Professional Documents
Culture Documents
Color Monitor: Service Manual
Color Monitor: Service Manual
com
E-mail:http://www.LGEservice.com/techsup.html
COLOR MONITOR
SERVICE MANUAL
CHASSIS NO. : CL-82
MODEL: L1717S (L1717S-SNN.AN**EP)
L1717S (L1717S-BNN.AN**EP)
L1717S (L1717S-GNN.AN**EP)
( ) **Same model for Service
CAUTION
BEFORE SERVICING THE UNIT,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
- +
SPECIFICATIONS
1. LCD CHARACTERISTICS 4. Max. Resolution
Type : TFT Color LCD Module D-sub Analog : 1280 x 1024@75Hz
Active Display Area : 17 inch
Pixel Pitch : 0.264 (H) x 0.264 (V) 5. POWER SUPPLY
Color Depth : 16.2M Colors 5-1. Power : AC 100~240V, 50/60Hz , 0.6A
Size : 358.5 (H) x 296.5 (V) x 17.0(D)
Electrical Interface : LVDS 5-2. Power Consumption
Surface Treatment : Hard-coating(3H), Anti-Glare
Operating Mode : Normally White, Transmissive mode MODE H/V SYNC VIDEO POWER CONSUMPTION LED COLOR
Backlight Unit : Top/Bottom edge side 4-CCFL POWER ON (NORMAL) ON/ON ACTIVE less than 35 W GREEN
(Cold Cathode Fluorescent Lamp)
OFF/ON
2. OPTICAL CHARACTERISTICS SLEEP MODE ON/OFF OFF less than 1 W AMBER
2-1. Viewing Angle by Contrast Ratio 10
OFF/OFF
Left : -60 min., -70(Typ) Right : +60 min., +70(Typ) POWER S/W OFF - - less than 1 W OFF
Top : +60 min., +75(Typ) Bottom : -50 min., -65(Typ)
2-3. Contrast Ratio : 350(min), 600(Typ) 6-1. Operating Temperature: 10C~35C (50F~95F)
(Ambient)
3. SIGNAL (Refer to the Timing Chart) 6-2. Relative Humidity : 10%~80%
3-1. Sync Signal (Non-condensing)
Type : Separate Sync, Composite, 6-3. MTBF : 50,000 HRS with 90% Confidence
SOG (Sync On Green) Lamp Life : 50,000 Hours(Min)
-2-
TAKE CARE DURING HANDLING THE LCD MODULE Leakage Current Hot Check Circuit
WITH BACKLIGHT UNIT.
AC Volt-meter
Must mount the module using mounting holes arranged
in four corners.
Do not press on the panel, edge of the frame strongly
or electric shock as this will result in damage to the Good Earth Ground
such as WATER PIPE,
screen. CONDUIT etc.
To Instrument's
Do not scratch or press on the panel with any sharp exposed
METALLIC PARTS
objects, such as pencil or pen as this may result in
damage to the panel.
1.5 Kohm/10W
Protect the module from the ESD as it may damage the
electronic circuit (C-MOS).
Make certain that treatment persons body are
grounded through wrist band.
Do not leave the module in high temperature and in
areas of high humidity for a long time.
The module not be exposed to the direct sunlight.
Avoid contact with water as it may a short circuit within
the module.
If the surface of panel become dirty, please wipe it off
with a softmaterial. (Cleaning with a dirty or rough cloth
may damage the panel.)
CAUTION
Please use only a plastic screwdriver to protect yourself
from shock hazard during service operation.
-3-
-4-
-5-
-6-
VIDEO
A
E
D B
SYNC
C
-7-
#5 #6
#7
-8-
5V 5V 3.3V1
R,G,B LVDS
differential (Low Voltage
Differential
1.8V TSU16AL
including
-9-
(ADC/LVDS/SCALER MTV312
3.3V1
/INPUT SWITCHING MICOM
12V 5V
/TMDS )
BLOCK DIAGRAM
AC I nput LIPS
R,G,B, H/ V Sync
D-SUB
DESCRIPTION OF BLOCK DIAGRAM
2. Power Part.
This part consists of the one 3.3V, and one 1.8V regulators to convert power which is provided 5V in Power board.
