Professional Documents
Culture Documents
Brochure Container Specification en PDF
Brochure Container Specification en PDF
safdsfsdgdgdgd
Introduction
dimensions
weights
design features
All values listed in the tables are given in metric. Ft and lbs
values are for easy reference only.
All details listed are nominal figures. Apart from the tolerances
given on internal dimensions on page 5 the tare weight can
vary 2 %.
This booklet only lists technical data. If you are looking for
further advice or your special requirements are not yet satisfied,
we are more than happy to assist you.
Please call your nearest Hapag-Lloyd office or agent and let
our experience work for you.
www.hapag-lloyd.com
Hapag-Lloyd 3
4 Hapag-Lloyd
General Information
Internal Dimensions Concentrated Loads
The internal dimensions and door openings of Concentrated loads are loads, that are not
all Hapag-Lloyd containers exceed the below distributed over the full length of floor, when
given ISO dimensions. However, the dimen- stowing heavy cargo in containers other than
sions mentioned on the following pages are flats or platforms due care has to be taken
nominal figures. Because of production toler- that concentrated loads will not exceed the
ances a difference in measurement is possible: strength of the bottom construction of the
container.
Tolerances Length Width Height
The maximum spreaded load should not
Maximum 10 mm 10 mm 10 mm exceed
Difference 3/8 3/8 3/8
for 20 containers 4 ts per running meter in
length (333/8) still higher on request
Maximum Gross Weights
for 40containers 3 ts per running meter in
20 containers: length
32500 kg (71650 lbs) valid for most Hapag-
Lloyd 20 containers; exceeds ISO minimum load must not exceed over max. payload
standards (ISO 668).
Gooseneck Tunnel on 40 Containers
40 and 45 containers: All Hapag-Lloyd 40 containers are fitted with
Up to 34 000 kg (74 959 lbs). a Gooseneck tunnel to enable the transport on
Gooseneck chassis.
Weight Limits for road and rail transport
For individually valid limits contact your local Timber Treatment
Hapag-Lloyd office. Exposed timber is treated according to
Australian, EU, Chinese and American require-
Floor Loads ments.
A container floor is capable of carrying
a fork-lift truck with a maximum axle load of Container Markings
5 460 kg (12 040 lbs), if the contact area per Containers built in 1997 or thereafter do also
wheel is at least 142 cm2 (22 sq.in) show the ISO Size Type Code.
(ISO 1496/I). For further information please see page 46.
Hapag-Lloyd 5
Contents page
Introduction 3
General Information 5
High Cube 40 12
General Purpose Container
yd
-Llo
Hapag
High Cube 45 14
General Purpose Container
-Llo yd
Hapag
Hardtop Container 20 16
40 18
-Llo yd
Hapag
High Cube 40 20
Hardtop Container
-Llo yd
Hapag
6 Hapag-Lloyd
page
Flat 20 30
Platform 20 34
40
Ventilated Container 20 36
Refrigerated Container 20 38
oyd
-Ll
.. . .
... Hapag
..
..
High Cube 40 40
Refrigerated Container
yd
-Llo
...
. .. .
Hapag
..
..
Tank Container 20 44
Hapag-Lloyd 7
General Purpose Container 20
ISO Size Type Code: 22 G0, 22 G1
Hapag-Lloyd 8
General Purpose Container 20
Steel container with 1941/8 781/2 7101/8 781/8 761/4 67 200 4 960 62 240 1172 HLXU 300 000 310 099 1) 2) 3)
corrugated walls 5 900 2 352 2 395 2 340 2 292 32 500 2 370 30 130 33,2 HLXU 310 100 340 699 1) 2) 3)
and wooden floor 941/4 785/8 7101/4 781/8 761/4 71 650 5 220 66 430 1172 HLXU 340 800 354 699 1) 2) 3)
5 895 2 350 2 392 2 340 2 292 32 500 2 570 29 930 33,2 HLXU 340 700 340 799 1) 2) 3)
and steel floor 1941/8 781/2 7101/8 781/8 761/4 71 650 5 670 65 980 1172 CPSU 108 363 108 469 5)
Steel container with 5 886 2 342 2 388 2 313 30 480 2 700 27 780 32,8
1933/4 781/8 710 77 67 200 5 950 61 250 1160 HLXU 365 000 365 649 4)
corrugated walls,
wooden floor and 5 859 2 350 2 390 2 309 32 500 2 850 29 650 32,1
removable steel roof 1933/4 781/8 791/2 773/4 71 650 6 280 65 370 1132 HLXU 365 650 365 949 4)
Remarks:
1) 10 lashing rings on each top longitudinal rail; particularly suitable for the transport of hanging garments racks.
