You are on page 1of 55

M/L

6 3/4” 7/8 M
7
7/8
6 3/4” 7/8 M/L 5.0 Stage

7/8
StaM 3.8 Stage
S
7 3/4” (8”) 7/8 M/L 4

4 3/4

7 3/4” (8”) 7/8 M/L 4


7 3/4” (8”) 7/8 M/L
6 3/4” 7/8 M/L 3.5 Stage
6 3/4” 7/8 M/L 5.0 Stage

1/4”
4 3/4” 7/8 M/L 3.8 Stage

4 3/4” 7/8 M/L 3.8


7 3/4” (8”) 7/8 M/L 4.0 Stage

3.07/8
7 3/4” (8”) 7/8 M/L 4.0 Stage

6 3/4”
7 3/4” (8”) 7/8 M/L 4.0 Stage

Stage
6 3/4” 7/8 M/L 5.0 Stage
6 1/4” 7/8 M/L 2.9
7 3/4” (8”) 7/8 M/L 4.0 Stage

6 3/4”
4 3/4” 7/8 M/L 3.8 Stage

7/8 7/8 M/L


7 3/4” (8”) 7/86M/L 4.0
3/4” 7/8 M/LStage
5.0 Stage

6 1/4”
Volume 1

6
6 3/4” 7/8 M/L 3/4” 3.8
Motor
Manual
6 1/4” 7/8 M/L 2.

4 3/4” 7/84M/L
7/8 M/L 3.5 Stage

1/4”
Office: 405-604-2969 Toll Free: 877-350-4497
9630 Pole Road, Oklahoma City, OK 73160
6 3/4” 7/8 M/L 5.0 Stage
6 3/4” 7/8 M/L 5.0

www.drillrighttechnology.com
8 M/L 3.5 Stage

6
To Our Customers,

Drill Right Tools has selected the very best bear-


ing assemblies and power sections in order to supply
our customers with performance they expect and the
reliability they deserve. Our motors are given thorough
inspections to ensure every component can endure the
rugged downhole conditions while still meeting de-
mands for maximum performance. Drill Right Tools has a
first-class facility built around maximizing efficiency and
quality control. Our goal is to help our customers achieve
accurate and efficient results without costly downtime
for failures. Drill Right Tools provides our customers with
a select range of tool sizes to help with directional and
horizontal applications. We're pleased that you have se-
lected Drill Right Tools to help achieve maximum results
in your application.

Sincerely,
Motor Components

rotor

stator Power Section

Adjustable Housing
0 to 3 or 4 Degrees
Articulated
Driveshaft

stabilizer
Sealed Bearing
Assembly
Motor Components

Power Section
The drive is Moineau pump operated in reverse. Drilling fluid pumped
through the assembly causes a rotor to turn and apply rotary motion and
torque to the drill bit, through the articulated driveshaft and the output shaft
in the sealed bearing assembly.

The power section consists of a helical shaped rotor running inside


the stator (an elastomer liner bonded to a steel tube). The stator elastomer
liner opening is dissimilar in shape to the rotor. The pitch length of the sta-
tor cavity is longer than the pitch length of the rotor. The dissimilarity in the
shapes of the rotor and stator produces wedge shaped cavities that are sealed
along their edges. The pressure that is produced as drilling fluid is pumped
through the power section causes the rotor to turn and the cavities to move
forward in the direction of fluid flow.

The multi-lobe configuration, employed in Drill Right Tools low


speed, high torque motors, uses a rotor with a multiple-lobed cross section
that also forms a helix. The elastomer liner in the stator has a cross section
containing one more lobe than the rotor. Its pitch length is longer than the
rotor’s pitch length by the ratio of the number of stator lobes divided by the
number of rotor lobes. Example: A 7 to 8 lobe configuration has 7 lobes on the
rotor, 8 lobes in the stator: and a helical pitch length of the stator equal to 8/7
times the pitch length of the rotor.

The number of stages of a Drill Right Tools PDM drive is the length of
the stator elastomer liner divided by its pitch length.

Drill Right Tools drives permit accurate determination of the bit


speed and bit torque “on bottom” from the rig floor at any time by referring to
the accompanying Motor Specifications and Performance pages. The output
torque is directly proportional to the pressure drop across it. This is a straight-
line relationship and can be determined from the standpipe pressure gauge.
The PDM drive’s speed is proportional to the circulation rate.

At a constant circulation rate, the speed drops off slightly as the


torque and pressure increase
Motor Components

The circulation rate can be read from the pump stroke counter.

The stator is threaded on both ends with a box that uses a standard
designed thread. It connects to the dump sub above and to the adjustable
housing below.

The rotor has a box connection that connects to the upper universal
joint of the articulated driveshaft assembly.

Adjustable Housing
Drill Right Tools adjustable housing connects the stator to the sealed
bearing assembly and encloses the articulated driveshaft assembly. The angle
setting is field adjustable to produce a wide range of build rates.

Fixed Housing
Fixed, non-adjustable housings are available (special order) in straight
or fixed bend configurations

The articulated driveshaft assembly converts the eccentric or pro-


cessional motion of the rotor into concentric rotation for input to the sealed
bearing assembly. It also accommodates any angle set on the adjustable bent
housing (or fixed bend housing) and carries the thrust load from the rotor
caused by the pressure drop across it.

The assembly consists of two universal joints connected by a drive-


shaft. The upper joint connects to the rotor and the lower joint connects to
the sealed bearing assembly. Both universal joints are lubricated, sealed, and
pressure balanced.

Sealed Bearing Assembly


The sealed bearing assembly transmits the rotation of the rotor,
through the articulated driveshaft assembly, to the drill bit. It carries the com-
pressive thrust load created by the weight on bit, and the radial and bending
loads developed while directional or steerable drilling. It also carries the ten-
sile "off-bottom" thrust load produced by the pressure drops across the rotor
and the drill bit, as well as any load caused by back reaming.
Motor Components


Drill Right Tools radial bearings and thrust bearings are sealed in an
oil chamber balanced to the hydrostatic pressure. The thrust bearings are
high capacity and there is no need to balance hydraulic thrust load to bit
load with the Drill Right Tools motor. The high capacity radial bearings readily
withstand side loads caused by drilling with a deflection device or uneven
cutting action along the drill bit periphery.

The lower connection is an API regular bit box.

Stabilizers
Drill Right Tools motors are available with a thread on the outside of
the sealed bearing assembly to accept straight or spiral blade screw-on sta-
bilizers or screw-on offset pads. A protector is installed over this thread when
stabilizers or offset pads are not being used.

Specify stabilizer / pad OD when ordering.

Stabilizers, thread protectors and offset pads should be torqued to


the values shown below.

ft-lbs N-m
4 3/4"or 5" 6000 8100
6 1/4" 10000 13550
6 3/4" 12000 16250
7 3/4" or 8" 20000 27000

Servicing
Drill Right Tools recommends that its downhole motors be serviced
after every run and be returned to an authorized Drill Right Tool service facil-
ity.

At Drill Right Tools, the motors are visually inspected and flushed.
Motors are completely disassembled and all parts cleaned and inspected.
Threaded connections and critical components in the motors are magnetic
particle inspected by qualified operators. Threads and parts are redressed as
necessary and worn parts are replaced. Make-up and breakout of all thread-
ed connections is performed and logged with an accurate torque machine
(Torquemaster) to ensure proper torque is applied to the threaded connec-
tion. Following reassembly, the tool is filled with oil and readied for shipping
and operation.
Operations

No matter whether the application is a correction run, directional
kick-off, sidetrack extended reach, horizontal well, or a coring run, careful
consideration of all parameters will go a long way in ensuring the successful
execution of the planned task.

Hydraulic requirements, circulating fluid data, RPM requirement,


and formation characteristics must be addressed to ensure the proper selec-
tion of the applicable Drill Right Tools motor.

Preparation for Running and Rig Site Motor Test


Drill Right Tools downhole motors are shipped from the service cen-
ter with all tool connections made up to the proper torque, and all compo-
nents inspected and tested for proper operation. High-torque low-speed mo-
tors are shipped with the rotor bore plugged unless otherwise specified. All
motors are shipped with a protector covering the screw-on stabilizer thread
unless a screw-on stabilizer is ordered. When ordered in advance, the screw-
on stabilizer is installed at the service center before shipment.

Set the motor in the slips and install a safety clamp. Remove the lift
sub and make up the kelly. Remove the safety clamp and slips and lower the
motor until the dump sub is below the drilling nipple, but visible. Start the rig
pumps slowly; Fluid should flow out of the dump sub ports.

Increase the pump rate slowly until the dump sub closes. Leave the
pumps running and make note of the circulation rate and stand pipe pressure
when the dump sub closes. With the pump running and the dump sub closed,
check to ensure that there is no drill fluid leakage through the ports. It is ad-
visable to increase the pump speed in two or three steps, to the maximum cir-
culation rate expected downhole, and note the circulation rate and standpipe
pressure in each case. Shut down the pump. The dump sub may not open due
to a pressure lock in the short hydraulic test circuit. If this occurs, bleed off the
pressure to permit the dump sub to open.

Make up the drill bit to the proper torque with a bit breaker and
the rig tong placed on the output shaft directly above the bit. Do not put rig
tongs on the sealed bearing assembly housings. Inspect the output shaft seal
area for any indication of an oil leak.


Operations
Running In
The drill string with a straight Drill Right Tools motor installed can
be run into the hole normally. When using a bent sub, or a non-zero angle in
the adjustable housing, be careful passing the motor through the blowout
preventors, casing shoes, liner hangers, ledges, or key seats to ensure that the
motor or drill bit does not hang up. Do not run into bottom, or “bottom fill’; as
it could plug the bit or damage the motor.

Starting the Motor


Begin circulating “off bottom” with the bit turning freely. Perform cir-
culation and pressure tests at the same circulation rates as the prior surface
test, and note the readings. The pressure will be higher due to the restrictions
of the drill string components added. The “off bottom” pressures noted may
be higher than calculated. This is caused by bit drag on the side of the hole
due to the bent sub, adjustable housing angle and stabilization.

Drilling
After a short hole-cleaning circulation period, slowly lower the bit
to bottom. When bottom is tagged, the standpipe pressure gauge will show
an immediate increase. Increase the bit weight slowly to achieve the desired
build up rate and/or rate of penetration. Do not exceed the recommended
maximum differential pressure across the motor.

