Professional Documents
Culture Documents
ACC307 Individual Assignment
ACC307 Individual Assignment
1
Assignment: Acoustics and Noise Control (Jan-Apr 2017)
During an urban design, the buildings can be constructed in certain ratio to prevent noise
propagation, from one region to another. Consider the twin-tower building structures can
be modeled as follows:
U is the upstream velocity of the noise source, a is the distance/length of the building
section as prescribed, while is a real number with the range of 0.5 1.5. The
governing equation for this case is the two dimensional wave equation, given as:
2 2
2 2
= ( + )
2 2 2
where t is time, x and y are the spatial components, while u is the speed of mechanical
displacement.
2
Assignment: Acoustics and Noise Control (Jan-Apr 2017)
In a report NOT MORE THAN 20 PAGES (only cover page and appendix can be
excluded), include the following details:
- COVER PAGE-
4. Discussion of Results***
5. Conclusion
-APPENDIX-
* The introduction shall at least include: (1) the importance of noise control; (2) roles of
acoustics in urban planning; (3) description of project.
** You may use other method other than explicit solution, such as Runge-Kutta method
and implicit methods. Kindly refer to "Chapra and Canale (2010). Numerical Methods for
Engineers, 6th Ed. Mcgraw Hill Higher Education" or any other numerical/computational
textbook for more information.
*** Discussion of the results shall at least include: (1) the description of relationship
between and u; (2) suggestion on how to reduce noise; (3) laws/precautions in pre-empt
noise pollution.
Note:
3
Assignment: Acoustics and Noise Control (Jan-Apr 2017)
4
Assignment: Acoustics and Noise Control (Jan-Apr 2017)
Note: Space one line before and after every figure or/and table. The figure(s)
must be clear to be seen.
8. Equations: See examples
2 2 2
= 2 ( 2 + 2 ) (1)
2
[1] Chen, Shiyi, and Gary D. Doolen. "Lattice Boltzmann method for fluid
flows."Annual review of fluid mechanics 30, no. 1 (1998): 329-364.
[2] Bejan, Adrian. Convection heat transfer. John wiley& sons, 2013.
[3] Tamura, I., Y. Tomota, and M. Ozawa. "Strength and ductility of Fe-Ni-C
alloys composed of austenite and martensite with various strengths." In
Proc. Conf. on Microstructure and Design of Alloys, Institute of Metals
and Iron and Steel Institute, London. 1973, 1,(129): 611-615. 1973.