2) Provided with passive vents.
3) Provided with extra lashing rings/bars for the transport of liner bags in the corner posts adjacent to the corner castings.
4) For special information please see 20 Hard Top Container.
5) Max Gross 30 480 kg
Hapag-Lloyd 9
General Purpose Container 40
ISO Size Type Code: 42 G0, 42 G1
Hapag-Lloyd 10
General Purpose Container 40
Remarks:
3) Special information, please see 40 Hard Top Container.
Hapag-Lloyd 11
High Cube General Purpose Container 40
ISO Size Type Code: 45 G0, 45 G1
-Lloyd
H apag
96
2.9 m
Especially for voluminous cargo up to Lashing devices have a permissible Consider overheight for inland
max. 2.70 m (8101/4) (see table). load of 1 000 kg (2 205 lbs) each. transportation
Numerous lashing devices on the top and Floor Height 170 mm - 5mm Provided with passive vents. ISO size
bottom longitudinal rails and the corner (Ground level to interior floor surface) type code: 45 G1
posts.
Hapag-Lloyd 12
High Cube General Purpose Container 40
Remarks:
21 lashing rings on each top longitudinal rail; particularly suitable for the transport of hanging garment equipment.
1) Special information, please see 40 High Cube Hard Top Container.
Hapag-Lloyd 13
High Cube General Purpose Container 45
ISO Size Type Code: L5 G0, L5 G1
g-Lloyd
Hapa
96
2.9 m
Especially for voluminous cargo up to Lashing devices have a permissible load Provided with passive vents
max. 2.70 m (8101/4) (see table). of 1 000 kg (2 205 lbs) each.
Minimum 10 Lashing rings on the top and Floor Height 170 mm - 5mm
bottom longitudinal rails. (Ground level to interior floor surface)
Units built with corner castings at 40 ft and Consider overheight for inland
45 ft positions. transportation
Hapag-Lloyd 14
High Cube General Purpose Container 45
Remarks:
1) Lashing rings total 68. Lash roads total 16
Hapag-Lloyd 15
Hardtop Container 20
ISO Size Type Code: 22 U6
This container type has been designed and
developed by Hapag-Lloyd.
Hapag-Lloyd 16
Hardtop Container 20
Remarks:
1) Provided with passive vents.
2) 10 lashing rings on each top longitudinal rail; particularly suitable for the transport of hanging garment equipment.
3) Provided with extra lashing rings/bars for the transport of liner bags in the corner post adjacent to the corner castings.
Hapag-Lloyd 17
Hardtop Container 40
ISO Size Type Code: 42 U6
Hapag-Lloyd 18
Hardtop Container 40
12 020 2 342 2 388 2 313 30 480 4 700 25 780 67,2 FANU 462 400 463 999 1)
Steel container with
corrugated walls, 3951/4 781/8 710 77 67 200 10 360 56 840 2374 HLXU 465 000 466 249
wooden floor and 12 020 2 345 2 380 2 300 30 480 4 700 25 780 65,3
removable steel roof 3951/4 781/4 795/8 761/2 67 200 10 360 56 840 2306 HLXU 467 950 467 999 2)
Remarks:
The 40 hardtop has a removable turnbuckle positioned dead centre between both top rails.
This may reduce the cargo height, if left in position and not stored.
1) Provided with passive vents.
2) Special design, roof locking clips.
Hapag-Lloyd 19
High Cube Hardtop Container 40
ISO Size Type Code: 45 U6
The roof can be removed by using a fork- The roof can easily lifted by hand 70 mm
lift. The weight of the steel roof is approx. (23/4), using the roof locking devices so
fastened to the walls on the outside using that the door-header can be swung out
450 kg (990 lbs) each section.
lashing devices. without removing the roof.
