Folding Instructions
Orchid Blossom
Chapter 10: Folding Instructions + 6 « «Orchid Blossom
1, Begin with a square, colored side
up. Fold and unfold in half vertically
and horizontally
2. Fold the bottom edge up te touch
the midpoint of the tight edge: the
tercuse hits the midpoint of the left
‘edge, but don’t make it sharp in the
Jett half of the model
3. Fold and unfold 4. Unfold, 5. Repeat steps 2-4 on the other thee
comers. Turn the paper over.
fe] i Desi
ee eee Origami Design Secrets6. Fold each comer inward along a7. Make vo more creases that
diagonal crease that connects two connect pairs of creas
crease/edge intersections; make each
crease sharp only where shown,
8. Fold four comers inward.
intersections,
By
ee
9, Fold a Waterbomb Base, but only 10. Squeeze the sides inward, gather LL, Reverse-fold the comer
make the creases sharp in the middle the excess paper in the middle and swing, inside.
of the paper. it over to the right. Repeat behing.
Ts fis]
Wis
I
12. Reverse-fold the inside
14, Repeat steps 11-13 on
cage along the center line.
the right and on both sides
behind.
Folding Instructions: Orchid Blossom « «
EAISEE)
9009
15, Fold and
unfold,
16, Fold the comer
to the crease you just
made and unfold
+
20, Fold dhe corner
down along a crease
aligned with the
edges behind.
21. Fold the comer
bback up so that the
raw edges line up
swith the crease you
just made.
vi)
25, Repeat 26, Fold two layers to
steps 20-24 the right in front and
behind, ‘two to the left behind,
spreading the layers
symmetrically.
#6 6 #666 Origami Design Secrets
18]
17. Fold and
unfold.
18. Open-sink
in and out,
v%
22, Fold the corner
over along the
center line of the
‘model.
a4
27. Reverse-fold the
19. Swing the flap to
the side and repeat
steps 15-18 on the
right, Repeat en both
sides behind,
23. Unfold to
step 20.
24, Reverse-fold the
‘corner in and out on
the existing crease,
yu
28, Open out the
vo hidden corners out two flaps to middle pair of edges
to the sides. (Thereare form small ‘on each side apart,
three layers in each; it cups, slighily; the model
doesn’t matter how you
divide the layers, but
divide them both the
same way.)
will not lie flatbots
30, Pleat the edges to
take up the
cess
payer, press the layers
of the tip togeth
round it into a bowl,
34, Fold the corners
over and ever on
existing creases,
37. Pinch the stem to narrow
itfurther; Spread the small
Aap
front to the sides,
31. Fold the model in 32, Reverse-fold three 33. Pull out four loose
halt (except for the top, Maps together as one. corners vompletely.
Which stays rounded).
Rotate 12 turn,
38. Squash-fokd five flaps 36, Narrow the stem with
(all but the middle flap) to ‘mountain folds.
stand out perpendicularly to
the other layers.
u
R Lt
38. Reverse-fold the tips of 39, Finished Orchid
the five Hat petals. Shupe Blossom,
the flower,
Folding Instructions: Orchid Blossom « » «