Professional Documents
Culture Documents
cc
Before upgrade, Please check you already get ready of all following items:
z
z
z
z
z
z
PT600 Device
Screwdriver (to open PT600)
USB cable
CP210x_Drivers
mcuisp_stm.exe
PT600 firmware file we provided (like PT600 1.15.hex)
www.bofan.cc
Second: Connect the USB cable to your computer, then you can go to your computers Device Manager to
check the USB com port, please refer to it as below:
Third: Double click mcuisp_stm.exe we offered, and then you need make some setting on this file, please
refer to below picture steps:
After youve done above steps, you use screwdriver to open the PT600 shield board same with below picture:
www.bofan.cc
After you open this shield board, then you connect the USB cable to PT600, and you move Switch of Upgrade turn to Right side,
and also move Switch of PT600 turn to Right.
(Please refer to below pictures to find the Switch of Upgrade and Switch of PT600)
After youve done all above steps, you will see mcuisp_stm.exe with some data as below picture show on your computer:
It means PT600 is upgrading, and after few seconds, you will see below picture,
www.bofan.cc
Thats All!