Professional Documents
Culture Documents
Thevenin
Thevenin
Figure 1
Connect the circuit as shown in Figure 1, using the dual power supply output
“Master” and “Slave”. Make sure you lay out the circuit on the bread board with the
horizontal and vertical components with the SAME orientation as in the circuit
diagram.
Using two DMM’s and starting with load resistance RL = 82Ω, measure the load
voltage and current.
Repeat the procedure above using load resistance of 47Ω, 130Ω (120Ω + 10Ω), 180Ω,
220Ω.
Figure 2
Connect the Thevenin’s Equivalent Circuit as shown in Figure 2 using the values
calculated in your pre-laboratory.
Measure and record the load voltage and current for each of the previous load
conditions: RL = 47Ω, 82Ω, 130Ω, 180Ω, 220Ω.
2. Mesh Analysis/Nodal Analysis
Figure 3
Results
THEVENIN’S EQUIVALENT CIRCUIT
MEASURED
MEASURED ORIGINAL
THEVENIN’S CALCULATED
NETWORK
Load Resistance RL EQUIVALENT CIRCUIT
47Ω
82 Ω
130 Ω
180 Ω
220 Ω
MESH ANALYSIS
E1 12
E2 10
VR1
VR2
VR3
IR1
IR2
IR3
NODAL ANALYSIS
E1 12V
E2 10V
V1
V2
V3
IR1
IR2
IR3