal
Monitor photodiode amplifier input terminal
Laser diode amplifier output terminal
APC circuit ON/OFF signal, LDO terminal control input terminal and bottom
and peak detection frequency switching terminals
Tracking error balance adjustment signal input terminal
Reference voltage (2VRO) output terminal
Tracking error signal generation amplifier reverse phase input terminal
Tracking error signal generation amplifier output terminal
Sub beam addition signal output terminal
Focus error signal generation amplifier output terminal
Focus error signal generation amplifier reverse phase input terminal
RFRP generation circuit mode switching terminal
Reference voltage (VREF) output terminal
Signal generation amplifier output terminal for track count
Bottom detection time constant adjustment terminal for RFCT signal
generation
RFRP signal center level output terminal
Peak detection time constant adjustment signal for RFCT signal generation
Signal generation amplifier input terminal for track count
RF signal amplitude adjustment amplifier output terminal
AGC, FE or TE amplifier gain switching terminal
RF signal amplitude adjustment amplifier input terminal
RF signal generation amplifier output terminal
GND terminal
RF signal generation amplifier input terminal

DEH-P4350-2,P3350-2,P3350B-2

- Pin Functions(TC9495F2)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57

Pin Name
TESTO
hso
uhso
EMPH
LRCK
VSS
BCK
AOUT
DOUT
MBOV
IPF
SBOK
CLCK
VDD
VSS
DATA
SFSY
SBSY
SPCK
SPDA
COFS
MONIT
VDD
TESIO0
P2VREF
HSSW
ZDET
PDO
TMAXS
TAMX
LPFN
LPFO
PVREF
VCOREF
VCOF
AVSS
SLCO
RFI
AVDD
RFCT
RFZI
RFRP
FEI
SBAD
TSIN
TEI
TEZI
FOO
TRO
VREF
RFGC
TEBC
FMO
FVO
DMO
2VREF
SEL

I/O
O
O
O
O
O
O
O
O
O
O
I/O

O
O
O
O
O
O
O
I
O
O
O
O
O
I
O
I
O
O
I
I
I
I
I
I
I
I
I
O
O
O
O
O
O
O
O

Function and Operation


Test mode terminal
Replay speed flag output terminal
Replay speed flag output terminal
Emphasis flag output terminal for sub code Q data
Channel clock (44.1 kHz) output terminal
Digital ground terminal
Bit clock output terminal
Digital audio data output terminal
Digital out output terminal
Buffer memory over signal output terminal
Correction flag output terminal
CRCC decision result output for sub code Q data
Clock input/output terminal for sub code P-W data read
Digital + power supply terminal (5 V)
Digital ground terminal
Sub code P-W data output terminal
Replay-system frame sync signal output terminal
Sub code block sync output terminal
Clock for processor status signal read
Processor status signal output terminal
Correction-system frame clock (7.35 kHz) output terminal
LSI internal signal output terminal
Digital + power supply terminal (5 V)
Test input/output terminal
PLL-system only 2VREF terminal
The VREF voltage is reached for double or quad speed.
One-bit DAC zero detection flag output terminal
Phase error signal issue between the EFM and PLCK signals
TMAX detection result output terminal
TMAX detection result output terminal
Reverse input terminal of amplifier for lowpass filter
Output terminal of amplifier for lowpass filter
PLL-system only VREF terminal
VCO center frequency reference level terminal
Filter terminal for VCO
Analog-system ground terminal
Output terminal of DAC for data slice level generation
RF signal input terminal
Analog-system power supply terminal (5 V)
RFRP signal center level input terminal
Input terminal for RFRP signal zero cross
RF ripple signal input terminal
Focus error signal input terminal
Sub beam addition signal input terminal
Test input terminal
Tracking error input terminal
Input terminal for tracking error or zero cross
Focus equalizer output terminal
Tracking equalizer output terminal
Analog reference power supply terminal
RF amplitude adjustment control signal output terminal
Tracking balance control signal output terminal
Feed equalizer output terminal
Speed error signal or feed search EQ output
Disc equalizer output terminal
Analog reference power supply terminal
APC circuit ON/OFF signal output terminal

