Professional Documents
Culture Documents
Clinitek AdvantusLIS PDF
Clinitek AdvantusLIS PDF
Interface Specification
04826807 Rev. A, 2008-05
04826807 Rev. A
Contents
Using this Manual
How this Manual is Organized . . . . . . . . . . . . . . . . . . . . . 0-1
Conventions Used in this Manual . . . . . . . . . . . . . . . . . . 0-2
1General Specifications
Serial Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Clinitek 500 Serial Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Clinitek Advantus Serial Port. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
2Data Flow
Transmission Specifications . . . . . . . . . . . . . . . . . . . . . . 2-1
Character Structure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Electrical Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Interface Connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Signal Levels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Speed. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Appendix E: Glossary
04826807 Rev. A
1 General Specifications
The Clinitek Advantus and Clinitek 500 Urine Chemistry Analyzers can transmit data to a
computer or Laboratory Information System (LIS). The Clinitek Advantus analyzer can use
either a serial interface or an ethernet port.
Serial Interface
The following information details the serial interface for each analyzer:
Clinitek 500 serial port
Clinitek Advantus serial port
Clinitek Advantus ethernet port
Table 1-2 Clinitek 500 Serial Port Connector RS232 25 Pin (DB25)
In addition, avoid any address in which all bits outside the subnet mask are 1. For example, if
the subnet mask is 255.255.255.0, and address of the form X.X.X.255. The RFC 950 defines
these as broadcast addresses that refer to every host on a local network so they should not be
assigned to an individual host.
Two bi-colored LEDs (light emitting diodes) are built into the port allowing the user to monitor
the port status.
Table 1-7 Port Status
Link LED Left side Activity LED Right side
This condition Means This condition Means
Off No link Off No activity
Amber 10Mbps Amber Half-duplex
Green 100Mpbs Green Full-duplex
04826807 Rev. A
2 Data Flow
The section contains the conventions used for the data exchanged between a host computer or
LIS and the Clinitek Advantus and Clinitek 500 analyzers.
NOTE:Some analyzer versions show Bayer in the record content. This a vestige of programming
and does not imply any connection or relationship between Bayer and Siemens.
Transmission Specifications
Transmission specifications include:
Character structure
Electrical characteristics
Interface connections
Signal levels
Speed
Character Structure
The method of data transmission is serial-by-bit start/stop. The order of the bits in a character is:
1. One start bit, corresponding to a binary 0.
2. The data bits of the character, least significant bit being transmitted first.
3. Parity bit.
4. Stop bit(s), corresponding to a binary 1.
The time between the stop bit of one character and the start bit of the next character may be of
any duration. The data interchange circuit is in the marking condition between characters.
The default character structure consists of one start bit, eight data bits, no parity bit, and one
stop bit. Other character structures are supported, such as seven data bits and odd parity or seven
data bits and even parity.
The character bit sequencing, structure, and parity sense definitions conform to ANSI standards
X3.15-1976 and X3.16-1976.
Electrical Characteristics
The voltage and impedance levels for the generator and receiver circuits conform to the EIA232-D-1986 standard.
22 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
Interface Connections
The Clinitek Advantus and Clinitek 500 support the connector requirements of ANSI standard
E1381-91.
Signal Levels
For the data interchange circuits, a marking condition corresponds to a voltage more negative
than minus three volts with respect to signal ground at the interface point. A spacing condition
corresponds to a voltage more positive than plus three volts with respect to signal ground at the
interface point.
Binary state ONE (1) corresponds to the marking condition; binary state ZERO (0) corresponds
to the spacing condition.
The signal levels conform to the EIA-232-D-1986 standard.
Speed
The default data transmission rate is 9600 baud. The data transmission rates supported are 2400,
4800, 9600, and 19200.
Data Characters
The control characters that the computer sends to the analyzer to manage the data flow are
shown in Table 2-1.
NOTE:Depending on the analyzer configuration, the computer uses either the <ENQ> or the
<BEL> character to initiate the request for identification.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 23
04826807 Rev. A
The characters that the analyzer and computer use to communicate data sets are shown in Table
2-2.
Table 2-2 Data Set Control Characters
Upon receiving the <ENQ>, the receiver must respond to the sender before the sender can begin
sending information. If the receiver is able to receive information, it responds with an <ACK>
transmission control character signifying that it is ready. With this sequence of events, the
establishment phase ends and the transfer phase begins.
If the receiver cannot immediately receive information from the sender, the receiver replies with
a <NAK> transmission control character. Upon receiving <NAK>, the sender must wait at least
10 seconds before again attempting to establish a communication link by transmitting another
<ENQ>.
If both systems simultaneously attempt to start a communication session by transmitting an
<ENQ>, the data link is considered to be in contention. The Clinitek analyzer has priority to
transmit information when contention occurs. The contention to start a communication session
is resolved as follows:
Upon receiving a reply of <ENQ> to its transmitted <ENQ>, the computer system must stop
trying to transmit; it must prepare to receive. The computer sets a timer. If an <ENQ> is not
received from the Clinitek analyzer within 20 seconds, a time-out occurs. After a time-out, the
receiver regards the line to be in the neutral state and may again attempt to acquire the line by
sending an <ENQ> to the Clinitek analyzer. If, however, the computer receives an <ENQ> from
the Clinitek analyzer within the 20-second period, it must reply with an <ACK> or <NAK>
depending on its readiness to receive information.
Upon receiving a reply of <ENQ> to its transmitted <ENQ>, the Clinitek analyzer must wait at
least 1 second before sending another <ENQ>.
Transfer Phase
During the transfer phase, the sender transmits messages to the receiver. The transfer phase
continues until all the messages have been sent.
Frames
Multiple messages are never combined in a single frame. Every message must begin in a new
frame. Records are never split across frames.
A frame is one of two types, an intermediate frame or an end frame. Intermediate frames
terminate with the characters <ETB>, checksum, <CR> and <LF>. End frames terminate with
the characters <ETX>, checksum, <CR> and <LF>. Messages less than 240 characters may be
sent in one end frame. Longer messages are sent in intermediate frames with the last part of the
message sent in an end frame.
The frame structure is as follows:
<STX> FN text <ETB> C1 C2 <CR> <LF> <-- intermediate frame
.
.
<STX> FN text <ETX> C1 C2 <CR> <LF> <-- end frame
where:
Frame Number
The frame number allows the receiver to distinguish between new and retransmitted frames. It is
a single digit sent immediately after the <STX> character.
The frame number is an ASCII digit ranging from 0 to 7. The frame number begins at 1 with the
first frame of the Transfer phase. The frame number is incremented by one for every new frame
transmitted. After 7, the frame number rolls over to 0, and continues in this fashion.
<STX> Start of Text transmission control character
FN single digit Frame Number 0 to 7
text Data Content of Message
<ETB> End of Transmission Block transmission control character
Checksum
The checksum permits the receiver to detect a defective frame. The checksum is encoded as two
characters which are sent after the <ETB> or <ETX> character. The checksum is computed by
adding the binary values of the characters, keeping the least significant eight bits of the sum.
The checksum is initialized to zero with the <STX> character. The first character used in
computing the checksum is the frame number. Each character in the message text is added to the
checksum (modulo 256). The computation for the checksum does not include <STX>, the
checksum characters, or the trailing <CR> and <LF>.
The checksum is an integer represented by eight bits, it can be considered as two groups of four
bits. The groups of four bits are converted to the ASCII characters of the hexadecimal
representation. The two ASCII characters are transmitted as the checksum, with the most
significant character first.
For example, a checksum of 122 can be represented as 01111010 in binary or 7A in
hexadecimal. The checksum is transmitted as the ASCII character 7 followed by the character
A.
Acknowledgments
The sender sends one frame at a time. After a frame is sent, the sender stops transmitting until a
reply is received. When the sender has transmitted the last character of a frame, it sets a timer.
The receiver must reply to each frame sent within 15 seconds. If the sender has not received an
<ACK>, a <NAK>, or an <EOT> in response to the frame sent within the 15-second time
period, the sender enters the termination phase of the communication session by sending an
<EOT>.
A reply of <ACK> from the receiver signifies the frame was received successfully and the
receiver is prepared to receive another frame. The sender then increments the frame number and
sends the next frame or terminates the communication session.
A reply of <NAK> from the receiver signifies the frame was not successfully received and the
receiver is prepared to receive the frame again. Upon receiving a <NAK> in response to a
frame, the sender increments a retransmit counter and retransmits the frame. If this counter
shows a single frame was sent and not accepted six times, the sender stops attempting to send
the frame and proceeds to the termination phase of the communication session by sending an
<EOT>.
A reply of <EOT> from the receiver tells the sender the frame was received successfully but
does not want to continue the communication session. It is a request to the sender to stop
transmitting. After receiving the receiver interrupt request, the sender sends the Message
Terminator record and ends the communication session.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 27
04826807 Rev. A
During the transfer phase, if the receiver responds to a frame with an <EOT> in place of the
usual <ACK>, the sender interprets this reply as a receiver interrupt request. The <EOT> is a
positive acknowledgment of the end frame and also a request to the sender to stop transmitting.
The sender then enters the termination phase to return the data link to the neutral state. This
gives the receiver an opportunity to enter the establishment phase and become the sender. The
original sender must not enter the establishment phase for at least 15 seconds or until the
receiver has sent a message and returned the data link to the neutral state.
If the receiver requests the sender to stop transmitting results before all the result records have
been sent and acknowledged for a patient, ALL the results for that patient must be retransmitted
the next time results are sent. If the receiver requests the sender to stop transmitting results after
the last result is sent for a patient, the next result transmission begins with the next patient
record.
Error Handling
A receiver checks every frame to guarantee it is valid. A reply of <NAK> is transmitted for
invalid frames. Upon receiving the <NAK>, the sender must retransmit the last frame with the
same frame number.
Any characters occurring before the <STX> or after the end of the block character (the <ETB>
or <ETX>) are ignored by the receiver when checking the frame.
The receiver should reject a frame when:
A character error is detected (parity error, framing error, etc.)
The frame checksum sent does not match the checksum computed on the received frame
The frame number is not the same as the frame number for a previously rejected frame or the
frame number is not one higher than the last accepted frame (modulo 8).
Upon receiving a <NAK>, the sender increments a retransmit counter and retransmits the frame.
If the retransmit counter shows a single frame was sent and not accepted six times, the sender
must abort the message by proceeding to the termination phase.
28 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
Timeouts
Both sender and receiver use timers to detect loss of coordination between them. The timer
provides a method for recovery if the communication line or the other device fails to respond.
Message Structure
This section describes the supported message types, the structure of those message types and
their supporting records. Each message consists of a hierarchy of records of various types.
The following rules apply when the analyzers are processing a message:
The laboratory computer system may ignore any field it does not require.
All fields in a record are always transferred.
The fields are always transferred in the positional order specified
All fields in records are variable length fields.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 29
04826807 Rev. A
Both the Clinitek Advantus and Clinitek 500 analyzers support similar record types with the
Clinitek Advantus supporting one additional record type. Table 2-3 describes the supported
record types.
Table 2-3 Supported Record Types
Record Type Description
Message Header Record marks the beginning of a message
It is always the first record sent in a message.
Request for Identification Record initiated by the laboratory computer
Two different types of sessions are supported: a
standard ASTM messaging session and a simple,
single character message session.
Patient Record contains information about a sample that applies to
every Result record for that sample
Result Record contains the result of a single test determination.
Because Clinitek urine chemistry test strips contain
multiple chemistry tests, the analyzer reports one
result record for each result.
Message Terminator Record signals the end of the record
If transmission terminates prior to the Message
Terminator record being received and
acknowledged, the entire message must be
retransmitted in a new session. That is, the patient
records and all result records for that patient must
be retransmitted.
Order Record
(Only the Clinitek Advantus
analyzer supports this record.)
sent by the computer system to the analyzer
The order record provides the Clinitek Advantus
analyzer with a list of sample IDs for which tests to
perform.
The functionality of the record only allows the
remote computer to send a list of Sample IDs. It
cannot send any additional information.
210 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
Communication Sessions
The Clinitek Advantus and Clinitek 500 analyzers support the following types of
communication sessions:
Request for Identification session
Order Communication Session (Clinitek Advantus analyzer only)
Results Reporting session
The computer or LIS sends the request information message using the following logical
structure:
message header record
request information record
The computer or LIS must send the request information record to the analyzer in a separate field
from the message header record.
NOTE:The computer or LIS does not send a message terminator record after the request
information record. The analyzer sends the message terminator after replying to the request
information query.
ASTM Identification Message Response
The analyzer sends the identification message response using the following logical structure:
message header record
message terminator record
If transmission is terminated before the computer receives and acknowledges the message
terminator record, you must resend the entire message in a new session.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 211
04826807 Rev. A
The ASTM communication session follows the pattern displayed in this table:
Table 2-4 Clinitek Advantus and Clinitek 500 ASTM Communication
Analyzer Dir. Computer or LIS
Send <ENQ> to acquire the line
<ACK>
Send Header field
<ACK>
Send Request for Identification
<ACK>
Send Identification (Header)
<ACK>
Send Message termination
<ACK>
Send <EOT> to release the line
212 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
An example of actual data exchanged for the standard ASTM identification request session
appears as shown in the following table:
Table 2-5 ASTM Data Exchange
NOTE:On the Clinitek Advantus, the manufacturer is Siemens Medical Solutions Diagnostics,
the product ID is 1420, and the analyzer serial number is after the product ID in the analyzer
transmission.
The computer or LIS sends the request information message using the <BEL> character.
NOTE:The computer or LIS does not send a message terminator record after the request
information record. The analyzer sends the message terminator after replying to the request
information query.
Row Analyzer Computer or LIS
1.
2. <ENQ>
3. <ACK>
4. <STX>1 H|\^&|||Laboratory
Computer System Name||||||
|P|1|19970526101230<CR>
<ETX>C1 C2<CR><LF>
5. <ACK>
6. <STX>2 Q|1<CR> <ETX>C1
C2<CR><LF>
7. <ACK>
8. <STX>1
H|\^&|||BAYER^6740^^01.00/
01.00||||||010|P|1|1997052610130
0<ETX>C1 C2<CR><LF>
9. <ACK>
10. <STX>2 L|1|N<CR> <ETX>C1
C2<CR><LF>
11. <ACK>
12. <EOT>
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 213
04826807 Rev. A
The analyzer sends the identification message response using the following logical structure:
message header record
message terminator record
If transmission is terminated before the computer receives and acknowledges the message
terminator record, you must resend the entire message in a new session.
