Professional Documents
Culture Documents
Router>enable
Router#configure terminal
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#hostname R1
R1(config)#enable secret class
R1(config)#line console 0
R1(config-line)#password cisco
R1(config-line)#login
R1(config-line)#exit
R1(config)#line vty 0 4
R1(config-line)#password cisco
R1(config-line)#login
R1(config-line)#exit
Konfigurasi IP Interface
R1(config)#interface se0/0/0
R1(config-if)#ip address 192.168.1.1 255.255.255.252
R1(config-if)#clock rate 64000
R1(config-if)#no sh
R1(config-if)#exit
***
KONFIGURASI R2
Router>enable
Router#configure terminal
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#hostname R2
R2(config)#enable secret class
R2(config)#line console 0
R2(config-line)#pass cisco
R2(config-line)#login
R2(config-line)#exit
R2(config)#line vty 0 4
R2(config-line)#pass cisco
R2(config-line)#login
R2(config-line)#exit
R2(config)#interface fa0/0
R2(config-if)#ip address 192.168.3.254 255.255.255.0
R2(config-if)#no shutdown
R2(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
R2(config-if)#exit
R2(config)#interface se0/0/1
R2(config-if)#ip address 192.168.1.2 255.255.255.252
R2(config-if)#no sh
R2(config-if)#
%LINK-5-CHANGED: Interface Serial0/0/1, changed state to up
R2(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/1, changed state to up
R2(config-if)#exit
R2(config)#router rip
R2(config-router)#version 2
R2(config-router)#network 192.168.3.0
R2(config-router)#network 192.168.1.0
***
PERIFIKASI KONFIGURASI
1. Tampilkan konfigurasi yang sedang berjalan pada tiap router dengan printah show running-
config
2. Temukan hostname, password, ip address dan protokol routing pada router yang telah di
konfigurasi
3. Ping PC2 dari Command Prompt PC1
4. Trace the network path atau mengecek jalur network dari PC1 ke PC2 (PC>tracert
192.168.3.3)
REFLEKSI
Pertanyaan :
1. Apa Perintah yang digunakan untuk masuk ke interface Fast Ethernet 0/0, dari pertama masuk
di mode user?
2. Pada Router, interface mana yang harus di konfigurasi clock rate-nya? (DCE or DTE)
Jawab :
1. Router>enable
Router#configure terminal
R2(config)#interface fa0/0
2. DCE