12V is provided for inverter, 12V is provided for LCD panel and 5V for micom.
Also, 5V is converted 3.3V and 1.8V by regulator. Converted power is provided for IC in the main board.
The inverter converts from DC12V to AC 700Vrms and operates back-light lamps of module.
3. MICOM Part.
This part is include video controller part. And this part consists of EEPROM IC which stores control data, Reset IC
and the Micom.
The Micom distinguishes polarity and frequency of the H/V sync are supplied from signal cable.
The controlled data of each modes is stored in EEPROM.
- 10 -
12V
50 ~ 60Hz
HVDC 100KHz 5V
EMI INPUT RECTIFIER ENERGY OUTPUT RECTIFIER
COMPONENTS AND FILTER TRANSFER AND FILTER
LINE GND
100 ~ 240V
PRIMARY SECONDARY
Operation description_LIPS
1. EMI components.
This part contains of EMI components to comply with global marketing EMI standards like FCC, VCCI CISPR, the
circuit included a line-filter, across line capacitor and of course the primary protection fuse.
3. Energy Transfer.
This part function is transfer the primary energy to secondary through a power transformer.
5. Photo-Coupler isolation.
This part function is to feed back the dc output changing status through a photo transistor to primary controller to
achieve the stabilized dc output voltage.
6. Signal collection.
This part function is to collect the any change from the dc output and feed back to the primary through photo
transistor.
- 11 -
1. Port Setup
a) Copy UserPort.sys file to
c:\WINNT\system32\drivers folder
b) Run Userport.exe
- 12 -
1) Turn off the power switch at the front side of the display.
2) Wait for about 5 seconds and press MENU, POWER switch with 1 second interval.
3) The SVC OSD menu contains additional menus that the User OSD menu as described below.
a) Auto Color : W/B balance and Automatically sets the gain and offset value.
b) NVRAM INIT : EEPROM initialize.(24C08)
c) CLEAR ETI : To initialize using time.
d) AGING : Select Aging mode(on/off).
e) R/G/B-9300K : Allows you to set the R/G/B-9300K value manually.
f) R/G/B-6500K : Allows you to set the R/G/B-6500K value manually.
g) R/G/B-Offset : Allows you to set the R/G/B-Offset value manually.(Analog Only)
h) R/G/B-Gain : Allows you to set the R/G/B-Gain value manually.(Analog Only)
i) MODULE : To select applied module.
IBM 9 6
Video Signal 5 1
Compatible PC 15 11
Generator 10 6
5 1
C
PARALLEL PORT
ed
13 1
us
2C
t
25
No
14
23
RS
OFF ON
5V
EL
Control Line
F
LL
C
RA
PA
VG ON
WE
S 5V
(110V/220V)
PO
E 74LS06
A
ST
NI
TO
Y
V-S
R
74LS06
E ST Switch
B
B
F V-Sync On/Off Switch
(Switch must be ON.)
- 13 -
NO POWER
(POWER INDICATOR OFF)
YES
YES NO PROBLEM
IS U201
NO
PIN90 (3.3V) CHECK 3.3V LINE
VOLTAGE ?
YES
YES
CHECK U201
Waveforms
1 U201-#96
- 14 -
NO RASTER
(OSD IS NOT DISPLAYED)
YES
1. CONFIRM BRIGHTNESS
J705 PIN10 NO OSD CONTRL STATE.
5V? 2. CHECK MICOM DIM-ADJ
PORT
YES
CHECK
PULSE AS
CONTACTING SCOPE
PROBE TO CAUTION LABEL. NO
(CONTACT PROBE TO LIPS
CAUTION LABEL.
CAN YOU SEE PULSE
AT YOUR
SCOPE?
YES
- 15 -
NO RASTER
(OSD IS NOT DISPLAYED)
YES
YES
U501
PIN43 IS 48KHz H-SYNC?
NO CHECK CONNECTION LINE
2 PIN44 IS 60Hz V-SYNC?
FROM D-SUB TO U501
IS PULSE APPEARED
AT SIGNAL PINS?
