Professional Documents
Culture Documents
Procast Short Tutorial PDF
Procast Short Tutorial PDF
- Create 3D models
- Mesh
- Precast
- Run
- Viewcast
1. Create 3D models
2.Mesh.
Perform detailed mesh in turn drew.
The mesh is the most difficult stages of procast
When meshing need to pay attention to your product
For example:
Your casting edges, or into such 1mm thick.
the grid can not be> 1 mm.
Because the mesh will fail.
But smaller mesh than the machine running slowly. So the grid mesh size depends on how much detail
and the ability of your computer.
Mesh lower die
---------------------
Determining heat transfer mold casting (interface)
------------------------
Determination of boundary conditions, such as temperature, velocity on heat transfer metal mold
environment, temperature cooling system .....
-----------------------------------
Set the gravitational acceleration
------------------
Set initial conditions: initial temperature of the mold, casting .... .. ..
---------------
Set to run the simulation conditions: flow, cycles, stress, or micro-structure
-----------------
Shrinkage Porosity
------------------------------------------------------------------------------------------------