Professional Documents
Culture Documents
13. Open-sink the 14, Fold one layer 15. Repeat steps 8-14 using the upward, ‘on the other flap. existing creases. . 16. Fold one flap down 17. Like this. Now we'll go 18, Fold and unfold along the to the lower left back to working on the entire diagonal. Then turn the paper model. over trom top to bottom. 19, Fold and unfold in half both 20. Fold a Preliminary Fold 21. Mountain-fold the corners vertically and horizontally. with the creases you just made. underneath as far as possible. Then rovate the paper 1/8 turn clockwise. Origami Design Secrets22, Peial-fold front and tear, 23, Fold the two 24, Fold the tip dowa flaps back down, tothe horizontal crease and unfold. 4 25, Open-sink the top 26. Fold one layer to 27, Fold one flap up in comer. the right in front and front and behind cone (o te left behind. 28. Crimp the two points out 29, Fold a rabbit ear from the to the sides. upright flap and swing it over to the right, Repeat behind, Folding Instructions: KNL Dragon « + « ey ice}Pie) 30. Fold a layer down in 31. Reverse-fold each of four edges down front. Repeat behind. to lie along the horizontal edges. 32. Mountain-fold the eomers to line up 33. Fold the left white point as far to the with the edges of the reverse folds from right as possible and unfold. Repeat with the previous steps the left point und with both points behind 34, Fold the front and back 35, Fold the front Clap up so that the raw flaps back upward, comer is directly over the middle of the model, Repeat behind, A LA 36, Pull out some loose paper: 37. Mountain-fold the edge Repeat behind, inside the near pocket ZL 38. Fold the two points 39. Rev front and rear to the left points up. +66 ee Origami Design Secrets40. Reverse-fold the head and tail twice each, x x 42, Crimp the top layer. 43. Swivel the top flap upward slightly. 48, Outside-reverse-fold 46, Finished head. thebottom jaw in and otto make a tongue. AL. Steps 42.46 will focus on the head. 44. Oulside-reverse-fold the bottom jaw. Outside reverse fold the nose. 47, Fold four rabbit ears to make legs, . Pleat the wings, ig Instructions: KNL Dragon 49, Finished KNL Dragon,Lizard VE: 1. Begin with a square, coloced side up, Fold and unfold along one diagonal 2. Fold the top edge down w the diagonal and make a pinch along the right edge. 3. Fold the top left comer down 4, Bring the two indicated points §. Fold the bottom right comer over to the bottom; make a pinch together and make a pinch along, to the left so that the edges line up along the left side and unfold. the bottom edge. and the crease goes through the mark You just made; make the crease sharp Up to the diagonal and unfold, Origami Design Secrets6. Fold the comer up so that the 7. Fold the bottom right comer 8. Fold the hottom edge up so that ‘edges line up and the crease hits up along the diagonal so thatthe the corner touches the white corner the diagonal at the same place: crease hits the edge at the same al the diagonal; crease all the way make the crease sharp from the place as the creases you just across and unfold. Repeat with the diagonal to the right edge and made, right edge. unfold mx) oo 9, Mountain-fold two corners behind. Then tum the paper over and rotate it so that the colored ‘comers are on the sides, 10. Fold and unfold along 11, Fold a rabbit ear, bringing ling the comers the two top comers together lersection in the along the center line center. 12. Reverse-fold the side points down tlie along the center line. 13. Squash-fold the white 14, Reverse-fold the edges. flap symmetrically. Folding Instructions: Lizard «ee ee18. Reverse-fold the next 16, Reverse-fold the 17, Fold two layers pair of edges. remaining pair of edges. to the right in front and one to the left behind, 18. Fold the edge 19, Fold the point up 20, Fold the leit edge 21, Fold the left edge ‘over to the vertical to the top of the lover to the crease ‘over fo the crease crease model. and unfold. you just made and Unfold q 22, Open-sink the 23, Fold the 24, Fold one comer in and out on point down, flap to the left. the existing creases. +6 eee 6 Origami Design Secrots( 25, Fold one flap up 26. Fold the white 27. Fold the left edge 28. Foldthe left edze as far as possible, edge to the center tothe crease you just tothe crease you just line and unfold ‘macle- and unfold made and untold rer? 29, Open-sink the 30, Spread-sink 31. Close up 32, Open-sink the | omer in and out on the corner, the flap. corner on the "the existing creases. existing creases <= =e Tea “ f) 34, Repeat steps 38. Fold one layer to the 236, Crimp the «wo 18.33 behind left in front and two to the points cut to the right behind, leaving the sides and slightly ‘model symmetric. upward 175 Folding Instructions: Lizard ee seesPR ad a 37. Wrap one 38, Sink the white 39, Reverse-fold the colored layer from comers, hind legs out tothe inside to outside sides. 40. Narrow the tail by 41, Partially rabbit-ear the tail 42. Reverse-fold the folding each side over and and turn the model over. hind ki over in thirds. 43, Reverse-fold the hind feet. 44. Crimp the head slightly and 45. Finished Lizard, Squash-fold the front feet and pall out the layers on the sides mountain-fold the forelegs of the head. Curve the tail, away from you. «= Origami Design SecretsTree Frog 1, Begin with a square, white side up. Fold and unfold along the diagonals, Turn the paper over, 2. Fold and unfold vertically 3. Fold the top left comer to the and horizontally. center; make a pinch that ‘crosses the diagonal crease and unfold Folding Instructions: Tree Frog « « «4. Fold me top edge to the pinch you just made; make another pinch on the diagonal crease and unfold 7. Fold the edge to the diagonal crease, allowing the corner behind to Mlip out. 10. Fold a Watesbomb Base using the existing creases. Origami Design Secrets §. Fold the bottom right comer up to the crease intersection, 8. Unfold the pleat and ‘urn the paper buck over. 11. Fold and unfold through the crease intersections, “OS 6, Like this. Turn the Paper over 9. Repeat steps 3-8 on the other aree corners, Leave the paper white side up when you're done L2, Open-sink the point in and out,13, Fold two edges down, 14, Reverse-fold wo comers out, 15, Steps 16-28 will focus on the region in the circle. qo 16, Pull the near layer to 17, Close up the model. 