The “off bottom” pressure is the total system pressure (read on the
stand pipe gauge), from the standpipe, through the drillstring, the annulus,
and back to the drilling nipple, while circulating with the bit “off bottom”(i.e.
zero weight on bit).

Periodically recheck the “off bottom” pressure. The standpipe pres-


sure will slowly increase after hole cleaning due to the hydraulic energy re-
quired to lift the cuttings.

The torque applied to the bit while “on bottom” is directly propor-
tional to the difference between the “on bottom” and “off bottom” pressures
(i.e. there are no friction losses through the rotating drill string). An increase
in the weight on bit produces an increase in torque. As the bit drills off, the
weight on bit decreases and correspondingly the pressure and torque de-
crease. The standpipe pressure gauge can therefore be used as a torque
indicator.
Operations

The range of Drill Right Tools motors permits selection of the correct
motor to provide the optimum combination of bit speed, bit torque, and cir-
culation rate for maximum rates of penetration. When the drilling conditions
permit, the rotary can be engaged.

Running into bottom can damage thrust bearings, and excessive


over pull on a stuck bit can damage “off bottom” bearings in the sealed bear-
ing assembly.

Drill Right Tools motors are designed for extended intervals of “on
bottom” drilling. The motors should be serviced after 150 operating hours,
under ideal drilling conditions. Drilling conditions other than ideal, such as
excessive bit weight, corrosive drilling fluids or rotating with high bend set-
tings will reduce this interval accordingly.

Reactive Torque
The drill bit attached to the mud motor at the bit box turns in a right
hand, or clockwise direction, if viewed from the drill floor. There is a reactive,
counter clockwise (or left-hand) torque produced as a result of the torque ap-
plied to the bit. This anticlockwise torque must be considered when establish-
ing tool face orientation and can be calculated by relating the:

1) difference between “off bottom” free spinning pressure; and

2) actual “on bottom” operating pressure.

A rough, determination of the angle of twist of the drill string can


be performed as follows:

1) Measure and record standpipe pressure “on bottom” with the
desired bit weight and circulation rate, and “off bottom” with the
same circulation rate.

2) From the motor performance sheets near the end of this book,
obtain the torque corresponding to the difference between the
“on bottom” and “off bottom” pressures.

3) The torsional angle can be determined by multiplying the above


torque, the length of drill pipe in the hole, and the angle factors
from the table below.
3 1/2" - 13.3 lb./ft. Drill Pipe
Imperial: 8 1/2° (degrees) / 100 lb-ftTorque /1000 ft.
Metric: 19° (degrees) / 100 N.m Torque /1000 m.
Operations

3 1/2" - 15.5 Ib./ft. Drill Pipe
Imperial: 7 1/2° (degrees) /100 Ib-ftTorque /1000 ft.
Metric: 17 (degrees) / 100 N.m Torque /1000 m.

41/2” - 16.6Ib./ft. Drill Pipe


Imperial: 3 1/3° (degrees) /100 Ib-ftTorque /1000 ft
Metric: 7 1/2° (degrees) / 100 N.m. Torque /1000 m.

5” - 19.5 Ib./ft. Drill Pipe


Imperial: 2 5/8° (degrees) / 100 lb-ftTorque /1000 ft.
Metric: 6° (degrees) / 100 N.m Torque /1000 m.

Directional drillers can get an indication of the reactive torque by the


measurement while drilling (MWD) equipment, and can adjust and lock the
rotary table in order to accommodate the desired tool face direction.

In most applications the use of measurement while drilling or steer-


ing tools to provide real time surface readout of azimuth, inclination and tool
face is much more reliable than the single shot method of orienting.

Stalling
If the drill bit is overloaded, the motor will stall. An increase in stand-
pipe pressure will occur and penetration will cease.

When a stall occurs, the drilling fluid deforms the stator elastomer
liner and flows through the PDM drive without turning the rotor. Bit stall
should be avoided, but when it occurs, it should be quickly remedied. Exces-
sive circulation through a stalled PDM drive or repeated stalling will seriously
damage the stator elastomer liner and other components within the motor.

If the bit is picked up off-bottom when in a drilling mode, the


”trapped” torque within the drill string will be released uncontrollably, poten-
tially causing damage to down-hole components or causing connections to
back-off. This is especially true when a stall has occurred.

If a stall condition occurs the following procedure should be followed


as soon as possible.

1) Shut down the rotary table immediately.


2) Release trapped torque slowly using the rotary table brake.
3) Lift the bit off bottom, and
4) Shut the pumps off, if necessary.
Operations
Over-running the Bit
Rotating the drillstring with any positive displacement motor in a
stalled condition may cause the upper portion of the motor (and drill string)
to over-run the bit. This condition may damage the stator elastomer liner.
High torque, low speed multi-lobe motors are most susceptible to this type of
damage.

Rotary RPM
Rotating the drill string while subjected to bending loads produce
fatigue loading on the motor. These bending loads can be produced even
when using adjustable bend settings that are within the recommended val-
ues (see “Maximum Adjustable Bend Setting for Rotary Drilling” in Section 11).
Drill string rotary speed should therefore be limited to 50 RPM to reduce the
cyclic loading on the motor.

Motor Pressure Drop


Exceeding the recommended operating maximum differential pres-
sure across the motor will reduce the stator life. Circulation rates exceeding
the recommended values also reduce the rotor and stator life.

To understand the conditions affecting the pressure drop across


positive displacement drilling motors, the following should be recognized:

The pressure drops across the dump sub, benthousing, articulated


driveshaft, and bearing mandrel of the sealed bearing assembly is
dependent on the circulation rate only (i.e. torque has no effect).
This pressure drop increases as the circulation rate increases.

The pressure drop across the rotor and stator increases linearly as
the torque increases, assuming a constant circulation rate.

The effect of mud weight alters the pressure drop across the motor
at no load. However, it has a negligible effect on the pressure
increase due to the torque “on bottom.”
Operations
Bit Pressure Drop
Continuous excessive pressure drops across the bit can cause early
seal failure in the sealed bearing assembly. The bit pressure drop should be
limited to 1,500 psi (10,000 kPa) for continuous drilling. However, Drill Right
Tools motors can be configured to operate with bit pressure drops in excess
of 1,500 psi. Please contact Drill Right Tools if these higher pressures are re-
quired.

Drilling Fluids
Drilling fluids with a pH below 4 or above 10 can cause damage to
the stator. Circulation through the rotor and stator can minimize this damage
and should therefore be maintained when operating in drilling fluids close to
the limits of this pH range. Allowing the drilling fluid to stagnate will aggra-
vate the problem.

Pumping acid through a motor can seriously attack the plated com-
ponents. The motor should be flushed and serviced as soon as possible.

Drilling fluids containing chlorides can reduce rotor and stator life
due to corrosion, especially at elevated temperatures. Special attention
should be paid to the internal coatings when the chloride concentration is in
excess of 30,000 PPM. Contact Drill Right Tools if chloride concentrations are
in excess of this. The motor should be flushed and serviced as soon as pos-
sible if it has been exposed to chlorides.

Drilling mud with a density of more than 16.7 PPG (2.00 kgf/I) will
cause abnormal erosion of motor internals due to suspended materials with
in these muds.

Well-mixed medium-to-fine lost circulation material can be used


without plugging or motor damage. If coarse lost circulation material is to be
used, a circulating sub should be installed above the motor assembly to
bypass the motor.

Sand content should be less than 2%. Solid content of more than 5%
will shorten rotor and stator life considerably.

Safe run times may have to be shortened to avoid down-hole motor


failure if the above recommendations are not followed.

Never try to cement through a motor.


Operations
Oil Based Drilling Fluids
Drill Right Tools motors can be successfully used in oil based mud if
the operating temperature is below the aniline point of the oil. However, oil
based fluids will deteriorate the elastomeric stator liner and consequently it is
recommended that the stator be relined after it has been run in an oil based
mud.

The aniline point (i.e. temperature) of an oil is an indication of its ten-


dency to cause swelling of elastomeric parts (e.g. stator, seals), and is a mea-
sure of the oil’s aromatic content. The lower the aniline point, the greater the
swelling tendency. The aniline point gives a measure of the solvent power of
a petroleum product for aniline, which is related to its solvent power for many
materials. This solubility increases with increasing temperature.

Operating a motor in an oil based fluid at temperatures above the


oil’s aniline point allows the aromatic portion of the oil to permeate and swell
the stator elastomer liner and reduce its hardness and strength. The swelling
increases the interference between the rotor and stator and results in heat
build-up that leads to rapid destruction of the stator elastomer liner. Power
sections with larger clearances are available to minimize the effects of swell-
ing.

Elastomeric compounds seem to perform better in mineral based


mud systems than in diesel oil based systems. Low toxicity oil base systems
are easier on elastomers because they contain fewer aromatics.

H2S (Sour) Service


Drill Right Tools motors are manufactured from steels with a hard-
ness in excess of that allowed by the National Association of Corrosion Engi-
neers (NACE) Specification MR0175. This hardness is required to achieve the
strength necessary for use in the drillstring, but it renders it susceptible to sul-
fide stress cracking (SSC). As a consequence the drilling environment should
be controlled if these tools are to be used in sour environments.

The drilling environment may be controlled using one or more of the following

1) Maintenance of the drilling fluid hydrostatic head to minimize


formation fluid in-flow.
2) Use of chemical sulfide scavengers.
3) Use of a drilling fluid in which oil is the continuous phase.
Operations
The following specifications provide recommendations for drilling
sour wells and for the control of the drilling environment:

1) The American Petroleum Institute (API) Recommended Practice


RP7G Section 9.

2) The National Association of Corrosion Engineers (NACE) Specifica-


tion MR0175,” Sulfide Stress Cracking Resistant Metallic Materials for
Oilfield Equipment”.

3) Alberta Recommended Practices for Drilling Critical Sour Wells.

The time that a motor is exposed to H2S in a typical drilling applica-


tion is insufficient for H2S to cause damage to the elastomers (e.g. stator liner)
within the motor.

Down-hole Temperature
An increase in static downhole temperature reduces the strength of
the stator elastomer liner. Consequently, the maximum pressure drop across
the power section, i.e. the full load pressure, must be reduced to avoid stator
elastomer premature deterioration. No reduction in full load pressure is nec-
essary up to a temperature of 140°F (60°C). Beyond that temperature, the full
load pressure obtained from the performance curves must be multiplied by
the dp reduction factor. For instance, if the full load pressure obtained from
section 11 is 600 psi and the static downhole temperature is 200°F (93°C), the
operating full load pressure is calculated by multiplying 600 psi by a dp reduc-
tion factor of 0.68, yielding 408 psi.

