Professional Documents
Culture Documents
Pioneer - Plasma - Top10 - Repair - Tips - pdp-433cmx - 434 - Pina La - 1110 PDF
Pioneer - Plasma - Top10 - Repair - Tips - pdp-433cmx - 434 - Pina La - 1110 PDF
MODELS
PDP-433CMX Page 3 (ADDITIONAL INFORMATION) Page 4
PDP-4304HD Page 5
PDP-4314HD Page 5
PDP-4330HD Page 3
PDP-4331HD Page 3
PDP-4340HD Page 5
PDP-502MX Page 6
PDP-505HD Page 6
PDP-503CMX Page 3 (ADDITIONAL INFORMATION) Page 4
PDP-5004HD Page 5
PDP-5014HD Page 5
PDP-5030HD Page 3
PDP-5031HD Page 3
PDP-5040HD Page 5
PRO-910HD Page 5
PRO-910HD Page 5
PRO-1110HD Page 5
1. Red LED slowly blinks 1 time continuously. - Trap switch detect. Unit
powered up with back off and trap switch open.
Unit must be put in factory mode to clear. From standby, Menu, Enter
and Power. (Enter, Display, Power some units).
3. Screen displays E06. - Remove AC, then power on. If still get E06, replace
power supply.
4. Unit shuts down and LED blinks Red or Green. Unit is in protection
mode. See bulletin SK-D03001 to diagnose.
6. Scan ICs are different. - Units originally had SN755860PJ. Units with
serial #s _ _ SS use SN755864APZP.
7. No audio from any input. - Reset media receiver by opening door, hold
down switch while powering on.
8. Unit shuts down, red LED blinks 5 times. - Replace power supply
10. Alternate red and green box on screen. - System cable between panel and
media receiver unplugged.
3
1. Display says out of range. - Unit must have video card to use. Without
card only computer video input can be used.
4
1. Red LED blinks continuously. - Trap switch detect. Unit powered up with
back cover off. - Enter factory service mode, go
2. Factory service mode. - From standby with remote display key, wait 4
seconds, then rapidly with arrow keys left, up, left,
6. Remote doesn't work. - From standby with remote key enter, power and
select SR+ for remote or 232C for RS232.
7. Alternate red and green box on screen.- System cable between media
receiver and panel unplugged.
8. Shuts down and red LED blinks 2 times. - Replace Power Supply Assy.
9. Shuts down and red LED blinks 5 times. - Replace Y Drive Assy.
10. Shuts down and red LED blinks 9 times. - Replace X Drive Assy.
5
1. Won't turn on, green LED blinks 5 times. - Replace Power Supply
5. Menu Items are "Grayed Out" - Unit must sense video at inputs for items
to be selected.
10. Bottom 1/4 of picture is repeated over 3rd 1/4 of picture. - Y Drive Assy.