Professional Documents
Culture Documents
Huawei CHR FAQ PDF
Huawei CHR FAQ PDF
OPTIMIZATION
User call logInformation about the call messages such as call setup, RAB setup,
Handover and Call Release.
Cell LogUser load and Power measurement of the cell over time which includes
RTP% and RTWP.
Call Start information such as RRC Establishment cause, Ec/No, serving cell and
propagation delay. It also captured IMSI for user identification and IMEI for phone
identification.
Radio Bearer setup information for both CS and PS calls such as RAB type and
requested but-rate.
Call Release information such as release cause, fault description and error codes.
RF measurement from Measurement Report such as Active Set and Monitored Set
Ec/No and RSCP and GSM cell RSSI (Refer Figure 1)
As for NodeB CHR log, uses "SET CHRSW" MML command to initiate the recording.
Pilot Pollution Analysis The measurement report form all UE allow RF Engineer to
identify interference in the network.
Over-shooting cell analysisUsing the propagation delay during the call setup
together with the RF measurement, RF Engineer can identify cells that cover too
large area.
VIP AnalysisUsing the IMSI, RF Engineer can find out the cause of complain from
the VIP customer.
Phone Model AnalysisOperator can study the performance of each phone in the
network.