In case your cargo has overheight the roof
The hardtop container provides many lash- This container type has been designed
sections can be lashed to a sidewall inside
ing devices to fasten your goods. for heavy loads. Whilst considering the
the container using only some 13 cm (51/8 )
The lashing devices on the corner posts technical data (including the permissible
of space.
and on the longitudinal rails of the roof and spreaded load limitations) please bear in
Floor Height 170 mm - 5mm floor are capable of bearing loads of up to mind theprevalent weight restrictions for
(Ground level to interior floor surface) 2,000 kg (4,410 lbs) each, and those in the land transport.
middle of the side walls up to 500 kg (1,100
If required, we can provide disposable lbs) each. Lashing to the side walls can only For further information please ask for our
tarpaulins for the transport which can be be done after the roof has been closed. brochure The Hardtop Container.
Hapag-Lloyd 20
High Cube Hardtop Container 40
Remarks:
Roof with hinged rings for easy removal by a fork-lift truck.
Up to 21 lashing rings on each top longitudinal rail; particularly suitable for the transport of hanging garment equipment.
The 40 hardtop has a removable turnbuckle positioned dead centre between both top rails.
This may reduce the cargo height, if left in position and not stored.
Hapag-Lloyd 21
Roof and door openings of Hardtop Containers 20, 40, 40/96
A removable
A A removable
door header removable
door header door header
D
D D
B
B B
B E F
B B E E F F
C
C C
A
A A
B
B B
Attention: Reduced inside height due to adjust bar, in the centre ~ -160 mm
Hapag-Lloyd 22
Roof and door openings of Hardtop Containers 20, 40, 40/96
Roof openings Door openings Roof lashed to sidewall
Length Width Width Height Reduced Inside Width
A B C D B E F Roof Door Hapag-Lloyd Foot-
Swing Between Up to Up to opening opening Serial note
Number
20 header top rails door top rail
opening header
86 high mm mm mm mm mm mm mm mm mm mm
ft ft ft ft ft ft ft ft ft ft
5 590 2 208 2 336 1 896 2 208 2 276 2 220 2 209 2 142 2 206 FANU 260 200 261 399
184 727/8 78 625/8 727/8 755/8 73/8 73 71/4 727/8 HLXU 365 000 365 649
5 590 2 208 2 336 1 896 2 208 2 292 2 220 2 209 2 142 2 206
184 727/8 78 625/8 727/8 761/4 73/8 73 71/4 727/8 FANU 261 400 261 799
5 590 2 208 2 336 1 896 2 208 2 275 2 231 2 215 2 148 2 212
184 727/8 78 625/8 727/8 723/4 733/4 731/8 71/2 73 HLXU 365 650 365 949
11 724 2 208 2 336 1 896 2 208 2 276 2 220 2 209 2 142 2 206 FANU 462 400 463 999
40 3851/2 727/8 78 625/8 727/8 755/8 73/8 73 71/4 727/8 HLXU 465 000 465 649
11 724 2 208 2 334 1 882 2 208 2 290 2 125 2 205 2 102 1 996
86 high 3851/2 727/8 777/8 621/2 727/8 761/8 6115/8 723/4 6103/4 661/2 HLXU 467 950 467 999
Hapag-Lloyd 23
Open Top Container 20
ISO Size Type Code: 22 U1
Especially for If required, we can provide disposable tar- Lashing devices have a permissible load of
overheight cargo paulins. For fastening tarpaulins, lashing 1 000 kg (2 20 lbs) each.
loading from top side, e.g. by crane bars are available on the outside of the
loading from door side, e.g. with cargo walls. Using one way tarpaulins requires the Dimensions of roof and door openings
hanging from overhead tackle corner castings to be accessible. please see page 29.
Hapag-Lloyd 24
Open Top Container 20
Remarks:
1) Concentrated load up increased from 4 tons per running meter in length (333/8)
Hapag-Lloyd 25
Open Top Container 40
ISO Size Type Code: 42 U1
ag-Lloyd
Hap
Especially for Door header can be swung out on all Dimensions of roof and door openings
overheight cargo open top containers please see page 29.
loading from top side, e.g. by rane
loading from door side, e.g. with cargo Numerous lashing devices on the top
hanging from overhead tackle and bottom longitudinal rails and the
corner posts. Lashing devices have a
Floor Height 170 mm - 5mm permissible load of 1 000 kg(2 205 lbs)
(Ground level to interior floor surface) each.