A standard power section can operate safely in static downhole tem-


peratures up to 225°F (107 degrees C). A higher static downhole tempera-
ture would require the use of a power section with larger clearances to avoid
premature deterioration. The Drill Right Tools motors have been successfully
used in temperatures up to 310°F (154° C) with special power sections. There-
fore, please consult Drill Right Tools should a static downhole temperature
greater than 225°F (107 degrees C) be anticipated.

Plugging Off
The motor may plug off with cuttings entering the drill string through
the filter plugs in the dump sub ports. To prevent this occurrence the hole
should be circulated to achieve “bottoms up” before running in the hole with a
motor.
Operations
This may also occur upon breaking connections when drilling cement
or unconsolidated sands, etc. As the annulus loads up with cuttings, and the
kelly is broken off, “U-Tubing” occurs, (i.e. the pressure in the annulus exceeds
the pressure in the bore due to different fluid densities). If this occurs, imme-
diately make the kelly back up and re-commence circulation and ensure that
the hole is cleaning properly. In some cases it may be necessary to blank off the
dump sub.

Hydraulic Extension
When using a positive displacement motor, the drill string stretches
when bottom is tagged, increasing the weight on bit. The sequence is as fol-
lows:

1. The motor is running freely “off bottom’:

2. When the string is lowered and the bit tags bottom, the torque
required to drive the bit causes an increase in the pressure across
the motor.

3. This increase in internal pressure in the drill string causes the drill
pipe to stretch and correspondingly, increases the weight on bit.

Usually the bit “drills off” and when the string is again lowered, the
above sequence repeats. However, under certain circumstances the motor
may stall and not drill off, and drilling with a positive displacement motor
becomes virtually impossible. The hydraulic extension maximizes due to the
stall pressure, and causes the bit to become imbedded. One solution is to
change the drill bit to a less aggressive style to avoid imbedding. An alter-
nate solution is to use a motor with a higher lobe configuration because these
require less pressure drop across the rotor and stator to produce the same
torque.

Partial Rotor Bypass


Drill Right Tools low speed motors with bored rotors permit higher
circulating rates than normally recommended as a portion of the circulating
fluid passes through the rotor center rather than the rotor stator interface. It
should be understood that the pressure drop across the rotor bore bypass
is the same as the pressure drop across the PDM drive section. At a very low
circulation rate, below a practical rate for operation, all circulation could be
through the rotor bore bypass and the rotor and output shaft will not turn
due to the static friction between the rotor and stator elastomer liner.
Operations
At high circulation rates “on bottom”; operating near the rated torque
of the motor, the resulting pressure drop across the PDM drive causes a sub-
stantial portion of total circulation to be directed through the rotor bore, keep-
ing the flow through the rotor stator interface within recommended operating
limits.

At high circulation rates “off bottom’; the pressure drop across the
PDM drive is low. Consequently, the portion of the circulating fluid passing
through the bypass is low, and the motor speed will exceed its recommended
limit. In order to avoid major damage, high circulating rates “off bottom” for
the purpose of checking pressure drop, should be kept to a short duration.

When circulating “off bottom’; for the purpose of hole cleaning, the
circulation rate should not exceed the maximum recommended for standard
motors without bored rotors.

Tripping Out of the Hole and Checking the Tool


No special procedures are required for tripping out of the hole with a
drill string containing a Drill Right Tools motor. The string automatically drains
through the dump sub. There is no requirement to perform any special checks
on the sealed bearing assembly or bit sub, as the thrust bearings are sealed in
an oil chamber.

Note: It is normal to see a small amount of drilling fluid draining from


the vent plugs and in certain models from the lower end of the seal bearing
assembly, just above the output shaft.

Note: Lighter mud weights will typically drain while tripping out of hole.
A motor that has not drained does not suggest that the motor is damaged.

Rig Site Maintenance


When drilling fluids containing chlorides have been used, it is im-
perative the Drill Right Tools motor is flushed, ideally with fresh water. Leaving
the motor unserviced causes severe pitting of the plated surfaces. The follow-
ing is the recommended minimum flushing procedure:

1) After the tools are removed above the dump sub, clean fluid
should be poured into the top of the dump sub and the piston
actuated with a hammer handle several times until it travels freely
up and down. Fluid should be flushed through the dump sub ports,
again actuating the piston until free travel is obtained.
Operations
2) Install the ported lift sub. Lift motor and place in bit breaker. Se-
cure the motor with a chain tong on the tool body. While rotating the
table slowly clockwise, for a minimum of 6 turns, add clean fluid in
the top or port provided.
Adjustable Housing Operating Instructions

These operating instructions apply to 2 degreee,3 degree


and 4 degree adjustable housings
power section

lock housing

tong area

adjusting ring
wear pad

offset housing
Figure 1 tong area

- Break joint with tong on tong areas.


- Keep adjusting ring engaged with offset housing and back off lock
housing 2 turns.
NOTE: Teeth must stay engaged during the back off
procedure.

power section

lock housing

adjusting ring

offset housing
Figure 2
- Slide adjusting ring up to disengage teeth.
- To adjust bend angle, rotate adjusting ring clockwise until the required
angle marked on the adjusing ring and offset housing match.

NOTE: Do not rotate counterclockwise beyond the 0


degree setting.
power section

apply thread dope lock housing


to this face before
retorquing

adjusting ring

offset housing

Figure 3
- Engaged teeth of adjusting ring at chosen angle setting.
- Apply thread dope to mating faces of the lock housing and adjusting
ring.
- Torque lock housing to recommended value listed in the table below.
- Matched number indicates angle of bend and exact short side of motor.

LOCK HOUSING MAKE-UP TORQUE


Motor size Imperial Metric
2 3/8" 1,600 lb-ft 2,200 N.m
2 7/8" 2,200 lb-ft 3,000 N.m
3 1/8" 4,500 lb-ft 6,100 N.m
3 3/8" 4,500 lb-ft 6,100 N.m
3 1/2" 5,000 lb-ft 6,800 N.m
3 3/4" 5,300 lb-ft 7,200 N.m
4 3/4" 10,000 lb-ft 13,500 N.m
5" 15,000 lb-ft 20,300 N.m
6 1/4" 23,000 lb-ft 31,000 N.m
6 3/4" / 7" 28,000 lb-ft 38,000 N.m
7 3/4" / 8" 43,000 lb-ft 58,000 N.m
9 5/8" 68,000 lb-ft 92,000 N.m
11 1/4" 80,000 lb-ft 108,000 N.m
Adjustable Housing Operations Instructions
In the event the adjusting ring disengages from the offset housing
and rotates with the lock housing, the procedure outlined below
should be followed to reset the adjusting ring to the proper posti-
tion prior to setting the bend angle:

Slide the adjusting ring up until teeth disengage from the


offset housing, if not already done.

Screw the adjusting ring (and the splined mandrel) clockwise


into the offset housing until the splined mandrel stops.

Back off 2 turns (counterclockwise rotation).

Rotate the adjusting ring clockwise until the “0” markings


align.

The adjustable housing is now reset and can be set to the desired
bend angle as indicated in the previous 2 pages.

The following table shows the available bend settings for the 2,3, and
4 degree adjustable housings.

Adjustable Housing Bend Settings


2 degree 3 degree 4 degree
0.00 0.00 0.00
0.26 0.39 0.35
0.52 0.78 0.69
0.77 1.15 1.04
1.00 1.50 1.37
1.22 1.83 1.69
1.41 2.12 2.00
1.59 2.38 2.29
1.73 2.60 2.57
1.85 2.77 2.83
1.93 2.89 3.06
1.98 2.97 3.28
2.00 3.00 3.46
3.63
3.76
3.86
3.94
3.98
4.00
Adj
ust
abl
eBentHous
ingProcedur
eFor
5”-
43/
4”7/8M/l2.
2S t
age
Applications
Deflection Devices
Directional drilling or sidetracking operations traditionally used a
bent sub or kick sub placed above the dump sub. A disadvantage of the bent
sub above the motor is that it places the bend too far “off bottom” and the drill
string should not be rotated.

Bent housings placed between the drive section and lower bearing
section place the bend closer to the bit, tilting the bit and bearing housing
axis in relation to the motor, minimizing bit wall drag. Motors containing bent
housings can be rotated. The disadvantage of conventional bent housings is
that their angle cannot be changed in the field.

Drill Right Tools adjustable housing has the advantages of placing


the bend close to the bit, and it can be rotated. It is easily adjustable from
straight to 3 degrees in 12 increments (or 2 degrees in 12 increments, or 4
degrees in 18 increments), on the rig floor. Drill Right Tools adjustable hous-
ing eliminates the need to select a bent housing angle before a motor can be
assembled and shipped. Drill Right Tools motors contain a screw-on stabilizer
thread on the lower sealed bearing assembly to enable the motor to be run
slick with the Drill Right Tools adjustable housing, or with field installable sta-
bilization as required.

Steerable Systems
The desired angle is set in the adjustable housing sufficient to alter
hole course with the drill string not rotating and the tool face oriented. When
the drill string is rotated with the motor operating, the system drills straight
ahead.

The broad range of circulation rates, bit speeds, and bit torques avail-
able with Drill Right Tools steerable downhole motors make them suitable for
use with journal bearing and roller tri-cone bits, PDC bits and diamond bits.

The measurement while drilling system, software, bit selection, and


operation of the total system is the expertise of others. Drill Right Tools con-
centrates on the ongoing development of improved motors and accessories,
to compliment the overall steerable system.
Applications
Performance Drilling
Drill Right Tools motors have been used successfully with higher
output power sections for straight hole “performance” drilling. These power
sections have more stages and consequently provide more uniform torque
output since the pressure per stage required producing a given torque is less.
The result is optimum rates of penetration.

Coring
Drill Right Tools multi-lobe series motors are ideally suited to coring
operations. The high torque, low speed characteristics provide increased pen-
etration rates at lower bit weights achieving better core recovery rates. Lower
drill string and casing wear is experienced, particularly in high angle holes. As
a rule no more than 60 feet (18 m) of core barrel should be run at a time.
Air or Two-Phase Drilling
The Drill Right Tools multi-lobe motors may be used for drilling with
air or two-phase drilling fluids as the circulating medium.

Two-phase drilling fluids can be defined as follows:

Mist: occurs when the liquid fraction is less than 2.5% at downhole
conditions. In this case the liquid stays as droplets within the gas.

