Professional Documents
Culture Documents
STR-S6707 STR-S6709: Off-Line Switching Regulators - With Bipolar Switching Transistor
STR-S6707 STR-S6709: Off-Line Switching Regulators - With Bipolar Switching Transistor
Data Sheet
STR-S6709
28113†
OFF-LINE SWITCHING REGULATORS
– WITH BIPOLAR SWITCHING TRANSISTOR
The STR-S6707, STR-S6708, and STR-S6709 are specifically
designed to meet the requirement for increased integration and reliabil-
COLLECTOR 1 ity in off-line quasi-resonant flyback converters. These devices incorpo-
2
rate the primary control and proportional drive circuit with a third-
COMMON
FAULT generation high-voltage bipolar switching transistor.
BASE 3
S
FAULT
Crucial system parameters such as maximum ON time and OFF
DRIVE
SINK 4 OSC. LATCH
time are fixed during manufacture. Local control circuit decoupling and
R
DRIVE 5 layout are optimized within each device.
OVER-CURRENT
PROTECTION 6 Cycle-by-cycle current limiting, under-voltage lock-out with hyster-
+
REF. esis, over-voltage protection, and thermal shutdown protect these
FDBK 7
devices during all normal and overload conditions. Over-voltage
INHIBIT 8
+
UVLO
protection and thermal shutdown are latched after a short delay. A
V IN 9
versatile triple-level inhibit circuit includes the OFF time synchronization
required to establish quasi-resonant operation. The inhibit function has
also been expanded to initiate operation in stand-by mode in which the
Dwg. PK-001 power supply delivers a small fraction of the steady-state output power.
The dual requirements of dielectric isolation and low transient thermal
impedance and steady-state thermal resistance are satisfied in an over-
ABSOLUTE MAXIMUM RATINGS molded single-in-line power package.
Supply Voltage, VIN ........................... 15 V
Proven in substantial volumes, these devices and their fixed-
Output Voltage, VCEX ....................... 850 V frequency counterparts represent a significant advance in off-line SMPS
VEBO ................................................ 7 V reliability growth and integration.
Continuous Output Current,
IC .......................................... See Table FEATURES
1 ms Single-Pulse Output Current, ■ Quasi-Resonant Operation for Low EMI and High Efficiency
ICM ........................................ See Table
■ Output Power to 220 W
Sink Current, IS ......................... See Table
■ Low-Power Output Standby Mode
Drive Current, ID .......................... -700 mA
■ Pulse-by-Pulse Over-Current Protection
Feedback Current, IFDBK ................. 20 mA
■ Latched Over-Voltage and Thermal Protection
Inhibit Voltage, VINH ........................... 15 V
■ Third-Generation Switching Transistor with Proportional Drive
Over-Current Protection Voltage Range,
■ Maximum ON Time and Off Time Set During Manufacture
VOCP ............................................ ±3.5 V
■ Internal Under-Voltage Lockout with Hysteresis
Insulation Voltage,VWM(RMS) ........... 2000 V
■ Over-Molded SIP with Integral Isolated Heat Spreader
Package Power Diss., PD ........ See Graph
Output Junction Temperature, TJ .. +150°C Always order by complete part number:
Internal Frame Temperature, TF ... +125°C Max. Cont. Peak Max. Sink
Operating Temperature Range, Part Number Current, IC Current, ICM Current, IS
TA ............................... -20°C to +125°C
STR-S6707 6A 12 A 1.5 A
Storage Temperature Range, STR-S6708 7.5 A 15 A 1.5 A
Tstg ............................. -40°C to +125°C STR-S6709 10 A 20 A 2A
™
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
9 8
R
UVLO
OVER-VOLT. FAULT PROPORTIONAL
PROTECT LATCH DRIVE
S Q 5 DRIVE
1 kΩ
REF.
4 SINK
TSD 0.7 Ω
OSC.
3 BASE
Rton
+ 1 COLLECTOR
0.75 V
+ 2 COMMON
FDBK 7
3300 pF Rtoff 1.4 V
-1 V
+
OVER-CURRENT
6
PROTECTION
+
5.1 V
Dwg. FK-001
30
60 STR-S6709 (20 A)
MOUNTING SURFACE
ALLOWABLE PACKAGE POWER DISSIPATION in WATTS
RECOMMENDED MAX.