Hapag-Lloyd 26
Open Top Container 40
Hapag-Lloyd 27
Roof and door openings of Open Top Containers 20, 40
A removable
A A door header
removable removable
door header door header
D
DB D
B B
B E F
B B E E F F
C
C C
A
A A
B
B B
Roof openings
Roof openings
Roof openings
Hapag-Lloyd 28
Roof and door openings of Open Top Containers 20, 40
Roof openings Door openings
Length Width Width Height
A B C D B E F Hapag-Lloyd Foot-
Swing Between Up to Up to Serial note
Number
20 header top rails door top rail
openings header
86 high mm mm mm mm mm mm mm
ft ft ft ft ft ft ft
5 360 2 205 2 335 1 880 2 205 2 280 2 125
177 723/4 78 62 723/4 753/4 6115/8 HLXU 260 000 260 849
5 338 2 230 2 338 1 902 2 230 2 280 2 231 CPSU 800 001 800 549
1761/8 733/4 78 627/8 733/4 753/4 71 HLXU 260 850 261 599
5 338 2 230 2 338 1 899 2 230 2 280 2 231
1761/8 733/4 78 627/8 733/4 753/4 71 HLXU 360 000 361 549
Hapag-Lloyd 29
Flat - All Types 20
ISO Size Type Code: 86 high, 22 P3, 22 P8
Especially for heavy loads and over- Maximum payload can only be used Collapsible flatracks, provided with spring
size cargo as well as project cargo. if distributed over the total floor area of assisted endwalls.
flatrack. If concentration of heavy load
Fork-lift pockets for loaded containers. on a small part of floor area is required Collapsible flatracks, provided with
please contact your Hapag-Lloyd partner twistlocks to interlock 7 units into a 86
Numerous very strong lashing devices on office for stowage advice. high pile.
the corner posts, longitudinal rails and on
the floor or base ends. Lashing devices on Flats are delivered without stanchions.
the longitudinal rails have a permissible If stanchions are required please inform us
load up to 5 000 kg each. upon booking.
Hapag-Lloyd 30
Flat 20
Steelframe with
collapsible endwalls 5 950 5 644 2 224 2 194 2 226 370 33 000 2 850 30 150
and softwood floor 1961/4 1861/8 731/2 727/8 735/8 121/2 72 752 6 238 66 469 HLXU 268 000 268 149 3)
Flat/Platform with 6038 5638 2 226 2 208 2 235 370 30 480 2 520 27 960
1993/4 186 735/8 723/8 74 121/2 67 200 5 560 61 64 HLXU 268 500 268 599
flushfolding
endwalls and 6038 5612 2 225 2 210 2213 370 34 000 2 740 31 260
softwood floor 1993/4 1847/8 735/8 73 731/8 121/2 74 950 6 040 68 910 HLXU 268 600 269 399 1)
Remarks:
1) Length between hinges at floor level: about 83mm less between posts
2) no stanchions pockets
3) collabsible but not flushfolding
Hapag-Lloyd 31
High Cube Flat 40
ISO Size Type Code: 45 P8
96
2.9 m
Especially for heavy loads and oversize Used as Tween decks in cargo holds and Maximum payload can only be used
cargo as well as project cargo. on hatch covers for oversized cargoes. if distributed over the total floor area of
the flatrack. If heavy loads are shorter,
Extraordinary very strong frame design with Numerous very strong lashing devices the payload is reduced. Hapag-Lloyd
folding endwalls which allow bracing and on longitudinal rails and base ends have a partner office will give stowage advice.
lashing as well as stacking. permissible load of 5 000 kg each.
Heavy cargo must rest on the main girder.
Collapsible flatracks, provided with twist- Gooseneck tunnel on both ends of all 40
locks to interlock 4 units into a 86 high flats. Flats are delivered without stanchions.
pile.
The permissible payload of the flat
Collapsible flatracks, provided with spring depends on the resting length of the
assisted endwalls. cargo onto the floor.