Foam: occurs when the liquid fraction is between 2.5% and 25% at
downhole conditions. Foams are typically specified as “% foam qual-
ity: Foam quality is the volume fraction of the gas (i.e. 75% foam
quality is 75% gas and 25% liquid, by volume).

Aerated mud: occurs when the liquid fraction is greater than 25% at
downhole conditions. In this case the gas stays as bubbles within
the liquid.

Since there are large volumes of oxygen present in air drilling,


corrosion of the drillstring can be a concern. Passivating (oxidizing)
inhibitors should be used to minimize this corrosion.

Selection / Setup
The critical issue with using a motor in an air or two-phase drilling application
is minimizing the temperature generated within the stator elastomer liner.
This can be accomplished as follows:

Run stators with larger clearances if temp. dictates.

Use the lowest foam quality possible (i.e. the highest amount of liquid).

Minimize the RPM

Minimize times with no circulation.

All of the above, in addition to the downhole temperature, interact


to determine the life of the stator. Failure of the stator elastomer liner is ac-
celerated by internal heat build-up. As the liner heats up it expands, causing
an increase in the interference fit that in turn causes more friction and further
heat build-up. Hard spots then develop in the liner and eventually chunking
occurs. The problem is further compounded by the poor thermal conductivity
of air compared to a drilling fluid.
Air or Two-Phase Drilling
There are rotors and stators available that are designed specifically
for air or two-phase drilling. These accommodate high flow rates and run at
lower pressure drops and should be selected if available. Please contact Drill
Right Tools for availability and application of these power sections.

When air drilling power sections are not available, use power sec-
tions that run the slowest at the same flowrate. Ideally, use high performance
power sections (more stages) because the differential pressure per stage re-
quired to produce a given torque is less. This lower differential pressure will be
less damaging to the stator elastomer liner. Although the motor will produce
the same torque at a given differential pressure when using air, the maximum
obtainable differential pressure will be less due to the extra slipage that oc-
curs with a gas. Consequently, the maximum obtainable torque (and stall) will
be lower.

A crossover sub should be used above the PDM drive rather than the
dump sub because airflow will not cause the dump sub to close. Alternatively
the dump sub ports can be blanked off.

While drilling with air or two-phase fluid, the fluid density in the
annulus may be higher than in the bore due to the cuttings in the annulus.
When a connection is being made the pressure is reduced in the bore that can
result in cuttings entering the bore. This can damage the motor or plug the
bit. A float valve should therefore be used when drilling with air or two-phase
fluids to prevent this. A small hole is sometimes drilled in the flapper to allow
pressure to equalize if the drillstring does become plugged between the float
valve and the bit.

Fluid / Lubricant Requirements


A lubricant is required to lubricate the stator elastomer liner. Soap or gel thor-
oughly mixed with water and injected at a minimum rate (in GPM) of 5% by
volume at downhole conditions is adequate for most applications. However,
other drilling concerns may dictate higher flow (i.e. avoiding formation of
mud rings).

Example next Page


Air or Two-Phase Drilling
Given:
Air flow rate required =2000 scfm
Bit Pressure drop = 100 psi
Hydrostatic pressure = 200 psi
Pressure to turn motor (no load) =75 psi

Calculated:

Motor exit pressure = 100 + 200 =300 psi



Pressure at no load =300 + 75 =375 psi

Flow at no load conditions
=(14.7/(14.7+375))*2000* 7.48 =564 gpm

Required minimum lubricant =.05*564 =28 gpm

Pressures
The pressure at the outlet of the motor (i.e. the motor exit pressure)
has a pronounced effect on the response of the motor. The motor exit pres-
sure is the sum of the hydrostatic pressure and the bit pressure drop. This is
the pressure that determines the volume flow rate through the motor.

As the motor exit pressure increases, the motor becomes less suscep-
tible to runaway and acts more like a motor running on liquid only.

Temperature
Typically, standard fit motors can be used except where the down-
hole temperature dictates that a stator with larger clearances is required.
Static bottom hole temperature up to 225°F (107°C) is considered standard.

The air expands as it exits the rotor stator and then the bit nozzles.
The resulting pressure drop has a cooling effect that can increase the life of
the stator.

Volume Requirements
In a standard air drilling application, the required air flow rate (in
SCFM) for proper motor operation is typically three to four times the maxi-
mum motor liquid flow rate (in GPM). This rule applies for motor exit pressures
up to approximately 300 psi.
Air or Two-Phase Drilling
As the motor exit pressure increases, the airflow rate required to
achieve the same motor operating speed (rpm) also increases. This is com-
mon in some under-balanced applications. In these cases the required air
flow rate increases. Consult Drill Right Tools engineering in these cases.

If higher flow rates are desired, the rotor can be fitted with a nozzle
to bypass a portion of the flow. However, the motor becomes even more sen-
sitive to stall if the rotor bypass is used.

Operation
In general, a motor driven by air, mist or foam should be started
while on bottom. It should not be allowed to run freely before tagging bot-
tom because this can cause high shock loads as the bit tags bottom which
may damage the motor. Ideally, the motor should be started with fluid first.

A motor is much more torque sensitive when using air, mists, or


foams, than with liquids and consequently is more susceptible to stalling.

When drilling operations are to be stopped, let the motor drill off
as the compressors and boosters are being shut down. Picking up “off bot-
tom” prior to equalizing the pressure can permit the air compressed in the
drill string to expand, overspeeding and possibly damaging the motor. It can
also cause the internal connections to back off.

Drilling with Nitrogen (N2)


Air itself consists of approximately 78% nitrogen. The density of ni-
trogen is approximately 3% less than that of air at standard temperature and
pressure. Functionally, the motors will run the same on nitrogen as air. How-
ever, the explosive decompression, as discussed below, is more severe with
nitrogen.

Since nitrogen is an inert gas the nitrile sealing components with-


in the motor, including the stator, are not affected chemically by nitrogen.
However, any sealing compound will absorb nitrogen (as well as other gases)
to some extent while under pressure. If the pressure has been applied long
enough and the pressure is released too quickly, the gas does not have suf-
ficient time to be expelled from the nitrile and explosive decompression can
occur, resulting in blistering. This is typically not a problem with continuous
pressure drops across the motor of 400 psi (3,000 kPa) and less.

After drilling for extended periods with nitrogen, stator damage can
be expected.
Trouble Shooting
Sudden Pressure Increase

This may occur when the motor stalls. To correct, pick up off bottom,
and then return to bottom with less bit weight.

The tool may be plugged internally, or the bit plugged requiring a
trip out of the hole for bit or motor replacement.

No Penetration
This may occur due to a worn bit, requiring a bit trip.

Formation changes may require changes in bit weight and circula-
tion rates.

The motor may be stalled, which can be detected by a pressure increase.

The stabilizer may be hanging up on the formation.

The bit may be balled up requiring a different bit for the formation.

The stator elastomer liner may be damaged requiring a trip out of


the hole and motor replacement.

Slow Pressure Decrease


This may result from a wash out in the string or the dump sub.

Lost circulation causes a decrease in pressure if there is no return


and may be confirmed by checking the pit level.

A gas kick causes a decrease in pressure and may be detected by an


increase in R.O.P. and confirmed by checking the pit level.
Motor Performance

Imperial Units
Max Max Torque rev/gal Pressure
Motor Flow Bit at at at
Rate Speed Full Load No Load Full Load
gpm RPM lb-ft rev/gal psi

4 3/4” 7/8 M/L 2.0 Stage 250 80 2150 0.32 260


4 3/4” 7/8 M/L 3.8 Stage 250 140 2430 0.56 490
5” -4 3/4” 7/8 M/L 2.2 Stage 250 130 1660 0.56 400
6 1/4” 7/8 M/L 2.9 Stage 500 85 5590 0.17 380
6 1/4” 7/8 M/L 4.8 Stage 400 140 4840 0.35 620
6 3/4” 7/8 M/L 3.0 Stage 600 170 3490 0.28 390
6 3/4” 7/8 M/L 3.5 Stage 600 90 7830 0.15 460
6 3/4” 7/8 M/L 5.0 Stage 600 170 5950 0.28 650
7 3/4” (8”) 7/8 M/L 4.5 Stage 900 140 8660 0.16 520
6 3/4” 7/8 M/L 3.0 Stage HR 600 170 6280 0.28 680

Metric Units
Max Max Torque rev/gal Pressure
Motor Flow Bit at at at
Rate Speed Full Load No Load Full Load
lpm RPM N.m rev/l kPa

4 3/4” 7/8 M/L 2.0 Stage 950 80 2913 0.085 2913


4 3/4” 7/8 M/L 3.8 Stage 950 140 3290 0.148 3380
5” -4 3/4” 7/8 M/L 2.2 Stage 950 130 2251 0.148 2800
6 1/4” 7/8 M/L 2.9 Stage 1890 85 7570 0.045 2620
6 1/4” 7/8 M/L 4.8 Stage 1510 140 6560 0.092 4270
6 3/4” 7/8 M/L 3.0 Stage 2270 170 4730 0.074 2690
6 3/4” 7/8 M/L 3.5 Stage 2270 90 10610 0.040 3170
6 3/4” 7/8 M/L 5.0 Stage 2270 170 8060 0.075 4480
7 3/4” (8”) 7/8 M/L 4.5 Stage 3410 140 11730 0.041 3590
6 3/4” 7/8 M/L 3.0 Stage HR 2270 170 8510 0.074 4650
4 3/4” 7/8 M/L 2.0 Stage (air)
A 2 ft (0.61m)
B 5.4 ft (1.65m)
C 22.5 ft (6.86 m)
D Maximum Diameter of Motor at Upset
A 5.38 in (137 mm)
D E set Pad: 2.65 in (67mm)
Common Top Connection: 3 1/2 IF 3 1/2 REG

