Patterndrafting and Designing for Stretch Fabrics
Session 2 - Sleeve Sloper Draft Reference
—+
This draft is for a STABLE KNIT One-Way-Stretch Sleeve Sloper. This sloper is drafted to be fit into your
Top Sloper. It will be drafted on the fold and then made to be a full sleeve.
These are the measurement needed for this draft. You can use personal measurements or measure-
ments from the size chart.
Measurement #
17, Sleeve length
19. Bicep
Armhole 20. Wrist
33%
Feet | cap reduction for
medium drop
The sleeve will be drafted
ona folded sheet of light-
weight paper
Measure armhole depth of the sloper
and record here The draft if shown in gray
Measure TOTAL around armhole cir-
cumference here
-33% of your armhole depth measure-
ment and record here
Ap A-B= sleeve length (17) Ag 2 ArC=armhole depth
minus amount for
‘D cap height
$
cY ° Square a line out from
s c
B
2
jo
v
g
2Patterndrafting and Designing for Stretch Fabrics
Session 2 - Sleeve Sloper Draft Reference
eee
>
A-D= half of total around
armhole measurement
circumference (taken in
step 1)
Place your ruler on point
Aand wherever your
armhole measurement
(from above) lies on the
bicep line (C line) mark D
Measure out 1/2” from H
G remains the same
Measure 1/2” in from F
B-E= half of wrist (20)
—+
Square out a bit from A
(away from the fold)
Divide A-D into fourths
and label F, G, and H.
‘Square out a short bit
from each point on either
side
curves to create the
sleeve crown shape
Remember to square
1/2” out from A at the
sleeve crown and 1/4” at
D for the underarm
Connect D-E with a
straightline to create the
inseam of the sleevePatterndrafting and Designing for Stretch Fabrics
Session 2 - Sleeve Sloper Draft Reference
To take the sleeve in Take in the sleeve 1/2”
for fitted styles: IA and blend a new
smooth inseam
Find the halfway point
of the inseam and mea-
sure 1” up from that c
point
B
Cut out the sleeve on the fold and open the paper to
draw in the grainline, as well as the elbow notch (as
illustrated)
Just remember if you do any adjustments to the under-
arm point of the top sloper, the same measurement ad-
justment needs to be done to the underarms of the
sleeve (point D, bring in our out according to the ad-
justment)
There is no front or back side to the sleeve draft since
the draft is symmetrical. The 1/4” adjustment we did on
the front armhole of the top sloper will accomodate the
body