Single Character Communication Session
The single character communication session follows the pattern displayed in this table:
Table 2-6 Single Character Communication Session
Single Character Data Exchange
An example of actual data exchanged for the single character identification request session
appears as shown in the following table:
Table 2-7 Single Character Data Exchange
NOTE:On the Clinitek Advantus, the manufacturer is Siemens Medical Solutions Diagnostics,
the product ID is 1420, and the analyzer serial number is after the product ID in the analyzer
transmission.
Analyzer Dir. Computer or LIS
Send <BEL> character
Send identification (Header)
<ACK>
Send message termination
<ACK>
Send EOT to release the line
Row Analyzer Computer or LIS
1.
2. <BEL>
3. <ACK>
4. <STX>1
H|\^&|||BAYER^6740^^01.00/
01.00||||||010|P|1|1997052610130
0<ETB>C1 C2<CR><LF>
5. <ACK>
6. <STX>2 L|1|N<CR> <ETX>C1
C2<CR><LF>
7. <ACK>
8. <EOT>
214 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
Message Terminator
If transmission is terminated before the computer receives and acknowledges the message
terminator record, you must resend the entire message in a new session.
<ETB>C1 C2<CR><LF>
8. <ACK>
Table continues on the next page.
216 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
9. <STX>4 O|26|1234567890147<CR>
O|27|1234567890148<CR>
O|28|1234567890149<CR>
O|29|1234567890150<CR>
O|30|1234567890151<CR>
O|31|1234567890152<CR>
O|32|1234567890153<CR>
O|33|1234567890154<CR>
O|34|1234567890155<CR>
O|35|1234567890156<CR>
O|36|1234567890157<CR>
O|37|1234567890158<CR>
<ETB>C1 C2<CR><LF>
10. <ACK>
11. <STX>5 O|38|1234567890159<CR>
O|39|1234567890160<CR>
O|40|1234567890161<CR>
O|41|1234567890162<CR>
O|42|1234567890163<CR>
O|43|1234567890164<CR>
O|44|1234567890165<CR>
O|45|1234567890166<CR>
O|46|1234567890167<CR>
O|47|1234567890168<CR>
O|48|1234567890169<CR>
O|49|1234567890170<CR>
<ETB>C1 C2<CR><LF>
12. <ACK>
13. <STX>6 O|50|1234567890171<CR>
<ETX>C1 C2<CR><LF>
14. <ACK>
15. <EOT>
Row Analyzer Computer or LIS
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 217
04826807 Rev. A
Message Terminator
If transmission is terminated before the computer receives and acknowledges the message
terminator record, you must resend the patient records and all result records for that patient.
The Order Communication session treats each patient record as an independent communication
session. The analyzer transmits an <ENQ> to acquire the line to transmit the next patient record
for each patient record that is available for transmission.
Results Data
To illustrate the transfer of data from the Clinitek Advantus and Clinitek 500 analyzers to a
computer or LIS, the following illustration displays actual results data assuming these
parameters:
urine chemistry test type is MULTISTIX 10 SG
color is reported
clarity is not reported
all chemistry tests on the strip are reported.
three tests are run
Send Message Termination record
<ACK>
Send next <ENQ> to initiate next
patient
or
Send <EOT> to release the line
Analyzer Flow Computer or LIS
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 219
04826807 Rev. A
COL YELLOW
GLU NEGATIVE
BIL NEGATIVE
KET NEGATIVE
SG <=1.005
BLO NEGATIVE
pH 5.5
PRO NEGATIVE
URO 0.2 E.U./dL
NIT NEGATIVE
LEU NEGATIVE
00003 05-26-97 10:25 AM
Tech ID: 323
ID: 398576435
* COL RED
GLU NEGATIVE
BIL NEGATIVE
KET NEGATIVE
SG <=1.005
* BLO MODERATE
pH 6.0
PRO NEGATIVE
URO 1.0 E.U./dL
NIT NEGATIVE
* LEU LARGE
220 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
2. <ENQ>
3. <ACK>
4. <STX>1 H|\^&|||BAYER^6740^^01.00/
01.00||||||010|P|1|19970526102500<CR> <ETX>C1
C2<CR><LF>
5. <ACK>
6. <STX>2 P|1|00001|19970526102500|312445446|323<CR>
P|2|C|P|MULTISTIX 10 SG|F|0000<CR>
<ETX>C1 C2<CR><LF>
7. <ACK>
8. <STX>3 R|1|N|COL|12|YELLOW|1|0|A<CR>
R|2|A|GLU|1|250^mg/dL|3|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|E<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|SMALL|4|0|A<CR>
<ETB>C1 C2<CR><LF>
9. <ACK>
10. <STX>4 R|7|N|pH|5|6.0|3|0|A<CR>
R|8|N|PRO|6|NEGATIVE|1|0|A<CR>
R|9|N|URO|7|1.0^E.U./dL|2|0|A<CR>
R|10|N|NIT|8|NEGATIVE|1|0|A<CR>
R|11|A|LEU|10|TRACE|2|1|0<CR>
<ETB>C1 C2<CR><LF>
11. <ACK>
12. <STX>5 L|1<CR> <ETX>C1 C2<CR><LF>
13. <ACK>
14. <EOT> <ENQ>
15. <ACK>
16. <STX>1 H|\^&|||BAYER^6740^^01.00/
01.00||||||010|P|1|19970526102600<CR> <ETX>C1
C2<CR><LF>
Table continues on the next page.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 221
04826807 Rev. A
17. <ACK>
18. <STX>2 P|1|00002|19970526102500|213543331|323<CR>
P|2|C|P|MULTISTIX 10 SG|F|0000<CR>
<ETX>C1 C2<CR><LF>
19. <ACK>
20. <STX>3 R|1|N|COL|12|YELLOW|1|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|E<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|N|BLO|9|NEGATIVE|1|0|A<CR>
<ETB> C1 C2<CR><LF>
21. <ACK>
22. <STX>4 R|7|N|pH|5|5.5|2|0|A<CR>
R|8|N|PRO|6|NEGATIVE|1|0|A<CR>
R|9|N|URO|7|0.2^E.U./dL|1|0|A<CR>
R|10|N|NIT|8|NEGATIVE|1|0|A<CR>
R|11|N|LEU|10|NEGATIVE|1|0|A<CR>
<ETB>C1 C2<CR><LF>
23. <ACK>
24. <STX>5 L|1<CR> <ETX>C1 C2<CR><LF>
25. <EOT> <ENQ>
26. <ACK>
27. <STX>1 H|\^&|||BAYER^6740^^1.00/
01.00||||||010|P|1|19970526102500<CR> <ETX>C1
C2<CR><LF>
28. <ACK>
29. <STX>2 P|1|00003|19970526102500|398576435|323<CR>
P|2|C|P|MULTISTIX 10 SG|F|0000<CR>
<ETX>C1 C2<CR><LF>
30. <ACK>
31. <STX>3 R|1|A|COL|12|RED|3|1|A<CR>
R|2|N|GLU|1|NEGATIVE|1|1|A<CR>
R|3|N|BIL|2|NEGATIVE|1|1|A<CR>
R|4|N|KET|3|NEGATIVE|1|1|A<CR>
R|5|N|SG|4|<=1.005|1|1|A<CR>
R|6|A|BLO|9|MODERATE|4|1|A<CR>
<ETB> C1 C2<CR><LF>
32. <ACK>
Row Analyzer
Computer or
LIS
Table continues on the next page.
222 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
NOTE:On the Clinitek Advantus, the manufacturer is SIEMENS, the product ID is 1420, and
the analyzer serial number is included after the product ID in the analyzer transmission.
If the laboratory computer calculates a different checksum value for a frame, the computer must
refuse to accept that frame and the analyzer must resend the frame. The analyzer may send the
frame a maximum of six times. If the frame is not accepted after the sixth transfer of the frame,
the analyzer must terminate the communication session. The analyzer may then initiate a new
session.
Table 2-12 displays a retransmission of the third results frame from the previous example. In
this instance, the laboratory computer does not calculate the same checksum value as that sent
by the analyzer for the third frame (line 7). The laboratory computer refuses to accept the frame
(<NAK>), and the Analyzer resends that frame.
33. <STX>4 R|7|N|pH|5|6.0|3|1|A<CR>
R|8|N|PRO|6|NEGATIVE|1|1|A<CR>
R|9|N|URO|7|1.0^E.U./dL|2|1|A<CR>
R|10|N|NIT|8|NEGATIVE|1|1|A<CR>
R|11|A|LEU|10|LARGE|5|1|A<CR>
<ETB>C1 C2<CR><LF>
34. <ACK>
35. <STX>5 L|1|N<CR> <ETX>C1 C2<CR><LF>
36. <ACK>
37. <EOT>
Row Analyzer
Computer or
LIS
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 223
04826807 Rev. A
R|8|N|PRO|6|NEGATIVE|1|0|A<CR>
R|9|N|URO|7|1.0^E.U./dL|2|0|A<CR>
R|10|N|NIT|8|NEGATIVE|1|0|A<CR>
R|11|A|LEU|10|LARGE|5|0|A<CR>
<ETB>C1 C2<CR><LF>
12. <ACK>
13. <STX>5 L|1|N<CR> <ETX>C1 C2<CR><LF>
14. <ACK>
15. <EOT>
224 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
After six attempts, if the third frame is not successfully retransmitted, the data exchange ends as
in Table 2-13. In Table 2-13, when the analyzer initiates a new session to send results, the
patient records and all the result records for the third patient must be sent again.
Table 2-13 Unsuccessful Resend Data Exchange
Row Analyzer
Computer or
LIS
1. <ENQ>
2. <ACK>
3. <STX>1 H|\^&|||BAYER^6740^^1.00/
01.00||||||010|P|1|19970526102500<CR> <ETX>C1
C2<CR><LF>
4. <ACK>
5. <STX>2 P|1|00003|19970526102500|398576435|323<CR>
P|2|C|P|MULTISTIX 10 SG|F<CR> <ETX>C1
C2<CR><LF>
6. <ACK>
7. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
8. <NAK>
9. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
10. <NAK>
11. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
12. <NAK>
Table continues on the next page.
Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow 225
04826807 Rev. A
A problem can also occur on the laboratory computer side of the communication session
making it impossible for the computer to continue to receive the test results from the Analyzer.
The laboratory computer transmits an <EOT> instead of an <ACK> to notify the analyzer that it
cannot continue to receive results.
If the laboratory computer asks to terminate the communication session before the analyzer
transmits all the result records for a patient, the analyzer must resend all the information for that
patient the next time it reports results.
If the laboratory computer asks to end a results reporting session after receiving the termination
for a particular message, the next time the computer report results, the analyzer does not have to
resend that message and may begin with the next set of results.
13. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
14. <NAK>
15. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
16. <NAK>
17. <STX>3 R|1|A|COL|12|RED|3|0|A<CR>
R|2|N|GLU|1|NEGATIVE|1|0|A<CR>
R|3|N|BIL|2|NEGATIVE|1|0|A<CR>
R|4|N|KET|3|NEGATIVE|1|0|A<CR>
R|5|N|SG|4|<=1.005|1|0|A<CR>
R|6|A|BLO|9|MODERATE|5|0|A<CR>
<ETB> C1 C2<CR><LF>
18. <NAK>
19. <EOT>
Row Analyzer
Computer or
LIS
226 Clinitek Advantus and Clinitek 500 Interface Specification: Data Flow
04826807 Rev. A
The analyzer must wait at least 15 seconds before attempting to take control of the line again
and send additional results. When the analyzer does send an <ENQ> and receives a reply of
<ACK> from the laboratory computer, the analyzer transmits the next set of results.
Using the previously illustrated communication session, the information in
Table 2-14 assumes that after the transmission of the first result, the laboratory computer is
unable to continue to receive results.
Table 2-14 Communication when the LIS NAKS
Row
Analyzer
Computer or
LIS
1.
2. <ENQ>
3. <ACK>
4. <STX>1 H|\^&|||BAYER^6740^^1.00/
01.00||||||010|P|1|19970526102500<CR> <ETX>C1
C2<CR><LF>
5. <ACK>
6. <STX>2 P|1|00001|19970526102502|312445446|323<CR>
P|2|C|P|MULTISTIX 8|F|0000<CR> <ETX>C1
C2<CR><LF>
7. <ACK>
8. <STX>3 R|1|N|COL|12|YELLOW|1|1|A<CR>
R|2|A|GLU|1|250^mg/dL|3|1|A<CR>
R|3|N|BIL|2|NEGATIVE|1|1|A<CR>
R|4|N|KET|3|NEGATIVE|1|1|E<CR>
R|5|N|SG|4|<=1.005|1|1|A<CR>
R|6|A|BLO|9|SMALL|4|1|A<CR>
<ETB>C1 C2<CR><LF>
9. <ACK>
10. <STX>4 R|7|N|pH|5|6.0|3|1|A<CR>
R|8|N|PRO|6|NEGATIVE|1|1|A<CR>
R|9|N|URO|7|1.0^E.U./dL|2|1|A<CR>
R|10|N|NIT|8|NEGATIVE|1|1|A<CR>
R|11|A|LEU|10|TRACE|2|1|A<CR> <ETB>C1
C2<CR><LF>
11. <ACK>
12. <EOT>
04826807 Rev. A
Restricted Characters
Table 3-1 identifies the characters that may not appear in message text.
32 Clinitek Advantus and Clinitek 500 Interface Specification: Formatting Test Records
04826807 Rev. A
Within text data fields, only ASCII characters 32-126 are permitted as usable characters with
the exception of those characters used as delimiter characters. The sender is responsible for
screening all text data fields to ensure that the text does not contain delimiter characters. The
contents of the data fields is case sensitive.
Fields are identified by their position within a record. The position is obtained by counting field
delimiters from the front of the record. This position-sensitive identification process requires
that when the contents of the field are null, its corresponding field delimiter must be included in
the record to ensure that the ith field can be found by counting (i-1) delimiters. Delimiters are
not included for trailing null fields; that is, if the tenth field was the last field containing data,
the record could terminate after the tenth field, and therefore would contain only nine delimiters.
Table 3-2 describes the delimiter characters.
