You are on page 1of 6
Ob the left side, write the letter corresponding to the correct answer. Show your solution. No solution, no credit Rl circuits, V; Np by___ degrees. lags, 90 leads, 90 d, leads, 45 100, The phase angle > of the © dina series RUC circuit, R100 6, X= 300.0, and Xe circuit is, degrees ned a ey po 4 (300-200) 45 48 ook 0% iar Cas B_3.in the two wattmeter method of measuring 3-phase power, the two wattmetors indicate equal and opposite readings when load power factor angle Is degrees lagging. 3.60 6.0 30 5 4.90 £110 4.The current drawn by a 120v dc motor of armature resistance 0.5 0 and back en voltis__ ampere, ve a. 60 60 Woy = \2o- (0-5) «30 4.90 te ome C_5, Ademotor develops a torque of 200 N-m at 25 cps. At 20rps, it will develop atorque A a.The iron loss of a transtormor ot 400 Hz is 10 watts, Assuming that eddy currant and hysteresis losses vary as the square of flux density, the iran Toss of the transformer a rated voltage but at §0 Hz would be _ watt. 3.80 b.Gt0 1.25 4. 100 9,The voltage applies to the high voltage side of a transformer during short circuit te 2% of ts rated voltage. The core loss will be_ percent if the rated core loss, boa 4, 0.04 ad & 10.4 200 KVA transformer has an iron loss'of 1 ky and full load copper toss of 2 kw. Its the foad KVP corresponding to maximum efficiency |s hva, a:100 baana (ees A 50 4 4.200 ey 1. copper less of a transformer at 2/8.of full load ls 4900 v, then its full joad copper fosswouldbe,__— watt Fal wah & a, 5600. b, 6400 375 4.423 OOS hu. 09 Wi a - © 42-7he maximum efficiency of a 100 kva transformer having iron toss of 900. and full toad copper loss of 1600.w occursat___ ues Sc 2.66.7 b.1732 £732 4.50 16. When a\V=Vsystem s converted into.a 0-4 system, Increase in capacity of the system is__percent. 2.866 66.7 2732 ,50 8. 174For suppivingaa balanced 3- 6 foad of 40 hva, rating of each transformer in open delta bank should be nearly kva. De 3.20 b.23 HOS 2346 4.25 © 18. The number of stator poles produced in the rotating magnetic field of a 3 phase induction motor having3 slats per pole per phase is a3 b6 e2 6.12 : $0 Hz, 3-phase Induction moto: is running at 950 rpm and has rotor b, 40 53 » -23. if stator voltage of 9 squirrel cage induction motor is reduced to SO% sercent of ts fll load v value, torque developed is reduced by 250 25 675 4.577 poles: 28 b6 64 42 _P._25.the windings of a 4- pole alternator having 36 slots and a coil span of t to 8 Is short= pitched by degrees 3.140 b.80 20 4.40 2.300 b. 150 Fy 30 4.60 *he fan alternator has 2 fractions! pitch of 3/6, the coil span is. x REE 24.450 Hz alternator will run at the greatest possible speed if itis wound for _—_ degrees. of its rated Aoaae 4.4000 % 32. One kw-hr. of energy equals nearly 9.1000 w. by, 860 heal 4186) 4, 735.5 W zero sequence Vis 42.A% a certain point of the system network the positive, negative and impedances are 0/25 pu, 0.25 pu, 0. pu respectively, The base MVAIS 75, base Determine the zero sequence current for a one line to ground fault, 3.262434 b.23B574A 95 WY 1680.24 4.6275 A, am $ (33. A 5000 kva, 13.8/0.48 KV, 59% Impedance transformer is tapped at 13,8 ky line where tine Thevenin’s equivalent impedance is 0.5 ohm. Determine the short circult current at the Secondary lor a symmetrical three phase fault at the secondary, 495,310.18 b.3315.1A © 20.5004 d. 6050.8 _D 24, at a certain location In:an electric systern, the available fault MVA is 400 MVA. A 15 IMVA, 34.5 KV/6.24 KV, 25% impedance, wye-wiye grounded transformer is installed ot that location. Determine the short circuit MVA atthe secondary side ofthe transformer : b.150MVA 4.240 MVA of 0,032 chm per phase. What Is the fault current if a three phase foult occurs at the breaker?, 8000.8, b. 5000.A ©. 62008 J, 12004 _38. A certain station has annual factors as follows: load factor = 50 %, capacity factor 40%. If maximum demand = 15 MW, detormine the plant capacity. 18,750 kw 15,000 kw €.4.350kw 1d. 3,750 kw Z (¢-19 WY DB 39. . Acertain station has annual factors as follows: load factor = 50 %, capacity factor = 40%. If maximum demand = 15 MW, determine the reserve capacity of the plant. 3.18,750 kw 25,000 kw . goo : agp — 5090.5 3980 © 4,350kw 43,750 kw « By =

You might also like