Professional Documents
Culture Documents
Vol30 Beest PDF
Vol30 Beest PDF
Assembling the Body 5. Connect the left leg and crank together with a single-
action rod (small) (E).
Frame
Upper
[1] Assembling the legs of the Mini Strandbeest [2] Attaching the crank to the legs Attach (E) to the upper
joint (E)
joint on the left leg, and
1.Attach the rubber feet to the ends of the lower triangles 2.Attach a connecting rod (large) (C) to an upper triangle 1. Attach the crankshaft to the frame (G). then push it onto the
(A). (B). crank that was attached
Insert the crankshaft into in Steps 2, 3, and 4 until
Line a rubber foot up with the slit on the Attach the larger joint (B) the slot in the middle of Protrusion it snaps into place. Make
end of one of the lower triangles (A), and on (C) to the largest the frame. There are three Frame
on joint sure to position the
then use the shaft (short) to push the rubber joint on (B), and then protrusions on the frame
(A) newly attached rod so
foot into the hole to attach it. Adjust the rotate (C) 90 and a protrusion on the Protrusion that it is in front.
position of the rubber foot so that it lines up downward. joints at each end of the
with the middle of the slit. Do the same for Left leg
crankshaft. Make sure
all twelve lower triangles (A) to attach a that the protrusion on the
Line the notches on Right leg
rubber foot to each. Protrusions
crankshaft is facing in the
(C) up with the
Notches same direction as those on Protrusion on
protrusions on (B) to
After inserting a rubber foot attach (C) to (B). the frame. Make two sets joint Once you have attached both legs, check to make sure that the rods
Rubber foot (C) like this. attached to the crank are in the order of upper left, lower right, lower left,
partway, push it all the way in
and upper right, as seen from the front. If the order is different, the legs
using the shaft (short). Crankshaft may not move smoothly.
6. Attach the second frame. 2. Insert the shafts (long) into the frames. 2. Insert the cogwheel shaft into the body.
Attach the second frame Insert the shafts (long) into the holes on the frames shown in the diagram. Insert the cogwheel shaft into two frames on the body. Once you have
firmly to the first frame, so
Second frame
Adjust the shafts (long) so that they stick out on either end by a small amount. inserted it into the second frame, turn the cogwheel shaft 90 so that it Finished
as to sandwich the legs that After completing these adjustments, pull on each rubber band loop and hook snaps into place.
you put together in Steps 2 them around the
Joints
to 5. Line up the three ends of the frames.
joints on the frames, and
position the slot in the
middle of the frame so that
it snaps into place on the Cogwheel shaft
central axis of the
crankshaft.
Shaft (long)
Crankshaft