You are on page 1of 6
10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps Login Contact Us answer Heavy Equipment ‘Askan Expert » Car Questions.» Heavy Equipment Repair Ahino dutro 2005 that has a fault code P1227..straight back..tps Resolved Question: Ihave a hino dutro 2005 that has a fault code P1227, when i clear it it comes straight back, the engine has de rated, will this be the tps? I haven't got access to the computer, that | cleared the code with this morning. Any ideas, would be appreciated, as I need the truck monday morning, our nearest hino dealer is 330km away Share this conversation Expert: Rudolph Diesel Chat Conversation Started Rudolph Diesel Hello Welcome to JA! Rudolph Diesel | will switch to Q@A Ask Your Own Heavy Equi ment Questi Expert: Rudolph Diesel Here is what to check ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl 6 10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps DTC P1227, Accelerator Pedal Position (APP) SENSOR Procedure for confirmation of DTC ‘Switch off ignition and wait for 10 seconds. At idle the battery voltage should be more than 10V. With Consult Il Without Consult II ‘Switch on ignition. Start and idle engine for 1 second. Choose Data Monitor mode. Switch off ignition, wait for 10 seconds and switch on again Start and idle engine for 1 second. With ECM conduct Diag Test Mode II, Self Diag Results DTC > Diagnostic Procedure. DTC > Diagnostic Procedure. Remember when measuring the input or output voltage, the ECM ground terminals are not to be used. Procedure for diagnosis Check the followin: Screws ‘Switch off ignition: Slacken and tighten the bodt ground screws. Power Supply Circuit to APP Sensor 2 Disconnect the harness connector to the APP sensor. Switch on igr n Between APP sensor terminal 5 and ground, check voltage (approx 5V) OK: skip the next step. NG: proceed to the next step. ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl 10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps Fi Set up an appointment to connect with a Heavy in Equipment Mechanic Welcome! How can | help with your equipment question? Fe s\ Di = B y. TI Fy OK: skip the next step. NG: proceed to the next step. Find the malfunction, check In Dutro models harness connectors M71, M201. harness connectors M1, E101. For open/short in harness between ECM and APP sensor. Repair open/short to ground/power in harness/connectors. For open & short in the APP Sensor 2 Input Signal Circuit Between ECM terminal 98 and APP sensor terminal 6, check hamess continuity, There should be continuity. For short to ground and power, check harness. OK: skip the next step. NG: proceed to check APP sensor. ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl 10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps Find the malfunction, check In Duter models harness connectors M71, M201. harness connectors M1, £101. For open/short in hamess between ECM and APP sensor. Repair open/short to ground/power in harness/connectors The component - APP Sensor OK: check Intermittent Incident. NG: replace APP Sensor. Inspection of the component: Accelerator Pedal Position Sensor Connect all the hamess connectors. Switch on igni n Between ECM terminal 106 sensor 1 signal and engine ground terminal 98 sensor 2 signal and engine ground check voltage as follows: Terminal Accelerator pedal Voltage 106APP Sensor 1 Fully released 0.6 - 0.9V Fully depressed 3.9 - 4.7V 98 APP Sensor 2 Fully released 0.3 - 0.6V Fully depressed 1.95 - 2.4V IF not good then replace the accelerator pedal assembly switch Ihave seen more of the APP sensor be the problem your having, ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl 10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps Let me know if i can help more! RD Rudolph Diesel, ASE ,Master Heavy Truck Technichian Category: Heavy Equipment Satisfied Customers: 1942 Experience: 25 YEARS OF HEAVY EQUIPMENT REPAIRS Rudolph Diesel and other Heavy Equipment Specialists are ready to help you Share this conversation Ask Rudolph Diesel Your Own Question Rudolph Diesel, ASE ,Master Heavy Truck Technichian Category: Heavy Equipment Satisfied Customers: 1942 Experience: 25 YEARS OF HEAVY EQUIPMENT REPAIRS ‘Type Your Heavy Equipment Question Here... Rudolph Diesel is online now Get an Answer Disclaimer: Information in questions, answers, and other posts on ths site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc), orto establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third- party service, please click on the “Verified” symbol in some Experts’ profiles. JustAnswer is not intended or designed for EMERGENCY ‘uestions which should be directed immediately by telephone or in-person to qualified professional ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl 56 10820%6 ‘Aino dro 2005 at has a fault code P1277 straight back. ps mor: (3 Ea @ Cee) Cm Contact Us | Terms of Service | Privacy & Security | About Us | Our Network | Sitemap © 2003-2016 JustAnswer LLC ip hvu justanswer com Mneavy-oquipmenlé25i-tine-duiro- 2005 aul cade-p1227-saigh-back-tps. Hl

You might also like