2.28 The length of the 2-mm-diameter steel wire CD has been adjusted so that
with no load applied, a gap of 1.5 mm exists between the end B of the rigid beam
ACB and a contact point £. Knowing that £ = 200 GPa, determine where a 20-kg
block should be placed on the beam in order to cause contact between B and £.
ai
oaom 1.5 mm.
0.08 m
PROBLEM 2.45
“The rigid bar 4#C is suspended from three wires of the same material. The cross
sectional area of the wire at 3 is equal to half of the cross-sectional area of the
\wites at and C. Determine the tension in each wite caused by the load P shown,
PROBLEM 2.59
Determine (a) the compressive force in the bars shown after a
‘temperature rise of 82°C, (6) the corresponding change in length of |
the bronze bar
@= AHR a= RE OG
PROBLEM 2.68
[A fabric used in air inlated structure is subjected toa biaxial loading
that results in normal stresses @,=120 MPa and o, =160 MPa
Knowing that the propertis of the fabric can be approximated as
E=87 GPa and y=0.M, dotemmine the change in length of (a side 4B,
(0) side BC, (€) diagonal AC.