Common Bottom Connection: 3 1/2 REG


Weight 950 lbs (430 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 6 6 1/4 6 3/4 6 6 1/4 6 3/4 6 6 1/4 6 3/4
0.39 1.5 1.5 1.4 2.5 2.7 3.0 1.8 1.8 1.8
0.78 4.2 3.5 2.9 5.0 5.2 5.5 4.6 4.6 4.6
1.15 7.0 6.2 4.7 7.4 7.6 7.9 7.2 7.2 7.2
1.50 9.6 8.8 7.3 9.6 9.8 10.1 9.7 9.7 9.7
1.83 12.1 11.3 9.7 12.1 11.9 12.2 12.1 11.9 12.0
2.12 14.2 13.4 11.8 14.2 13.8 14.0 14.2 13.8 14.0
2.38 16.2 15.3 13.7 16.2 15.3 15.7 16.2 15.5 15.7
2.60 17.8 17.0 15.4 17.8 17.0 17.1 17.8 17.0 17.1
E 2.77 19.1 18.2 16.6 19.1 18.2 18.2 19.1 18.2 18.2
B 2.89 20.0 19.1 17.5 20.0 19.1 18.9 20.0 19.1 18.9
2.97 20.6 19.7 18.1 20.6 19.7 19.4 20.6 19.7 19.4
3.00 20.8 20.0 18.3 20.8 20.0 19.6 20.8 20.0 19.6

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
6 6 1/4 6 3/4 6 6 1/4 6 3/4 6 6 1/4 6 3/4
0.0 3.00 3.00 3.00 2.89 3.00 3.00 2.77 2.89 3.00
3.0 3.00 3.00 3.00 2.60 2.77 3.00 2.38 2.38 3.00
6.0 3.00 3.00 3.00 2.12 2.38 3.00 1.83 2.12 2.60
9.0 2.60 2.77 3.00 1.83 1.83 2.38 1.50 1.83 2.12
12.0 2.12 2.38 2.77 1.50 1.83 2.12 1.15 1.50 1.83
15.0 1.83 2.12 2.38 1.15 1.50 1.50 0.78 1.15 1.15
18.0 1.50 1.50 2.12 0.78 1.15 1.15 0.78 0.78 0.78
21.0 1.15 1.15 1.50 0.39 0.78 0.78 0.39 0.39 0.39
24.0 0.78 0.78 1.15 0.00 0.00 0.39 0.00 0.00 0.00
27.0 0.39 0.39 0.78 0.00
30.0 0.00 0.00 0.39
33.0 0.00 0.00
36.0

C
4 3/4” 7/8 M/L 2.0 Stage(air)
cations based on series 24x motor.
Maximum Pump Rate 250 gpm 950 lpm
Revolutions per Unit Volume 0.32 rev/gal 0.085 rev/l
Pressure at Full Load 260 psi 1790 kPa
Torque at Full Load 2,150 lb-ft 2913 Nm
Maximum Weight on Bit 69,000 lbs 310 kN
Maximum Pull to Re-Run Motor 144,000 lbs 650 kN
Pull to Yield Motor 331,000 lbs 1490 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 500 1000 1500 2000 2500 kPa

0 100 200 300 400 psi

90
80 250 (950)
70 200 (760)
SPEED : RPM

60 150 (570)
50
100 (380)
40
30
20
10 gpm (lpm)
0

3500
4500
3000
TORQUE : N.m
TORQUE : lb-ft

2500 3600

2000 2700
1500
FULL LOAD

1800
1000

500 900

45
40 30
OUTPUT POWER : HP

OUTPUT POWER : kw

250 (950)
35
25
30
200 (760)
25 20
20 150 (570) 15
15
100 (380) 10
10
5 5
gpm (lpm)
0 0
4 3/4” 7/8 M/L 3.8 Stage
A 2ft (0.61 m)
B 5.4ft (1.65 m)
C 23.9ft (7.28 m)
D Maximum Diameter of Motor at Upset
A 5.38 in (137 mm)
D
E set Pad: 2.65 in (67mm)
Common Top Connection: 3 1/2 IF 3 1/2 REG
Common Bottom Connection: 3 1/2 REG

Weight 1010 lbs (460 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 6 6 1/4 6 3/4 6 6 1/4 6 3/4 6 6 1/4 6 3/4
0.39 1.4 1.4 1.4 2.5 2.6 2.9 1.8 1.8 1.8
0.78 4.1 3.4 2.8 3.9 5.1 5.4 4.5 4.5 4.5
1.15 6.8 6.1 4.6 7.3 7.4 7.7 7.1 7.1 7.1
1.50 9.4 8.6 7.1 9.4 9.6 9.9 9.5 9.5 9.5
1.83 11.8 11.0 9.5 11.8 11.7 12.0 11.8 11.7 11.8
2.12 13.9 13.1 11.6 13.9 13.6 13.8 13.9 13.6 13.8
2.38 15.8 15.0 13.5 15.8 15.0 15.4 15.8 15.2 15.4
2.60 17.5 16.6 15.1 17.5 16.6 16.8 17.5 16.6 16.8
E 2.77 18.7 17.9 16.3 18.7 17.9 17.8 18.7 17.9 17.8
B 2.89 19.6 18.8 17.1 19.6 18.8 18.6 19.6 18.8 18.6
2.97 20.2 19.3 17.7 20.2 19.3 19.1 20.2 19.3 19.1
3.00 20.4 19.6 17.9 20.4 19.6 19.3 20.4 19.6 19.3

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
6 6 1/4 6 3/4 6 6 1/4 6 3/4 6 6 1/4 6 3/4
0.0 3.00 3.00 3.00 3.00 3.00 3.00 2.77 3.00 3.00
3.0 3.00 3.00 3.00 2.60 2.77 3.00 2.38 2.60 3.00
6.0 3.00 3.00 3.00 2.12 2.38 3.00 2.12 2.12 2.60
9.0 2.60 2.89 3.00 1.83 1.83 2.38 1.50 1.83 2.12
12.0 2.12 2.38 2.77 1.50 1.83 2.12 1.15 1.50 1.83
15.0 1.83 2.12 2.38 1.15 1.50 1.50 0.78 1.15 1.15
18.0 1.50 1.50 2.12 0.78 1.15 1.15 0.78 0.78 0.78
21.0 1.15 1.15 1.50 0.39 0.78 0.78 0.39 0.39 0.39
24.0 0.78 0.78 1.15 0.00 0.00 0.39 0.00 0.00 0.00
27.0 0.39 0.39 0.78
30.0 0.00 0.00 0.39
33.0 0.00
36.0

C
cations based on series 24x motor.

4 3/4” 7/8 M/L 3.8 Stage


Maximum Pump Rate 250 gpm 950 lpm
Revolutions per Unit Volume 0.56 rev/gal 0.148 rev/l
Pressure at Full Load 490 psi 3380 kPa
Torque at Full Load 2,430 lb-ft 3293 Nm
Maximum Weight on Bit 69000 lbs 310 kN
Maximum Pull to Re-Run Motor 144000 lbs 650 kN
Pull to Yield Motor 331000 lbs 1490 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 kPa
0 100 200 300 400 500 600 psi

150
250 (950)
125
220 (830)
SPEED : RPM

100 190 (270)


160 (610)
75

50 gpm (lpm)

25

3000
4000
2500 3500
TORQUE : lb-ft

TORQUE : N.m

3000
2000
2500
1500 2000
FULL LOAD

1000 1500
1000
500
500
0 0

70
50
60
OUTPUT POWER : HP

OUTPUT POWER : kw

40
50 )
(950
250 )
40 ( 0
8 3 30
220 )
(270
30 190 )
(610 20
160
20
gpm (lpm) 10
10

0 0
6 3/4” 7/8 M/L 3.0 StageHR
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 20 ft (6.1 m)
D Maximum Diameter of Motor at Upset
A 7.63 in (194 mm)
D E set Pad: 3.63 in (92mm)
Common Top Connection: 4 1/2 REG 4 1/2 IF
4 1/2 H-90 5 H-90
Common Bottom Connection: 4 1/2 REG 6 5/8 REG
Weight 1700 lbs (770 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8
0.39 1.6 1.9 1.5 3.1 3.3 4.2 1.9 1.9 1.9
0.78 3.6 3.1 3.0 5.6 5.8 6.6 4.7 4.8 4.8
1.15 6.5 5.8 4.5 8.0 8.2 8.9 7.5 7.5 7.5
1.50 9.3 8.6 5.8 10.3 10.4 11.1 10.0 10.0 10.0
1.83 11.9 11.2 8.2 11.9 12.6 13.2 12.4 12.4 12.4
2.12 14.3 13.5 10.4 14.3 14.4 15.0 14.3 14.4 14.5
2.38 16.3 15.6 12.4 16.3 15.6 16.7 16.3 16.1 16.4
2.60 18.1 17.4 14.1 18.1 17.4 18.0 18.1 17.5 18.0
E 2.77 19.5 18.7 15.5 19.5 18.7 19.1 19.5 18.7 19.1
B 2.89 20.4 19.7 16.4 20.4 19.7 19.9 20.4 19.7 19.9
2.97 21.0 20.3 17.0 21.0 20.3 20.4 21.0 20.3 20.4
3.00 21.3 20.5 17.2 21.3 20.5 20.5 21.3 20.5 20.5

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/4
0.0 3.00 3.00 3.00 2.60 2.77 2.60 2.12 2.38 2.12
3.5 2.60 2.89 3.00 2.12 1.83 2.12 1.83 1.50 1.50
7.0 2.38 2.38 3.00 1.15 1.50 1.50 1.15 1.15 1.15
10.5 1.83 2.12 2.89 0.78 0.78 1.15 0.39 0.39 0.39
14.0 1.50 1.83 2.38 0.39 0.39 0.39 0.00 0.00 0.00
17.5 1.15 1.15 2.12 0.00 0.00 0.00
21.0 0.78 0.78 1.83
24.5 0.39 0.39 1.15
28.0 0.00 0.00 0.78
31.5 0.00 0.39
35.0 0.39
38.5 0.00
42.0

C
4 3/4” 7/8 M/L 3.8 StageHR
cations based on series 24x motor.
Maximum Pump Rate 250 gpm 950 lpm
Revolutions per Unit Volume 0.56 rev/gal 0.148 rev/l
Pressure at Full Load 860 psi 5900 kPa
Torque at Full Load 4,450 lb-ft 6025 Nm
Maximum Weight on Bit 69000 lbs 310 kN
Maximum Pull to Re-Run Motor 144000 lbs 650 kN
Pull to Yield Motor 331000 lbs 1490 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 3000 5000 7000 kPa

0 200 400 600 800 1000 psi

150
250 (950)
125
200 (760)
SPEED : RPM

100 150 (560)

75

50 gpm (lpm)

