Professional Documents
Culture Documents
General principles
Risk management
Physical damage to structures and life hazard
Electrical and electronic systems within structures
This series, on adoption, would supersede IS 2309 : 1989 'Code of practice for the
protection of buildings and allied structures against lightning'. The text of IEC Standard
would be considered for approval as suitable for publication as an Indian Standard
without deviations. Certain conventions are, however, not identical to those used in
Indian Standards. Attention is particularly drawn to the following:
a)
b)
Comma (,) has been used as a decimal marker, while in Indian Standards
the current practice is to use a point (.) as the decimal marker.
In this adopted standard, references appear to certain International Standards for which
Indian Standards also exist. The corresponding Indian Standards, which are to be
substituted in their respective places, are listed below along with their degree of
equivalence for the editions indicated:
International Standard
Degree of
Equivalence
IEC 60079-10-1:2008, Explosive IS 5572 : 2009 Classification of Technically
atmospheres
Part
10-1: hazardous areas (other than mines) Equivalent
Classification of areas Explosive gas having flammable gases and
atmospheres
vapours for electrical installation
IEC 60079-10-2:2009, Explosive
atmospheres
Part
10-2:
Classification of areas Combustible
dust atmospheres
IEC
60079-14:2007,
Explosive
atmospheres Part 14: Electrical
installations design, selection and
erection
Identical
Identical to
IEC 6164311:2011
which has
superseded
IEC 61643-1
IEC 62305-1:2010, Protection against Doc:ET 20(6447)/ IEC 62305lightning Part 1: General principles
1:2010 Protection against lightning
Part 1: General principles
Identical
IEC 62305-2:2010, Protection against Doc:ET 20(6448)/ IEC 62305lightning Part 2: Risk management
2:2010 Protection against lightning
Part 2: Risk management
Identical
Identical
The technical committee would review the provisions of the following Standards referred
in this adopted standard and would decide whether they are acceptable for use in
conjunction with this standard:
Standard
Title
IEC 61557-4
IEC 61643-21
IEC 62561-3
ISO 3864-1
The page numbers given here are not the same as in the International Standard.
For the purpose of deciding whether the particular requirement of this standard is
complied with, the final value, observed or calculated, expressing the result of a test, shall
be rounded off in accordance with IS 2 : 1960 Rules for rounding off numerical values
(revised). The number of significant places retained in the rounded off value should be
the same as that of the specified value in this standard.
Note: The technical content of the documents is not available on website. For details,
please refer the corresponding IEC 62305-3 : 2010 or kindly contact:
Head
Electrotechnical Department
Bureau of Indian Standards
9, B. S. Zafar Marg,
New Delhi-110002
Email: eetd@bis.org.in
Telephone/ fax: 011-23231192