40 FRAME TEMP. = +100°C 5.0
3.0
L = 6 mH
IB1 = 2.5 A (STR-S6707/08) or 3 A (STR-S6709)
LIMITED BY FRAME IB2 = 0.8 A (STR-SA6707/08) or 1.2 A (STR-S6709)
TEMP. = +125°C MAX. ton = 100 µs
dc < 1%
20
1.0
FREE AIR
0.5
3.2 W
0 0.3
20 60 100 140 0 200 400 600 800 1000
TEMPERATURE in °C COLLECTOR-EMITTER VOLTAGE in VOLTS
Dwg. GK-003-2 Dwg. GK-002
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
Copyright © 1994 Allegro MicroSystems, Inc.
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
STR-S6709
FUNCTIONAL BLOCK DIAGRAM 4 SINK
20 Ω
AS ABOVE
EXCEPT FOR SINK OUTPUT
www.allegromicro.com
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
TYPICAL CHARACTERISTICS
100
50
30
DC CURRENT GAIN
VCE= 4 V
10
STR-S6709
STR-S6708
STR-S6707
5.0
3.0
1.0
0.01 0.03 0.1 0.3 1.0 3.0 10 30 100
COLLECTOR CURRENT in AMPERES
Dwg. GK-001
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
+ + OUTPUT
9 8 +
R
FULL-BRIDGE
100 V/120 V
+
AC INPUT
RECTIFIER
S Q 5
VOLTAGE
SENSE
4 +
– OUTPUT
+ 1
+ 2
7
Dwg. EK-004A
APPLICATIONS INFORMATION
WARNING — These devices are designed to be operated at lethal voltages and energy levels. Circuit
designs that embody these components must conform with applicable safety requirements. Precau-
tions must be taken to prevent accidental contact with power-line potentials. Do not connect
grounded test equipment.
The use of an isolation transformer is recommended during circuit development and breadboarding.
www.allegromicro.com
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
Dimensions in Inches
(for reference only)
0.953 ±0.008
T M REF.
0.610
±0.008 0.130 ø 0.216
0.118 ±0.008 ±0.008
1.49 ±0.012
0.709 ±0.008
0.130
±0.004
0.276
±0.016
0.216
1 9
0.016 0.100
0.033 0.026
±0.004
+0.008 +0.008
–0.004 –0.004
0.177
±0.028
PACKAGE LEAD
CENTER CENTER
Dwg. MK-003-9 in
NOTE: Exact body and lead configuration at vendor’s option within limits shown.
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
Dimensions in Millimeters
(controlling dimensions)
24.2 ±0.2
T REF
15.5 ±0.2 M
3.3 ø 5.5
3.0 ±0.2 ±0.2
23.0 ±0.3
18.0 ±0.2
3.3
±0.1
7.0
±0.4
5.5
1 9
0.4 2.54
0.85 0.65
+0.2 ±0.1
+0.2
–0.1 –0.1
4.5
±0.7
PACKAGE LEAD
CENTER CENTER
Dwg. MK-003-9 mm
NOTE: Exact body and lead configuration at vendor’s option within limits shown.
www.allegromicro.com
STR-S6707 THRU STR-S6709
OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
The products described here are manufactured in Japan by Sanken Electric Co., Ltd. for
sale by Allegro MicroSystems, Inc.
Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. reserve the right to make, from
time to time, such departures from the detail specifications as may be required to permit
improvements in the performance, reliability, or manufacturability of their products.
Therefore, the user is cautioned to verify that the information in this publication is current
before placing any order.
These products are not authorized for use as critical components in life-support
appliances, devices, or systems without express written approval.
The information included herein is believed to be accurate and reliable. However,
Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. assume no responsibility for its
use; nor for any infringements of patents or other rights of third parties which may result
from its use.
™
115 Northeast Cutoff, Box 15036
Worcester, Massachusetts 01615-0036 (508) 853-5000