Professional Documents
Culture Documents
Cat Extreme Application Grease PDF
Cat Extreme Application Grease PDF
Discover the Difference
Cat® Extreme Application Grease is developed, tested, and approved
by Caterpillar to meet same high standards as all Genuine Cat Parts.
Corrosion Protection—Resists oxidation and protects metal against rust. Will not
corrode or damage steel, copper bearing alloys or conventional seal materials.
Cat® Extreme Application Grease
Grease Selection Guide
Cat Extreme Application Grease 1 Cat Extreme Application Grease - Desert Cat Prime Application Grease Cat Ball Bearing Grease 1
NLGI 1 NLGI 2 NLGI 2 NLGI 2
(-20 to 140ºC/-4 to 284ºF) (-20 to 140ºC/284ºF) (-20 to 140ºC/-4 to 284ºF) Temps above -20ºC/-4ºF)
With 5% Moly With 5% Moly With 3% Moly Without Moly
Cat Extreme Application Grease 2 Cat Extreme Application Grease - Arctic Cat Utility Grease 1
NLGI 2 NLGI 0.5 NLGI 2
(-15 to 140ºC/+5 to 284ºF) Temps down to -50ºC/58ºF) (-20 to 140ºC/-4 to 284ºF)
With 5% Moly With 5% Moly Without Moly
Typical Properties
NLGI 1 2 Recommended Use
Color Grey Black Cat Extreme Application Greases are
formulated for grease fittings and
Molybdenum Disulfide, % 5 5
lubrication points in high-load and
Operating Temperature Range, °C -20 to +140 -15 to +140 high-speed applications with operating
temperatures ranging from -20°C to +140°C
Operating Temperature Range, °F -5 to +285 +5 to 285
(-4C to +284°F) for NLGI 1 and -15°C to
Base Oil Type Mineral 140°C (+5°F to +284°F) for NLGI 2.
ASTM D445 Base Oil Viscosity 40°C, mm²/s 150
Health and Safety
Thickener Type Calcium Sulfonate
For information on proper use for health,
ASTM D2265 Dropping point, °C > 260 > 260
safety and environment, please refer to
ASTM D217 Penetration, worked 60, mm/10 325 280 the Material Safety Data Sheet (MSDS).
Read and understand the MSDS before
ASTM D2596 4 Ball weld load, kg 620 620
using this product. Always observe good
ASTM D1743 Rust prevention, distilled water Pass Pass hygiene measures. For a copy of the
ASTM D1263 Water wash-out, 175°F, mass % 3 3 MSDS, contact us or visit the web at
www.catmsds.com.
The values shown are typical values and should not be used as quality control parameters to either accept or reject product.
Specifications are subject to change without notice.
PEHJ0403
www.cat.com