Hapag-Lloyd 32
High Cube Flat 40
no stanchions 12 048 11 652 2 320 2 347 2 265 648 55 000 5 900 49 100
pockets 3961/4 3823/4 773/8 783/8 751/8 211/2 121 250 12 900 108 350 HLXU 868 000 869 599 1)
Remarks:
Timber treated according to Australien requirements.
1) Lashing rings 17 each side
Hapag-Lloyd 33
Flat-Collapsible and /or Convertible into a Platform 20/40
ISO Size Type Code: according to Flat Series
Especially for heavy loads and oversized Timber treated according to Australian Special requirements for big and more
cargo. requirements. heavy cargoes, please contact our
special cargo department.
Strong bottom construction. Numerous very strong lashing devices. Solution plans are already worked out
or will be calculated.
Gooseneck tunnel on both ends of all 40 Easy handling/transportation:
platforms. 20 interlocked pile of max. 7 units
40 interlocked pile of max. 4 units
Static load up to 85 000 kg as a 40 Combined height of less than
foundation base. On request available 2 591 mm 86.
Hapag-Lloyd 34
Platform 20/40
Steel container with collapsible flushfolding 6 058 2 438 370 32 500 4 050 28 450
endwalls can be converted to a platform 20 8 121/2 71 650 8 929 62 721 HLXU 368 700 369 499 1)
2 high 40 12 192 2 245 648 45 000 5 700 39 300 FANU 468 400 468 599 2)3)
40 743/8 211/2 99 210 12 570 86 640 HLXU 468 000 469 799 2)3)
Steel container with collapsible flushfolding 12 192 2 245 648 55 000 5 850 49 150
endwalls can be converted to a platform 40 743/8 211/2 121 250 12 900 108 350 HLXU 868 000 869 999 2)3)
Remarks:
1) Fork-lift pockets
2) Useable as a foundation base, static load up to 85.000 kg
on request available
3) Equipped with 2 gooseneck tunnels
Hapag-Lloyd 35
Ventilated Container 20
ISO Size Type Code: 22 V0
Especially for cargo which needs Natural ventilation is provided by openings Numerous lashing devices on the top and
ventilation. in top and bottom longitudinal rails. bottom longitudinal rails and the corner
posts. Lashing devices have a permissible
Fork-lift pockets for loaded containers. The labyrinth construction of these ventila- load of 1000 kg (2205 lbs) each.
tion openings ensures weatherproofness.
Floor Height 170 mm - 5mm
(Ground level to interior floor surfce)
Hapag-Lloyd 36
Ventilated Container 20
Remarks:
10 lashing rings on each top longitudinal rail; particularly suitable for the transport of hanging garments racks.
2) Provided with extra lashing rings/bars for the transport of liner bags in the corner posts adjacent to the corner castings.
3) ISO size type code: 22 V0
Hapag-Lloyd 37
Refrigerated Container (Temperature Controlled Container) 20
ISO Size Type Code: 22 R1, 22 R9
Hapag-Lloyd 38
Refrigerated Container 20
Containers are available for set points as low as -35 C and up to +30 C, please contact your local Hapag-Lloyd office for availability.
5 459 2 295 2 268 2 168 2 291 2 259 30 480 3 050 27 430 28,4
17107/8 763/8 751/4 713/8 761/8 747/8 67 200 6 720 60 480 1003 HLXU 270 500 270 699
5 448 2 290 2 264 2 164 2 286 2 260 30 480 3 060 27 420 28,3
17101/2 761/8 751/8 711/8 76 75 67 200 6 750 60 450 999 HLXU 370 000 370 849
5 534 2 316 2 331 2 231 2 316 2 290 30 480 3 030 27 450 29,9
1817/8 771/8 773/4 733/4 771/8 761/8 67 200 6 680 60 520 1056 HLXU 370 850 371 049
5 529 2 316 2 331 2 290 2 316 2 290 30 480 2 960 27 520 29,9
5 771/8 773/4 761/8 771/8 761/8
Steelframe, 181 /8 67 200 6 530 60 670 1056 HLXU 371 050 371 249
Sandwich 5 535 2 284 2 270 2 224 2 290 2 264 30 480 2 942 27 538 28,7
walls 1817/8 757/8 753/8 731/2 761/8 751/8 67 200 6 490 60 710 1014 HLXU 371 250 374 999
Remarks:
1) Not to be used for foodstuffs.