Character ASCII Value HEX Value
<SOH> 001 01
<STX> 002 02
<ETX> 003 03
<EOT> 004 04
<ENQ> 005 05
<ACK> 006 06
<BEL> 007 07
<LF> 010 0A
<CR> 013 0D
<DLE> 016 10
<DC1> 017 11
<DC2> 018 12
<DC3> 019 13
<DC4> 020 14
<NAK> 021 15
<SYN> 022 16
<ETB> 023 17
Clinitek Advantus and Clinitek 500 Interface Specification: Formatting Test Records 33
04826807 Rev. A
Transmitted records may include more fields than are required by the receiving system. When
processing a record, the receiving system may ignore any field it does not require. All fields in a
record are always transferred, and the fields are always transferred in the positional order
specified to facilitate accurate identification by the computer system.
All fields in records are variable length fields.
For all record types, dates are recorded in YYYYMMDD format and times are represented as
HHMMSS.
Date and time together are specified as a fourteen-character string: YYYYMMDDHHMMSS.
Delimiter
Character
Representation Definition
Record Delimiter Carriage Return <CR>
(ASCII 13)
The record delimiter marks the end of
each record.
Field Delimiter Vertical Bar (|)
(ASCII 124)
The field delimiter is used to separate
adjacent fields.
Repeat Delimiter Backslash (\)
(ASCII 92)
The repeat delimiter is used to separate
variable numbers of descriptors for fields
containing parts of equal members of the
same set.
Component
Delimiter
Caret (^)
(ASCII 94)
The component delimiter is used to
separate data elements within a field.
Escape Delimiter Ampersand (&)
(ASCII 38)
The escape delimiter is used within text
fields to signify special case operations.
Applications of the escape delimiter are
optional and may be used or ignored at
the discretion of either the transmitter or
the receiver. All applications must accept
the escape delimiter and use it to
9. Characteristics of
the server
This field contains characteristics of the sender such as
parity, checksums, and optional protocols.
The request information record consists of 3 fields of information with each field in a
predefined position as described in Table 3-6.
Table 3-6 Request Information Record Table
Test Strip ID
The following table displays the supported test strips by analyzer.
Table 3-10 Test Strip IDs
Clinitek Advantus Clinitek 500
Multistix 10 SG (N Multistix SG-L) Multistix 10 SG
Multistix 9 Multistix 9
Multistix 9 SG Multistix 9 SG
Multistix 8 SG Multistix 8 SG
Multistix SG Multistix SG
Multistix SG L Multistix SG L
Multistix Multistix
N-Multistix SG N-Multistix SG
Nephrostix L Nephrostix L
Uro-Hemacombistix Uro-Hemacombistix
Uro-Hemacombistix SG L Uro-Hemacombistix SG L
Uro-Labstix Uro-Labstix
Uro-Labstix SG L Uro-Labstix SG
Hemacombistix Long Uro-Labstix SG L
Lifestix Combistix SG Long
Multistix PRO 7G Hemacombistix Long
Multistix PRO 10LB Uristix Long
Multistix PRO 10LS Lifestix
Multistix PRO 11 Multistix PRO 6B
Clinitek Microalbumin 9 Multistix PRO 6K
Multistix PRO 7G
Multistix PRO 7pH
Multistix PRO 10
Multistix PRO 10LB
Multistix PRO 10LS
Error Codes
The error code field may contain a value that represents multiple errors. For example, if a low
dark value is detected under readhead 1 and a skewed strip is detected at readhead 2, the error
code is 0109.
Clinitek Advantus Error Codes
The following table displays the error codes used by the Clinitek Advantus analyzer:
Table 3-11 Clinitek Advantus Error Codes
Clinitek 500 Error Codes
The following table displays the error codes used by the Clinitek 500 analyzer:
Table 3-12 Clinitek 500 Error Codes
Error Codes
Error Readhead 1 Readhead 2
Low dark value 0100 0001
High dark value 0200 0002
A-D converter over-range 0300 0003
Low lamp(s) level 0400 0004
Low channel output 0500 0005
Missing strip N/A 0006
Upside down or dry strip 0700 N/A
Misaligned strip 0800 0008
Skewed strip 0900 0009
Reflectance > 100% 1000 0010
Auto strip type error 2000 N/A
Detected strip does not match expected value N/A 0020
Divide by zero error 3000 0030
Error Codes
Error Readhead 1 Readhead 2
Low dark value 0100 0001
High dark value 0200 0002
A-D converter over-range 0300 0003
Low lamp(s) level 0400 0004
Low channel output 0500 0005
Missing strip N/A 0006
Upside down or dry strip 0700 N/A
Table continues on the next page.
314 Clinitek Advantus and Clinitek 500 Interface Specification: Formatting Test Records
04826807 Rev. A
1. Record type P
2. Record sequence
number
The nth occurrence of this record type within the message
3. Test result status Indicates whether the result is normal or abnormal.
If the result is within the normal range for the test, this
field contains an N.
If the test result is outside the normal range for the
test, this field contains an A.
For microscopic data results on the Clinitek Advantus
analyzer, this field reports N.
4. Test name
abbreviation
The abbreviation for the test or physical value.
Abbreviations are language dependent.
For microscopic data results on the Clinitek Advantus
analyzer, this field contains the header name as configured
by the user for the relevant microscopic data result.
Refer to Test Strip Assays and Abbreviations page 3-16.
5. Test number ID A numeric value for the test.
Refer to Test Strip Assays and Abbreviations page 3-16.
Error Codes
Error Readhead 1 Readhead 2
Table continues on the next page.
Clinitek Advantus and Clinitek 500 Interface Specification: Formatting Test Records 315
04826807 Rev. A
The following table contains microscopic data test and numeric IDs for results on the Clinitek
Advantus analyzer:
Table 3-15 Microscopic Data Results
Test Abbreviation Numeric ID
Glucose GLU 1
Bilirubin BIL 2
Ketone KET 3
Specific Gravity SG 4
pH pH 5
Protein PRO 6
Urobilinogen URO 7
Nitrite NIT 8
Occult Blood BLO 9
Leukocytes LEU 10
Color --- 11
Clarity --- 12
Creatinine CRE 13
Protein to Creatinine Ratio P:C 14
Albumin ALB 15
Albumin to Creatinine Ratio A:C 16
Microscopic Data Numeric ID Microscopic Data Numeric ID
RBC /uL 100 PATH CASTS 115
RBC /HPF 101 PATH CASTS /HPF 116
RBC /LPF 102 PATH CASTS /LPF 117
WBC /uL 103 CYSTALS 118
WBC /HPF 104 CYSTALS /HPF 119
WBC /LPF 105 CYSTALS /LPF 120
EC /uL 106 YEAST 121
EC /HPF 107 YEAST /HPF 122
EC /LPF 108 YEAST /LPF 123
BACT /uL 109 SPERM 124
BACT /HPF 110 SRC 125
BACT /LPF 111 OTHER 126
CASTS /uL 112 TOTAL COUNT 127
CASTS /HPF 113 Custom data 128
CASTS /LPF 114
3-18 Clinitek Advantus and Clinitek 500 Interface Specification: Formatting Test Records
086D0001-01, Rev. A
04826807 Rev. A
References
1. Centers for Disease Control. 1988. Update: Universal precautions for
prevention of transmission of human immunodeficiency virus, hepatitis B
virus and other bloodborne pathogens in healthcare settings. MMWR,
37:377382, 387, 388.
2. Clinical and Laboratory Standards Institute (formerly NCCLS). Protection of
Laboratory Workers from Occupationally Acquired Infections; Approved
Guideline - Third Edition. CLSI Document M29-A3.[ISBN 1-56238-567-4].
Clinical and Laboratory Standards Institute, 940 West Valley Road, Suite
1400, Wayne, Pennsylvania 19087-1898 USA, 2005).
3. Federal Occupational Safety and Health Administration. Bloodborne
Pathogens Standard. 29 CFR 1910. 1030.
04826807 Rev. A
with repairing instruments that exhibit malfunctions due to defects in materials and/or
workmanship during the warranty period.
Siemens, at its election, provides warranty service either by providing repair service of the
instrument on site, or by exchanging the defective instrument or component, subject to the
limitations and exclusions set forth in Replacement of Parts and Warranty and Service
Exclusions below. Repairs, replacements or exchanges of instruments or components provided
during the warranty or any additional service period, does not extend the warranty or service
period beyond the initially agreed upon period.
When the customer calls for service, the Siemens representative or authorized distributor
informs the customer of the type of service available for the customers instrument, and
instructs the customer as to how to obtain that service.
Warranty Period
The limited warranty period generally commences upon installation of the original instrument at
the customers location and extends for a period of 1 year thereafter, unless otherwise
specifically agreed to by and between Siemens (or its authorized distributors) and customer in a
writing signed by duly authorized representatives of both parties (sales representatives are
generally not authorized representatives of Siemens for these purposes).
B2 Clinitek Advantus and Clinitek 500 Interface Specification: Service, Ordering, and Warranty
04826807 Rev. A
Replacement of Parts
In performing service, Siemens or its authorized distributors provide appropriate parts to repair
the instrument, or arranges for the exchange of the instrument or affected parts, at no charge
with the exception of certain parts or subassemblies that are considered Customer Maintenance
Items. Customer Maintenance Items include, but are not limited to, the following items: lamps,
electrodes or sensors (which are covered by a separate warranty), reagents, calibrators, controls,
paper, and pens. Consult the appropriate system operators manuals for a complete list of
Customer Maintenance Items for any specific model of instrument.
Clinitek Advantus and Clinitek 500 Interface Specification: Service, Ordering, and Warranty B3
04826807 Rev. A
Siemens reserves the right to change the design or construction of specific models of
instruments at any time without incurring any obligation to make such changes available to
individual customers or instruments. If Siemens notifies customers of a change that improves
the performance or reliability of their instrument, and requests to retrofit that instrument, the
customer must agree to allow Siemens or an authorized distributor, at Siemens expense, to
retrofit components or make design changes, which does not adversely affect the instruments
performance characteristics.
Addresses
For technical assistance contact your local technical support provider. For customer service or
additional information contact your local technical support distributor.
Siemens Medical Solutions Diagnostics
511 Benedict Avenue
Tarrytown, NY 10591
Siemens Medical Solutions Diagnostics Pty Ltd
ABN 65 007 436 651
885 Mountain Highway
Bayswater Victoria 3153
Australia
8.5
>=9.0
No change
PRO NEGATIVE NEGATIVE
Multistix Family of Test
Strips
TRACE
30 mg/dL
100 mg/dL
>=300 mg/dL
TRACE
1+
2+
3+
PRO NEGATIVE NEGATIVE
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
LOW
1+
2+
3+
PRO NEGATIVE NEGATIVE
Multistix PRO 6B
Multistix PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
1+
2+
3+
NIT NEGATIVE No change
POSITIVE
GLU NEGATIVE NEGATIVE
Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
TRACE
1+
2+
3+
C2 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
2+
3+
4+
KET NEGATIVE NEGATIVE
TRACE
15 mg/dL
40 mg/dL
>=80 mg/dL
TRACE
1+
2+
3+
BIL NEGATIVE NEGATIVE
SMALL
MODERATE
LARGE
1+
2+
3+
BLO NEGATIVE NEGATIVE
TRACE-LYSED
TRACE-INTACT
SMALL
MODERATE
LARGE
TRACE-LYSED
TRACE-INTACT
1+
2+
3+
URO 0.2 E.U./dL
1.0 E.U./dL
No change
2.0 E.U./dL
4.0 E.U./dL
>=8.0 E.U./dL
LEU NEGATIVE NEGATIVE
TRACE
SMALL
MODERATE
LARGE
TRACE
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C3
04826807 Rev. A
A:C
Multistix and Multistix
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
No change
CLA CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C5
04826807 Rev. A
MODERATE
LARGE
1+
2+
3+
BLD NEGATIVE NEGATIVE
TRACE-LYSED
TRACE-INTACT
Ca 25 Ery/uL
Ca 80 Ery/uL
Ca 200 Ery/uL
TRACE-LYSED
TRACE-INTACT
1+
2+
3+
UBG 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU NEGATIVE NEGATIVE
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
TRACE
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C7
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.433.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
HIGH ABNORMAL
A:C
Clinitek Microalbumin 9
NORMAL DILUTE
<3.4 mg/mmol
NORMAL
No change
3.433.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
HIGH ABNORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL DILUTE No change
NORMAL
17.0 mg/mmol
ABNORMAL
33.9 mg/mmol
ABNORMAL
>56.6 mg/mmol
ABNORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
33.9 mg/mmol
ABNORMAL
>56.6 mg/mmol
ABNORMAL
P:C
Clinitek Microalbumin 9
NORMAL DILUTE No change
NORMAL
33.9 mg/mmol
ABNORMAL
170 mg/mmol
ABNORMAL
339 mg/mmol
ABNORMAL
>=566 mg/mmol
ABNORMAL
Test Abbreviation Normal Plus System
C8 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
No change
CLA CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C9
04826807 Rev. A
1+
2+
3+
NIT NEGATIVE No change
POSITIVE
GLU NEGATIVE NEGATIVE
150 mg/L
No change
CRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C11
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
HIGH ABNORMAL
A:C
Clinitek Microalbumin 9
NORMAL DILUTE
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
HIGH ABNORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL No change
33.9 mg/mmol
ABNORMAL
>56.6 mg/mmol
ABNORMAL
P:C
Clinitek Microalbumin 9
NORMAL DILUTE No change
NORMAL
33.9 mg/mmol
ABNORMAL
170 mg/mmol
ABNORMAL
339 mg/mmol
ABNORMAL
>=566 mg/mmol
ABNORMAL
Test Abbreviation Normal Plus System
C12 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
No change
CLA CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C13
04826807 Rev. A
Strips
TRACES
0.3 g/L
1.0 g/L
>=3.0 g/L
TRACES
1+
2+
3+
PRO NEGATIF NEGATIF
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
FAIBLE
1+
2+
3+
PRO NEGATIF NEGATIF
Multistix PRO 6B
Multistix PRO 6K
0.3 g/L
1.0 g/L
3.0 g/L
1+
2+
3+
NIT NEGATIF No change
POSITIF
GLU NEGATIF NEGATIF
Multistix and Multistix
PRO Families of Test
Strips
TRACES
2.5 g/L
5.0 g/L
>=10.0 g/L
TRACES
1+
2+
3+
C14 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
0.15 g/L
0.4 g/L
>=0.8 g/L
TRACES
1+
2+
3+
BIL NEGATIF NEGATIF
FAIBLE
MOYEN
FORT
1+
2+
3+
SNG NEGATIF NEGATIF
TRACES-LYSE
TRACES-INTACT
env. 25 GR/uL
env. 80 GR/uL
env. 200 GR/uL
TRACES-LYSE
TRACES-INTACT
1+
2+
3+
URO 0.2 mg/dL
1.0 mg/dL
No change
2.0 mg/dL
4.0 mg/dL
>=8.0 mg/dL
LEU NEGATIF NEGATIF
env. 15 GB/uL
env. 70 GB/uL
env. 125 GB/uL
env. 500 GB/uL
TRACES
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C15
04826807 Rev. A
A:C
Clinitek Microalbumin
and Multistix PRO
Families of Test Strips
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ANORMAL ELEVE
A:C
Clinitek Microalbumin 9
NORMAL, DILUEE
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ANORMAL ELEVE
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL, DILUEE No change
NORMAL
150 mg/g
ANORMAL
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Clinitek Microalbumin 9
NORMAL DILUEE No change
NORMAL
300 mg/g
ANORMAL
1500 mg/g
ANORMAL
3000 mg/g
ANORMAL
>=5000 mg/g
ANORMAL
Test Abbreviation Normal Plus System
C16 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CLR. JAUNE
JAUNE
FONC. JAUNE
CLR. ORANGE
ORANGE
FONC. ORANGE
CLR. ROUGE
ROUGE
FONC. ROUGE
CLR. VERT
VERT
FONC. VERT
CLR. BLEU
BLEU
FONC. BLEU
CLR. MARRON
MARRON
FONC. MARRON
No change
ASP LIMPIDE
LEG. TROUBLE
TROUBLE
OPAQUE
AUTRE
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C17
04826807 Rev. A
French S. I. Units
Table C-5 Franais, units internationales (SI)
Test Abbreviation Normal Plus System
DEN <=1.005
1.010
1.015
1.020
1.025
>=1.030
No change
pH 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO NEGATIF NEGATIF
Multistix Family of Test
Strips
TRACES
0.3 g/L
1.0 g/L
>=3.0 g/L
TRACES
1+
2+
3+
PRO NEGATIF NEGATIF
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
FAIBLE
1+
2+
3+
PRO NEGATIF NEGATIF
Multistix PRO 6B
Multistix PRO 6K
0.3 g/L
1.0 g/L
3.0 g/L
1+
2+
3+
NIT NEGATIF No change
POSITIF
GLU NEGATIF NEGATIF
Multistix and Multistix
PRO Families of Test
Strips
5.5 mmol/L
14 mmol/L
28 mmol/L
>=55 mmol/L
TRACES
1+
2+
3+
C18 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
FAIBLE
MOYEN
FORT
TRACES-LYSE
TRACES-INTACT
1+
2+
3+
URO 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU NEGATIF NEGATIF
TRACES
FAIBLE
MOYEN
FORT
TRACES
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C19
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ANORMAL ELEVE
A:C
Clinitek Microalbumin 9
.
