Professional Documents
Culture Documents
Sheet 1 PLC PDF
Sheet 1 PLC PDF
3. A ship’s engine must be capable of being stopped and started from both the
bridge (S1 and S3) and from the engine room (S2 and S4). The relay control
(contactor control) for this operation is shown in the figure below, where
contactor K1 connects the main power supply to the engine. Explain how the
control functions. Draw the logical diagram
Page 1 of 3
4. Complete the following ladder logic diagram so that: the indicator lamp
energizes if and only if both switch A and switch B are simultaneously
actuated.
5. Complete the following ladder logic diagram so that: the indicator lamp
energizes if either switch A or switch B is actuated.
6. Draw the relay logic diagram for a circuit that operates as follows:
a) One motor and one pilot light are to be controlled in a control circuit.
b) Use two start pushbuttons and two stop pushbuttons. Pressing any one of
the start pushbuttons must turn on the motor. Pressing any one of the two
stop pushbuttons must stop the motor operation.
c) When the motor is running, the pilot light must be on.
7. Draw the relay logic diagram for a circuit that operates as follows:
Page 2 of 3
a) In a motor control system, one master stop pushbutton (Stop_PB) is
available for stopping the operation at any time.
b) If the temperature switch (TSW) is closed, pressing the red pushbutton
(Red_PB) will turn on both motors one (M1) and two (M2).
c) If TSW is open, pressing Red_PB will only turn on M2.
d) If TSW is closed and the green pushbutton (Green_PB) is pressed once,
M1 will run.
e) Closing the temperature switch turns on the white pilot light.
8. Draw the relay logic diagram for a circuit that operates as follows:
b) One pushbutton is for the continuous run mode of operation. The second
one is for the temporary run mode of operation.
Page 3 of 3