Professional Documents
Culture Documents
(2)
(1)
Page 1 of 8
(to next
Picture)
Page 2 of 8
3 Download to PLC
Connect PLC to PC by USB cable
(USB driver might need to be installed: the Driver is stored at Path as below picture)
Page 3 of 8
Step 2. Config IP address at PC
Page 4 of 8
Step 2. Install MX Component and test communication PC to PLC
Install MX Component (Software from Mitsubishi) which helps to
connect Mitsubishi PLCs with the Microsoft PC world
The Software should be purchased from Mitsubishi (~500USD)
Following steps are how to config MX Component and test communication PC to PLC
1 Click [Start] -> [All Programs] -> [MELSOFT -> Application] -> [MX Component]
-> [Communication Setup Utility]
(You might need right click, choose "Run as Administrator" to
[Communication Setup Utility])
3 After the screen shown, set "Logical station number" to "1" and click the [Next>] button
Page 5 of 8
4 Set as below
5 Set as below
Page 6 of 8
6 Set as below
7 Click to [Finish]
8 When the setting is completed, the "Communication Setup Utility" screen appears
Page 7 of 8
9 Testing
Page 8 of 8