25

6000
8000
5000 7000
TORQUE : lb-ft

TORQUE : N.m

6000
4000
5000
3000 4000
FULL LOAD

2000 3000
2000
1000 1000
0 0

105
100
90
OUTPUT POWER : HP

OUTPUT POWER : kw

80
75
)
60 (950 60
250 )
( 0
7 5
45 200 )
(560 40
150
30
gpm (lpm) 20
15

0 0
5” - 4 3/4” 7/8 M/L 2.2 Stage
A 1.5 ft (0.46m)
B 5.75 ft (1.75m)
C 18.9 ft (5.76 m)
D Maximum Diameter of Motor at Upset
A 8.63 in (141.2 mm)
D E set Pad: 3.54 in (89.9mm)
Common Top Connection: 3 1\2 IF

Common Bottom Connection: 3 1\2 REG


Weight 780 lbs (350 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 6 6 1/8 6 1/4 6 6 1/8 6 1/4 6 6 1/8 6 1/4
1.15 8.5 7.6 6.7 8.5 8.3 8.1 8.5 7.8 7.4
1.50 13.8 12.7 11.6 13.8 12.2 12.7 13.7 12.9 12.1
1.83 19.0 17.8 16.6 19.0 17.8 16.6 19.0 17.9 16.8
2.12 23.8 22.4 21.1 23.8 22.4 21.1 23.8 22.9 21.1
2.38 28.1 26.7 25.4 28.1 26.7 25.4 28.1 26.7 25.4
2.60 31.8 30.3 29.0 31.8 30.3 29.0 31.8 30.3 29.0
2.77 34.7 33.2 31.8 34.9 33.3 31.8 34.8 33.3 31.8
2.90 36.9 35.5 34.0 37.1 35.6 34.0 37.1 35.6 34.0
E 3.00 38.6 37.2 35.6 38.9 37.5 35.6 38.9 37.5 35.6
B

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
6 6 1/8 6 1/4 6 6 1/8 6 1/4 6 6 1/8 6 1/4
0.0 3.00 3.00 3.00 2.60 2.77 2.77 2.38 2.38 2.38
3.5 2.90 2.90 3.00 2.12 2.38 2.38 1.83 2.12 2.12
7.0 2.60 2.77 2.77 1.83 2.12 2.12 1.50 1.83 1.83
10.5 2.12 2.38 2.38 1.50 1.83 1.83 1.15 1.50 1.50
14.0 1.83 2.12 2.12 1.15 1.50 1.50 0.00 0.00 0.00
17.5 1.50 1.83 1.83 1.15 1.15
21.0 1.15 1.50 1.50
24.5 1.15 1.15

C
5” - 4 3/4“ 7/8 M/L 2.2 Stage
cations based on series 24x motor.
Maximum Pump Rate 300 gpm 950 lpm
Revolutions per Unit Volume 0.56 rev/gal 0.148 rev/l
Pressure at Full Load 400 psi 2800 kPa
Torque at Full Load 1660 lb-ft 2251 Nm
Maximum Weight on Bit 45,000 lbs 200.2 kN
Maximum Pull to Re-Run Motor 144,000 lbs 650 kN
Pull to Yield Motor 210,000 lbs 1472 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 kPa

0 60 120 180 240 300 360 420 480 psi

160
140
250 (946)
120
SPEED : RPM

100
175 (662)
80
60 100 (379)
40
20 gpm (lpm)
0

2500
2250 2400
2000
TORQUE : N.m
TORQUE : lb-ft

2000
1750
1500 1600
1250
1200
1000
FULL LOAD

750 800
500
400
250
0 0

40
35 25
OUTPUT POWER : HP

OUTPUT POWER : kw

250 (950)
30
20
25 200 (760)
20 15
15 150 (570)
10
10
100 (380) 5
5 gpm (lpm)
0 0
6 1/4” 7/8 M/L 2.9 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 28 ft (8.53m)
D Maximum Diameter of Motor at Upset
A 7.12 in (181 mm)
D E set Pad: 3.44 in (87mm)
Common Top Connection: 4 1/2 REG 4 1/2 XH
4 1/2 H-90
Common Bottom Connection: 4 1/2 REG
Weight 2040 lbs (930 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4
0.39 1.2 1.4 1.2 2.2 2.5 2.6 1.6 1.6 1.6
0.78 3.2 2.4 2.4 4.3 4.6 4.7 3.9 3.9 3.9
1.15 5.4 4.1 3.6 6.2 6.5 6.6 6.1 6.1 6.1
1.50 7.6 6.3 5.7 8.1 8.3 8.4 8.1 8.1 8.1
1.83 9.6 8.3 7.7 9.8 10.1 10.1 9.8 10.1 10.1
2.12 11.4 10.0 9.5 11.4 11.6 11.6 11.4 11.6 11.6
2.38 13.0 11.6 11.1 13.0 12.9 13.0 13.0 12.9 13.0
2.60 14.3 12.9 12.4 14.3 14.1 14.1 14.3 14.1 14.1
E 2.77 15.3 14.0 13.4 15.3 15.0 15.0 15.3 15.0 15.1
B 2.89 16.1 14.7 14.1 16.1 15.6 15.7 16.1 15.6 15.7
2.97 16.6 15.2 14.6 16.6 16.0 16.1 16.6 16.0 16.1
3.00 16.8 15.3 14.8 16.8 16.2 16.2 16.8 16.2 16.2

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4
0.0 3.00 3.00 3.00 2.60 3.00 3.00 2.38 3.00 3.00
2.5 3.00 3.00 3.00 2.12 2.89 2.89 2.12 2.60 2.60
5.0 2.60 3.00 3.00 1.83 2.38 2.38 1.83 2.12 2.12
7.5 2.12 2.60 2.77 1.50 1.83 1.83 1.15 1.50 1.50
10.0 1.83 2.12 2.38 1.50 1.50 1.50 1.15 1.15 1.15
12.5 1.50 1.83 2.12 1.15 1.15 1.15 0.78 0.78 0.78
15.0 1.15 1.50 1.50 0.39 0.39 0.78 0.39 0.39 0.39
17.5 0.78 1.15 1.15 0.00 0.00 0.00 0.00 0.00 0.00
20.0 0.39 0.78 0.78
22.5 0.00 0.39 0.39
25.0 0.00 0.39
27.5 0.00
30.0

C
6 1/4” 7/8 M/L 2.9 Stage
cations based on series 24x motor.
Maximum Pump Rate 500 gpm 1890 lpm
Revolutions per Unit Volume 0.17 rev/gal 0.045 rev/l
Pressure at Full Load 380 psi 2620 kPa
Torque at Full Load 5,590 lb-ft 7574 Nm
Maximum Weight on Bit 87,000 lbs 390 kN
Maximum Pull to Re-Run Motor 215,000 lbs 970 kN
Pull to Yield Motor 642,000 lbs 2890 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 kPa
0 100 200 300 400 500 600 psi

90
80 500 (1890)
70
SPEED : RPM

400 (1510)
60
50 300 (1140)
40
30 200 (760)
20
10 gpm (lpm)
0

10000
9000 12000
8000
TORQUE : N.m
TORQUE : lb-ft

10000
7000
6000 8000
5000
6000
4000
FULL LOAD

3000 4000
2000
2000
1000
0 0

90
500 (1890)
80 60
OUTPUT POWER : HP

OUTPUT POWER : kw

70
50
60 400 (1510)
50 40
40 300 (1140) 30
30
20
20
200 (760)
10 10
gpm (lpm)
0 0
6 1/4” 7/8 M/L 4.8 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 26.6 ft (8.11m)
D Maximum Diameter of Motor at Upset
A 7.12 in (181 mm)
D E set Pad: 3.44 in (87mm)
Common Top Connection: 4 1/2 REG 4 1/2 XH
4 1/2 H-90
Common Bottom Connection: 4 1/2 REG
Weight 1940 lbs (880 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4
0.39 1.3 1.4 1.2 2.4 2.7 2.8 1.7 1.7 1.7
0.78 3.3 2.5 2.5 4.5 4.8 4.9 4.1 4.1 4.1
1.15 5.7 4.3 3.8 6.5 6.8 6.9 6.3 6.3 6.3
1.50 7.9 6.6 6.0 8.4 8.7 8.8 8.4 8.4 8.4
1.83 10.0 8.7 8.1 10.0 10.5 10.6 10.2 10.5 10.5
2.12 11.9 10.5 9.9 11.9 12.1 12.1 11.9 12.1 12.1
2.38 13.6 12.1 11.6 13.6 13.5 13.5 13.6 13.5 13.5
2.60 15.0 13.5 13.0 15.0 14.7 14.7 15.0 14.7 14.7
E 2.77 16.1 14.6 14.0 16.1 15.6 15.6 16.1 15.6 15.6
B 2.89 16.8 15.4 14.8 16.8 16.2 16.3 16.8 16.2 16.3
2.97 17.3 15.9 15.3 17.3 16.7 16.7 17.3 16.7 16.7
3.00 17.5 16.1 15.5 17.5 16.8 16.9 17.5 16.8 16.9

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4 7 7/8 8 1/2 8 3/4
0.0 3.00 3.00 3.00 2.60 3.00 3.00 2.38 2.89 3.00
2.5 3.00 3.00 3.00 2.12 2.77 2.77 2.12 2.38 2.38
5.0 2.60 3.00 3.00 1.83 2.38 2.38 1.50 2.12 2.12
7.5 2.12 2.60 2.77 1.50 1.83 1.83 1.15 1.50 1.50
10.0 1.83 2.12 2.38 1.15 1.50 1.50 1.15 1.15 1.15
12.5 1.50 1.83 2.12 0.78 1.15 1.15 0.78 0.78 0.78
15.0 1.15 1.50 1.50 0.39 0.39 0.78 0.39 0.39 0.39
17.5 0.78 1.15 1.15 0.00 0.00 0.00 0.00 0.00 0.00
20.0 0.39 0.78 0.78
22.5 0.00 0.39 0.39
25.0 0.00 0.39
27.5 0.00
30.0

C
cations based on series 24x motor.

