Professional Documents
Culture Documents
Service Table PDF
Service Table PDF
Service tables
The following chapter contains the well-known service tables with
the service specifications of the Volkswagen brand. Since, in the
past, individual service specifications were set up in various
markets, mostly through severe operating conditions, these are
listed in service tables with specific deviations.
Service tables → Chapter
Service tables with market-specific deviations → Chapter
Note
For combined kilometre and time display applies: whichever
occurs first.
Depending on conditions under which the vehicle is used
→ Chapter and vehicle equipment, extra service work must be
performed in addition to the interval service, inspection service
or interval service inspection.
It is also possible, to perform additional work outside the
service intervals with regard to the entries in the service
schedule (or sticker: your next service).
Service tables
Service intervals → Anchor.
VW engine oil standards → Anchor
Filter change intervals → Anchor
Caution
Only applies to diesel engines:
In some countries the sulphur content in diesel fuel
exceeds 2000 ppm.
The high sulphur content leads to excessive wear of
cylinders and it considerably reduces the cleanliness
of pistons.
Therefore, in countries with elevated sulphur content in
diesel fuel, change engine oil and fuel filter every 7,500
km.
Your importer will inform you about countries with
elevated sulphur content in diesel fuel.
Note
For extremely uneconomical driving style or use under extreme conditions → Chapter, the shortest interval
for an oil change service or interval service is “15,000 km or 1 year”.
However, other intervals apply for other countries. Your importer will inform you about this.
PASSAT 3C
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 2 of 7
Note
For combined kilometre and time display applies: whichever
occurs first.
VW engine oil standards
Caution
Only engine oils approved by VW may be used, up-to-date
information → ServiceNet, Technical information,
Inspections and Servicing, Approved oils, or ask your
importer.
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 3 of 7
Note
Vehicles with retrofitted diesel particulate filter are allocated in the
table to diesel engines without diesel particulate filter. Vehicles
with diesel particulate filter (factory-fitted) can be identified by PR
No. 7GG or 7MB on the vehicle data sticker.
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 4 of 7
1)A new engine oil filter must be installed at every engine oil change.
2)Only applies to diesel engines: In some countries the sulphur content in diesel fuel exceeds 2000 ppm. The
high sulphur content leads to excessive wear of cylinders and it considerably reduces the cleanliness of
pistons. Therefore, in countries with elevated sulphur content in diesel fuel, change engine oil and fuel filter
every 7,500 km. Your importer will inform you about countries with elevated sulphur content in diesel fuel.
Toothed belt change intervals
If the engine is fitted with toothed belt or timing chain can be found in the engine list.
Note
The camshaft drive with timing chain is maintenance-free!
Note
For technical reasons it is possible that several cross references are not directed to the correct chapter. In this
case select the procedure manually in the information.
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 5 of 7
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 6 of 7
Note
This chapter only provides information on market-specific
deviations. This means that all maintenance points that are not
shown here are to be found in the normal service tables.
Russian market from model year 2010
Interval Description
of work
Every 15,000 km →
Interval service (QG0/QG2)
Maintenance
(appears on service interval display) or 1 year 1)
tables
Every 30,000 km →
Inspection service
Maintenance
(does not appears on service interval display) or 2 years 1) tables
Every 15,000 km
– Dust and pollen filter (cabin filter): Renew → Chapter
or 1 year 1)
Every 30,000 km
– Spark plugs: Renew → Chapter
or 2 years 1)
– Fuel filter: Renew Every 30,000 km → Chapter
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011
Service tables Page 7 of 7
– Air filter element: Check and renew, if necessary, and clean Every 30,000 km
→ Chapter
housing or 2 years 1)
– Camshaft drive toothed belt: Renew
Every 90,000 km → Chapter
Only valid for 2.0 l TFSI
Interval Description
of work
– Sliding sunroof drains: Check flow and clean if necessary Every 60,000 km → Chapter
vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3 04.03.2011