Hapag-Lloyd 39
Refrigerated Container (Temperature Controlled Container) 40
ISO Size Type Code: 45 R1 High Cube, 42 R9
oyd
Container built and tested to fulfill or even
exceed industrial standards and regulations.
g- Ll
Each single containers certified by leading
classification societies.
...
. .. .
Hapa
State of the art insulation factors.
Low CO2 footprint due to low power ..
..
consuming refrigeration technology.
Only environment friendly refrigerants used.
Container available to maintain temperature
control range as low as -35C up to + 30C
Containers built to maintain temperature in
ambient environment up to 50C. Hygienically designed sealing free container
with side lining protecting scuff lining.
State of the art integrated data logger Containers certified for cold treatment
storing temperatures and events hourly. Please note maximum stowage height in
control (USDA). below tables as indicated red line inside
Advanced fresh air exchange control based ATO-DLO certification e.g.for flower bulb the container in order to ensure proper air
on CO2 available. transportation. circulation
Transfresh option available. Bulb Mode option available. All cargo shall be pre-cooled to match the
Fresh air recording available. On demand defrost avoiding unnessary required in transit temperature.
Controlled fresh air supply with up to heat supply. Technical specification and illustration of
280 cbm/h. Dedicated equipment for non-foodstuff electric plug see page 42.
Mosts reefers with de-humification option cargoes,others solely for foodstuff cargoes. All containers suitable for shore power
equiped. Low tare weight = high payload designed supply like clip-on generators.
MTS multi temp. setting option available. container. Voltages: 380V / 50 Hz to 460V / 60Hz
Hapag-Lloyd 40
High Cube Refrigerated Container 40
Containers are available for set points as low as -35 C and up to +30 C, please contact your local Hapag-Lloyd office for availability.
96 high 11 577 2 286 2 525 2 400 2 286 2 490 34 000 4 110 28 890 66,8 HLXU 476 650 477 999
37113/4 76 833/8 7101/2 76 82 74 950 9 060 65 900 2 366 HLXU 776 000 776 099 1)
11 555 2 294 2 237 2 130 2 294 2 478 34 000 4 060 29 940 66,5
37107/8 761/4 74 611/78 761/4 811/2 74 950 9 480 62 170 2 400 CPSU 500 000 500 327
11 590 2 294 2 554 2 450 2 290 2 569 34 000 4 660 29 340 67,0
381/4 761/4 841/2 83/8 761/8 851/8 74 950 9 350 62 250 2 345 CPSU 510 000 517 298
11 583 2 286 2 532 2 412 2 294 2 550 34 000 4 120 29 880 67,0
38 76 835/8 711 761/4 843/8 74 950 9 080 65 870 2 366 HLXU 478 600 478 999
11 595 2 296 2 542 2 402 2 294 2 550 34 000 4 190 29 810 67,7
381/2 763/8 84 7101/2 761/4 843/8 74 950 9 230 65 720 2 390 HLXU 670 000 670 399
11 595 2 296 2 542 2 402 2 294 2 550 34 000 4 150 29 850 66,8
Steelframe, 381/2 763/8 84 7101/2 761/4 843/8 74 950 9 150 65 609 2 359 HLXU 670 400 677 399
Sandwich 11 595 2 296 2 542 2 402 2 294 2 550 34 000 4 150 29 850 66,8
walls 381/2 763/8 84 7101/2 761/4 843/8 74 950 9 150 65 609 2 366 HLXU 870 000 879 999
Remarks:
1) Not to be used for foodstuffs.
Hapag-Lloyd 41
Electric Plug on Refrigerated Containers
Hapag-Lloyd 42
Change of Temperature setpoint on Refrigerated Containers
Thermo King Carrier
To change the controller setpoint, turn the 1. Press the UP I or DO key
UNIT ON/OFF switch ON. to change the setpoint
(the left display will blink).
