PROBLEM 6.10
f
For the beam and loading
shown. consider section 2-7
Isom and detenmine (a) the largest
&
"
Lave.
: ir [Shee est ton
h el ONE vig ses a
ee
PROBLEM 6.12
For the beam and loading showa, consider
section ren and determine (2) tho largest shearing
stress in that section, (P) the shearing stress at
point a
SakN Ask
*
cir
ii
PROBLEM 6.18
For the beam and foading shown. determine the
minimum required width 5, knowing that for the
grade of umber used oy-12MPa and
a = 825 KPa.
PROBLEM 6.20
A timber beam 4B of length Zand rectangular cross section canes 2
‘uniformly distributed load w and is supported as shown. (2) Show that
the ratio fp/Oq of the misimm valves ofthe sieaniag aad normal
ssresses i the Beam is equal 19 2h/L, whese fi and L ate especialy.
the depth and the length of the beam. (0) Determine the dept sad
the width 6 of the beam, knowing that Z=5m w= 8kNim.
08 MPa, and cy = 12 MPa
Tf
PROBLEM 6.21
For the beum and loading shown,
consider section nn and determine the
shearing siress at (a) point a, (B) the
‘hearing stess at point
To
PROBLEM 6.24
For the beam snd loading
shown, determine the largest
shearing stress in sectionPROBLEM 6.25
|A beam having the cross section shown is subjected to a vertical shear V. Determine (2) the
‘horizontal line along which the shearing stess 16 maximum, (6) the constant inthe following,
@ ‘Sprenin fri mum ew ts
‘where isthe cross-sectional area ofthe beam
PROBLEM 6.35
‘An extruded aluminum beam has the cross section shown,
‘Knowing that the vertical shear in the beam is 150 IN, determine
the shearing stress at (a) point a, (6) point 6
PROBLEM 6.36
r ‘Am extruded aluminum beam has the cross seetion shown, Knowing that the
APO] rife vertical shear in the beam is 150 KN, determine the shearing stress at
FG) point a. point’
R 0
1
r
PROBLEM 6.37
ait soning thats given vec sheaV cuss 4 main seagate of
‘Supe tras tude eating ego vert show, Secu
thong mente hee pon cea
ie Ie
PROBLEM 6.39 :
6.39 The vertical shear is 5.3 KN in a beam having the
cross section shown, Determine (a) the distanced fT
aunts
te
. i
moe
stress at points a and b4) PROBLEM 6.40
“The extmded heam shown has a uniform wall thickness of 3mm. Knowing that
"the vertical shear inthe beam is 9 KN, determine the shearing stress at each of the
five points indicated,
| |
a
I
PROBLEM 6.41
five points indicated.
yee 6
vol | “Te ext beam shown as uniform wll hikes f 3mm, Knowing that
} the vertical shear in the beam is 9 KN, determine the shearing stress at each ofthe
PROBLEM 6.42
‘Kuowing tht 9 given vestical shear V causes a maximum sheanng stress of
ste Rpm cu am em
_p.. Seeaicashes bane