18. Fold the comer down 19. Unsink a layer of paper the right and release some tnd squash-fold the from inside the petal fold trapped paper. You may interior commer. The result should be Findit easier to do steps symmetric. 16-19 all at once, ao 20, Close up the Map. 21. Repeat steps 22. Spread-sink 23, Fold and unfold 16-20 on the left. the edges, along angle bisector. YE, Spread sink two 25, Close up the flaps. 26. Turn the paper over, 27. Fold the two corners, flaps down, Be) fling bso: ree fog «+ «++ MEEmoe is oo 28, Repeat steps 29. Bring the bottom left and right corners 30, Squash-fod the lf 22.25 on this side. together, swinging the excess paper to th in front and the opposite left in front and to the right behind, Spread flap behind, spreading the the extra Layers up near the tip evenly, front thick layers up near thet to back, symmetrically. ¥ v 31. Reverse-fold in the 32, Petabfold the 33. Fold the side 34. Open: sink the ‘two remaining flaps, edge in fron comers to the ‘comers on the creases center and unfold, you just made 35. Fold and unfold 36, Fold the small 37. Lift up the point and 38, Fold the raw through all layers point down as faras squeeze it in half, forming a cede inside on possible. rabbit cur from asingle layer existing creases, of paper and opening out a layer on the lower flaps. The Paper will not lic fat Origami Design Secrets=> 39, Stret pois out Lo the sides, the two near 40, Tuck the paper underneath ard close the model up 41. Turn the model over. 42, Repeat steps 32.38 on this side. i i 32a a 43, Squash-fold the 44. Poldasmall 45. Fold one wide 46, Repeat steps 47. Fold half the top and flatten point down: layer tothe rightin 32-40 in frontand layers to the right front and one to the lef behind, AB.Foldasingle 49, Reverse-fold wo $0. Make a small flap slong the edges and stretch the crimp across the folded edge and flap over to the right. flap and close it up, unfold. The result will not lie flat Folding Instructions: Tree Frog «+ ee behind, ve 51. Reverse-fold the corner back to the left in front and halt to the left behind WaT WT 82. Repeat steps 48-51 on the other three flaps.a © D S4, Reverse fold 55. Reverse-fold 56. Fold the tip of the flap to the the flap downward the flap up and right slong creases so that the raw unfold. . aligned with the edges are aligned. 53. Steps 54-62 will focus on the flap in the ciree bE folded edge. 57. Crimp the tip 88. Reverse-fold $9, Reverse-fold 60. Reverse-fold 61, Reverse-fold Uupward so that the the tip inside, the edue. three edges back three edges back raw edge ends up to the left, to the righ, horizon { “Or 62. Like this. ota, 63, Repeat steps 64. Turn the 54-62.0m the right model over. 68, Steps 65-76 near flap. will focus on the flap in the circle, coxa Daigo4 (6. Divide the Nap ino quarters along the bottom edge. 67. Reverse-fold along aline that connects to the rightmost mark, 70, Reverse-fold the 71. Reverse-fold the larger flap along creases larger flap to the left aligned with the folded along, verical creases. edges. 74, Reverse-fold { four flaps along vertical creases. 66-76 Repeat steps 78. Steps 719-83 fon the right will focus on the top of the model. 79, Reverse-fold two points out to the sides Folding Instructions: Tree Frog s + 6 & ® 68. Reverse-fold the flap back to the left along, vertical creases, 69. Reverse-fold the two small comers to the right one in front, one behind), DL 72. Reverse fold the point so that its right edye is vertical, 73. Reverse-lold (wo flaps to the right so that a crease lines up with a falded edge in each reverse told LP Ng 75. Reverse-fold the four flaps so that the raw edges are all vertical 76, Like this. ve @ 80. Mountain-fold the near layers. Valley-fold the far layers.ety S86 81. Fold down two layers 82, Pull out the layers and 83, Blunt the nose, from the front and two layers spread each point into a from the rear of each of the smooth bulging eye. ‘vo small points, OGe 4. Fold and 85. Fold the small 86, Fold a 87. Sink the 88, Fold the unfold through point upward, ingle layer in comers on the sanall point the near layers. on each side, existing creases, back down, 89. Hold the near pair 90. Reverse-fold the 91, Mountain-fold the sides of of flaps out and slightly leas downward and the body and swivel the lower upward, towanl each other, edges of the legs upward, Repeat on the far side of the legs, Origami Design Secrets92, Mountain-fold the 93, Reverse-fold the 94, Turn the 95. Reverse-fold the two comers at the bottoms knees and narrow the model over. bottom flaps up and then out of the legs. legs on both near and to the sides (it's easier to do far sides, both reverse folds on each leg before flattening). Divide the layers asymmetrically, with one layer on the near side and three on the Far side. “Or 96. Fold the one near edge 97. Narrow the body with 98, Crimp the fon ofeach leg flap down and mountain and valley folds spreading the layers the three far edges hehind, that line up with the edges symmetrically, Turn the behind. model over. 99. Crimp the forelegs and 100, Spread the toe 101. Finished Tree Frog. ‘end them dowenwacd. Mountain-fold the back. Crimp the feet so that they ‘Shape the body. ‘point slightly forward Folding Instructions: Tree Frog