Complete the following steps:
2. Press the ENTER
EN key at the
1. Press the S E key. ENTER
desired setting to confirm and
2. Press the F or F key to scroll to TEMP SETP line. exit the selection menu.
Daikin
1. Press the F2 key to scroll to SET-SPC.
Hapag-Lloyd 43
Tank Container 20
ISO Size Type Codes: 20 T5 = 8 high, 22 T0 = 86 high, 22 T5, 22 T6
FOODSTUFFS, e. g.:
Alcohols
Fruit juices
Edible oils National road/rail weight limitations have
Food additives Tanks must not be filled to 100 % of their to be maintained when arranging land trans-
capacity. Sufficient ullage space shall be left ports.
CHEMICAL PRODUCTS, e. g.: which must be deter-mined depending on
Flammables the thermal expansion of the product to be For the cleaning of tanks and disposal of
Oxidising agents carried. residues tariff rules apply. Tanks moving in a
Toxic substances dedicated service are exempted from such
Corrosives Certain dangerous products must be carried rules until the dedication is terminated.
in tanks having no openings below the sur-
Tanks must be filled to not less than 80 % of face level of the liquid. Such tanks must be For more details please contact your
their capacity to avoid dangerous surge/ discharged through a syphon pipe by either nearest Hapag-Lloyd office or agent and
swell during transport. pressure or pumping. let our experience work for you.
Hapag-Lloyd 44
Essential Conversion Factors
Multiply Number of by to optain equivalent
Inches/in 25.4
Number of
Millimetres/mm + 30
C F + 86
Feet/ft 0.3048 Metres/m + 85
Millimetres/mm 0.0394 Inches/in + 80
Metres/m 3.281 Feet/ft + 25
+ 75
Sq. Metres/m 10.7639 Sq. Feet/ft
+ 70
Sq. Feet/ft 0.0929 Sq. Metres/m + 20
Cu. Feet/ft 0.0283 Cu. Metres/m + 65
Cu. Metres/m 35.315 Cu. Feet/ft
+ 15 + 60
Litres 0.0353 Cu. Feet/ft
Cu. Feet/ft 28.317 Litres + 55
Litres 0.2642 U.S. Gallons + 10 + 50
U.S. Gallons 3.785 Litres
+ 45
Litres 0.22 U.K. Gallons
+ 5 + 40
U.K. Gallons 4.5461 Litres
U.K. Gallons 1.2001 U.S. Gallons + 35
U.S. Gallons 0.8327 U.K. Gallons 0 + 32
+ 30
Kilograms/kg 2.2046 Pounds/lb
Pounds/lb 0.4536 Kilograms/kg + 25
5
Long Tons (2240 lb) 1.01605 Tonnes (2204.62 lb) + 20
Tonnes (1000 Kg) 0.9842 Long Tons (1016.05 Kg)
10 + 15
Bar 14.504 PSI
PSI 0.06895 Bar + 10
Inches HG 0.4912 PSI 15 + 5
PSI 2.036 Inches HG
0
Kg/sq. cm 14.223 PSI
20 5
PSI 0.0703 Kg/sq. cm
Kg/sq. cm 0.9807 Bar 10
Bar 1.02 Kg/sq. cm 25
15
Kg/sq. cm 28.976 Inches HG
Inches HG 0.0345 Kg/sq. cm 20
30
Degrees Fahrenheit 5/9, after Degrees Celsius
subtracting 32 (Centigrade)
Degrees Celsius 9/5, and Degrees
(Centigrade) add 32 Fahrenheit
Hapag-Lloyd 45
Container Size Type Codes according to ISO 6346
46 Hapag-Lloyd
Disclaimer:
While we assume that the information and content provided by us is true and correct,
it may, nevertheless, contain errors or inaccuracies.
Hapag-Lloyd does not assume any liability for the accuracy of the information and contents
provided in the brochure, or for the consequences resulting from using the information and
content provided in the brochure. Hapag-Lloyd does not guarantee or represent that said
information and content is exhaustive. Claims as to the exhaustive nature of said information
and content are excluded. The information and content is only provided for advertising
purposes and is non-binding. No explicit or implied warranties or guarantees are made.
Company Headquarters
Hapag-Lloyd AG
Ballindamm 25 20095 Hamburg
Germany
America:
Hapag-Lloyd (America) Inc.
399 Hoes Lane Piscataway, NJ 08854
USA
Asia:
Hapag-Lloyd (Asia) Pte. Ltd.
200 Cantonment Road #08-03 Southpoint
Singapore 089763