6 1/4” 7/8 M/L 4.8 Stage


Maximum Pump Rate 400 gpm 1510 lpm
Revolutions per Unit Volume 0.35 rev/gal 0.092 rev/l
Pressure at Full Load 620 psi 4270 kPa
Torque at Full Load 4,840 lb-ft 6558 Nm
Maximum Weight on Bit 87,000 lbs 390 kN
Maximum Pull to Re-Run Motor 215,000 lbs 970 kN
Pull to Yield Motor 642,000 lbs 2890 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 5000 6000 kPa

0 200 400 600 800 1000 psi

140
400 (1510)
120
SPEED : RPM

100 320 (1210)

80
240 (910)
60
160 (910)
40

20
gpm (lpm)
0

8000
10000
7000
TORQUE : N.m
TORQUE : lb-ft

6000 8000
5000
6000
4000
3000
FULL LOAD

4000
2000
1000 2000

0 0

150
gpm (lpm) 100
OUTPUT POWER : HP

400 (1510)
OUTPUT POWER : kw

125
80
100 320 (1210)
60
75
240 (910)
50 40

25 160 (910)
20

0 0
6 3/4” 7/8 M/L 3.0 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 20 ft (6.1 m)
D Maximum Diameter of Motor at Upset
A 7.63 in (194 mm)
D E set Pad: 3.63 in (92mm)
Common Top Connection: 4 1/2 REG 4 1/2 IF
4 1/2 H-90 5 H-90
Common Bottom Connection: 4 1/2 REG 6 5/8 REG
Weight 1700 lbs (770 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8
0.39 1.6 1.9 1.5 3.1 3.3 4.2 1.9 1.9 1.9
0.78 3.6 3.1 3.0 5.6 5.8 6.6 4.7 4.8 4.8
1.15 6.5 5.8 4.5 8.0 8.2 8.9 7.5 7.5 7.5
1.50 9.3 8.6 5.8 10.3 10.4 11.1 10.0 10.0 10.0
1.83 11.9 11.2 8.2 11.9 12.6 13.2 12.4 12.4 12.4
2.12 14.3 13.5 10.4 14.3 14.4 15.0 14.3 14.4 14.5
2.38 16.3 15.6 12.4 16.3 15.6 16.7 16.3 16.1 16.4
2.60 18.1 17.4 14.1 18.1 17.4 18.0 18.1 17.5 18.0
E 2.77 19.5 18.7 15.5 19.5 18.7 19.1 19.5 18.7 19.1
B 2.89 20.4 19.7 16.4 20.4 19.7 19.9 20.4 19.7 19.9
2.97 21.0 20.3 17.0 21.0 20.3 20.4 21.0 20.3 20.4
3.00 21.3 20.5 17.2 21.3 20.5 20.5 21.3 20.5 20.5

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/4
0.0 3.00 3.00 3.00 2.60 2.77 2.60 2.12 2.38 2.12
3.5 2.60 2.89 3.00 2.12 1.83 2.12 1.83 1.50 1.50
7.0 2.38 2.38 3.00 1.15 1.50 1.50 1.15 1.15 1.15
10.5 1.83 2.12 2.89 0.78 0.78 1.15 0.39 0.39 0.39
14.0 1.50 1.83 2.38 0.39 0.39 0.39 0.00 0.00 0.00
17.5 1.15 1.15 2.12 0.00 0.00 0.00
21.0 0.78 0.78 1.83
24.5 0.39 0.39 1.15
28.0 0.00 0.00 0.78
31.5 0.00 0.39
35.0 0.39
38.5 0.00
42.0

C
cations based on series 24x motor.

6 3/4” 7/8 M/L 3.0 Stage


Maximum Pump Rate 600 gpm 2270 lpm
Revolutions per Unit Volume 0.28 rev/gal 0.074 rev/l
Pressure at Full Load 390 psi 2690 kPa
Torque at Full Load 3,490 lb-ft 4792 Nm
Maximum Weight on Bit 122,000 lbs 550 kN
Maximum Pull to Re-Run Motor 277,000 lbs 1250 kN
Pull to Yield Motor 672,000 lbs 3020 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 kPa
0 100 200 300 400 500 600 psi

180
160 600 (2270)

140 500 (1890)


SPEED : RPM

120
400 (1510)
100
80 300 (1140)
60
40
20 gpm (lpm)
0

6000 8000

5000 7000
TORQUE : N.m
TORQUE : lb-ft

6000
4000
5000
3000 4000
FULL LOAD

3000
2000
2000
1000 1000
0 0

140 100
90
OUTPUT POWER : HP

120
OUTPUT POWER : kw

600 (2270)
80
100 70
500 (1890)
80 60
400 (1510) 50
60 40
40 300 (1140) 30
20
20
gpm (lpm) 10
0 0
6 3/4” 7/8 M/L 3.0 StageHR
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 20 ft (6.1 m)
D Maximum Diameter of Motor at Upset
A 7.63 in (194 mm)
D E set Pad: 3.63 in (92mm)
Common Top Connection: 4 1/2 REG 4 1/2 IF
4 1/2 H-90 5 H-90
Common Bottom Connection: 4 1/2 REG 6 5/8 REG
Weight 1700 lbs (770 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8
0.39 1.6 1.9 1.5 3.1 3.3 4.2 1.9 1.9 1.9
0.78 3.6 3.1 3.0 5.6 5.8 6.6 4.7 4.8 4.8
1.15 6.5 5.8 4.5 8.0 8.2 8.9 7.5 7.5 7.5
1.50 9.3 8.6 5.8 10.3 10.4 11.1 10.0 10.0 10.0
1.83 11.9 11.2 8.2 11.9 12.6 13.2 12.4 12.4 12.4
2.12 14.3 13.5 10.4 14.3 14.4 15.0 14.3 14.4 14.5
2.38 16.3 15.6 12.4 16.3 15.6 16.7 16.3 16.1 16.4
2.60 18.1 17.4 14.1 18.1 17.4 18.0 18.1 17.5 18.0
E 2.77 19.5 18.7 15.5 19.5 18.7 19.1 19.5 18.7 19.1
B 2.89 20.4 19.7 16.4 20.4 19.7 19.9 20.4 19.7 19.9
2.97 21.0 20.3 17.0 21.0 20.3 20.4 21.0 20.3 20.4
3.00 21.3 20.5 17.2 21.3 20.5 20.5 21.3 20.5 20.5

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/4
0.0 3.00 3.00 3.00 2.60 2.77 2.60 2.12 2.38 2.12
3.5 2.60 2.89 3.00 2.12 1.83 2.12 1.83 1.50 1.50
7.0 2.38 2.38 3.00 1.15 1.50 1.50 1.15 1.15 1.15
10.5 1.83 2.12 2.89 0.78 0.78 1.15 0.39 0.39 0.39
14.0 1.50 1.83 2.38 0.39 0.39 0.39 0.00 0.00 0.00
17.5 1.15 1.15 2.12 0.00 0.00 0.00
21.0 0.78 0.78 1.83
24.5 0.39 0.39 1.15
28.0 0.00 0.00 0.78
31.5 0.00 0.39
35.0 0.39
38.5 0.00
42.0

C
6 3/4” 7/8 M/L 3.0 StageHR
cations based on series 24x motor.
Maximum Pump Rate 600 gpm 2270 lpm
Revolutions per Unit Volume 0.28 rev/gal 0.074 rev/l
Pressure at Full Load 680 psi 4650 kPa
Torque at Full Load 6,280 lb-ft 8510 Nm
Maximum Weight on Bit 122,000 lbs 550 kN
Maximum Pull to Re-Run Motor 277,000 lbs 1250 kN
Pull to Yield Motor 672,000 lbs 3020 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 kPa
0 100 200 300 400 500 600 700 800 psi

180
160 600 (2270)

140 500 (1890)


SPEED : RPM

120
400 (1510)
100
80 300 (1140)
60
gpm (lpm)
40
20
0

8000 12000
7000 11000
10000
6000
TORQUE : N.m
TORQUE : lb-ft

9000
5000 8000
7000
4000 6000
5000
3000
FULL LOAD

4000
2000 3000
2000
1000
1000
0 0

240
160
OUTPUT POWER : HP

OUTPUT POWER : kw

200 600 (2270)


140
160 500 (1890) 120
100
120 400 (1510) 80
80 60
300 (1140)
40
40 gpm (lpm) 20
0 0
6 3/4” 7/8 M/L 3.5 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 30.1 ft (9.54 m)
D Maximum Diameter of Motor at Upset
A 7.63 in (194 mm)
D E set Pad: 3.63 in (92mm)
Common Top Connection: 4 1/2 REG 4 1/2 IF
4 1/2 H-90 5 H-90
Common Bottom Connection: 4 1/2 REG 6 5/8 REG
Weight 2660 lbs (1210 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8
0.39 1.1 1.2 1.1 2.0 2.1 2.5 1.5 1.5 1.5
0.78 2.3 2.1 2.4 3.8 3.9 4.3 3.5 3.5 3.5
1.15 4.3 3.9 3.1 5.6 5.7 6.0 5.5 5.5 5.5
1.50 6.3 5.8 4.0 7.3 7.4 7.7 7.3 7.4 7.4
1.83 8.1 7.6 5.6 8.9 8.9 9.2 8.9 8.9 9.1
2.12 9.7 9.2 7.1 10.3 10.3 10.6 10.3 10.3 10.6
2.38 11.1 10.6 8.5 11.5 11.6 11.8 11.5 11.6 11.8
2.60 12.3 11.8 9.7 12.6 12.6 12.9 12.6 12.6 12.9
E 2.77 13.2 12.8 10.6 13.2 13.4 13.7 13.4 13.4 13.7
B 2.89 13.9 13.4 11.3 13.9 14.0 14.2 13.9 14.0 14.2
2.97 14.3 13.8 11.7 14.3 14.4 14.6 14.3 14.4 14.6
3.00 14.5 14.0 11.9 14.5 14.5 14.7 14.5 14.5 14.7

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/4
0.0 3.00 3.00 3.00 3.00 3.00 3.00 2.89 3.00 2.77
2.5 3.00 3.00 3.00 2.60 2.38 2.60 2.38 2.38 2.12
5.0 3.00 3.00 3.00 1.83 1.83 2.12 2.12 1.83 1.83
7.5 2.60 2.77 3.00 1.50 1.50 1.50 1.15 1.15 1.15
10.0 2.12 2.38 3.00 1.15 1.15 1.15 0.78 0.78 0.78
12.5 1.83 1.83 2.38 0.39 0.39 0.39 0.39 0.39 0.39
15.0 1.15 1.50 2.12 0.00 0.00 0.00 0.00 0.00 0.00
17.5 0.78 1.15 1.50
20.0 0.39 0.78 1.15
22.5 0.00 0.39 0.78
25.0 0.00 0.39
27.5 0.00
30.0