25

DEH-P4350-2,P3350-2,P3350B-2

Pin No.
58-61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87-89
90-93
94
95
96
97
98
99
100

Pin Name
FLGA-D
VDD
VSS
IO0
IO1
IO2
IO3
dmout

I/O
O

ckse
dact
TESIN
TESIO1
VSS
PXI
PXO
VDD
XVSS
XI
XO
XVDD
DVSR
RO
DVDD
DVR
LO
DVSL
TEST1-3
BUS0-3
VDD
VSS
BUCK
cee
TEST4
tsmod
rst

I
I
I
I

Function and Operation


External flag output terminal for internal signal monitor
Digital + power supply terminal (5 V)
Digital ground terminal
RF amplifier gain switching terminal
Not used
HOME detection switch input terminal
FocusDrv and signal output terminal
Field equalizer PWM output terminal for IO0 and IO1
Disc equalizer PWM output terminal for IO2 and IO3
Usually open
DAC test mode terminal
Test input terminal
Test input/output terminal
Digital ground terminal
DPS-system clock oscillator circuit input terminal
DPS-system clock oscillator circuit output terminal
Digital + power supply terminal (5 V)
Ground terminal for system clock oscillator circuit
System clock oscillator circuit input terminal
System clock oscillator circuit output terminal
For system clock oscillator circuit + power supply terminal
R channel D/A converting unit power supply terminal
R channel data forward rotation output terminal
D/A converting unit power supply terminal (5 V)
Reference voltage terminal
L channel forward rotation output terminal
L channel D/A converting unit power supply terminal
Test mode terminal
Data input/output terminal for microcomputer interface
Digital + power supply terminal (5 V)
Digital ground terminal
Clock terminal for microcomputer interface
Chip enable signal for microcomputer interface
Test mode terminal
Test mode terminal
Reset signal input terminal

O
O
I
O
I

I
O

I
O

O
I
I/O

I
I
I
I
I

*TC9495F2

30

80

1
100

81

26

31

50
51

IC's marked by* are MOS type.


Be careful in handling them because they are very
liable to be damaged by electrostatic induction.

DEH-P4350-2,P3350-2,P3350B-2

- Pin Functions(BA5996FM)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28

Pin Name
VR
OPIN2(+)
OPIN2(-)
OPOUT2
OPIN1(+)
OPIN1(-)
OPOUT1
GND
MUTE
POWVCC1
VO1(-)
VO1(+)
VO2(-)
VO2(+)
VO3(+)
VO3(-)
VO4(+)
VO4(-)
POWVCC2
GND
CNT
LDIN
OPOUTSL
OPINSL
OPOUT3
OPIN3(-)
OPIN3(+)
PREVCC

Function and Operation


Input pin for reference voltage
Input pin for non-inverting input for CH2 preamplifier
Input pin for inverting input for CH2 preamplifier
Output pin for CH2 preamplifier
Input pin for non-inverting input for CH1 preamplifier
Input pin for inverting input from CH1 preamplifier
Output pin for CH1 preamplifier
Ground pin
Mute control pin
Power supply pin for CH1, CH2, and CH3 at "Power" stage
Driver CH1 - Negative output
Driver CH2 - Positive output
Driver CH2 - Negative output
Driver CH2 - Positive output
Driver CH2 - Positive output
Driver CH2 - Negative output
Driver CH4 - Positive output
Driver CH4 - Negative output
Power supply pin for CH4 at "Power" stage
Ground pin
Control pin
Loading input
Output pin for preamplifier for thread
Input pin for preamplifier for thread
CH3 preamplifier output pin
Input pin for inverting input for CH3 preamplifier
Input pin for non-inverting input for CH3 preamplifier
PreVcc

BA5996FM
14

15

28

27

You might also like