AT MODE 12?
YES
TROUBLE IN CABLE
OR LCD MODULE
Waveforms
1 U201-#96, 97 2 U501-#43 H-SYNC 2 U501-#44 V-SYNC
- 16 -
TROUBLE IN DPM
CHECK CHECK PC
NO PC IS NOT GOING
3 R216, R217
R778, R781 INTO DPM OFF MODE
YES
CHECK
U501 PIN 43.44 NO
CHECK H/V SYNC LINE
SYNC PULSE ?
YES
TROUBLE IN U501
Waveforms
3 R216, R778 H-Sync 3 R217, R781 V-Sync
- 17 -
POWER
MAIN
CONTROL
- 18 -
090
100
080
EXPLODED VIEW
070
040
060
020
050
010
110
- 19 -
3091TKL178D CABINET ASSEMBLY, L1717S BRAND L155 SILVER TCO99 C-CKD-WA LOCAL-For Europe,U.K
3091TKL178G CABINET ASSEMBLY, L1717S BRAND L155 SILVER AU VER.-DI LOCAL-For Austrailia
3091TKL178B CABINET ASSEMBLY, L1717S BRAND L178 BLACK - A CKD-WA LOCAL-For Europe,U.K
3091TKL178F CABINET ASSEMBLY, L1717S BRAND L155 GRAY TCO99 E-CKD-WA LOCAL-For Europe.U.K
020 6304FLP275A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-TLA3 LG PHILPS TFT COLOR P5,645CH,250NITS,8MS,LPL NJ/KUMI,PB FREE,EGI,MAGNA S D-IC,EGI,SXGA
or 6304FLP199A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-A6K3 LG PHILPS TFT COLOR 8MS,LPL NJ/KUMI,PB FREE,EGI,SS S D-IC,EGI,250NITS,SXGA,LVDS
6304FLP274A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-TLA1 LG PHILPS TFT COLOR P5,645CH,250NITS,8MS,LPL NJ/KUMI,PB FREE,EGI,OKI S D-IC,EGI,SXGA,L
or 6304FLP280A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-TLA4 LG PHILPS TFT COLOR P6,645CH,250NITS,8MS,LPL NJ/KUMI,PB FREE,EGI,MAGNA,S D-IC,EGI,SXGA
or 6304FLP279A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-TLA2 LG PHILPS TFT COLOR P6,645CH,250NITS,8MS,LPL NJ/KUMI,PB FREE,EGI,OKI S D-IC,SXGA,LVDS
or 6304FLP275A LCD(LIQUID CRYSTAL DISPLAY), LM170E01-TLA3 LG PHILPS TFT COLOR P5,645CH,250NITS,8MS,LPL NJ/KUMI,PB FREE,EGI,MAGNA S D-IC,EGI,SXGA
030 3809TKL123D BACK COVER ASSEMBLY, L1717S L125 HF350 BK - DI LOCAL-For Europe,Austrailia,U.K
3809TKL123B BACK COVER ASSEMBLY, L1717S L125 HF350 BK - A CKD-WA LOCAL-For Europe,U.K
3809TKL123A BACK COVER ASSEMBLY, L1717S L125 HF350 BK-NT LOCAL-For Russia
040 3043TKK264E TILT SWIVEL ASSEMBLY, L1717S BK W/O BC ASSY - DI LOCAL-For Europe,Austrailia,U.K
3043TKK264C TILT SWIVEL ASSEMBLY, L1717S BK WITHOUT BC ASSY - B CKD-WA LOCAL-For Europe, U.K
060 3313TL7083F MAIN TOTAL ASSEMBLY, L1730SN MST E DI LOCALCKD BRAND CL-82 LF-For Europe,Austrailia,U.K
3313TL7083C MAIN TOTAL ASSEMBLY, L1730SN MSTAR - 10 LANGUAGE NT LOCAL CKD BRAND CL-82 LF-WA-For Europe,U.K,Russia
070 6871TPT312B PWB(PCB) ASSEMBLY,POWER, L1750** UNION POWER TOTAL BRAND 4-LAMP(17/19) SOCKET TYPE
or 6871TPT282G PWB(PCB) ASSEMBLY,POWER, M-CHASSIS 1719 SOCKET,2PIN,450V POWER TOTAL LIEN CHANG PB FREE
110 6871TSTA92D PWB(PCB) ASSEMBLY,SUB, L1717S CONTROL TOTAL BRAND DI LOCAL CKD LF-For Europe,Austrailia,U.K
6871TSTA92B PWB(PCB) ASSEMBLY,SUB, L1717S CONTROL TOTAL BRAND NT LOCAL CKD LF-WA-Europe,U.K,Russia
- 20 -
- 21 -
R522 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R4 0RD2001Q609 2K OHM 1/4 W(3.4) 5.00% TA52
R523 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP R5 0RD2001Q609 2K OHM 1/4 W(3.4) 5.00% TA52
R530 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP SW1 140-058E SKHV10910B LGEC NON 12V 20A