NORMAL, DILUEE
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ANORMAL ELEVE
P:C
Multistix PRO 10LS
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CLR.JAUNE
JAUNE
FONC.JAUNE
CLR.ORANGE
ORANGE
FONC.ORANGE
CLR.ROUGE
ROUGE
FONC.ROUGE
CLR.VERT
VERT
FONC.VERT
CLR.BLEU
BLEU
FONC.BLEU
CLR.MARRON
MARRON
FONC.MARRON
No change
ASP LIMPIDE
LEG. TROUBLE
TROUBLE
OPAQUE
AUTRE
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C21
04826807 Rev. A
POSITIV
GLU NEGATIV NEGATIV
Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
SPUR
1+
2+
3+
C22 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
SPUR
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
KRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C23
04826807 Rev. A
A:K
Multistix and Multistix
PRO Families of Test
Strips
<30 mg/g
NORMAL
No change
30-300 mg/g
ABNORMAL
>300 mg/g
STARK ABNORMAL
A:K
Clinitek Microalbumin 9
A OK / K GERING
<30 mg/g
NORMAL
No change
30-300 mg/g
ABNORMAL
>300 mg/g
STARK ABNORMAL
P:K
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
P OK / K GERING No change
NORMAL
150 mg/g
ABNORMAL
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:K
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:K
Clinitek Microalbumin 9
P OK / K GERING No change
NORMAL
300 mg/g
ABNORMAL
1500 mg/g
ABNORMAL
3000 mg/g
ABNORMAL
>=5000 mg/g
ABNORMAL
Test Abbreviation Normal Plus System
C24 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
HELL GELB
GELB
DUNK.GELB
HELL ORANGE
ORANGE
DUNK.ORANGE
HELL ROT
ROT
DUNK.ROT
HELL GRUEN
GRUEN
DUNK.GRUEN
HELL BLAU
BLAU
DUNK.BLAU
HELL BRAUN
BRAUN
DUNK.BRAUN
No change
CLA KLAR
FLOCKIG
S.FLOCKIG
TRUEB
ANDERS
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C25
04826807 Rev. A
German S. I. Units
Table C-7 Deutsch, Einheiten: Internationales Einheitensystem (SI)
Test Abbreviation Normal Plus System
SG <=1.005
1.010
1.015
1.020
1.025
>=1.030
No change
pH 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO NEGATIV NEGATIV
Multistix Family of Tests SPUR
0.3 g/L
1.0 g/L
>=3.0 g/L
SPUR
1+
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
WENIG
1+
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 6B
Multistix PRO 6K
0.3 g/L
1.0 g/L
3.0 g/L
1+
2+
3+
NIT NEGATIV No change
POSITIV
GLU NEGATIV NEGATIV
Multistix and Multistix
PRO Families of Test
Strips
5.5 mmol/L
14 mmol/L
28 mmol/L
>=55 mmol/L
SPUR
1+
2+
3+
C26 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
55 mmol/L
>=110 mmol/L
SPUR
1+
2+
3+
4+
KET NEGATIV NEGATIV
SPUR
1.5 mmol/L
3.9 mmol/L
>=7.8 mmol/L
SPUR
1+
2+
3+
BIL NEGATIV NEGATIV
SCHWACH
MAESSIG
STARK
1+
2+
3+
OBL 0 Ery/uL NEGATIV
Ca 10 Ery/uL
Ca 10 Ery/uL
Ca 25 Ery/uL
Ca 80 Ery/uL
Ca 200 Ery/uL
SPUR-LYSE
SPUR-ZELLEN
1+
2+
3+
UBG 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU 0 Leu/uL NEGATIV
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
SPUR
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
KRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C27
04826807 Rev. A
A:K
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
STARK ABNORMAL
A:K
Clinitek Microalbumin 9
A OK / K GERING
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ABNORMAL
>33.9 mg/mmol
STARK ABNORMAL
P:K
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
P OK / K GERING No change
NORMAL
17.0 mg/mmol
ABNORMAL
33.9 mg/mmol
ABNORMAL
>56.6 mg/mmol
ABNORMAL
P:K
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
33.9 mg/mmol
ABNORMAL
>56.6 mg/mmol
ABNORMAL
P:K
Clinitek Microalbumin 9
P OK / K GERING No change
NORMAL
33.9 mg/mmol
ABNORMAL
170 mg/mmol
ABNORMAL
339 mg/mmol
ABNORMAL
>=566 mg/mmol
ABNORMAL
Test Abbreviation Normal Plus System
C28 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
HELL GELB
GELB
DUNK.GELB
HELL ORANGE
ORANGE
DUNK.ORANGE
HELL ROT
ROT
DUNK.ROT
HELL GRUEN
GRUEN
DUNK.GRUEN
HELL BLAU
BLAU
DUNK.BLAU
HELLBRAUN
BRAUN
DUNK.BRAUN
No change
CLA KLAR
FLOCKIG
S. FLOCKIG
TRUEB
ANDERS
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C29
04826807 Rev. A
1+
2+
3+
SAN NEGATIVO NEGATIVO
TRACCE(LIS.)
TRACCE(INT.)
LEGGERO
MEDIO
FORTE
TRACCE(LIS.)
TRACCE(INT.)
1+
2+
3+
URO 0.2 E.U./dL
1.0 E.U./dL
No change
2.0 E.U./dL
4.0 E.U./dL
>=8.0 E.U./dL
LEU NEGATIVO NEGATIVO
Ca 15 Cel/uL
Ca 70 Cel/uL
Ca 125 Cel/uL
Ca500 Cel/uL
TRACCE
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C31
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<30 mg/g
NORMALE
No change
30-300 mg/g
ANORMALE
>300 mg/g
MOLTO ANORMALE
A:C
Clinitek Microalbumin 9
URINA DILUITA
<30 mg/g
NORMALE
No change
30-300 mg/g
ANORMALE
>300 mg/g
MOLTO ANORMALE
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
URINA DILUITA No change
NORMALE
150 mg/g
ANORMALE
300 mg/g
ANORMALE
>500 mg/g
ANORMALE
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMALE No change
300 mg/g
ANORMALE
>500 mg/g
ANORMALE
P:C
Clinitek Microalbumin 9
URINA DILUITA No change
NORMALE
300 mg/g
ANORMALE
1500 mg/g
ANORMALE
3000 mg/g
ANORMALE
>=5000 mg/
ANORMALE
Test Abbreviation Normal Plus System
C32 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CHIA.GIALLO
GIALLO
SCUR.GIALLO
CHIA.ARANCIONE
ARANCIONE
SCUR.ARANCIONE
CHIA.ROSSO
ROSSO
SCUR.ROSSO
CHIA.VERDE
VERDE
SCUR.VERDE
CHIA.AZZURRO
AZZURRO
SCUR.AZZURRO
CHIA.MARRONE
MARRONE
SCUR.MARRONE
No change
ASP LIMPIDA
LEG. TORBIDA
TORBIDA
MOL. TORBIDA
ALTRO
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C33
04826807 Rev. A
3+
NIT NEGATIVO No change
POSITIVO
GLU NEGATIVO NEGATIVO
Multistix and Multistix
PRO Families of Test
Strips
5.5 mmol/L
14 mmol/L
28 mmol/L
>=55 mmol/L
TRACCE
1+
2+
3+
C34 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMALE
No change
3.4-33.9 mg/mmol
ANORMALE
>33.9 mg/mmol
MOLTO ANORMALE
A:C
Clinitek Microalbumin 9
URINA DILUITA
<3.4 mg/mmol
NORMALE
No change
3.4-33.9 mg/mmol
ANORMALE
>33.9 mg/mmol
MOLTO ANORMALE
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
URINA DILUITA No change
NORMALE
17.0 mg/mmol
ANORMALE
33.9 mg/mmol
ANORMALE
>56.6 mg/mmol
ANORMALE
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMALE No change
33.9 mg/mmol
ANORMALE
>56.6 mg/mmol
ANORMALE
P:C
Clinitek Microalbumin 9
URINA DILUITA No change
NORMALE
33.9 mg/mmol
ANORMALE
170 mg/mmol
ANORMALE
339 mg/mmol
ANORMALE
>=566 mg/mmol
ANORMALE
Test Abbreviation Normal Plus System
C36 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CHIA.GIALLO
GIALLO
SCUR.GIALLO
CHIA.ARANCIONE
ARANCIONE
SCUR.ARANCIONE
CHIA.ROSSO
ROSSO
SCUR.ROSSO
CHIA.VERDE
VERDE
SCUR.VERDE
CHIA.AZZURRO
AZZURRO
SCUR.AZZURRO
CHIA.MARRONE
MARRONE
SCUR.MARRONE
No change
ASP LIMPIDA
LEG. TORBIDA
TORBIDA
MOL. TORBIDA
ALTRO
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C37
04826807 Rev. A
pH 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO - Multistix Family of Test
Strips
+/30 mg/dL
100 mg/dL
>=300 mg/dL
+/1+
2+
3+
PRO - Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
LOW
1+
2+
3+
PRO - Multistix PRO 6B
Multistix PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
1+
2+
3+
NIT - No change
+
GLU - Multistix and Multistix
PRO Families of Test
Strips
0.1 g/dL
0.25 g/dL
0.5 g/dL
>=1.0 g/dL
+/1+
2+
3+
C38 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
GLU - -
A:C
Multistix and Multistix
PRO Families of Test
Strips
.
<30 mg/g
NORMAL
No change
30300 mg/g
ABNORMAL
>300 mg/g
HIGH ABNORMAL
A:C
Clinitek Microalbumin 9
NORMAL DILUTE
<30 mg/g
NORMAL
No change
30300 mg/g
ABNORMAL
>300 mg/g
HIGH ABNORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL DILUTE No change
NORMAL
150 mg/g
ABNORMAL
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:C
Clinitek Microalbumin 9
NORMAL DILUTE No change
NORMAL
300 mg/g
ABNORMAL
1500 mg/g
ABNORMAL
3000 mg/g
ABNORMAL
>=5000 mg/g
ABNORMAL
Test Abbreviation Normal Plus System
C40 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
No change
CLA +/1+
2+
OTHER
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C41
04826807 Rev. A
1+
2+
3+
PRO - Multistix PRO 6B
Multistix PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
1+
2+
3+
NIT - No change
+
GLU - Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
1+
2+
3+
4+
C42 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
+/1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C43
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
.