C
6 3/4” 7/8 M/L 3.5 Stage
cations based on series 24x motor.
Maximum Pump Rate 600 gpm 2270 lpm
Revolutions per Unit Volume 0.15 rev/gal 0.040 rev/l
Pressure at Full Load 460 psi 3170 kPa
Torque at Full Load 7,830 lb-ft 10610 Nm
Maximum Weight on Bit 122,000 lbs 550 kN
Maximum Pull to Re-Run Motor 277,000 lbs 1250 kN
Pull to Yield Motor 672,000 lbs 3020 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 kPa
0 100 200 300 400 500 600 psi

100
90 600 (2270)
80
SPEED : RPM

500 (1890)
70
60 400 (1510)
50
300 (1140)
40
30
20
10 gpm (lpm)
0

12000 16000

10000 14000
TORQUE : N.m
TORQUE : lb-ft

12000
8000
10000
6000 8000
FULL LOAD

6000
4000
4000
2000 2000
0 0

160
140
OUTPUT POWER : HP

OUTPUT POWER : kw

100
120
100 600 (2270) 80

80 500 (1890) 60
60 400 (1510)
300 (1140) 40
40
20 20
gpm (lpm)
0 0
6 3/4” 7/8 M/L 5.0 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.01m)
C 25.8 ft (7.86 m)
D Maximum Diameter of Motor at Upset
A 7.63 in (194 mm)
D E set Pad: 3.63 in (92mm)
Common Top Connection: 4 1/2 REG 3 1/2 REG
4 1/2 H-90 5 H-90
Common Bottom Connection: 4 1/2 REG 6 5/8 REG
Weight 2190 lbs (1000 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8
0.39 1.3 1.5 1.2 2.4 2.5 3.1 1.7 1.7 1.7
0.78 2.8 2.5 2.5 4.6 4.7 5.2 4.1 4.1 4.1
1.15 5.2 4.6 3.6 6.6 6.7 7.2 6.3 6.3 6.3
1.50 7.4 6.9 4.8 8.5 8.6 9.1 8.5 8.5 8.5
1.83 9.6 9.0 6.6 10.3 10.4 10.8 10.3 10.4 10.5
2.12 11.5 10.9 8.4 11.9 12.0 12.4 11.9 12.0 12.3
2.38 13.2 12.6 10.1 13.2 13.4 13.8 13.3 13.4 13.8
2.60 14.6 14.0 11.4 14.6 14.6 15.0 14.6 14.6 15.0
E 2.77 15.7 15.1 12.5 15.7 15.7 15.9 15.7 15.5 15.9
B 2.89 16.5 15.9 13.3 16.5 16.5 16.5 16.5 16.2 16.5
2.97 17.0 16.4 13.8 17.0 17.0 16.9 16.9 16.6 16.9
3.00 17.2 16.6 14.0 17.2 17.2 17.1 17.1 16.8 17.1

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/8 8 1/2 8 3/4 9 7/4
0.0 3.00 3.00 3.00 2.77 2.89 2.77 2.60 2.60 2.38
3.0 3.00 3.00 3.00 2.38 2.12 2.12 2.12 1.83 1.83
6.0 2.60 2.77 3.00 1.50 1.50 1.83 1.50 1.50 1.50
9.0 2.12 2.38 3.00 1.15 1.15 1.15 0.78 0.78 0.78
12.0 1.83 1.83 2.60 0.39 0.78 0.78 0.39 0.39 0.39
15.0 1.50 1.50 2.12 0.00 0.00 0.39 0.00 0.00 0.00
18.0 0.78 1.15 1.83
21.0 0.39 0.78 1.15
24.0 0.00 0.39 0.78
27.0 0.00 0.39
30.0 0.00
33.0
36.0

C
6 3/4” 7/8 M/L 5.0 Stage
cations based on series 24x motor.
Maximum Pump Rate 600 gpm 2270 lpm
Revolutions per Unit Volume 0.28 rev/gal 0.074 rev/l
Pressure at Full Load 650 psi 4480 kPa
Torque at Full Load 5,950 lb-ft 8062 Nm
Maximum Weight on Bit 122,000 lbs 550 kN
Maximum Pull to Re-Run Motor 277,000 lbs 1250 kN
Pull to Yield Motor 672,000 lbs 3020 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 5000 6000 kPa

0 200 400 600 800 1000 psi

180
160 600 (2270)
140 500 (1890)
SPEED : RPM

120 400 (1510)


100
300 (1140)
80
60
40
20 gpm (lpm)
0

10000
9000 12000
8000
TORQUE : N.m
TORQUE : lb-ft

7000 10000
6000 8000
5000
6000
4000
FULL LOAD

3000 4000
2000
2000
1000
0

240
160
OUTPUT POWER : HP

OUTPUT POWER : kw

200 600 (2270)


140
160 500 (1890) 120
100
120 400 (1510)
80
80 300 (1140) 60
40
40
gpm (lpm) 20
0 0
7 3/4” (8”) 7/8 M/L 4.5 Stage
A 2.3ft (0.7 m)
B 6.6 ft (2.04m)
C 27 ft (8.23 m)
D Maximum Diameter of Motor at Upset
A 8.63 in (219 mm)
D E set Pad: 4.13 in (105mm)
Common Top Connection: 6 5/8 REG 7 H-90

Common Bottom Connection: 6 5/8 REG


Weight 3030 lbs (1370 kg)

Predicted Build Rates - Degrees/100ft (30m)


Bend Slick Single Two
Setting Stabilizer Stabilizers
Hole Size Hole Size Hole Size
Deg 9 7/8 10 5/8 12 1/4 9 7/8 10 5/8 12 1/4 9 7/8 10 5/8 12 1/4
0.39 1.2 1.1 1.1 2.4 2.7 3.4 1.7 1.7 1.7
0.78 2.3 2.3 2.2 4.4 4.7 5.3 3.9 3.9 3.9
1.15 4.1 3.4 4.0 6.3 6.6 7.1 6.1 6.1 6.1
1.50 6.1 4.7 4.3 8.1 8.4 8.8 8.1 8.1 8.1
1.83 8.1 6.6 5.2 9.8 10.0 10.5 9.8 10.0 10.0
2.12 9.8 8.3 6.0 11.3 11.5 11.9 11.3 11.5 11.7
2.38 11.3 9.8 6.8 12.6 12.8 13.2 12.6 12.8 13.2
2.60 12.6 11.1 8.0 13.7 13.9 14.3 13.7 13.9 14.3
E 2.77 13.6 12.1 9.0 14.6 14.8 15.1 14.6 14.8 15.1
B 2.89 14.3 12.8 9.7 15.2 15.4 15.7 15.2 15.4 15.7
2.97 14.8 13.3 10.1 15.6 15.8 16.1 15.6 15.8 16.1
3.00 15.0 13.4 10.3 15.8 16.0 16.3 15.8 16.0 16.3

Maximum Adjustable Bend Setting


For Rotary Drilling - Degrees
Hole Slick Single Two
Curvature Stabilizer Stabilizers
Hole Size Hole Size Hole Size
9 7/8 10 5/8 12 1/4 9 7/8 10 5/8 12 1/4 9 7/8 10 5/8 12 1/4
0.0 3.00 3.00 3.00 2.38 2.38 2.60 2.12 2.12 2.12
3.0 2.77 3.00 3.00 1.83 1.83 2.12 1.50 1.50 1.50
6.0 2.38 2.77 3.00 1.15 1.50 1.50 1.15 1.15 1.15
9.0 1.83 2.38 3.00 0.78 0.78 1.15 0.39 0.39 0.39
12.0 1.50 1.83 2.77 0.39 0.39 0.39 0.00 0.00 0.00
15.0 1.15 1.50 2.38 0.00
18.0 0.39 0.78 1.83
21.0 0.00 0.39 1.50
24.0 0.00 0.78
27.0 0.39
30.0 0.00
33.0
36.0

C
7 3/4” (8”)7/8 M/L 4.5 Stage
cations based on series 24x motor.
Maximum Pump Rate 900 gpm 3410 lpm
Revolutions per Unit Volume 0.16 rev/gal 0.042 rev/l
Pressure at Full Load 520 psi 3580 kPa
Torque at Full Load 8,660 lb-ft 11734 Nm
Maximum Weight on Bit 142,000 lbs 640 kN
Maximum Pull to Re-Run Motor 349,000 lbs 1570 kN
Pull to Yield Motor 775,000 lbs 3490 kN

ON-BOTTOM MINUS OFF-BOTTOM PRESSURE


0 1000 2000 3000 4000 5000 6000 kPa

0 100 200 300 400 500 600 700 800 psi

160
140 900 (3410)
120
SPEED : RPM

100 700 (2650)

80
500 (1890)
60
40 300 (1140)
20 gpm (lpm)
0

14000
17500
12000
15000
TORQUE : N.m
TORQUE : lb-ft

10000
12500
8000
10000
6000 7500
FULL LOAD

4000 5000
2000 2500
0 0

250
175
gpm (lpm) 900 (3410)
OUTPUT POWER : HP

OUTPUT POWER : kw

200 150

700 (2650) 125


150
100

100 500 (1890) 75


50
50
300 (1140) 25
0 0
Office: 405-604-2969 9630 Pole Road
Toll Free: 877-350-4497 Oklahoma City, OK 73160
Fax: 405-604-2970
www.drillrighttechnology.com

Darrell Husted, President,CEO dhusted@drillrihttechnology.com


Wayne Taylor, Vice President wtaylor@drillrighttehnology.com
Mark Franklin, Vice President Operations mfranklin@drillrighttechnology.com
Karl Spring, Manager of MWD Services kspring@drillrighttechnology.com
John Husted, Drill Right Tools jhusted@drillrighttechnology.com

Sales

Charles (Dick) Spencer 405-850-5935


Roy Lyles 405-249-6020
Ronnie Hill 405-625-7406 7 3/4”
6 3/4”
6 1/4” 7/8 M
(8”)
7/87/8

7 3/4” (8”) 7/8 M/L 4


7 3/4” (8”) 7/8 M/L 4.0 Stage

6 1/4” 7
M/LM/L
7 3/4” (8”) 7/8 M/L

6 3/4” 7/8 M/L 5.0 Stage

4 3/
6 1/4”
6 1/4” 7/8

7 3/4” (8”) 7/8 M/L


4 3/4” 7/8 M/L 3.8 S

7 3/4” (8”) 7/8 M/L 4.0

4 3/4” 7/8 M/L 3.8


5.0 Sta
6 1/4” 7/8

7 3/4” (8”) 7/8 M/L 4.0 Stage


7 3/4” (8”) 7/8 M/L 4
4 3/4” 7/8 M
6 3/4” 7/8

4.0
6 3/4”4
ge

ge

You might also like