R534 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP SW2 140-058E SKHV10910B LGEC NON 12V 20A
R535 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP SW3 140-058E SKHV10910B LGEC NON 12V 20A
R537 0RJ3301D677 3.3K OHM 1/10 W 5% 1608 R/TP SW4 140-058E SKHV10910B LGEC NON 12V 20A
R543 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP SW5 140-058E SKHV10910B LGEC NON 12V 20A
R544 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP ZD1 0DZ560009AG GDZJ5.6B TP GRANDE DO-34 500
R545 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP ZD2 0DZ560009AG GDZJ5.6B TP GRANDE DO-34 500
R547 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP LED1 0DLLT0089AA LITEON LTL-1BEDJ-0C2 TP GREE
R548 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
R549 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
R555 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R557 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R560 0RJ1501D677 1.5K OHM 1/10 W 5% 1608 R/TP
R701 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R702 0RJ2001D677 2K OHM 1/10 W 5% 1608 R/TP
R703 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R704 0RJ2001D677 2K OHM 1/10 W 5% 1608 R/TP
R706 0RJ0752D677 75 OHM 1/10 W 5% 1608 R/TP
R708 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP
R709 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP
R712 0RJ0102D677 10 OHM 1/10 W 5% 1608 R/TP
R716 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R717 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R720 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R722 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R723 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
R724 0RJ0332D677 33 OHM 1/10 W 5% 1608 R/TP
R726 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
R727 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
R737 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R744 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R747 0RJ4701D677 4.7K OHM 1/10 W 5% 1608 R/TP
R751 0RJ4700D677 470 OHM 1/10 W 5% 1608 R/TP
R752 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R753 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R754 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R755 0RJ1000D677 100 OHM 1/10 W 5% 1608 R/TP
R769 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R778 0RJ0682D677 68 OHM 1/10 W 5% 1608 R/TP
R781 0RJ0682D677 68 OHM 1/10 W 5% 1608 R/TP
R803 0RH0000D622 0 OHM 1 / 10 W 2012 5.00% D
R804 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
R805 0RH2000D622 200 OHM 1 / 10 W 5% D R/TP
R806 0RH2000D622 200 OHM 1 / 10 W 5% D R/TP
R808 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R816 0RJ1002D677 10K OHM 1/10 W 5% 1608 R/TP
R820 0RJ0000D677 0 OHM 1/10 W 5% 1608 R/TP
R821 0RH0000D622 0 OHM 1 / 10 W 2012 5.00% D
R824 0RJ0272D677 27 OHM 1/10 W 5% 1608 R/TP
R825 0RJ2000D677 200 OHM 1/10 W 5% 1608 R/TP
OTHERs
CONTROL BOARD
- 22 -
1. TSU56AL / TSU16AL
3
1
U201-#96, 97
Waveforms
1
3
R216, R778 H-Sync
3
R217, R781 V-Sync
- 23 -
2
U501-#43 H-SYNC
Waveforms
2
U501-#44 V-SYNC
- 24 -
- 25 -
3
R216, R778 H-Sync
Waveforms
3
R217, R781 V-Sync
- 26 -