Professional Documents
Culture Documents
CONCORD TABLE
legs, and sand the curves on a time to set up. Make sure the bot
drum sander. toms of the legs are square to the
5. Drill 3/8"-diameter holes to ac outside of the spindle.
commodate the dowels in the legs 9. Glue and clamp the stock for
as shown. the top (B). When the glue has
6. Use a router with a 1/4" round dried, lay out the 16"-diameter cir
ing over bit to shape the curved cle and cut it out using a scroll saw,
edges of the legs. Do not shape the bandsaw, or jigsaw.
straight sections. 10. Disc sand the edges of the top.
7. On the drum sander, sand a The top edge can be shaped with a
concave curve in the straight por router and a roman ogee bit.
tion of the legs. This will provide a 11. Drill a 1"-diameter hole in the
better fit when attaching the legs center of the top brace (D) to ac
to the spindle. commodate the dowel.
8. Mark and drill two 3/8"-diame- 12. Screw the top brace to the
ter holes in the spindle base as spindle, then screw the top to the
shown to accommodate the dow top brace. Glue can be used for
els. Glue the legs to the spindle, extra reinforcement.
one at a time, and allow each leg 13. Finish the table as desired.