<30 mg/g
NORMAL
No change
30300 mg/g
ABNORMAL
>300 mg/g
HIGH ABNORMAL
A:C
Clinitek Microalbumin 9
NORMAL DILUTE
<30 mg/g
NORMAL
No change
30300 mg/g
ABNORMAL
>300 mg/g
HIGH ABNORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL DILUTE No change
NORMAL
150 mg/g
ABNORMAL
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ABNORMAL
>500 mg/g
ABNORMAL
P:C
Clinitek Microalbumin 9
NORMAL DILUTE No change
NORMAL
300 mg/g
ABNORMAL
1500 mg/g
ABNORMAL
3000 mg/g
ABNORMAL
>=5000 mg/g
ABNORMAL
Test Abbreviation Normal Plus System
C44 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
No change
Clarity +/1+
2+
OTHER
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C45
04826807 Rev. A
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO NEGATIVO NEGATIVO
Multistix Family of Test
Strips
INDICIO
30 mg/dL
100 mg/dL
>=300 mg/dL
INDICIO
1+
2+
3+
PRO NEGATIVO NEGATIVO
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
BIAXO
1+
2+
3+
PRO NEGATIVO NEGATIVO
Multistix PRO 6B
Multistix PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
1+
2+
3+
NIT NEGATIVO No change
POSITIVO
GLI NEGATIVO NEGATIVO
Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
INDICIO
1+
2+
3+
C46 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
1000 mg/dL
>=2000 mg/dL
INDICIO
1+
2+
3+
4+
CET NEGATIVO NEGATIVO
INDICIO
15 mg/dL
40 mg/dL
>=80 mg/dL
INDICIO
1+
2+
3+
BIL NEGATIVO NEGATIVO
PEQUENO
MODERADO
GRANDE
1+
2+
3+
SAN NEGATIVO NEGATIVO
INDICIO-LISADO
INDICIO-INTACTO
PEQUENO
MODERADO
GRANDE
INDICIO-LISADO
INDICIO-INTACTO
1+
2+
3+
URO 0.2 mg/dL
1.0 mg/dL
No change
2.0 mg/dL
4.0 mg/dL
>=8.0 mg/dL
LEU NEGATIVO NEGATIVO
INDICIO
PEQUENO
MODERADO
GRANDE
INDICIO
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C47
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ANORMAL ALTO
A:C
Clinitek Microalbumin 9
DILUIDO NORMAL
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ANORMAL ALTO
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
DILUIDO NORMAL No change
NORMAL
150 mg/g
ANORMAL
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Clinitek Microalbumin 9
DILUIDO NORMAL No change
NORMAL
300 mg/g
ANORMAL
1500 mg/g
ANORMAL
3000 mg/g
ANORMAL
>=5000 mg/g
ANORMAL
Test Abbreviation Normal Plus System
C48 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CL.AMARELO
AMARELO
OSC.AMARELO
CL.LARANJA
LARANJA
OSC.LARANJA
CL.VERMELHO
VERMELHO
OSC.VERMELH
CL.VERDE
VERDE
OSC.VERDE
CL.AZUL
AZUL
OSC.AZUL
CL.MARRON
MARROM
OSC.MARROM
No change
ASP CLARO
POUCO NEBULOSO
NEBULOSO
TURVO
OUTROS
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C49
04826807 Rev. A
1+
2+
3+
SAN NEGATIVO NEGATIVO
INDICIO-LISADO
INDICIO-INTACTO
PEQUENO
MODERADO
GRANDE
INDICIO-LISADO
INDICIO-INTACTO
1+
2+
3+
URO 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU NEGATIVO NEGATIVO
INDICIO
PEQUENO
MODERADO
GRANDE
INDICIO
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C51
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ANORMAL ALTO
A:C
Clinitek Microalbumin 9
DILUIDO NORMAL
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ANORMAL ALTO
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
DILUIDO NORMAL No change
NORMAL
17.0 mg/mmol
ANORMAL
33.9 mg/mmol
ANORMAL
>56.6 mg/mmol
ANORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
33.9 mg/mmol
ANORMAL
>56.6 mg/mmol
ANORMAL
P:C
Clinitek Microalbumin 9
DILUIDO NORMAL No change
NORMAL
33.9 mg/mmol
ANORMAL
170 mg/mmol
ANORMAL
339 mg/mmol
ANORMAL
>=566 mg/mmol
ANORMAL
Test Abbreviation Normal Plus System
C52 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CL.AMARELO
AMARELO
OSC.AMARELO
CL.LARANJA
LARANJA
OSC.LARANJA
CL.VERMELHO
VERMELHO
OSC.VERMELH
CL.VERDE
VERDE
OSC.VERDE
CL.AZUL
AZUL
OSC.AZUL
CL.MARRON
MARROM
OSC.MARROM
No change
ASP CLARO
POUCO NEBULOSO
NEBULOSO
TURVO
OUTROS
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C53
04826807 Rev. A
2+
3+
NIT NEGATIVO No change
POSITIVO
GLU NEGATIVO NEGATIVO
Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
INDICIOS
1+
2+
3+
C54 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
>=8.0 E.U./dL
LEU NEGATIVO NEGATIVO
Apr 15 Leu/uL
Apr 70 Leu/uL
Apr 125 Leu/uL
Apr 500 Leu/uL
INDICIOS
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C55
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ALTAMENTE ANORMAL
A:C
Clinitek Microalbumin 9
DILUIDO NORMAL
<30 mg/g
NORMAL
No change
30-300 mg/g
ANORMAL
>300 mg/g
ALTAMENTE ANORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
DILUIDO NORMAL No change
NORMAL
150 mg/g
ANORMAL
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ANORMAL
>500 mg/g
ANORMAL
P:C
Clinitek Microalbumin 9
DILUIDO NORMAL No change
NORMAL
300 mg/g
ANORMAL
1500 mg/g
ANORMAL
3000 mg/g
ANORMAL
>=5000 mg/g
ANORMAL
Test Abbreviation Normal Plus System
C56 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CL.AMARILLO
AMARILLO
OSC.AMARILLO
CL.ANARANJAD
ANARANJAD
OSC.ANARANJAD
CL.ROJO
ROJO
OSC.ROJO
CL.VERDE
VERDE
OSC.VERDE
CL.AZUL
AZUL
OSC.AZUL
CL.MARRON
MARRON
OSC.MARRON
No change
ASP CLARO
LIG.TURBIO
TURBIO
MUY TURBIO
OTROS
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C57
04826807 Rev. A
No change
pH 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO NEGATIVO NEGATIVO
Multistix Family of Tests INDICIOS
0.3 g/L
1.0 g/L
>=3.0 g/L
INDICIOS
1+
2+
3+
PRO NEGATIVO NEGATIVO
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
Bajo
1+
2+
3+
PRO NEGATIVO NEGATIVO
Multistix PRO 6B
Multistix PRO 6K
0.3 g/L
1.0 g/L
3.0 g/L
1+
2+
3+
NIT NEGATIVO No change
POSITIVO
GLU NEGATIVO NEGATIVO
Multistix and Multistix
PRO Families of Test
Strips
5.5 mmol/L
14 mmol/L
28 mmol/L
>=55 mmol/L
INDICIOS
1+
2+
3+
C58 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
14 mmol/L
28 mmol/L
55 mmol/L
>=110 mmol/L
INDICIOS
1+
2+
3+
4+
CET NEGATIVO NEGATIVO
INDICIOS
1.5 mmol/L
3.9 mmol/L
>=7.8 mmol/L
INDICIOS
1+
2+
3+
BIL NEGATIVO NEGATIVO
BAJO
MODERADO
ALTO
1+
2+
3+
SAN 0 Eri/uL NEGATIVO
Apr 10 Eri/uL
Apr 10 Eri/uL
Apr 25 Eri/uL
Apr 80 Eri/uL
Apr 200 Eri/uL
IND.HEMOLIZ.
IND.INTACTOS
1+
2+
3+
URO 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU 0 Leu/uL NEGATIVO
Apr 15 Leu/uL
Apr 70 Leu/uL
Apr 125 Leu/uL
Apr 500 Leu/uL
INDICIOS
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
CRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C59
04826807 Rev. A
A:C
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ALTAMENTE ANORMAL
A:C
Clinitek Microalbumin 9
DILUIDO NORMAL
<3.4 mg/mmol
NORMAL
No change
3.4-33.9 mg/mmol
ANORMAL
>33.9 mg/mmol
ALTAMENTE ANORMAL
P:C
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
DILUIDO NORMAL No change
NORMAL
17.0 mg/mmol
ANORMAL
33.9 mg/mmol
ANORMAL
>56.6 mg/mmol
ANORMAL
P:C
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
33.9 mg/mmol
ANORMAL
>56.6 mg/mmol
ANORMAL
P:C
Clinitek Microalbumin 9
DILUIDO NORMAL No change
NORMAL
33.9 mg/mmol
ANORMAL
170 mg/mmol
ANORMAL
339 mg/mmol
ANORMAL
>=566 mg/mmol
ANORMAL
Test Abbreviation Normal Plus System
C60 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
CL.AMARILLO
AMARILLO
OSC.AMARILLO
CL.NARANJA
NARANJA
OSC.NARANJA
CL.ROJO
ROJO
OSC.ROJO
CL.VERDE
VERDE
OSC.VERDE
CL.AZUL
AZUL
OSC.AZUL
CL.MARRON
MARRON
OSC.MARRON
No change
ASP CLARO
LIG.TURBIO
TURBIO
MUY TURBIO
OTROS
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C61
04826807 Rev. A
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
LAAG
1+
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 6B
Multistix PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
1+
2+
3+
NIT NEGATIV No change
POSITIV
GLU NEGATIV NEGATIV
Multistix and Multistix
PRO Families of Test
Strips
100 mg/dL
250 mg/dL
500 mg/dL
>=1000 mg/dL
SPAAR
1+
2+
3+
C62 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
A:K
Multistix and Multistix
PRO Families of Test
Strips
.
<30 mg/g
NORMAL
No change
30300 mg/g
ONORMAL
>300 mg/g
HOEG ONORMAL
A:K
Clinitek Microalbumin 9
NORMAL SPAEDNING
<30 mg/g
NORMAL
No change
30300 mg/g
ONORMAL
>300 mg/g
HOEG ONORMAL
P:K
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL SPAEDNING No change
NORMAL
150 mg/g
ONORMAL
300 mg/g
ONORMAL
>500 mg/g
ONORMAL
P:K
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
300 mg/g
ONORMAL
>500 mg/g
ONORMAL
P:K
Clinitek Microalbumin 9
NORMAL SPAEDNING No change
NORMAL
300 mg/g
ONORMAL
1500 mg/g
ONORMAL
3000 mg/g
ONORMAL
>=5000 mg/g
ONORMAL
Test Abbreviation Normal Plus System
C64 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT.GUL
GUL
DK.GUL
LT.ORANGE
ORANGE
DK.ORANGE
LT.ROED
ROED
DK.ROED
LT.GROEN
GROEN
DK.GROEN
LT.BLAA
BLAA
DK.BLAA
LT.BRUN
BRUN
DK.BRUN
No change
CLA KLAR
ANINGEN OKLAR
OKLAR
GRUMLIG
ANNAT
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C65
04826807 Rev. A
Swedish S.I. Units Table C-15 Engelsk og kinesisk, Enheder - Internationale (SI)
Test Abbreviation Normal Plus System
DEN <=1.005
1.010
1.015
1.020
1.025
>=1.030
No change
pH 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
>=9.0
No change
PRO
Multistix Family of Test
Strips
NEGATIV
SPAAR
0.3 g/L
1.0 g/L
>=3.0 g/L
NEGATIV
SPAAR
1+
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
Clinitek Microalbumin 9
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
LAAG
1+
2+
3+
PRO NEGATIV NEGATIV
Multistix PRO 6B
Multistix PRO 6K
0.3 g/L
1.0 g/L
3.0 g/L
1+
2+
3+
NIT NEGATIV No change
POSITIV
GLU NEGATIV NEGATIV
Multistix and Multistix
PRO Families of Test
Strips
5.5 mmol/L
14 mmol/L
28 mmol/L
>=55 mmol/L
SPAAR
1+
2+
3+
C66 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
1+
2+
3+
URO 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU NEGATIV NEGATIV
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
SPAAR
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
KRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C67
04826807 Rev. A
A:K
Multistix and Multistix
PRO Families of Test
Strips
<3.4 mg/mmol
NORMAL
No change
3.433.9 mg/mmol
ONORMAL
>33.9 mg/mmol
HOEG ONORMAL
A:K
Clinitek Microalbumin 9
NORMAL SPAEDNING
<3.4 mg/mmol
NORMAL
No change
3.433.9 mg/mmol
ONORMAL
>33.9 mg/mmol
HOEG ONORMAL
P:K
Multistix PRO 10LS
Multistix PRO 10LB
Multistix PRO 10SB
Multistix PRO 7G
NORMAL SPAEDNING No change
NORMAL
17.0 mg/mmol
ONORMAL
33.9 mg/mmol
ONORMAL
>56.6 mg/mmol
ONORMAL
P:K
Multistix PRO 6B
Multistix PRO 6K
NORMAL No change
33.9 mg/mmol
ONORMAL
>56.6 mg/mmol
ONORMAL
P:K
Clinitek Microalbumin 9
NORMAL SPAEDNING No change
NORMAL
33.9 mg/mmol
ONORMAL
170 mg/mmol
ONORMAL
339 mg/mmol
ONORMAL
>=566 mg/mmol
ONORMAL
Test Abbreviation Normal Plus System
C68 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT.GUL
GUL
DK.GUL
LT.ORANGE
ORANGE
DK.ORANGE
LT.ROED
ROED
DK.ROED
LT.GROEN
GROEN
DK.GROEN
LT.BLAA
BLAA
DK.BLAA
LT.BRUN
BRUN
DK.BRUN
No change
CLA KLAR
ANINGEN OKLAR
OKLAR
GRUMLIG
ANNAT
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C69
04826807 Rev. A
1+
2+
3+
NIT NEGATIV No change
POSITIV
GLU NEGATIV NEGATIV
Multistix and Multistix
PRO Families of Test
Strips
1+
2+
3+
4+
SPAAR
1+
2+
3+
C70 Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables
04826807 Rev. A
Clinitek Microalbumin 9 1+
2+
3+
4+
5+
SPAAR
1+
2+
3+
4+
KET NEGATIV NEGATIV
1+
2+
3+
4+
SPAAR
1+
2+
3+
BIL NEGATIV No change
1+
2+
3+
BLD NEGATIV No change
+/+/-INTAKT
1+
2+
3+
URO 3.2 umol/L
16 umol/L
No change
33 umol/L
66 umol/L
>=131 umol/L
LEU NEGATIV NEGATIV
1+
2+
3+
4+
SPAAR
1+
2+
3+
ALB 10 mg/L
30 mg/L
80 mg/L
150 mg/L
No change
KRE 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
No change
Test Abbreviation Normal Plus System
Clinitek Advantus and Clinitek 500 Interface Specification: Result Unit Tables C71
04826807 Rev. A
A:K
Multistix and Multistix
COL
If color is determined by
the Tech, an additional
option of OTHER is
available.
