Professional Documents
Culture Documents
Note:
1. Plotter’s two connection methods: USB and LAN.
USB CONNECTION
1. Run “PLOTSETUP” file, finish control center installation. While
Type” as USB.
1
SINAJET TECH
2. Click “Finish” and wait for a few seconds for USB driver
picture showed:
2
SINAJET TECH
model showed on the lower left corner, plotter can work normally.
3
SINAJET TECH
LAN CONNECTION
There are two different connection methods with LAN connection:
Setup Wizard
LAN cable. Open control center, in case the green light is on and
plotter model showed on the lower left corner, plotter can work
normally.
by “setup wizard”.
same HUB
4
SINAJET TECH
Type” as USB.
(2). Click “Finish” and wait for a few seconds for USB driver
5
SINAJET TECH
USB cable. You will see reminder as “The computer detects new
picture showed:
6
SINAJET TECH
(5). Open control center, make sure the plotter is online (the green
picture showed:
7
SINAJET TECH
(6) Connect computer to the HUB and check your company’s “IP
program----Appendix-----Command Prompt”
you will see the Local Network IP Address, Below picture shown
picture showed:
8
SINAJET TECH
Click “Save”. “Do you want to change the plotter network address
inside red line is the same as computer data (inside red line).
But IP address last data can not be the same (data between
0-255), this data also must be different from any other device’s
(9) Disconnect the USB cable. Connect the plotter and HUB with
model showed in the lower left corner. Then plotter can work
normally.
10