Professional Documents
Culture Documents
Ma PP
Ma PP
- There are 3 buttons: Mode, Reset, and Start. (The fourth is the Light button).
The instructions below assume you are in the main "time" screen.
- TIME/CALENDAR: press Mode 2 seconds, then press Mode again but just 1 second. You
will adjust, in this order: seconds, minutes, hours, month, day, day of the week.
In each setting, you press Reset to adjust (it only goes up). Once set, press Start
to move to the next setting.
- 24 h vs. am/pm: press Reset and holding it pressed, press Mode to change from 24
h to am/pm (indicated with a/p on the center top).
- ALARM TIMING: press Mode 2 seconds. Reset moves hours/minutes up. Start changes
from hours to minutes. To exit, press Mode.
- ALARM on/off. Reset shows you the alarm. By holding Reset pressed, press Start to
turn the alarm on/off.
- STOPWATCH. Press Mode one second. To start, press Start. To stop, press Start.
Once stopped, Reset will reset it. Mode will exit.
57 of 59 people found the following review helpful
HASH(0x8b7a29cc) out of 5 stars Directions that I wrote for myself and figured I'd
post ... 18 Dec. 2014
Directions that I wrote for myself and figured I'd post:
Pasnew Watch
Light Start
Mode
Reset
Press Start to move between hour, minute, month, date, and day
Press Reset to move until correct hour, minute, month, date and day are set
(make sure AM or PM for hour are correctly chosen)
Set Alarm
For Chime
Hold Reset and Press Start button until chime only is highlighted
Chime will sound at each hour