LT.GUL
GUL
DK.GUL
LT.ORANGE
ORANGE
DK.ORANGE
LT.ROED
ROED
DK.ROED
LT.GROEN
GROEN
DK.GROEN
LT.BLAA
BLAA
DK.BLAA
LT.BRUN
BRUN
DK.BRUN
No change
CLA KLAR
ANINGEN OKLAR
OKLAR
GRUMLIG
ANNAT
No change
Test Abbreviation Normal Plus System
04826807 Rev. A
Output Data
The transmission of test results data from the Clinitek 200+ instrument can be controlled by
either the instrument or by the interfaced laboratory information system (LIS). If the Handshake
option is set to ON, the communication protocol uses software handshaking and the LIS
controls the transmission of data. If the Handshake option is set to OFF, the communication
protocol does not use software handshaking and the instrument controls the transmission of
data.
Data transmission from the instrument can be suspended by a connected LIS in one of two
ways:
The Handshake option can be set to ON and the hardware handshake line can be used to stop
data flow.
An XOFF character (<DC3>) can be sent to the instrument to stop data flow. Data flow does
not resume until an XON character (<DC1> or <DC2>) is sent.
Parameter Setting Options (Shaded options are default options)
Computer On Off
Handshake On Off
Checksum On Off
Baud Rate 110 300 600 1200 2400 4800 9600 19200
Character Bits 7 8
Parity Even Odd None
D2 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
The Clinitek 200+ always supports the receipt of the control characters shown in Table D-2
regardless of the setting for the Handshake option.
Table D-2 Data Control Characters
When the Handshake option is set to ON, the Clinitek 200+ supports the output control
characters shown in Table D-3.
Table D-3 Data Output Control Characters
Calculation of Checksum
Example Instrument ID Message with used to represent the SPACE character:
Steps:
1. Determine the ASCII decimal value of each character (including the SPACE
character) between but not including the <STX> and <ETX> control
character.
2. Sum the ASCII values. (3725)
Control Character Definition
<STX> START OF TEXT character (02H, <^B>).
<CR> Represents the carriage return character (0DH, <^M>).
<LF> Represents the line feed character (0AH, <^J>).
3. Divide the sum of the ASCII values by 256. Discard the quotient. (3725 / 256
= 14 with remainder of 141)
4. Convert the remainder to a hexadecimal value. (141 / 16 = 8 with a remainder
of 13). Hexadecimal equivalent is 8D.
5. That value is the checksum. Insert it into the message packet prior to sending
the <ETX>.
ASCII Decimal Value Equivalent Hexadecimal Value
00
11
22
33
44
55
66
77
88
99
10 A
11 B
12 C
13 D
14 E
15 F
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D5
04826807 Rev. A
The instrument ID message is output to the serial port when an <ENQ> (05H) control character
is received followed by a <DC1> or <DC2>. Even though the instrument ID message packet
contains a checksum, the LIS does not have to acknowledge receipt of the packet.
Table D-5 Variable Field Definition
Table D-6 Instrument ID Packet
Table D-7 Format for Language/Units
Table D-8 Format for Test Strip Names for Multistix Family
Variable Variable Field Definition
Represents the space character
A Represents the time in 24-hour format.
B Represents the date in the active date format. The formats are
MM-DD-YY, DD-MM-YY, and YYMM-DD.
C Represents the software version.
D Represents the active language/unit option
E Represents the active test strip option
Line Line Content
1 <STX><CR><LF>
2 IDAA:AABB-BB-BB<CR><LF>
3 CT200+C.CCC<CR><LF>
4 DDDDDDDDDDDDDDDD<CR><LF>
5 EEEEEEEEEEEEEEEEEEEEEEE<CR><LF>
6 Ck1Ck2<ETX>
ENGLISH-CONV. FRENCH-CONV. ITALIAN
ENGLISH-+/- FRENCH-S.I. SPANISH
ENGLISH-S.I. GERMAN
Multistix10SG HEMACOMBISTIX MultistixPRO7G
Multistix9 URO-HEMACOMBISGL MultistixPRO7PH
Multistix8SG MultistixPRO10LB MultistixPRO6B
Multistix5 MultistixPRO10LS MultistixPRO6K
MultistixSGL MultistixPRO10SB
N-MultistixSGL MultistixPRO10
D6 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
MULTISTIX 9 MULTISTIX9
URO-HEMACOMBISTIX URO-HEMACOMBISTIX
URO-LABSTIX URO-LABSTIX
COMBISTIX SG - LONG COMBISTIXSG
URISTIX - LONG URISTIX-LONG
LIFESTIX LIFESTIX
MULTISTIX PRO 11 MULTISTIXPRO11
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D7
04826807 Rev. A
For those tests that can be marked as abnormal (positive), an asterisk (*) is used to designate the
clinical result as being outside of the normal range for serial output, 80-column printer output,
and form printer output. For output to the internal printer, the block character () designates the
clinical result as being outside of the normal range of results. For serial output data, the asterisk
is always placed directly to the right of the reagent tag of the abnormal test result. For printed
output data, the asterisk or block character is always placed directly to the left of the reagent tag
of the abnormal test result.
Table D-12 Serial Data Results Formats for General Information
Variable Definition
G Represents the quantitative result for the A:C Ratio. This field is variable in
length and contains only the test result.
H Represents the qualitative result for the A:C Ratio. This field is variable in
length and contains only the test result.
I If the P:C ratio is Normal Dilute or Normal this field displays that value. If
the P:C ratio is Abnormal, this field contains the quantitative result for the
P:C Ratio. This field is variable in length and contains only the test result.
J If the P:C ratio is Abnormal contains the translation for Abnormal;
otherwise this line is not printed (sent).
Line #
Line Content
Specimen ID Set to NO
Line Content
Specimen ID Set to YES
1 <STX><CR><LF> <STX><CR><LF>
2 #A-AAABB-BB-BB<CR><LF> #A-AAABB-BB-BB<CR><LF>
3 ID=CCCCCCCCCCCCC<CR><LF>
4 Color:DDDDDDDDDD<CR><LF>
5 Clarity:EEEEEEEEEE<CR><LF>
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D9
04826807 Rev. A
13 NIT*FFFFFFFFFFFFFF<CR><LF>
15 LEU*FFFFFFFFFFFFFF<CR><LF>
16 Ck1Ck2<ETX>
D10 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
With the exception of the lines used for reporting ratio results, each line contains 20 characters
plus the <CR><LF> control characters. The lines used for reporting ratio results are variable in
length.
Table D-14 Multistix PRO 10LB, 10LS, 10SB, 10, 7G, 7PH
NOTE:Lines 3, 4, and 5 are eliminated if the Specimen ID option is set to NO. When the
Specimen ID option is set to YES, but the Color and/or Clarity options are set to NO, the Color
value field and/or the Clarity value field are filled with the space character.
NOTE:If the P:C result is Normal or Normal Dilute, there is no quantitative (I) result reported.
The qualitative result (J) is reported in its place.
Line # Line Content
1 <STX><CR><LF>
2 #A-AAABB-BB-BB<CR><LF>
3 ID=CCCCCCCCCCCCC<CR><LF>
4 Color:DDDDDDDDDD<CR><LF>
5 Clarity:EEEEEEEEEE<CR><LF>
6 GLU*FFFFFFFFFFFFFF<CR><LF>
7 BIL*FFFFFFFFFFFFFF<CR><LF>
8 KET*FFFFFFFFFFFFFF<CR><LF>
9 SGFFFFFFFFFFFFFF<CR><LF>
10 BLO*FFFFFFFFFFFFFF<CR><LF>
11 pHFFFFFFFFFFFFFF<CR><LF>
12 URO*FFFFFFFFFFFFFF<CR><LF>
13 NIT*FFFFFFFFFFFFFF<CR><LF>
14 LEU*FFFFFFFFFFFFFF<CR><LF>
15 PRO*FFFFFFFFFFFFFF<CR><LF>
16 CREFFFFFFFFFFFFFF<CR><LF>
17 P:C*IIIIIIIIIIIII,JJJJJJJJJJJJJJ<CR><LF>
18 Ck1Ck2<ETX>
D12 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Specimen ID option is set to YES, but the Color and/or Clarity options are set to NO, the Color
value field and/or the Clarity value field are filled with the space character.
NOTE:If the P:C result is Normal or Normal Dilute, there is no quantitative (I) result
1.030
Blood (BLO) NEGATIVE
TRACE-INTACT
TRACE-LYSED
SMALL
MODERATE
LARGE
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVE
TRACE
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
TRACE
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
TRACE
SMALL
MODERATE
LARGE
NEGATIVE
TRACE
SMALL
MODERATE
LARGE
D14 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Clinitek Advantus or
500 Clinitek 200
Glucose (GLU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
100 mg/dL
250 mg/dL
500 mg/dL
1000 mg/dL
Bilirubin (BIL) NEGATIVE
1+
2+
3+
NEGATIVE
SMALL
MODERATE
LARGE
Ketone (KET) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLO) NEGATIVE
TRACE-INTACT
TRACE-LYSED
1+
2+
3+
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
NEGATIVE
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
SMALL
MODERATE
LARGE
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D15
04826807 Rev. A
NEGATIVE
TRACE
+
++
+++
D16 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
+
++
+++
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
NORMAL
NORMAL
+
++
+++
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
+
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
+
++
+++
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D17
04826807 Rev. A
LARGE
Ketone (KET) NEGATIVE
TRACE
1.5 mmol/L
3.9 mmol/L
7.8 mmol/L
NEGATIVE
TRACE
1.5 mmol/L
3.9 mmol/L
7.8 mmol/L
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLO) NEGATIVE
TRACE-INTACT
TRACE-LYSED
Ca 25 Ery/uL
Ca 80 Ery/uL
Ca 200 Ery/uL
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVE
TRACE
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
TRACE
0.3 g/L
1.0 g/L
3.0 g/L
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
NEGATIVE
TRACE
SMALL
MODERATE
LARGE
D18 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
++
+++
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
NEGATIVE
+
++
+++
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
+
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
++
++
+++
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D19
04826807 Rev. A
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
env. 15 GB/uL
env. 70 GB/uL
env. 125 GB/uL
env. 500 GB/uL
NEGATIF
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
D20 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D21
04826807 Rev. A
TRACES
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIF
TRACES
0.3 g/L
1.0 g/L
3.0 g/L
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
TRACES
FAIBLE
MOYEN
FORT
NEGATIF
ENV. 15 LEU/uL
ENV. 70 LEU/uL
ENV. 125 LEU/uL
ENV. 500 LEU/uL
D22 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SNG) NEGATIF
TRACES-INTACT
TRACES-LYSE
1+
2+
3+
NEGATIF
ENV. 10 GR/uL
ENV. 10 GR/uL
ENV. 25 GR/uL
ENV. 80 GR/uL
ENV. 200 GR/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACES
0.3 g/L
1.0 g/L
3.0 g/L
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
TRACES
1+
2+
3+
NEGATIF
ENV. 15 LEU/uL
ENV. 70 LEU/uL
ENV. 125 LEU/uL
ENV. 500 LEU/uL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D23
04826807 Rev. A
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (UBG) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) 0 Leu/uL
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
0 cells/uL
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
D24 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
SPUR
1+
2+
3+
NEGATIV
SPUR
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OBL) NEGATIV
SPUR-ZELLEN
SPURLYSE
1+
2+
3+
0 rbc/uL
Ca 10 rbc/uL
Ca 10 rbc/uL
Ca 25 rbc/uL
Ca 80 rbc/uL
Ca 200 rbc/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIV
SPUR
1+
2+
3+
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (UBG) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D25
04826807 Rev. A
Ca 25 rbc/uL
Ca 80 rbc/uL
Ca 200 rbc/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIV
SPUR
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) NEGATIV
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
0 cells/uL
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
D26 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
500 mg/dL
1000 mg/dL
Bilirubin (BIL) NEGATIV
1+
2+
3+
NEGATIV
SCHWACH
MAESSIG
STARK
Ketone (KET) NEGATIV
SPUR
1+
2+
3+
NEGATIV
SPUR
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OBL) NEGATIV
SPUR-ZELLEN
SPUR-LYSE
1+
2+
3+
0 rbc/uL
Ca 10 rbc/uL
Ca 10 rbc/uL
Ca 25 rbc/uL
Ca 80 rbc/uL
Ca 200 rbc/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIV
SPUR
1+
2+
3+
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) NEGATIV
SPUR
1+
2+
3+
0 cells/uL
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D27
04826807 Rev. A
1.025
1.030
Blood (SAN) NEGATIVO
TRACCE(INT.)
TRACCE(LIS.)
LEGGERO
MEDIO
FORTE
NEGATIVO
TRACCE
TRACCE
LEGGERO
MEDIO
FORTE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVO
TRACCE
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVO
TRACCE
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
Ca 15 Cel/uL
Ca 70 Cel/uL
Ca 125 Cel/uL
Ca 500 Cel/uL
NEGATIVO
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
D28 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200
Glucose (GLU) NEGATIVO
TRACCE
1+
2+
3+
NEGATIVO
0.1 g/dL
0.25 g/dL
0.50 g/dL
1.0 g/dL
Bilirubin (BIL) NEGATIVO
1+
2+
3+
NEGATIVO
LEGGERO
MEDIO
FORTE
Ketone (KET) NEGATIVO
TRACCE
1+
2+
3+
NEGATIVO
TRACCE
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (PS) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SAN) NEGATIVO
TRACCE(INT.)
TRACCE(LIS.)
1+
2+
3+
NEGATIVO
TRACCE
TRACCE
LEGGERO
MEDIO
FORTE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVO
TRACCE
1+
2+
3+
NEGATIVO
TRACCE
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
TRACCE
1+
2+
3+
NEGATIVO
Ca 15 cells/uL
Ca 70 cells/uL
Ca 125 cells/uL
Ca 500 cells/uL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D29
04826807 Rev. A
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OB) +/-INTACT
+/-LYSED
1+
2+
3+
+/+/1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) +/30 mg/dL
100 mg/dL
300 mg/dL
+/30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -++
Leukocytes (WBC) +/1+
2+
3+
-
+/1+
2+
3+
D30 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) +/1+
2+
3+
+/30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
+
Leukocytes (WBC) +/1+
2+
3+
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D31
04826807 Rev. A
+/1+
2+
3+
+/1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OB) +/-LYSED
+/-INTACT
1+
2+
3+
+/+/1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) +/30 mg/dL
100 mg/dL
300 mg/dL
+/30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
D32 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) +/1+
2+
3+
+/30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
+
Leukocytes (WBC) +/1+
2+
3+
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D33
04826807 Rev. A
BAJO
MODERADO
ALTO
NEGATIVO
BAJO
MODERADO
ALTO
Ketone (CET) NEGATIVO
INDICIOS
15 mg/dL
40 mg/dL
80 mg/dL
NEGATIVO
INDICIOS
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (DEN) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SAN) NEGATIVO
IND.INTACTOS
IND.HEMOLIZ.
