Professional Documents
Culture Documents
Mod-09 Rev
Mod-09 Rev
MODULE 9
1.
A discontinuity is:
A.
B.
C.
D.
E.
2.
Whether a particular weld discontinuity is critical can be judged on the basis of:
A.
B.
C.
D.
E.
3.
The weld discontinuity that results from improper termination of the welding arc is referred to as :
A.
B.
C.
D.
E.
7.
Toe crack
Undercut
Lamellar tear
Overlap
None of the above
Underbead cracks can result from which of the following welding practices ?
A.
B.
C.
D.
E.
6.
Porosity
Incomplete fusion
Slag inclusion
Crack
Arc strike
5.
4.
Always a defect
Always a reject
Always acceptable
Rejectable if it exceeds code limits
None of the above
Undercut
Overlap
Crater crack
Incomplete fusion
All of the above
Of the following processes which is likely to have slag inclusions in a completed weld ?
A.
B.
C.
D.
E.
SMAW
PAW
FCAW
SAW
None of the above
Page 1 of 3
MINT
8.
The discontinuity that results from the entrapment of gas within the weld cross section is referred
to as :
A.
B.
C.
D.
E.
9.
What weld discontinuity results when the welder travels too slowly, causing excess weld metal to
flow out of the joint and lay on the base metal surface without fusing ?
A.
B.
C.
D.
E.
10.
Incomplete fusion
Undercut
Overlap
Scratch start
Arc strike
14.
Excess convexity
Excess weld reinforcement
Overfill
All of the above
None of the above
The weld discontinuity that results from the initiation of the welding arc outside the weld joint is
referred to as :
A.
B.
C.
D.
E.
13.
Underfill
Undercut
Overlap
Incomplete fusion
None of the above
12.
Undercut
Underfill
Overlap
Incomplete fusion
None of the above
What weld metal discontinuity results when the welder fails to completely fill the weld groove ?
A.
B.
C.
D.
E.
11.
Crack
Slag inclusion
Incomplete fusion
Porosity
None of the above
Porosity
Tungsten inclusion
Slag inclusion
A and B above
B and C above
Which of the following is not a base metal discontinuity, resulting from improper steel making
practices ?
A.
B.
C.
D.
E.
Lamination
Lamellar tear
Seam
Pipe shrinkage
None of the above
Page 2 of 3
MINT
Questions 15 through 19 refer to the figure shown below :
15.
16.
17.
Toe crack
Incomplete fusion
Root crack
Lamellar tear
Underbead cracks
19.
Lamination
Porosity
Lamellar tear
Seam
Lap
18.
Longitudinal crack
Transverse crack
Face crack
Toe crack
Root crack
Undercut
Underfill
Overlap
Incomplete fusion
Toe crack
Lamination
Seam
Delamination
Base metal crack
Incomplete fusion
Page 3 of 3