Apr 25 Hem/uL
Apr 80 Hem/uL
Apr 200 Hem/uL
NEGATIVO
Apro 10 ERI/uL
Apro 10 ERI/uL
Apro 25 ERI/uL
Apro 80 ERI/uL
Apro 200 ERI/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVO
INDICIOS
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVO
INDICIOS
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
Apr 15 Leu/uL
Apr 70 Leu/uL
Apr 125 Leu/uL
Apr 500 Leu/uL
NEGATIVO
Apro 15 cel/uL
Apro 70 cel/uL
Apro 125 cel/uL
Apro 500 cel/uL
D34 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
IND.INTACTOS
IND.HEMOLIZ.
1+
2+
3+
NEGATIVO
Apro 10 ERI/uL
Apro 10 ERI/uL
Apro 25 ERI/uL
Apro 80 ERI/uL
Apro 200 ERI/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO) NEGATIVO
INDICIOS
1+
2+
3+
NEGATIVO
INDICIOS
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
INDICIOS
1+
2+
3+
NEGATIVO
Apro 15 cel/uL
Apro 70 cel/uL
Apro 125 cel/uL
Apro 500 cel/uL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D35
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Glucose (GLU) NEGATIVE
100 mg/dL
250 mg/dL
500 mg/dL
1000 mg/dL
NEGATIVE
100 mg/dL
250 mg/dL
500 mg/dL
1000 mg/dL
Bilirubin (BIL) NEGATIVE
SMALL
MODERATE
LARGE
NEGATIVE
SMALL
MODERATE
LARGE
Ketone (KET) NEGATIVE
TRACE
15 mg/dL
40 mg/dL
80 mg/dL
NEGATIVE
TRACE
15 mg/dL
40 mg/dL
80 mg/dL
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLO) NEGATIVE
TRACE-LYSED
TRACE-INTACT
SMALL
MODERATE
LARGE
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Family of Test
Strips
NEGATIVE
TRACE
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
TRACE
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
30 mg/dL
100 mg/dL
300 mg/dL
D36 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO)
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT)
NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU)
NEGATIVE
TRACE
SMALL
MODERATE
LARGE
NEGATIVE
TRACE
SMALL
MODERATE
LARGE
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D37
04826807 Rev. A
1.020
1.025
1.030
Blood (BLO) NEGATIVE
TRACE-LYSED
TRACE-INTACT
1+
2+
3+
NEGATIVE
TRACE
TRACE
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Family of Test
Strips
NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
LOW
1+
2+
3+
NEGATIVE
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
1+
2+
3+
NEGATIVE
1+
2+
3+
D38 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
<30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D39
04826807 Rev. A
2+
3+
Bilirubin (BIL) NEGATIVE
1+
2+
3+
NEGATIVE
1+
2+
3+
Ketone (KET) NEGATIVE
1+
2+
3+
4+
NEGATIVE
1+
1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLD) NEGATIVE
+/+/- INTACT
1+
2+
3+
NEGATIVE
1+
1+
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVE
+/1+
2+
3+
NEGATIVE
NEGATIVE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
1+
2+
3+
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
NORMAL
NORMAL
1+
2+
3+
D40 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
1+
2+
3+
4+
NEGATIVE
1+
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D41
04826807 Rev. A
1+
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
NEGATIVE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
LOW
1+
2+
3+
NEGATIVE
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
1+
2+
3+
NEGATIVE
1+
2+
3+
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
NORMAL
NORMAL
1+
2+
3+
D42 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
1+
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
Invalid Result Value ERROR ERROR
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D43
04826807 Rev. A
LARGE
Ketone (KET) NEGATIVE
TRACE
1.5 mmol/L
3.9 mmol/L
7.8 mmol/L
NEGATIVE
TRACE
1.5 mmol/L
3.9 mmol/L
7.8 mmol/L
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLD) NEGATIVE
TRACE-LYSED
TRACE-INTACT
Ca 25 Ery/uL
Ca 80 Ery/uL
Ca 200 Ery/uL
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVE
TRACE
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
TRACE
0.3 g/L
1.0 g/L
3.0 g/L
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIVE
0.3 g/L
1.0 g/L
3.0 g/L
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
D44 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
NEGATIVE
Ca 15 Cells/uL
Ca 70 Cells/uL
Ca 125 Cells/uL
Ca 500 Cells/uL
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D45
04826807 Rev. A
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
LOW
1+
2+
3+
NEGATIVE
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
1+
2+
3+
NEGATIVE
1+
2+
3+
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
D46 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIVE
POSITIVE
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVE
TRACE
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL DILUTE
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D47
04826807 Rev. A
0.8 g/L
Specific Gravity (DEN) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SNG) NEGATIF
TRACES-LYSE
TRACES-INTACT
env. 25 GR/uL
env. 80 GR/uL
env. 200 GR/uL
NEGATIF
env. 10 GR/uL
env. 10 GR/uL
env. 25 GR/uL
env. 80 GR/uL
env. 200 GR/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIF
TRACES
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIF
TRACES
0.3 g/L
1.0 g/L
3.0 g/L
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIF
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVE
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIF
0.3 g/L
1.0 g/L
3.0 g/L
Urobilinogen (URO) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
D48 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
env. 15 GB/uL
env. 70 GB/uL
env. 125 GB/uL
env. 500 GB/uL
NEGATIF
env. 15 GB/uL
env. 70 GB/uL
env. 125 GB/uL
env. 500 GB/uL
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ANORMAL
>300 mg/g ANORMAL
ELEVE
<30 mg/g NORMAL
30-300 mg/g ANORMAL
>300 mg/g ANORMAL
ELEVE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL, DILUEE
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
NORMAL, DILUEE
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
NORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
Invalid Result Value ERREUR ERREUR
Color (COL) JAUNE CLR.
JAUNE
JAUNE FONC.
ORANGE CLR.
ORANGE
ORANGE FONC.
ROUGE CLR.
ROUGE
ROUGE FONC.
VERT CLR.
VERT
VERT FONC.
BLEU CLR.
BLEU
BLEU FONC.
MARRON CLR.
MARRON
MARRON FONC.
PAILLE
JAUNE
JAUN FONCE
AMBRE
ORANGE
ORANGE
ROUGE
ROUGE
ROUGE
VERT
VERT
VERT
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
Clarity (ASP) LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D49
04826807 Rev. A
Clinitek Advantus or
500 Clinitek 200+
Glucose (GLU) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACES
1+
2+
3+
Bilirubin (BIL) NEGATIF
1+
2+
3+
NEGATIF
1+
2+
3+
Ketone (CET) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACES
1+
2+
3+
Specific Gravity (DEN) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SNG) NEGATIF
TRACES-LYSE
TRACES-INTACT
1+
2+
3+
NEGATIF
TRACES
TRACES
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACES
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIF
FAIBLE
1+
2+
3+
NEGATIF
FAIBLE
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIF
1+
2+
3+
NEGATIF
1+
2+
3+
Urobilinogen (URO) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
D50 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACES
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g ABNORMAL
ELEVE
<30 mg/g, NORMAL
30-300 mg/g, ANORMAL
>300 mg/g, HIGH
ANORMAL ELEVE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL, DILUEE
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
NORMAL, DILUEE
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
NORMAL
300 mg/g, ANORMAL
>500 mg/g, ANORMAL
Invalid Result Value ERREUR ERREUR
Color (COL) JAUNE CLR.
JAUNE
JAUNE FONC.
ORANGE CLR.
ORANGE
ORANGE FONC.
ROUGE CLR.
ROUGE
ROUGE FONC.
VERT CLR.
VERT
VERT FONC.
BLEU CLR.
BLEU
BLEU FONC.
MARRON CLR.
MARRON
MARRON FONC.
PAILLE
JAUNE
JAUN FONCE
AMBRE
ORANGE
ORANGE
ROUGE
ROUGE
ROUGE
VERT
VERT
VERT
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
Clarity (ASP) LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D51
04826807 Rev. A
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
D52 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
TRACES
FAIBLE
MOYEN
FORT
NEGATIF
TRACE
FAIBLE
MOYEN
FORT
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ANORMAL
> 33.9 mg/mmol ANORMAL
ELEVE
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ANORMAL
> 33.9 mg/mmol ANORMAL
ELEVE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL, DILUEE
NORMAL
17.0 mg/mmol ANORMAL
33.9 mg/mmol ANORMAL
>56.6 mg/mmol ANORMAL
NORMAL, DILUEE
NORMAL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D53
04826807 Rev. A
NEGATIF
TRACE
1+
2+
3+
Bilirubin (BIL) NEGATIF
1+
2+
3+
NEGATIF
1+
2+
3+
Ketone (CET) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACE
1+
2+
3+
Specific Gravity (DEN) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SNG) NEGATIF
TRACES-LYSE
TRACES-INTACT
1+
2+
3+
NEGATIF
TRACES
TRACES
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVE
FAIBLE
1+
2+
3+
NEGATIF
FAIBLE
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIF
1+
2+
3+
NEGATIF
1+
2+
3+
Urobilinogen (URO) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
D54 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIF
POSITIF
NEGATIF
POSITIF
Leukocytes (LEU) NEGATIF
TRACES
1+
2+
3+
NEGATIF
TRACE
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol ANORMAL
> 33.9 mg/mmol ANORMAL
ELEVE
< 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol ANORMAL
> 33.9 mg/mmol ANORMAL
ELEVE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL, DILUEE
NORMAL
17.0 mg/mmol ANORMAL
33.9 mg/mmol ANORMAL
>56.6 mg/mmol ANORMAL
NORMAL, DILUEE
NORMAL
17.0 mg/mmol ANORMAL
33.9 mg/mmol ANORMAL
>56.6 mg/mmol ANORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ANORMAL
>56.6 mg/mmol ANORMAL
NORMAL
33.9 mg/mmol ANORMAL
>56.6 mg/mmol ANORMAL
Invalid Result Value ERREUR ERREUR
Color (COL) CLR. JAUNE
JAUNE
FONC. JAUNE
CLR. ORANGE
ORANGE
FONC. ORANGE
CLR. ROUGE
ROUGE
FONC. ROUGE
CLR. VERT
VERT
FONC. VERT
CLR. BLEU
BLEU
FONC. BLEU
CLR. MARRON
MARRON
FONC. MARRON
PAILLE
JAUNE
JAUN FONCE
AMBRE
ORANGE
ORANGE
ROUGE
ROUGE
ROUGE
VERT
VERT
VERT
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
AUTRE
Clarity (ASP) LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
LIMPIDE
LEG TROUB
TROUBLE
OPAQUE
AUTRE
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D55
04826807 Rev. A
Ca 10 Ery/uL
Ca 10 Ery/uL
Ca 25 Ery/uL
Ca 80 Ery/uL
Ca 200 Ery/uL
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIV
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIV
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIV
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIV
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (UBG) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
D56 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) 0 Leu/uL
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
0 Leu/uL
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g STARK
ABNORMAL
<30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g STARK
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
P OK/ K GERING
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
P OK/ K GERING
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
Invalid Result Value FEHLER FEHLER
Color (COL) HELL GELB
GELB
DUNK. GELB
HELL ORANGE
ORANGE
DUNK. ORANGE
HELL ROT
ROT
DUNK. ROT
HELL GRUEN
GRUEN
DUNK. GRUEN
HELL BLAU
BLAU
DUNK. BLAU
HELL BRAUN
BRAUN
DUNK. BRAUN
HELL
GELB
DUNKEL
BRAEUNL.
ORANGE
ORANGE
ROT
ROT
ROT
GRUEN
GRUEN
GRUEN
ANDERS
ANDERS
ANDERS
ANDERS
ANDERS
ANDERS
Clarity (ASP) KLAR
FLOCKIG
S. FLOCKIG
TRUEB
ANDERS
KLAR
FLOCKIG
S. FLOCKIG
TRUEB
ANDERS
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D57
04826807 Rev. A
WENIG
1+
2+
3+
NEGATIV
WENIG
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIV
1+
2+
3+
NEGATIV
1+
2+
3+
Urobilinogen (UBG) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
D58 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) NEGATIV
SPUR
1+
2+
3+
0 Leu/uL
SPUR
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g STARK
ABNORMAL
<30 mg/g NORMAL
S. FLOCKIG
TRUEB
ANDERS
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D59
04826807 Rev. A
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIV
SPUR
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIV
SPUR
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIV
0.15 g/L
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIV
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIV
0.3 g/L
1.0 g/L
3.0 g/L
NEGATIV
30 mg/dL
100 mg/dL
300 mg/dL
D60 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) 0 Leu/uL
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
0 Leu/uL
Ca 15 Leu/uL
Ca 70 Leu/uL
Ca 125 Leu/uL
Ca 500 Leu/uL
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol STARK
ABNORMAL
<30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g STARK
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
P OK/ K GERING
NORMAL
17.0 mg/mmol ABNORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
P OK/ K GERING
NORMAL
150 mg/mmol ABNORMAL
300 mg/mmol ABNORMAL
>500 mg/mmol ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
33.9 mg/mmol ABNORMAL
>56.6 mg/mmol ABNORMAL
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
Invalid Result Value FEHLER FEHLER
Color (COL) HELL GELB
GELB
DUNK. GELB
HELL ORANGE
ORANGE
DUNK. ORANGE
HELL ROT
ROT
DUNK. ROT
HELL GRUEN
GRUEN
DUNK. GRUEN
HELL BLAU
BLAU
DUNK. BLAU
HELL BRAUN
BRAUN
DUNK. BRAUN
HELL
GELB
DUNKEL
BRAEUNL.
ORANGE
ORANGE
ROT
ROT
ROT
GRUEN
GRUEN
GRUEN
ANDERS
ANDERS
ANDERS
ANDERS
ANDERS
ANDERS
Clarity (CLA) KLAR
FLOCKIG
S. FLOCKIG
TRUEB
ANDERS
KLAR
FLOCKIG
S. FLOCKIG
TRUEB
ANDERS
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D61
04826807 Rev. A
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OBL) NEGATIV
SPUR-LYSE
SPUR-ZELLEN
1+
2+
3+
NEGATIV
SPUR
SPUR
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIV
SPUR
1+
2+
3+
NEGATIV
SPUR
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIV
WENIG
1+
2+
3+
NEGATIV
WENIG
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIV
1+
2+
3+
NEGATIV
1+
2+
3+
D62 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (UBG) 3.2 umol/L
16 umol/L
33 umol/L
66 umol/L
131 umol/L
0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
Nitrite (NIT) NEGATIV
POSITIV
NEGATIV
POSITIV
Leukocytes (LEU) NEGATIV
SPUR
1+
2+
3+
NEGATIV
SPUR
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 0.9 mmol/L
4.4 mmol/L
8.8 mmol/L
17.7 mmol/L
26.5 mmol/L
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) < 3.4 mg/mmol NORMAL
3.4-33.9 mg/mmol
ABNORMAL
> 33.9 mg/mmol STARK
ABNORMAL
<30 mg/g, NORMAL
30-300 mg/g, ABNORMAL
>300 mg/g, STARK
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
P OK/ K GERING
NORMAL
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D63
04826807 Rev. A
D64 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
Ca 15 Cel/uL
Ca 70 Cel/uL
Ca 125 Cel/uL
Ca 500 Cel/uL
NEGATIVO
Ca 15 Cells/uL
Ca 70 Cells/uL
Ca 125 Cells/uL
Ca 500 Cells/uL
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMALE
30-300 mg/g
ABNORMALE
>300 mg/g MOLTO
ABNORMALE
<30 mg/g NORMALE
30-300 mg/g
ABNORMALE
>300 mg/g MOLTO
ABNORMALE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
URINA DILUITA
NORMALE
150 mg/g ABNORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
URINA DILUITA
NORMALE
150 mg/g ABNORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
NORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
Invalid Result Value ERRORE ERRORE
Color (COL) CHIA. GIALLO
GIALLO
SCUR. GIALLO
CHIA. ARANCIONE
ARANCIONE
SCUR. ARANCIONE
CHIA. ROSSO
ROSSO
SCUR. ROSSO
CHIA. VERDE
VERDE
SCUR. VERDE
CHIA. AZZURO
AZZURO
SCUR. AZZURO
CHIA. MARRONE
MARRONE
SCUR. MARONE
PAGLIER.
GIALLO
GIALLO SC.
AMBRA
ARANCIO
ARANCIO
ROSSO
ROSSO
ROSSO
VERDE
VERDE
VERDE
ALTRO
ALTRO
ALTRO
ALTRO
ALTRO
ALTRO
Clarity (ASP) LIMPIDA
LEG. TORB
TORBIDA
MOL.TORB
ALTRO
LIMPIDA
LEG. TORB
TORBIDA
MOL.TORB
ALTRO
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D65
04826807 Rev. A
D66 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
TRACCE
1+
2+
3+
NEGATIVO
TRACCE
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMALE
30-300 mg/g
ABNORMALE
>300 mg/g MOLTO
ABNORMALE
<30 mg/g NORMALE
30-300 mg/g
ABNORMALE
>300 mg/g MOLTO
ABNORMALE
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
URINA DILUITA
NORMALE
150 mg/g ABNORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
URINA DILUITA
NORMALE
150 mg/g ABNORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMALE
300 mg/g ABNORMALE
>500 mg/g ABNORMALE
NORMALE
300 mg/g, ABNORMALE
>500 mg/g, ABNORMALE
Invalid Result Value ERRORE ERRORE
Color (COL) CHIA. GIALLO
GIALLO
SCUR. GIALLO
CHIA. ARANCIONE
ARANCIONE
SCUR. ARANCIONE
CHIA. ROSSO
ROSSO
SCUR. ROSSO
CHIA. VERDE
VERDE
SCUR. VERDE
CHIA. AZZURO
AZZURO
SCUR. AZZURO
CHIA. MARRONE
MARRONE
SCUR. MARONE
PAGLIER.
GIALLO
GIALLO SC.
AMBRA
ARANCIO
ARANCIO
ROSSO
ROSSO
ROSSO
VERDE
VERDE
VERDE
ALTRO
ALTRO
ALTRO
ALTRO
ALTRO
ALTRO
Clarity (ASP) LIMPIDA
LEG. TORB
TORBIDA
MOL.TORB
ALTRO
LIMPIDA
LEG. TORB
TORBIDA
MOL.TORB
ALTRO
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D67
04826807 Rev. A
1.0 g/dL
Bilirubin (BIL) 1+
2+
3+
1+
2+
3+
Ketone (KET) +/1+
2+
3+
+/1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OB) +/-LYSED
+/-INTACT
1+
2+
3+
+/+/1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
+/30 mg/dL
100 mg/dL
300 mg/dL
+/-
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
D68 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
+
Leukocytes (WBC) +/1+
2+
3+
+/1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
<30 mg/g, NORMAL
30-300 mg/g, ABNORMAL
>300 mg/g, HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL DILUTE
NORMAL
150 mg/g, ABNORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) +/1+
2+
3+
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D69
04826807 Rev. A
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
+/1+
2+
3+
+/1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
LOW
1+
2+
3+
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
1+
2+
3+
1+
2+
3+
D70 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
+
Leukocytes (WBC) +/1+
2+
3+
+/1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
<30 mg/g, NORMAL
30-300 mg/g, ABNORMAL
>300 mg/g, HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL DILUTE
NORMAL
150 mg/g, ABNORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) +/1+
2+
3+
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D71
04826807 Rev. A
1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OB) +/-INTACT
+/-LYSED
1+
2+
3+
+/+/1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
+/30 mg/dL
100 mg/dL
300 mg/dL
+/30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
30 mg/dL
100 mg/dL
300 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
Urobilinogen (URO) 0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
+
Leukocytes (WBC) +/1+
2+
3+
+/1+
2+
3+
D72 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
<30 mg/g, NORMAL
30-300 mg/g, ABNORMAL
>300 mg/g, HIGH
ABNORMAL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL DILUTE
NORMAL
150 mg/g, ABNORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) +/1+
2+
3+
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D73
04826807 Rev. A
Clinitek Advantus or
500 Clinitek 200+
Glucose (GLU) 1+
2+
3+
4+
1+
2+
3+
4+
Bilirubin (BIL) 1+
2+
3+
1+
2+
3+
Ketone (KET) +/1+
2+
3+
+/1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (OB) +/-LYSED
+/-INTACT
1+
2+
3+
+/+/1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of
Test Strips
+/1+
2+
3+
+/1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
LOW
1+
2+
3+
LOW
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
1+
2+
3+
1+
2+
3+
D74 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO)
0.1 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) -+
-+
Leukocytes (WBC)
+/1+
2+
3+
+/1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ABNORMAL
>300 mg/g HIGH
ABNORMAL
<30 mg/g, NORMAL
30-300 mg/g, ABNORMAL
>300 mg/g, HIGH
ABNORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NORMAL DILUTE
NORMAL
150 mg/g ABNORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL DILUTE
NORMAL
150 mg/g, ABNORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
NORMAL
300 mg/g, ABNORMAL
>500 mg/g, ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) LT. YELLOW
YELLOW
DK. YELLOW
LT. ORANGE
ORANGE
DK. ORANGE
LT. RED
RED
DK. RED
LT. GREEN
GREEN
DK. GREEN
LT. BLUE
BLUE
DK. BLUE
LT. BROWN
BROWN
DK. BROWN
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) +/1+
2+
OTHER
+/1+
2+
3+
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D75
04826807 Rev. A
INDICIO-INTACTO
PEQUENO
MODERADO
GRANDE
NEGATIVE
TRACE
TRACE
SMALL
MODERATE
LARGE
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strip
NEGATIVO
INDICIO
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
TRACE
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVO
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVO
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVE
30 mg/dL
100 mg/dL
300 mg/dL
D76 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
NORMAL
300 mg/g ABNORMAL
>500 mg/g ABNORMAL
Invalid Result Value ERROR ERROR
Color (COL) CL. AMERELO
AMERELO
ES. AMERELO
CL. LARANJA
LARANJA
ES. LARANJA
CL. VERMELHO
VERMELHO
ES. VERMELHO
CL. VERDE
VERDE
ES. VERDE
CL. AZUL
AZUL
ES. AZUL
CL. MARROM
MARROM
ES. MARROM
STRAW
YELLOW
DK YELLOW
AMBER
ORANGE
ORANGE
RED
RED
RED
GREEN
GREEN
GREEN
OTHER
OTHER
OTHER
OTHER
OTHER
OTHER
Clarity (CLA) CLARO
POUCO NEBULOSO
NEBULOSO
TURVO
OUTROS
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D77
04826807 Rev. A
NEGATIVE
1+
2+
3+
Ketone (KET) NEGATIVO
INDICIO
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
Specific Gravity (SG) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (BLO) NEGATIVO
INDICIO-LISADO
INDICIO-INTACTO
1+
2+
3+
NEGATIVE
TRACE
TRACE
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVO
INDICIO
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
D78 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.2 mg/dL
1.0 mg/dL
2.0 mg/dL
4.0 mg/dL
8.0 mg/dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVE
POSITIVE
Leukocytes (LEU) NEGATIVO
INDICIO
1+
2+
3+
NEGATIVE
TRACE
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
TURVO
OUTROS
CLEAR
SL CLOUDY
CLOUDY
TURBID
OTHER
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D79
04826807 Rev. A
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strip
NEGATIVO
INDICIOS
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVO
INDICIO
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVO
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVO
15 mg/dL
30 mg/dL
100 mg/dL
300 mg/dL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVO
30 mg/dL
100 mg/dL
300 mg/dL
NEGATIVO
30 mg/dL
100 mg/dL
300 mg/dL
D80 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
VERDE
OSC. VERDE
CL. AZUL
AZUL
OSC. AZUL
CL. MARRON
MARRON
OSC. MARRON
COLURICA
AMARILLO
AM. OSCURO
AMBAR
ANARANJ
ANARANJ
ROJIZO
ROJIZO
ROJIZO
VERDOSO
VERDOSO
VERDOSO
OTROS
OTROS
OTROS
OTROS
OTROS
OTROS
Clarity (ASP) CLARO
LIG. TURB
TURBIA
MUY TURB
OTROS
CLARO
LIG. TURB
TURBIA
MUY TURB
OTROS
Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode D81
04826807 Rev. A
3+
Specific Gravity (DEN) 1.005
1.010
1.015
1.020
1.025
1.030
1.005
1.010
1.015
1.020
1.025
1.030
Blood (SAN) NEGATIVO
IND.INTACTOS
IND.HEMOLIZ.
1+
2+
3+
NEGATIVO
INDICIO
INDICIO
1+
2+
3+
pH (pH) 5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
5.0
5.5
6.0
6.5
7.0
7.5
8.0
8.5
9.0
Protein (PRO)
MULTISTIX Group of Test
Strips
NEGATIVO
INDICIOS
1+
2+
3+
NEGATIVO
INDICIO
1+
2+
3+
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
NEGATIVO
BAJO
1+
2+
3+
NEGATIVO
BAJO
1+
2+
3+
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NEGATIVO
1+
2+
3+
NEGATIVO
1+
2+
3+
D82 Clinitek Advantus and Clinitek 500 Interface Specification: Clinitek 200/200+ Emulation Mode
04826807 Rev. A
Test
Clinitek Advantus or
500 Clinitek 200+
Urobilinogen (URO) 0.2 U.E./dL
1.0 U.E./dL
2.0 U.E./dL
4.0 U.E./dL
8.0 U.E./dL
0.2 E.U./dL
1.0 E.U./dL
2.0 E.U./dL
4.0 E.U./dL
8.0 E.U./dL
Nitrite (NIT) NEGATIVO
POSITIVO
NEGATIVO
POSITIVO
Leukocytes (LEU) NEGATIVO
INDICIOS
1+
2+
3+
NEGATIVO
INDICIO
1+
2+
3+
Albumin (ALB) 10 mg/L
30 mg/L
80 mg/L
150 mg/L
10 mg/L
30 mg/L
80 mg/L
150 mg/L
Creatinine (CRE) 10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
10 mg/dL
50 mg/dL
100 mg/dL
200 mg/dL
300 mg/dL
A:C Ratio (A:C) <30 mg/g NORMAL
30-300 mg/g ANORMAL
>300 mg/g ALTAMENTE
ANORMAL
<30 mg/g NORMAL
30-300 mg/g ANORMAL
>300 mg/g ALTAMENTE
ANORMAL
P:C Ratio (P:C)
MULTISTIX PRO 11
MULTISTIX PRO 10LS
MULTISTIX PRO 10LB
MULTISTIX PRO 10SB
MULTISTIX PRO 7G
DILUIDO NORMAL
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
DILUIDO NORMAL
NORMAL
150 mg/g ANORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
MULTISTIX PRO 6B
MULTISTIX PRO 6K
NORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
NORMAL
300 mg/g ANORMAL
>500 mg/g ANORMAL
Invalid Result Value ERROR ERROR
Color (COL) CL. AMARILLO
AMARILLO
OSC. AMARILLO
CL. NARANJA
NARANJA
OSC. NARANJA
CL. ROJO
ROJO
OSC. ROJO
CL. VERDE
VERDE
OSC. VERDE
CL. AZUL
AZUL
OSC. AZUL
CL. MARRON
MARRON
OSC. MARRON
COLURICA
AMARILLO
AM. OSCURO
AMBAR
ANARANJ
ANARANJ
ROJIZO
ROJIZO
ROJIZO
VERDOSO
VERDOSO
VERDOSO
OTROS
OTROS
OTROS
OTROS
OTROS
OTROS
Clarity (CLA) CLARO
LIG. TURB
TURBIA
MUY TURB
OTROS
CLARO
LIG. TURB
TURBIA
MUY TURB
OTROS
04826807 Rev. A
Appendix E: Glossary
A:C albumin to creatinine ratio
<ACK> Computer acknowledges that it received the data correctly,
SG Specific Gravity
Spacing Transmit signal is at positive levels.
<STX> control code for the tart of text character
URO Urobilinogen